Chevrolet Silverado GMT K2XX (2013-2015) hvac control module Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 AIR TMP 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 B(+) A/C ON AIR TEMP RF SUNLD AMB AIR TMP GMLAN L AMBIENT AIR TEMPERATURE SENSOR (ON LEFT SIDE OF RADIATOR SUPPORT) AMBIENT LIGHT/SUNLOAD SENSOR ASSEMBLY (TOP CENTER OF DASH) AUTO BATT POS VOLT BLK WIRE BLK/WHT WIRE BREAKOUT) BRN WIRE COLNT LVL GROUND LOW REF COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE ENGINE COOLANT LEVEL SWITCH (6.6L) (ON BOTTOM OF SURGE TANK) EVAPORATOR TEMPERATURE SENSOR (ON HVAC ASSEMBLY) FAN DN FAN UP FRESH AIR FRNT DFG FRT DEF A/C IND FSH AIR GROUND GROUND DISTRIBUTION SYSTEM GROUND IGN 3 REAR DEFOG GRY WIRE GRY/BLK WIRE HVAC CONTROL MODULE INSTRUMENT PANEL CLUSTER (IPC) DRIVER INFORMATION CENTER (DIC) DISPLAY LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT SUNLOAD SENSOR LEFT TEMP CONTROL LF SUNLD L AIR TMP R AIR TMP LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE DN MODE UP MTR SPD CTRL OFF ORG/ WIRE POWER DISTRIBUTION SYSTEM DEFOGGER SYSTEM PPL PPL/WHT WIRE R AIR TMP AIR TMP R AIR TMP TEMP SENS MODE CTRL L AIR TMP RECIR CTRL R AIR TMP REAR DFG RECIR RECIRC RED WIRE RED/WHT WIRE RER DEF RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RIGHT SUNLOAD SENSOR RIGHT TEMP CONTROL SERIAL DATA TAN WIRE UPPER LEFT AIR TEMPERATURE SENSOR (UNDER UPPER LEFT SIDE OF DASH) UPPER RIGHT AIR TEMPERATURE SENSOR (UNDER UPPER RIGHT SIDE OF DASH) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

2 OR MORE OF W/ ONSTAR, AUDIO AMPLIFIER (IF EQUIPPED) (UNDER REAR OF CENTER CONSOLE) BLK WIRE BLK/WHT WIRE CHIME MODULE (CENTER OF DASH, BEHIND RADIO) DATA LINK CONNECTOR (DLC) (LOWER LEFT SIDE OF DASH) DIGITAL RADIO RECEIVER (BEHIND RIGHT END OF DASH) DIGITAL RADIO RECEIVER (IF EQUIPPED) (BEHIND RIGHT END OF DASH) DIGITAL RADIO, REAR SEAT, DK GRN WIRE DRIVER DOOR LOCK/WINDOW SWITCH DRIVER'S SEAT EARPHONE JACKS RADIO CONTROL GROUND DISTRIBUTION SYSTEM HEATED SEAT CONTROL MODULE (W/ SPO HEATED SEATS) HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LOW SPD GMLAN SER DATA LOW SPEED GMLAN SERIAL DATA LOW SPEED SERIAL DATA LTR FUSE 53 (EXCEPT 6.6L) FUSE 50 (6.6L) MEMORY SEAT MODULE (W/ INDIVIDUAL FRONT SEAT) (UNDER FRONT OF NOT USED NOT USED PASSENGER DOOR LOCK/WINDOW SWITCH POWER DISTRIBUTION SYSTEM RADIO REAR OBJECT SENSOR CONTROL MODULE (AT REAR CARGO AREA, BEHIND TRIM PANEL) REAR SEAT AUDIO (RSA) CONTROL REAR SEAT AUDIO (RSA) CONTROL (IF EQUIPPED) RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (TOP REAR OF PASSENGER COMPT) RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) TAN WIRE TAN/BLK WIRE THEFT DETERRENT CONTROL MODULE (TDM) (ON RIGHT SIDE OF STEERING COLUMN) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) (BEHIND CENTER OF DASH) W/ DIGITAL RADIO W/ DIGITAL RADIO, REAR SEAT, ONSTAR, EARPHONE JACKS RADIO CONTROL W/ FRONT SEAT, REMOTE CONTROL W/ INDIVIDUAL FRONT SEAT W/ LUXURY EDITION W/ ONSTAR W/ RADIO PROVISIONS W/ REAR SEAT, EARPHONE JACKS RADIO CONTROL W/ REMOTE KEYLESS ENTRY W/O INDIVIDUAL FRONT SEAT W/O LUXURY EDITION W/O LUXURY EDITION, W/ ODOMETER SECURITY PROVISIONS W/O RADIO PROVISIONS WHT WIRE

