Chevrolet Silverado Classic 1500 HD (2007-2007) blunt cut) Wiring diagrams

4.3L, 8.1L 4.3L: 10 GA- 4.8L, 5.3L, 6.0L ABS FUSE TBC BATT FUSE AUDIO AMPLIFIER AUXILIARY BATTERY RELAY (RIGHT REAR OF ENGINE COMPT) BATTERY (LEFT) BATTERY (RIGHT) BATTERY CABLE JUNCTION BLOCK BLK WIRE BLK/WHT WIRE BLUNT CUT) BRN WIRE CIG LTR FUSE CIGAR LIGHTER COOL FAN FUSE COOL/FAN RELAY 1 COOL/FAN RELAY 2 COOL/FAN RELAY 3 DATA LINK CONNECTOR DIGITAL RADIO RECEIVER DIGITAL RADIO RECEIVER REAR SEAT AUDIO (RSA) CONTROLLER ELECTRONIC BRAKE CONTROL MODULE BODY CONTROL MODULE EMERGENCY VEHICLE ROOF LAMP RELAY EVAPORATIVE EMISSION CANISTER VENT SOLENOID EXCEPT 4.3L EXCEPT LUXURY FUSE FUSIBLE LINK 1 FUSIBLE LINK 4 FUSIBLE LINK 5 FUSIBLE LINK 6 GENERATOR (4.3L, 8.1L) GENERATOR (4.8L, 5.3L, 6.0L) HD TRAILERING EQUIPMENT PROVISIONAL (BLUNT CUT) I/P JUNCTION BLOCK (RIGHT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN A FUSE STUD 2 FUSE IGN B FUSE STUD 1 FUSE LUXURY MEGA FUSE MOBILE RADIO FUSE BLOCK (RIGHT SIDE OF DASH) NCA WIRE NOT USED NOT USED ORG/ WIRE RADIO AMP FUSE RADIO FUSE REAR SEAT AUDIO (RSA) CONTROLLER RADIO RADIO RED WIRE RED/BLK WIRE RELAY RELAY/ FUSE RTD FUSE S/ROOF FUSE RR WPR FUSE EAP FUSE STARTER STARTER RELAY SUNROOF CONTROL MODULE (BEHIND RIGHT SIDE OF DASH, NEAR "A" PILLAR) TO IGNITION SWITCH (DIAGRAM 5 OF 6) TO IGNITION SWITCH (DIAGRAM 6 OF 6) TO IPC/DIC FUSE (DIAGRAM 2 OF 6) TRAILER CONNECTOR (7 WAY) UNDERHOOD COOLING FAN FUSE BLOCK (LEFT SIDE OF ENG COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VSES/ ECAS FUSE FUSE W/ AUX BATTERY W/ WRECKER EMERGENCY LAMP WHEEL TRAILER WIRING PROVISIONAL (BLUNT CUT) WRECKER RELAY

