Chevrolet Sportvan G30 (1985-1994) alt fuse Wiring diagrams

** (RIGHT FRAME RAIL, NEAR BATTERY) ACCY ALT FUSE AUDIO ALARM MODULE CONVENIENCE CENTER AUTO APPLY PARK BRAKE BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE IND BRAKE PRESSURE WARNING SWITCH (NEAR MASTER CYLINDER) BRN/WHT WIRE BULB TEST COOLANT TEMP COOLANT TEMP GAUGE DAYTIME RUNNING LAMPS MODULE DAYTIME RUNNING LAMPS RELAY DAYTIME RUNNING LIGHTS IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE SENDER FUEL GAUGE FUEL LEVEL FUEL PUMP, SENDER (IN FUEL TANK) FUSE BLOCK GRY WIRE HEADLIGHTS SYSTEM HI-BEAM IND HOT IN RUN, BULB TEST OR START HOT W/ LAMP SWITCH IN PARK OR HEAD I/P GROUND IGN IGNITION SWITCH ILLUM ILLUM. LAMPS INSTR LPS FUSE INSTRUMENT CLUSTER LEFT TURN IND LOCK OFF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAL- FUNCTION IND OIL PRESS GAUGE OIL PRESS. SIGNAL OIL PRESSURE SWITCH, SENDER (TOP REAR OF ENGINE) PARK BRAKE IND PARK BRAKE WARNING SWITCH PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF I/P, BEHIND SHIPPING PANEL) PPL RIGHT TURN IND RUN WIRE SAFETY BELT IND SPEED- OMETER TAN WIRE TAN/WHT WIRE VEHICLE SPEED VEHICLE SPEED SENSOR (ON OUTPUT SHAFT OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (INSIDE LEFT SIDE OF SHIPPING PANEL) VOLT- METER W/ DRL W/O DRL WHT WIRE YEL WIRE

ALT FUSE AUDIO ALARMS BACKUP LAMP SWITCH (AUTO TRANS) BACKUP LAMP SWITCH (MANUAL TRANS) DK BLU WIRE ECM CRANK FUSE FROM FUSIBLE LINK A FROM IGNITION SWITCH FUSE BLOCK GENERATOR FUEL HEATER GLOW PLUG CONTROLLER I/P CLUSTER PNK WIRE PNK/BLK WIRE RED WIRE TCC/ BRAKE SWITCH TCM TRANS FUSE TRANSMISSION TURN SIGNAL FLASHER TURN-B/U FUSE VEHICLE SPEED SENSOR BUFFER WATER-IN-FUEL SENSOR COLD ADVANCE FAST IDLE TEMPERATURE SWITCH WITH AUTOMATIC TRANSMISSION ONLY WITH MANUAL TRANSMISSION ONLY

ALL OTHERS ALT FUSE AUDIO ALARM MODULE BACKUP LAMP SWITCH CONVENIENCE CENTER DK BLU WIRE ECM CRANK FUSE EGR ELECTRONIC VACUUM REGULATOR SOLENOID VALVE (VIN K ONLY) EGR SOLENOID EVAPORATIVE CANISTER PURGE SOLENOID FUSE BLOCK GENERATOR HEATED OXYGEN SENSOR (VIN Z W/ MANUAL TRANSMISSION) I/P CLUSTER IDLE SPEED CONTROL ACTUATOR IGNITION COIL IGNITION SWITCH INJ FUSE INJECTOR 1 INJECTOR 2 KNOCK SENSOR SYSTEM (W/ MANUAL TRANSMISSION) PCM PNK WIRE PNK/BLK WIRE RED WIRE TCC/ BRAKE SWITCH TRANS FUSE TRANSMISSION TURN SIGNAL FLASHER TURN-B/U FUSE VEHICLE SPEED SENSOR BUFFER (EXCEPT VIN K W/ MANUAL TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (VIN K W/ MANUAL TRANSMISSION) VIN K WITH HEAVY DUTY AUTOMATIC TRANSMISSION VIN N W/ AUTOMATIC TRANSMISSION W/ AUTOMATIC TRANSMISSION WHT WIRE