2500 2501 COMPUTER DATA LINES SYSTEM 66 46 DATA BUS + DATA BUS - BLK WIRE BLK/WHT WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ECT SENS SIG ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) ENGINE COOLANT LEVEL SWITCH (ON BOTTOM OF SURGE TANK) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT CENTER OF ENGINE) ENGINE COOLING FAN (FRONT CENTER OF ENGINE COMPT) FAN FUSE 68 FAN RLY RELAY GMLAN L GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOGIC B+ GND LOW REF LT GRN WIRE MANUAL A/C AUTOMATIC A/C RLY SPD SIG SERIAL DATA SPD SIG SW SIG TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

BLK WIRE BODY CONTROL MODULE COLLISION ALERT INDICATORS DATA LINK CONNECTOR DRIVER SEAT HEATING, COOLING SWITCH FORWARD ADJUSTABLE PEDAL RELAY HEADLAMP SWITCH HVAC CONTROL MODULE IGNITION MAIN RELAY IGNITION RUN/ CRANK RELAY INSTRUMENT CLUSTER INSTRUMENT PANEL JUNCTION BLOCK INSTRUMENT PANEL MULTI- FUNCTION SWITCH LEFT INSTRUMENT PANEL FUSE BLOCK NCA WIRE PASSENGER SEAT HEATING, COOLING SWITCH REARWARD ADJUSTABLE PEDAL RELAY RETAINED ACCESSORY POWER RELAY 1 STEERING WHEEL ANGLE SENSOR TRANSMISSION SHIFT LEVER TRANSMISSION SHIFT LOCK CONTROL SOLENOID ACTUATOR TURN SIGNAL/ MULTI-FUNCTION SWITCH WHT WIRE WINDSHIELD WIPER MOTOR

AUTOMATIC A/C MANUAL A/C 15 10 BLK WIRE BLOWER MOTOR CONTROL MODULE BREAKOUT) CENTER CONSOLE ACCESSORY POWER OUTLET CENTER CONSOLE COMPARTMENT ACCESSORY POWER OUTLET CENTER HIGH MOUNTED STOP LAMP (CHMSL) CREW CAB DATA LINK CONNECTOR (DLC) DRIVER INFORMATION CENTER (DIC) SWITCH ELECTRONIC ADJUSTABLE PEDALS PCB RELAY ELECTRONIC COMPASS MODULE FROM FROM SPLICE HORN SWITCH HVAC CONTROL MODULE I/P 2 ACCESSORY POWER OUTLET INSIDE REARVIEW MIRROR (ISRVM) LOGIC LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT STEERING WHEEL CONTROL SWITCH MIDDLE LEFT FRONT ROOF FRONT CLEARANCE OUTER LAMP ROOF CLEARANCE LAMP NCA WIRE PARK ENABLE PCB RELAY PASSENGER OUTSIDE REARVIEW MIRROR PASSENGER WINDOW SWITCH PASSENGER DOOR LOCK/ WINDOW SWITCH REAR DOME READING LAMPS RIGHT FRONT OUTER ROOF CLEARANCE LAMP RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RIGHT STEERING WHEEL CONTROL SWITCH RIGHT SUNSHADE (IF EQUIPPED) SUNROOF MODULE SUNROOF SWITCH W/ ACCESSORY STEERING CONTROL W/ ACCESSORY STEERING CONTROL, W/ ODOMETER SECURITY WIRING PROVISIONS W/ BODY BUILDER EMERGENCY LAMP W/ COMFORT, DECOR LEVEL 3 W/ LUXURY EDITION W/ MANUAL FOLDING MIRROR, HEATED MIRROR W/ MANUAL FOLDING MIRROR, HEATED MIRROR (IN RIGHT FRONT DOOR HARNESS) W/ ROOF MARKER LAMP W/ ROOF MOUNTED LAMP PROVISIONS W/ STEERING WHEEL HEATER, ACCESSORY STEERING CONTROL, AUTOMATIC CRUISE CONTROL W/ STEERING WHEEL HEATER, AUTOMATIC CRUISE CONTROL W/ SUNROOF MOUNTED/SLIDING LAMP PROVISION W/ SUNROOF MOUNTED/SLIDING LAMP PROVISION W/O ROOF MARKER LAMP W/ SUNROOF SLIDING W/ WRECKER EMERGENCY LAMP W/O STEERING WHEEL HEATER W/O STEERING WHEEL HEATER, ACCESSORY STEERING CONTROL, AUTOMATIC CRUISE CONTROL WHT WIRE