4.3L, 8.1L 4.3L: 10 GA- 4.8L, 5.3L, 6.0L ABS FUSE TBC BATT FUSE AUDIO AMPLIFIER AUXILIARY BATTERY RELAY (RIGHT REAR OF ENGINE COMPT) BATTERY (LEFT) BATTERY (RIGHT) BATTERY CABLE JUNCTION BLOCK BLK WIRE BLK/WHT WIRE BLUNT CUT) BRN WIRE CIG LTR FUSE CIGAR LIGHTER COOL FAN FUSE COOL/FAN RELAY 1 COOL/FAN RELAY 2 COOL/FAN RELAY 3 DATA LINK CONNECTOR DIGITAL RADIO RECEIVER DIGITAL RADIO RECEIVER REAR SEAT AUDIO (RSA) CONTROLLER ELECTRONIC BRAKE CONTROL MODULE BODY CONTROL MODULE EMERGENCY VEHICLE ROOF LAMP RELAY EVAPORATIVE EMISSION CANISTER VENT SOLENOID EXCEPT 4.3L EXCEPT LUXURY FUSE FUSIBLE LINK 1 FUSIBLE LINK 4 FUSIBLE LINK 5 FUSIBLE LINK 6 GENERATOR (4.3L, 8.1L) GENERATOR (4.8L, 5.3L, 6.0L) HD TRAILERING EQUIPMENT PROVISIONAL (BLUNT CUT) I/P JUNCTION BLOCK (RIGHT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN A FUSE STUD 2 FUSE IGN B FUSE STUD 1 FUSE LUXURY MEGA FUSE MOBILE RADIO FUSE BLOCK (RIGHT SIDE OF DASH) NCA WIRE NOT USED NOT USED ORG/ WIRE RADIO AMP FUSE RADIO FUSE REAR SEAT AUDIO (RSA) CONTROLLER RADIO RADIO RED WIRE RED/BLK WIRE RELAY RELAY/ FUSE RTD FUSE S/ROOF FUSE RR WPR FUSE EAP FUSE STARTER STARTER RELAY SUNROOF CONTROL MODULE (BEHIND RIGHT SIDE OF DASH, NEAR "A" PILLAR) TO IGNITION SWITCH (DIAGRAM 5 OF 6) TO IGNITION SWITCH (DIAGRAM 6 OF 6) TO IPC/DIC FUSE (DIAGRAM 2 OF 6) TRAILER CONNECTOR (7 WAY) UNDERHOOD COOLING FAN FUSE BLOCK (LEFT SIDE OF ENG COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VSES/ ECAS FUSE FUSE W/ AUX BATTERY W/ WRECKER EMERGENCY LAMP WHEEL TRAILER WIRING PROVISIONAL (BLUNT CUT) WRECKER RELAY

AUTO PARK BACK-UP LAMPS CIRCUIT BLK WIRE BLK/WHT WIRE BLU WIRE BLUNT CUT (W/ CAMPER BLUNT CUT) BODY CONTROL MODULE (BCM) (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK LT EMERGENCY VEHICLE ROOF LAMP RELAY FRT PARK FUSE GRN WIRE GRY WIRE GRY/BLK WIRE HARN, NEAR TRAILER CONNECTOR BREAKOUT) HAZARD SWITCH HEAD HEADLAMP SWITCH HOT AT ALL TIMES HOT IN RUN, START I/P RELAY BLOCK IGN E FUSE LEFT FRONT MARKER LAMP LEFT FRONT PARK/ TURN SIGNAL LAMP LEFT RIGHT LT BLU WIRE LT GRN WIRE OFF PARK LP RELAY PNK WIRE PRK LMP ON RED WIRE RIGHT FRONT MARKER LAMP RIGHT FRONT PARK/ TURN SIGNAL LAMP SERIAL DATA PRK LMP RLY STUD 1 FUSE STUD 2 FUSE TAN WIRE TO TRL PARK FUSE TRAILER CONNECTOR TURN SIGNAL/ MULTI-FUNCTION SWITCH UNDER- HOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHEEL TRAILER WIRING PROVI- SIONAL) WHT WIRE YEL WIRE