3 121 PNK WIRE 4.3L AND 7.4L 5.7L ACCY ALT FUSE BLK WIRE BLK/RED WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IGNITION COIL (TOP RIGHT REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (LEFT REAR OF ENGINE, NEAR OIL PRESSURE SENDER) KNOCK SENSOR MODULE (TOP RIGHT SIDE OF ENGINE) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION (SERVICE ENGINE SOON) INDICATOR MANIFOLD ABSOLUTE PRESSURE SENSOR (ABOVE VALVE COVER) NCA WIRE ORG/ WIRE PNK 25 26 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 2 3 4 PPL 23 24 PPL/WHT WIRE PROVISIONS FOR TACHOMETER RED WIRE RED/BLK WIRE RUN WIRE TAN/BLK WIRE TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

3 121 PNK WIRE 4.3L 5.7L ACCY ALT FUSE BLK WIRE BLK/RED WIRE BLK/WHT WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE FUEL PUMP AND SENDER (IN FUEL TANK) FUEL PUMP OIL PRESSURE SWITCH (TOP REAR OF ENGINE) FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY (LOWER LEFT SIDE OF SHIPPING PANEL) FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IGNITION COIL (TOP OF ENGINE NEAR DISTRIBUTOR) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (RIGHT SIDE OF ENGINE) KNOCK SENSOR MODULE (TOP RIGHT SIDE OF ENGINE) LOCK OFF LT GRN/BLK WIRE MALFUNCTION (SERVICE ENGINE SOON) INDICATOR NCA WIRE ORG/ WIRE OXYGEN SENSOR (IN EXHAUST MANIFOLD) HEATED OXYGEN SENSOR (IN EXHAUST MANIFOLD) PNK PPL PPL WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE PROVISIONS FOR TACHOMETER RED WIRE RUN WIRE TAN/BLK WIRE VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (BEHIND RIGHT SIDE OF I/P) WHT WIRE

3 121 PNK WIRE 4.3L AND 7.4L 5.7L ACCY ALT FUSE BLK WIRE BLK/RED WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IGNITION COIL (TOP RIGHT REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (LEFT REAR OF ENGINE, NEAR OIL PRESSURE SENDER) KNOCK SENSOR MODULE (TOP RIGHT SIDE OF ENGINE) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION (SERVICE ENGINE SOON) INDICATOR MANIFOLD ABSOLUTE PRESSURE SENSOR (ABOVE VALVE COVER) NCA WIRE ORG/ WIRE PNK 25 26 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 2 3 4 PPL 23 24 PPL/WHT WIRE PROVISIONS FOR TACHOMETER RED WIRE RED/BLK WIRE RUN WIRE TAN/BLK WIRE TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

3 121 PNK WIRE 4.3L 5.7L ACCY ALT FUSE BLK WIRE BLK/RED WIRE BLK/WHT WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE FUEL PUMP AND SENDER (IN FUEL TANK) FUEL PUMP OIL PRESSURE SWITCH (TOP REAR OF ENGINE) FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY (LOWER LEFT SIDE OF SHIPPING PANEL) FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IGNITION COIL (TOP OF ENGINE NEAR DISTRIBUTOR) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (RIGHT SIDE OF ENGINE) KNOCK SENSOR MODULE (TOP RIGHT SIDE OF ENGINE) LOCK OFF LT GRN/BLK WIRE MALFUNCTION (SERVICE ENGINE SOON) INDICATOR NCA WIRE ORG/ WIRE OXYGEN SENSOR (IN EXHAUST MANIFOLD) HEATED OXYGEN SENSOR (IN EXHAUST MANIFOLD) PNK PPL PPL WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE PROVISIONS FOR TACHOMETER RED WIRE RUN WIRE TAN/BLK WIRE VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (BEHIND RIGHT SIDE OF I/P) WHT WIRE

"TRANS" LAMP 1-2 SHIFT SOL 2-3 SHIFT SOL TCC SOL 2-3 SHIFT SOL CTRL 1-2 SHIFT SOL CTRL DIAGNOSTIC TEST A/C INPUT BRAKE SIGNAL TCC CONTROL PPL ACCY AIR CONDI- TIONING SYSTEM ALT FUSE B/H BATTERY FEED BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN WIRE BULB TEST COLD ADVANCE FAST IDLE TEMPERATURE SWITCH (RIGHT REAR OF ENGINE) COLD ADVANCE SOLENOID (TOP FRONT OF ENGINE) DATA LINK CONNECTOR (BEHIND LEFT SIDE SHIPPING DIODE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECM BAT FUSE ECM CRANK FUSE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENGINE SPEED SIGNAL SENSOR GROUND TP SENSOR INPUT FAST IDLE SOLENOID (TOP LEFT SIDE OF ENGINE) FUEL HEATER (TOP REAR OF ENGINE) FUEL SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) FUSE BLOCK FUSIBLE LINK (20 GA-RUST) FUSIBLE LINKS GLOW PLUG CONTROLLER (LEFT SIDE OF ENGINE) GLOW PLUG WAIT LAMP GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT AT ALL TIMES FUSIBLE LINK HOT IN CRANK HOT IN RUN, BULB TEST OR START INPUTS INSTRUMENT CLUSTER LEFT BANK GLOW PLUGS LOCK OFF LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PANEL) PCS HI PCS LO IGNITION PNK RANGE SIGNAL A RANGE SIGNAL B RANGE SIGNAL C WIRE PNK WIRE PNK/BLK WIRE PPL PRESSURE CONTROL SOLENOID RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RIGHT BANK GLOW PLUGS RUN WIRE SERVICE TRANS OUTPUT SERIAL DATA SYSTEM GROUND SYSTEM GROUND 452 416 SENSOR GROUND 5 VOLTS REF TAN/BLK WIRE TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT) TRAN- SMISSION FLUID TEMP (TFT) SENSOR TRANS FLUID TEMP SIG MAP SENS TRANS FUSE TRANSMISSION CONTROL MODULE (TCM) (BEHIND LEFT SIDE OF SHIPPING PANEL) TRANSMISSION INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VEHICLE SPEED INPUT TRANS INPUT SPD LO TRANS INPUT SPD HI VEHICLE SPEED SENSOR (REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT SIDE OF I/P) VEHICLE SPD OUTPUT VSS WATER IN FUEL INDICATOR WATER-IN FUEL SENSOR (TOP REAR OF ENGINE) WHT WIRE WHT/BLK WIRE YEL/BLK WIRE

ACCY ALT FUSE BLK WIRE BULB TEST COLD ADVANCE FAST IDLE TEMPERATURE SWITCH (RIGHT REAR OF ENGINE) COLD ADVANCE SOLENOID (TOP FRONT OF ENGINE) DK BLU WIRE FAST IDLE SOLENOID (TOP LEFT SIDE OF ENGINE) FUEL HEATER (TOP REAR OF ENGINE) FUEL SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) FUSE BLOCK FUSIBLE LINK (12 GA- RUST) (NO LOCATION AVAILABLE) FUSIBLE LINK (20 GA- RUST) (ON STARTER MOTOR) FUSIBLE LINKS GLOW PLUG CONTROLLER (LEFT SIDE OF ENGINE) GLOW PLUG WAIT LAMP GROUND (NO LOCATION AVAILABLE) HOT AT ALL TIMES HOT IN RUN OR START HOT IN START INSTRUMENT CLUSTER LEFT BANK GLOW PLUGS LOCK OFF LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE RED WIRE RIGHT BANK GLOW PLUGS RUN WIRE WATER IN FUEL INDICATOR WATER-IN FUEL SENSOR (TOP REAR OF ENGINE) YEL/BLK WIRE

3 121 PNK WIRE 4.3L AND 7.4L 5.7L ACCY ALT FUSE BLK WIRE BLK/RED WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IGNITION COIL (TOP RIGHT REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (LEFT REAR OF ENGINE, NEAR OIL PRESSURE SENDER) KNOCK SENSOR MODULE (TOP RIGHT SIDE OF ENGINE) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION (SERVICE ENGINE SOON) INDICATOR MANIFOLD ABSOLUTE PRESSURE SENSOR (ABOVE VALVE COVER) NCA WIRE ORG/ WIRE PNK 25 26 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 2 3 4 PPL 23 24 PPL/WHT WIRE PROVISIONS FOR TACHOMETER RED WIRE RED/BLK WIRE RUN WIRE TAN/BLK WIRE TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE