Chevrolet Silverado 3500 (2002-2006) tan Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 TP SENSOR 1 SIG ACCELERATION PEDAL POSITION SENSOR (BEHIND ACCELERATOR PEDAL) APP SENSOR 1 SIG BLK WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL ON/OFF SWITCH CRUISE FUSE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ETC FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, START LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOW REF APP SENSOR 3 SIG LOW REF LOW REF APP SENSOR 2 SIG PPL LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) OFF ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ACCEL SERIAL DATA SET/COAST STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) TAN WIRE THROTTLE ACTUATOR CONTROL MOTOR (ON THROTTLE BODY) THROTTLE POSITION SENSOR (ON THROTTLE BODY ASSEMBLY) UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

ABS FUSE ABS IND PNK WIRE BLK WIRE BLK/WHT WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH, NEAR KICK PANEL) BRAKE FLUID LEVEL SW IN BRAKE FLUID LEVEL SWITCH (ON LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE FUSE BRAKE IND BRAKE INPUT SERIAL DATA BRN WIRE CLUTCH START SWITCH (TOP OF CLUTCH CLUTCH ASSY) CPP SW SIG DIESEL DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) ENGINE CONTROLS SYSTEM FRONT AXLE ACT/SW INPUT VSS INPUT LEFT FRONT SENSOR (+) RIGHT FRONT SENSOR (-) FRONT AXLE ACTUATOR/ SWITCH (ON AXLE HOUSING) GAS GROUND MOTOR, SOLENOID PWR GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGN 1 FUSE IGNITION LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOGIC LT BLU WIRE LT GRN/BLK WIRE M/T ONLY NCA WIRE OF TRANSFER CASE) PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL/ PPL/ PPL/ PPL/ PPL/WHT WIRE RED WIRE RIGHT FRONT WHEEL SPEED SENSOR SIDE OF TRANSMISSION) STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TRANSFER CASE SHIFT CONTROL MODULE (LEFT SIDE OF DASH, BEHIND HEADLAMP SWITCH) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW VSS OUTPUT WHT WIRE YEL WIRE YEL/BLK WIRE

ABS FUSE ABS IND. BLK WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH, NEAR KICK PANEL) BRAKE FLUID LEVEL SWITCH (ON LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE FUSE BRAKE IN BRAKE IND BRN WIRE BRN/WHT WIRE DEL TORQUE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) GAS DIESEL GROUND DISTRIBUTION SYSTEM GROUND MOTOR, SOLENOID PWR GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGN 1 FUSE IGNITION LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) DELIVERED TORQUE INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOGIC LOW TRACTION INDICATOR ILLUM LAMP LT BLU WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) ORG/BLK WIRE PNK PNK POWER DISTRIBUTION SYSTEM WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) PPL PPL 1122 832 PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL/WHT WIRE RED WIRE REQ TORQUE RIGHT FRONT WHEEL SPEED SENSOR SERVICE TRAC CNTL SIG SIDE OF TRANSMISSION) STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TRACTION CONTROL SWITCH TRACTION OFF INDICATOR UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW VSS OUT WHT WIRE YEL WIRE YEL/BLK WIRE

A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND GROUND TEMP SEN ASS CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LOWER LEFT AIR TEMPERATURE SENSOR (LEFT END OF HVAC MODULE) LOWER RIGHT AIR TEMPERATURE SENSOR (BOTTOM OF HVAC MODULE) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UPPER LEFT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) UPPER RIGHT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) WHT WIRE WHT/BLK WIRE YEL WIRE

11 12 PPL AMBIENT LIGHT SENS LO REF AMBIENT LIGHT SENS SIG RIGHT SUNLOAD SENSOR SIG LEFT SUNLOAD SENSOR SIG AMBIENT LIGHT SENSOR BLK WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE GRY WIRE LEFT AIR TEMPERATURE ACTUATOR (BOTTOM OF HVAC MODULE) LEFT SOLAR SENSOR LOGIC LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) PPL RECIRCULATION ACTUATOR (UPPER RIGHT OF HVAC MODULE) RIGHT AIR TEMPERATURE ACTUATOR (TOP OF HVAC MODULE) RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT SOLAR SENSOR SUNLOAD SENSOR ASSEMBLY (TOP CENTER OF DASH) TAN WIRE WHT WIRE WHT/BLK WIRE YEL WIRE