1694 1478 TRANSMISSION SYSTEM 2755 2530 5425 LOW REF FUEL PRESS VOLT INJ + GROUP 4 INJ 6 INJ 3 2931 6265 LOW REF CMP SENSOR SIG 492 432 MAF SENSOR SIG TURBOCHARGER SIG TUR VANE POS SIG APP SENSOR 2 SIG BLK WIRE BLK/WHT WIRE BLUNT CUT) BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (FRONT OF ENGINE, NEAR COOLING FAN PULLEY) COOLANT LEVEL SIG COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM CRUISE SET SW SIG DK BLU WIRE DK BLU/WHT WIRE EGR VAL POS SIG ECT SENSOR SIG ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE SENSOR (TOP OF ENGINE, NEAR OIL FILTER TUBE) ENGINE OIL LEVEL SWITCH (LEFT REAR OF OIL PAN) GRN WIRE GRY WIRE GRY/BLK WIRE IAT SENSOR 2 SIG IAT SENSOR SIG LOW REF LOW REF ENG SHUTOFF SIG CPP SW SIG LOW REF TUR VANE POS INJ + GROUP 3 INJ 5 INJ 4 5930 5423 PPL 845 844 LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE PTO ON SW SIG CRUISE ON SW SIG LOW REF LOW REF 397 552 CRUISE CONTROL SYSTEM RED/BLK WIRE STARTING/ CHARGING SYSTEM STARTER ENABLE FUEL PRESS INJ + GROUP 2 2834 5422 TAN WIRE TAN/WHT WIRE TURBOCHARGER VANE POSITION CONTROL SOLENOID VALVE WATER IN FUEL SENSOR (ON FUEL FILTER ELEMENT) WHT WIRE YEL WIRE YEL/BLK WIRE

2 3 4 5 6 7 8 PNK WIRE 9 10 11 12 13 PNK WIRE AXLE SW SIG BACKUP VOLT BLK WIRE BLK/WHT WIRE BLUNT CUT) BODY RELAY BLOCK BRN WIRE CKP SENSOR SIG CLUTCH PEDAL POSITION SWITCH DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) FRP SENSOR SIG FUEL PRESSURE REGULATOR GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ACC, RUN, START HOT IN RUN BRK FUSE HOT IN RUN, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IGN 0 FUSE IGN 1 INJ 1 INJ 2 INTAKE AIR HEATER FUSE INTAKE AIR TEMPERATURE (IAT) SENSOR 2 (IN AIR INDUCTION TUBE) LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK 1 2 WIRE PNK 23 24 25 26 27 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 28 29 30 31 PPL/WHT WIRE RED WIRE RED/BLK WIRE STOPLAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TRANSMISSION SYSTEM TUR VAN POS UNDER- HOOD FUSE BLOCK (LEFT SIDE ENG COMPT) WATER IN FUEL WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

12 13 14 PNK WIRE 20 21 PPL 3 4 PNK WIRE BLK WIRE BLUNT CUT) BRN WIRE BRN/WHT WIRE CRANKSHAFT POSITION SENSOR (RIGHT SIDE OF ENGINE) CRUISE CONTROL SYSTEM CRUISE FUSE DK BLU WIRE DK GRN/WHT WIRE FOG LP FUSE FUEL PUMP (LEFT SIDE FRAME RAIL) GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IND LOGIC LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OFF ON ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE POWER TAKE OFF RELAY (NEAR UNDERHOOD FUSE BLOCK) POWER TAKE OFF SWITCH PPL PPL 5 6 7 8 PPL/WHT WIRE SET- TAN WIRE TURBOCHARGER VANE POSITION SENSOR UNDERHOOD FUSE BLOCK WHT WIRE WHT/BLK WIRE YEL WIRE

1694 1478 TRANSMISSION SYSTEM 2755 2530 5425 LOW REF FUEL PRESS VOLT INJ + GROUP 4 INJ 6 INJ 3 2931 6265 LOW REF CMP SENSOR SIG 492 432 MAF SENSOR SIG TURBOCHARGER SIG TUR VANE POS SIG APP SENSOR 2 SIG BLK WIRE BLK/WHT WIRE BLUNT CUT) BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (FRONT OF ENGINE, NEAR COOLING FAN PULLEY) COOLANT LEVEL SIG COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM CRUISE SET SW SIG DK BLU WIRE DK BLU/WHT WIRE EGR VAL POS SIG ECT SENSOR SIG ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE SENSOR (TOP OF ENGINE, NEAR OIL FILTER TUBE) ENGINE OIL LEVEL SWITCH (LEFT REAR OF OIL PAN) GRN WIRE GRY WIRE GRY/BLK WIRE IAT SENSOR 2 SIG IAT SENSOR SIG LOW REF LOW REF ENG SHUTOFF SIG CPP SW SIG LOW REF TUR VANE POS INJ + GROUP 3 INJ 5 INJ 4 5930 5423 PPL 845 844 LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE PTO ON SW SIG CRUISE ON SW SIG LOW REF LOW REF 397 552 CRUISE CONTROL SYSTEM RED/BLK WIRE STARTING/ CHARGING SYSTEM STARTER ENABLE FUEL PRESS INJ + GROUP 2 2834 5422 TAN WIRE TAN/WHT WIRE TURBOCHARGER VANE POSITION CONTROL SOLENOID VALVE WATER IN FUEL SENSOR (ON FUEL FILTER ELEMENT) WHT WIRE YEL WIRE YEL/BLK WIRE