AMBIENT LIGHT SENSOR AMBIENT LIGHT/ SUNLOAD SENSOR AUTOMATIC A/C AUTOMATIC A/C MANUAL A/C 8 3 AUTOMATIC TRANSMISSION SHIFT LEVER BLK WIRE BODY CONTROL MODULE (BCM) BRAKE FLUID LEVEL SWITCH DATA LINK CONNECTOR DRIVER DOOR LATCH DRIVER DOOR LOCK/ WINDOW SWITCH DRIVER DRIVER DOOR DOOR LOCK LATCH SWITCH DRIVER SEAT BACK VENTILATION HEATING, COOLING MODULE DRIVER SEAT CUSHION VENTILATION HEATING, COOLING MODULE DRIVER WINDOW SWITCH FRONT DOOR LOCK DIODE FRONT DOOR UNLOCK DIODE HEADLAMP, PANEL I/P DIMMER MULTI-FUNCTION SWITCH SWITCH HEATER HVAC CONTROL MODULE INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) MANUAL A/C NCA WIRE PASSENGER DOOR LATCH PASSENGER DOOR LOCK SWITCH PASSENGER SEAT ADJUSTER SWITCH PASSENGER SEAT BACK VENTILATION HEATING, COOLING MODULE PASSENGER SEAT CUSHION VENTILATION HEATING, COOLING MODULE PASSENGER SEAT LUMBAR SWITCH POWER WINDOW REAR DOOR LOCK DIODE REAR DOOR UNLOCK DIODE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) THEFT DETERRENT MODULE TURN SIGNAL/ MULTI-FUNCTION SWITCH W/ FRONT HEATED/ COOLING SEATS W/ NON BUCKET FRONT INDIVIDUAL SEAT W/O W/O NON BUCKET FRONT INDIVIDUAL SEAT W/O NON BUCKET, FRONT INDIVIDUAL SEAT, W/ COMFORT, DECOR LEVEL 3 W/O POWER DOOR LOCK CONTROL W/O POWER W/ POWER DOOR LOCK DOOR LOCK CONTROL CONTROL WHT WIRE WINDSHIELD WASHER SOLVENT WINDSHIELD WIPER MOTOR

7 3 SUPPLY VOLT LOW REF BATT POS VOLT BLK WIRE COMPUTER DATA LINES SYSTEM DDM FUSE 4 DK GRN WIRE DRIVER DOOR LOCK/ WINDOW SWITCH DRIVER OUTSIDE REARVIEW MIRROR GMLAN SERIAL DATA GRN WIRE GROUND GROUND DISTRIBUTION SYSTEM HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, LOGIC LOW REF ORG/ WIRE PASSENGER DOOR LOCK/WINDOW SWITCH PASSENGER OUTSIDE REARVIEW MIRROR PDM FUSE 9 POWER DISTRIBUTION SYSTEM REAR DEFOGGER IND REAR DEFOGGER SWITCH RED WIRE RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) SERIAL DATA SUPPLY VOLT WHT WIRE

1 2 4 10 5 7 RETRACT CTRL EXTEND CTRL SENS SIG LOW REF SENS SIG 2 6 1 7 3 9 4 POSITION CTRL MTR COMM POSITION CTRL SPLY VOLT LOW REF 4 6 B+ GND 9 2 12 SERIAL DATA PNK WIRE AUTOMATIC DAY/NIGHT MIRROR BLK WIRE BLK/WHT WIRE BRN WIRE COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM ELECTROCHROMIC DDM FUSE 4 DEFOGGER SWITCH DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DOWN L/R SELECT DRIVER DOOR LOCK/ WINDOW SWITCH DRIVER MEMORY/HEATED SEAT SWITCH DRIVER OUTSIDE REARVIEW MIRROR EXIT EXTEND GROUND DISTRIBUTION SYSTEM GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, L/R SELECT SW PWR LEFT LOGIC LT BLU WIRE LT BLU/WHT WIRE MIRROR CIRCUIT ORG/ WIRE ORG/BLK WIRE OUTSIDE REARVIEW MIRROR SWITCH PNK WIRE RED/WHT WIRE RETRACT RIGHT SERIAL DATA SW SIG LOGIC WHT WIRE YEL WIRE

AIR BAG/ INFO FUSE AMP FUSE BCM 1 FUSE BCM 3 FUSE BCM 5 FUSE BODY CONTROL MODULE DATA LINK CONNECTOR (DLC) DRIVER SEAT HEATING, COOLING SWITCH (W/ CLIMATE CONTROL SEATS) DRIVER WINDOW SWITCH FROM UNDERHOOD FUSE BLOCK (DIAGRAM 2 OF 5) FUSE HVAC CONTROL MODULE INFLATABLE SEAT RESTRAINT MEMORY CONTROL SENSING, MODULE DIAGNOSTIC MODULE INFO DISPLAY MODULE INSTRUMENT CLUSTER IPC FUSE LEFT INSTRUMENT PANEL FUSE BLOCK (LOWER LEFT SIDE OF DASH) LTD HTD CLD SEAT FUSE MIR WNDW MDL FUSE OUTSIDE REARVIEW MIRROR SWITCH PASSENGER BACK SEAT BLOWER ASSEMBLY PASSENGER CUSHION SEAT BLOWER ASSEMBLY PASSENGER PRESENCE MODULE PASSENGER SEAT HEATING, COOLING SWITCH (W/ CLIMATE CONTROL SEATS) PEPS/HVAC FUSE PRK ENBL/ EAP FUSE PRODUCTION PRODUCTION PRODUCTION) RED/BRN WIRE RED/DK BLU WIRE RED/GRN WIRE RED/GRY WIRE RED/LT GRN WIRE RED/VIO WIRE RED/WHT WIRE RED/YEL WIRE SEAT AUDIO HEATING AMPLIFIER CONTROL MODULE (W/ HEATED SEATS) SEAT DRIVER CUSHION SEAT MEMORY BLOWER CONTROL ASSEMBLY MODULE (W/ HEATED SEATS) TRANSMISSION PARK POSITION RELAY

ACCY/RUN CRNK FUSE APO 1/LTR FUSE APO 2 FUSE APO 3 FUSE APO 4 FUSE APO FUSE BLK WIRE BODY CONTROL MODULE BREAKOUT) CENTER CONSOLE 1 ACCESSORY POWER RECEPTACLE CENTER CONSOLE 2 ACCESSORY POWER RECEPTACLE CENTER CONTROL COMPARTMENT ACCESSORY POWER RECEPTACLE CENTER SEAT ACCESSORY POWER RECEPTACLE COLLISION ALERT INDICATORS EMERGENCY VEHICLE PROVISION (BLUNT CUT) END OF DASH) FROM LT DRS FUSE (DIAGRAM 1 OF 5) FROM TRANSFER UNDERHOOD CASE FUSE BLOCK CONTROL (DIAGRAM MODULE 2 OF 5) FROM USB/OBS DET FUSE (DIAGRAM 4 OF 5) FUSE FUSE BLOCK (LOWER LEFT SIDE OF DASH) GRN/VIO WIRE GRY/VIO WIRE HTD WHL FUSE HVAC CONTROL MODULE HVAC/AUX HVAC IGN IGNITION MAIN RELAY INSIDE REARVIEW MIRROR INSTRUMENT CLUSTER INSTRUMENT PANEL 1 ACCESSORY POWER RECEPTACLE INSTRUMENT PANEL 2 ACCESSORY POWER RECEPTACLE INSTRUMENT PANEL JUNCTION BLOCK IPC IGN/SDM IGN FUSE LT GRN/VIO WIRE MOBILE DEVICE SLIDING SUNROOF WIRELESS REAR MOTOR CHARGER WINDOW MODULE SWITCH PASSENGER AIR BAG DISABLED INDICATOR REAR BODY JUNCTION BLOCK REARVIEW CAMERA RED WIRE RED/BRN WIRE RED/DK BLU WIRE RED/WHT WIRE RETAINED ACCESSORY POWER RELAY 1 RETAINED ACCESSORY POWER RELAY 2 RIGHT INSTRUMENT PANEL FUSE BLOCK (IN RIGHT SEO ALC FUSE SEO RAP FUSE STEERING WHEEL AIR BAG COIL STEERING WHEEL HEATING CONTROL MODULE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VIO/BLK WIRE VIO/GRY WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE W/ DRIVER, PASSENGER SPLIT SEATS W/O DRIVER, PASSENGER SPLIT SEATS