AMBIENT LIGHT SENSOR (TOP CENTER OF DASH) ANTI-THEFT SYSTEM ANTI-THEFT SYSTEM DOOR LOCKS SYSTEM BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY RELAY BLOCK (NEAR LEFT KICK PANEL) BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRN WIRE CARGO LP SW INPUT INTERIOR LAMP CTRL FLASH TO PASS SW SIG DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DOOR LATCH SW SIG COURTESY LAMP PWR DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM DRIVER DOOR KEY SW SIG LF DR OPEN SW SIG FRONT FOG LP SW INT LP DEFEAT SW SIG DRL RLY COIL CLASS 2 DATA GROUND IGN 1 EXTERIOR LIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM FOG LP RLY CTRL EXTERIOR COURTESY LPS RLY CTRL GROUND BATTERY DOOR UNLOCK CTRL DOOR LOCK CTRL GRY WIRE GRY/BLK WIRE HEADLAMP SW INPUT LED DIM SIG VSS HEADLIGHTS SYSTEM COMPUTER DATA LINES SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM ENGINE CONTROLS SYSTEM HOT AT ALL TIMES TBC FUSE HOT IN RUN CRUISE FUSE HOT IN RUN, START IGN 1 FUSE IGN 3 PRK BK SW SIG LT SEAT BELT SW TOW/HAUL SW SIG IGNITION KEY ALARM SWITCH INST PANEL LP PWR AMBIENT LIGHT SEN SIG INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM KEY IN IGN SW SIG LEFT I/P FUSE BLOCK LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT TURN SIG LAMP PWR RT TURN SIG LAMP PWR NCA WIRE ORG/ WIRE ORG/BLK WIRE PARK BRAKE SWITCH PNK WIRE POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM (RAP) INTERIOR LIGHTS SYSTEM HORNS SYSTEM PPL PPL HIGH BEAM INPUT INTERIOR PARK LP PWR PPL/WHT WIRE RAP RELAY CTRL INADVERTENT PWR RLY CTRL HORN RLY CTRL RED/WHT WIRE SECURITY SYSTEM SEN SIG SERIAL DATA TAN WIRE TOW/HAUL SWITCH UNDERHOOD JUNCTION BLOCK WARNING SYSTEM WHT WIRE YEL WIRE

5 20 22 DOOR AJAR SW SIG DOOR SW LO REF SERIAL DATA AJAR SW BASE BATTERY PK LAMP REL HEADLIGHTS CTRL GROUND HORN RLY CTRL SERIAL DATA BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE BRN WIRE CLASS 2 DATA DK BLU WIRE DK GRN WIRE DRIVER DOOR LATCH ASSEMBLY (REAR OF DRIVER'S DOOR) DRIVER DOOR MODULE EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM FRONT PASSENGER DOOR LATCH ASSEMBLY (REAR OF RIGHT FRONT DOOR) FRONT PASSENGER DOOR MODULE GROUND GRY WIRE GRY/BLK WIRE HORNS SYSTEM HOT AT ALL TIMES I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) I/P JUNCTION BLOCK (RIGHT SIDE OF DASH, BEHIND PANEL) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) INSIDE DRIVER DOOR) INSTRUMENT PANEL CLUSTER (IPC) KEY SW LEFT REAR DOOR LATCH ASSEMBLY (CREW CAB) (REAR OR LEFT REAR DOOR) LOGIC LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK/WHT WIRE RF DOOR AJAR SW LF DOOR AJAR SW RIGHT REAR DOOR LATCH ASSEMBLY (CREW CAB) (REAR OR RIGHT REAR DOOR) RR DOOR AJAR SW LR DOOR AJAR SW SECURITY INDICATOR SPLICE PACK TAN WIRE TBC BATT FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE

BLK WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE HOT AT ALL TIMES HOT IN HVAC CONTROL MODULE (BEHIND CENTER OF DASH) I/P FUSE BLOCK (LOWER LEFT I/P JUNCTION FUSE BLOCK (LOWER RIGHT SIDE OF DASH) LT BLU WIRE OFF ORG/ WIRE PPL RED WIRE RUN WIRE SIDE OF DASH) HTR A/C FUSE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) YEL WIRE

A/C COMP RELAY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C FUSE A/C HIGH PRESSURE RECIRCULATION SWITCH (IN A/C MUFFLER HOSE) A/C HIGH PRESSURE SWITCH (REAR OF COMPRESSOR) A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C REQUEST A/C SWITCH AIR TEMPERATURE ACTUATOR (BOTTOM CENTER OF BLK WIRE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR RELAY ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BLOWER RELAY BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRN WIRE CTRL RECIRC DOOR DEFOGGER SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT HVAC FUSE GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL ASSEMBLY HVAC CONTROL MODULE (BEHIND CENTER OF DASH) IGN E FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LOW OFF LT BLU WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT FRONT OF ENGINE OF ENGINE COMPT) PPL PRESS SW A/C HIGH REAR DEFOG RLY IGN 3 VOL A/C REQUEST ACT POS SIG RECIRCULATION ACTUATOR (TOP OF HVAC MODULE) RED WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE YEL WIRE

11 11 17 17 (GASOLINE) (DIESEL) A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C FUSE A/C HIGH PRESS SW A/C HIGH PRESSURE RECIRCULATING SWITCH (IN A/C MUFFLER HOSE) A/C HIGH PRESSURE SWITCH (REAR OF COMPRESSOR) A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C REQUEST A/C SWITCH AIR TEMPERATURE ACTUATOR (BOTTOM CENTER OF BLK WIRE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BLOWER RELAY BRN WIRE DEFOGGER SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT HVAC FUSE GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC MODULE IGN E FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LO OFF LT BLU WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT FRONT OF ENGINE COMPT) PPL REAR DEFOG RLY IGN 3 VOL A/C REQUEST ACT POS SIG RECIRC DOOR CTRL RECIRCULATION ACTUATOR (TOP OF HVAC MODULE) RED WIRE RELAY CTRL A/C COMP RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE YEL WIRE