Chevrolet Suburban X (2000-2006) body control module (below steering column) Wiring diagrams

1 2 6 8 16 19 20 21 40 42 46 47 48 51 62 63 GND TCC PWM PC SOL HI PC SOL LO 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID 3-2 SHIFT SOLENOID A/T FLUID PRESSURE MANUAL MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) EXCEPT SEO FLUID TEMP SENSOR FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START HOT IN RUN, START I/P RELAY BLOCK (BELOW LEFT SIDE OF DASH) INSTRUMENT CLUSTER INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (BELOW STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV RUN WIRE SEO SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC PWM SOLENOID TCC SOLENOID TOW/HAUL SWITCH TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) PCM 1 FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR THE BATTERY) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 6 8 16 19 20 21 40 42 46 47 48 51 62 63 GND TCC PWM PC SOL HI PC SOL LO 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID 3-2 SHIFT SOLENOID A/T FLUID PRESSURE MANUAL MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) EXCEPT SEO FLUID TEMP SENSOR FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START HOT IN RUN, START I/P RELAY BLOCK (BELOW LEFT SIDE OF DASH) INSTRUMENT CLUSTER INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (BELOW STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV RUN WIRE SEO SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC PWM SOLENOID TCC SOLENOID TOW/HAUL SWITCH TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) PCM 1 FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR THE BATTERY) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 6 8 16 GND TCC PWM PC SOL HI PC SOL LO 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID A/T FLUID PRESSURE MANUAL MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR (IN TRANSMISSION) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) EXCEPT SEO FLUID TEMP SENSOR FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START HOT IN RUN, START I/P RELAY BLOCK (BELOW LEFT SIDE OF DASH) INSTRUMENT CLUSTER INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (BELOW STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV RUN WIRE SEO SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TCC PWM SOLENOID TOW/HAUL SWITCH TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) PCM 1 FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR THE BATTERY) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 6 8 16 GND TCC PWM PC SOL HI PC SOL LO 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID A/T FLUID PRESSURE MANUAL MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR (IN TRANSMISSION) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) EXCEPT SEO FLUID TEMP SENSOR FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START HOT IN RUN, START I/P RELAY BLOCK (BELOW LEFT SIDE OF DASH) INSTRUMENT CLUSTER INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (BELOW STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV RUN WIRE SEO SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TCC PWM SOLENOID TOW/HAUL SWITCH TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) PCM 1 FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR THE BATTERY) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

3-2 SS CTRL REF LOW A/C SYSTEM ANTI-LOCK BRAKES SYS 470 451 1671 1667 451 1669 1664 1478 ANTI-LOCK BRAKES SYS 771 420 776 48 1744 846 1101 625 451 BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC SUSPENSION SYSTEM FUEL COMP SIG B+ CLS 2 DATA CLS 2 DATA FUSE FUSE FUSE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE HOT IN RUN, START INJ 7 CTRL INJ 4 CTRL INJECTORS KS SIGNAL KS SIGNAL CKP SIG REQ TORQ SIG SERIAL DATA SERIAL DATA LEV SW SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OIL LEV SW SIG ORG/ WIRE ORG/BLK WIRE PCMB FUSE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL/WHT WIRE PRND B SIG CMP SIG ECT SIG IGN INJ 5 CTRL INJ 8 CTRL RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE REF LOW REF LOW (A/T) REF LOW REF LOW GND STARTING/ CHARGING SYSTEM TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

3-2 SS CTRL REF LOW A/C SYSTEM ANTI-LOCK BRAKES SYS 470 451 1671 1667 451 1669 1664 1478 ANTI-LOCK BRAKES SYS 771 420 776 48 1744 846 1101 625 451 BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC SUSPENSION SYSTEM FUEL COMP SIG B+ CLS 2 DATA CLS 2 DATA FUSE FUSE FUSE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE HOT IN RUN, START INJ 7 CTRL INJ 4 CTRL INJECTORS KS SIGNAL KS SIGNAL CKP SIG REQ TORQ SIG SERIAL DATA SERIAL DATA LEV SW SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OIL LEV SW SIG ORG/ WIRE ORG/BLK WIRE PCMB FUSE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL/WHT WIRE PRND B SIG CMP SIG ECT SIG IGN INJ 5 CTRL INJ 8 CTRL RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE REF LOW REF LOW (A/T) REF LOW REF LOW GND STARTING/ CHARGING SYSTEM TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

3-2 SS CTRL REF LOW A/C SYSTEM ANTI-LOCK BRAKES SYS 470 451 1671 1667 451 1669 1664 1478 ANTI-LOCK BRAKES SYS 771 420 776 48 1744 846 1101 625 451 BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC SUSPENSION SYSTEM FUEL COMP SIG B+ CLS 2 DATA CLS 2 DATA FUSE FUSE FUSE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE HOT IN RUN, START INJ 7 CTRL INJ 4 CTRL INJECTORS KS SIGNAL KS SIGNAL CKP SIG REQ TORQ SIG SERIAL DATA SERIAL DATA LEV SW SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OIL LEV SW SIG ORG/ WIRE ORG/BLK WIRE PCMB FUSE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL/WHT WIRE PRND B SIG CMP SIG ECT SIG IGN INJ 5 CTRL INJ 8 CTRL RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE REF LOW REF LOW (A/T) REF LOW REF LOW GND STARTING/ CHARGING SYSTEM TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

18 19 20 21 PNK WIRE 2700 474 A/C SYSTEM 2755 451 1670 1666 451 1668 1665 1174 REF LOW GND 440 1049 710 B+ CLS 2 DATA CLS 2 DATA 720 469 REF LOW (A/T) REF LOW 772 633 410 1020 845 PRND B SIG CMP SIG ECT SIG IGN INJ 5 CTRL INJ 8 CTRL BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC SUSPENSION MODULE FUSE FUSE FUSE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START HOT IN RUN, START INJ 1 CTRL INJ 6 CTRL DAMPING SIG RLY CTRL GND INJ 7 CTRL INJ 4 CTRL INJECTORS KS SIGNAL KS SIGNAL CKP SIG LEFT I/P FUSE BLOCK IGN 0 FUSE LEV SW SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OIL LEV SW SIG ORG/ WIRE ORG/BLK WIRE PCMB FUSE PNK 1 2 3 4 5 WIRE PNK PNK 27 28 WIRE PNK PNK 6 7 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL PPL 32 33 34 35 36 37 38 PPL/WHT WIRE PRND A SIG BRK SW SIG PRND P SIG PPL RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE REF LOW REF LOW GND SERIAL DATA (-) SERIAL DATA (+) STARTING SYSTEM TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE