Wiring diagram engine performance 6.6l vin 1s, california for Chevrolet Silverado 3500 (2002-2006)

28 29 PPL 508 84 439 440 1868 87 CRUISE CONTROL SYSTEM BATTERY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LEFT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CAN-LOW CAN-HIGH CCP SW CKP SIGNAL CMP SIG ECT SIG OFF/RUN/CRK CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE SENSOR (NEXT TO OIL FILLER TUBE) FUSE GEN 2 TO GROUND LOW REF GRY WIRE GRY/BLK WIRE HOT IN OFF, RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE HOT IN RUN, START IA HTR COOL LEV LOW REF LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE OIL LEV SW ORG/ WIRE ORG/BLK WIRE PLUG SIG PNK WIRE PNK/BLK WIRE PPL PPL IA HTR FICM RELAY LOW REF PPL LOW REF LOW REF RED/BLK WIRE SPLICE PACK STARTING/ CHARGING SYSTEM TAN WIRE UNDER- HOOD FUSE BLOCK VACUUM SENSOR VACUUM SIG WATER IN FUEL SENSOR (ATTACHED TO FUEL FILTER) WATER IN FUEL SET/COAST IGN 1 BATT LOW REF RES/ACC WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

28 29 PPL 30 SERIES 20 SERIES ACCELERATOR PEDAL POSITION SENSOR (BEHIND ACCELERATOR PEDAL) BATTERY BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (FRONT OF ENGINE) DK BLU WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/RED WIRE DK GRN/WHT WIRE ECMB FUSE ECMPRV FUSE FUEL HEATER (TOP OF FUEL FILTER ELEMENT) FUEL PUMP (AUXILIARY TANK (LEFT SIDE FRAME RAIL) FUEL PUMP RELAY FUSE HOLDER GLOW PLUG CONTROLLER GLOW PLUGS GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES BATTERY FUSE HOT IN RUN, START UNDER- HOOD FUSE BLOCK FUEL HT FUSE IGN 1 IGN 1 RELAY INTAKE AIR HEATER (REAR OF ENGINE) INTAKE AIR HEATER RELAY (REAR OF ENGINE) INTAKE AIR TEMPERATURE/ MASS AIRFLOW SENSOR (IN AIR INDUCTION TUBE) LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PLUG 1 V+ PLUG 2 V+ PLUG 3 V+ PLUG 4 V+ PLUG 5 V+ PLUG 6 V+ PLUG 7 V+ PLUG 8 V+ PLUG SIG PNK WIRE PNK/BLK WIRE PPL RED WIRE RED/BLK WIRE RED/GRN WIRE RED/WHT WIRE RELAY CTRL TAN WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

BARO SENSOR (LEFT SIDE OF ENGINE) BLK WIRE BLK/WHT WIRE BOOST SENSOR (ON INTAKE MANIFOLD) CAN HI CAN LOW DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE SPD FUEL INJECTORS FUEL PRESSURE SENSOR FUSE GROUND GRY WIRE GRY/BLK WIRE HOT IN RUN, START HOT IN RUN, START UNDER- HOOD FUSE BLOCK IGN IGN 2,3,5,8 IGN POS INJ 8 INJB FUSE LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/BLU WIRE LT GRN/ORG WIRE LT GRN/PPL WIRE LT GRN/RED WIRE LT GRN/WHT WIRE NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE RED WIRE RED/BLK WIRE TAN WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 GROUND EGR SOL 12 V REDF GROUND LOW REF FUEL PRES REG 5 VOLT REF A/C SYSTEM A/C SYSTEM A/C SYSTEM ANTI-LOCK BRAKE SYSTEM BARO SENS MAF SENS BLK/WHT WIRE BLU WIRE BODY RELAY BLOCK BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION SWITCH (TOP OF PEDAL BRACKET) CRUISE CONTROL SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EGR EGR VALVE VALVE VENT THROTTLE SOLENOID SOLENOID EGR VALVE SOLENOID ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ENGINE SPEED FUEL PRES REG LOW REF F PMP RLY CTRL ENGINE SPD A/C HI PRES APP SENS 3 FUEL LEV SENS FUEL RAIL PRESSURE REGULATOR FUEL TEMPERATURE SENSOR (UNDER UPPER INTAKE SHIELD) FUSE GLOW PLUG RLY GRY WIRE GRY/BLK WIRE HOT IN RUN BRAKE FUSE HOT IN RUN, START IA HTR INSTRUMENT CLUSTER SYSTEM (FUEL LEVEL) INSTRUMENT PANEL CLUSTER LEFT I/P FUSE BLOCK LOW REF APP SENS 1 FUEL TEMP SIG LOW REF FP SENS TCC BRAKE LOW REF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/BLK WIRE PNK IGN 1 VOLT WIRE PNK PNK WIRE PNK WIRE PPL PPL/WHT WIRE RECIRC DOOR A/C CLU RLY RED WIRE SOUND SYSTEM STARTING SYSTEM STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TRANS. SYSTEM TRANSMISSION CONTROL MODULE (LEFT FRONT OF ENG COMPT) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANS) VEHICLE SPEED SENSOR ADAPTER WAIT TO RPM OUT WAIT TO START WHT WIRE YEL WIRE YEL/BLK WIRE