2 3 4 5 6 7 8 PNK WIRE 9 10 11 12 13 PNK WIRE AXLE SW SIG BACKUP VOLT BLK WIRE BLK/WHT WIRE BLUNT CUT) BODY RELAY BLOCK BRN WIRE CKP SENSOR SIG CLUTCH PEDAL POSITION SWITCH DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) FRP SENSOR SIG FUEL PRESSURE REGULATOR GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ACC, RUN, START HOT IN RUN BRK FUSE HOT IN RUN, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IGN 0 FUSE IGN 1 INJ 1 INJ 2 INTAKE AIR HEATER FUSE INTAKE AIR TEMPERATURE (IAT) SENSOR 2 (IN AIR INDUCTION TUBE) LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK 1 2 WIRE PNK 23 24 25 26 27 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 28 29 30 31 PPL/WHT WIRE RED WIRE RED/BLK WIRE STOPLAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TRANSMISSION SYSTEM TUR VAN POS UNDER- HOOD FUSE BLOCK (LEFT SIDE ENG COMPT) WATER IN FUEL WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

12 13 14 PNK WIRE 20 21 PPL 3 4 PNK WIRE BLK WIRE BLUNT CUT) BRN WIRE BRN/WHT WIRE CRANKSHAFT POSITION SENSOR (RIGHT SIDE OF ENGINE) CRUISE CONTROL SYSTEM CRUISE FUSE DK BLU WIRE DK GRN/WHT WIRE FOG LP FUSE FUEL PUMP (LEFT SIDE FRAME RAIL) GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IND LOGIC LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OFF ON ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE POWER TAKE OFF RELAY (NEAR UNDERHOOD FUSE BLOCK) POWER TAKE OFF SWITCH PPL PPL 5 6 7 8 PPL/WHT WIRE SET- TAN WIRE TURBOCHARGER VANE POSITION SENSOR UNDERHOOD FUSE BLOCK WHT WIRE WHT/BLK WIRE YEL WIRE

1 2 PNK WIRE BLK WIRE BLK/WHT WIRE BLUNT CUT BLUNT CUT BLUNT CUT) BRK FUSE CRUISE FUSE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (LEFT SIDE OF TIMING COVER) CRUISE CONTROL SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN GRY WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE OIL PRESSURE (EOP) SENSOR (TOP REAR OF ENGINE) FOG LP FUSE FUEL TANK PRESSURE SENSOR (ON FUEL TANK, INTEGRAL TO FUEL PUMP, SENDER ASSEMBLY) GRY LT GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IND LOGIC LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP REAR OF ENGINE, ON INTAKE MANIFOLD) OFF ON SET ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWER TAKE OFF RELAY (NEAR UNDERHOOD FUSE BLOCK) POWER TAKE OFF SWITCH PPL PPL PNK PNK WIRE PPL/WHT WIRE RED WIRE RED/WHT WIRE STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) STOP LP FUSE TAN WIRE TAN/WHT WIRE TRANSMISSIONS SYSTEM UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION/ TRANSFER CASE) WHT WIRE YEL WIRE