Chevrolet Silverado 3500 (2002-2006) low ref Wiring diagrams

A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND GROUND TEMP SEN ASS CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LOWER LEFT AIR TEMPERATURE SENSOR (LEFT END OF HVAC MODULE) LOWER RIGHT AIR TEMPERATURE SENSOR (BOTTOM OF HVAC MODULE) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UPPER LEFT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) UPPER RIGHT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) WHT WIRE WHT/BLK WIRE YEL WIRE

80 13 45 27 14 35 43 31 58 9 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) BLK WIRE CLASS 2 SER DATA LO PRESS SENS SIG CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE GRY WIRE HOT AT ALL TIMES A/C COMP FUSE HOT IN RUN OR START IGN E FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) LOGIC LOW REF POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) RED WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE

10 12 PNK WIRE 16 5 PNK WIRE 8 7 PNK WIRE AIR TEMP SENSOR AIRBAG FUSE AMBIENT PHOTO SENSOR BACK UP LAMP VOLTAGE OUTPUT BACK UP VOLTAGE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY RELAY BLOCK COMPASS COMPUTER DATA LINES SYSTEM DK GRN/WHT WIRE DRIVER DOOR MODULE (DDM) (IN DRIVER'S DOOR) DRIVER OUTSIDE REARVIEW MIRROR ELECTROCHROMIC MIRROR EXTERIOR LIGHTS SYSTEM (BACK-UP CIRCUIT) GROUND GRY WIRE HOT IN RUN, START IGN 3 INSIDE REARVIEW MIRROR LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LOW REF LOW REF MIR SIGNAL LT GRN WIRE OUTSIDE AIR TEMPERATURE SENSOR (AT CENTER OF CORE SUPPORT, BEHIND GRILLE) PNK WIRE RR LIGHT PHOTO SENSOR SELECTOR SWITCH SERIAL DATA TEMP UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) YEL WIRE

22 14 SERIAL DATA BATTERY 7 8 SUPPLY VOLT LOW REF BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DDM FUSE DRIVER DOOR MODULE (DDM) (IN DRIVER'S DOOR) DRIVER OUTSIDE REARVIEW MIRROR FRONT PASSENGER DOOR MODULE (FPDM) (IN RIGHT FRONT DOOR) GROUND HOT AT ALL TIMES HVAC CONTROL MODULE (IN CENTER OF DASH) I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) LOW REF ORG/ WIRE PASSENGER OUTSIDE REARVIEW MIRROR PDM FUSE R DEF REAR DEFOG SWITCH SERIAL DATA SUPPLY VOLT TAN WIRE WHT WIRE

A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT DEF GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE CONTROL MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF OFF BLOW MT CTRL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RECIRC SWITCH RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE WHT/BLK WIRE YEL WIRE

ANTI-LOCK BRAKE SYSTEM B+ CLS 2 DATA CLS 2 DATA SENS GND REF LOW BLK WIRE BLK/WHT WIRE BODY CONTROL THEFT DETERRENT MODULE (BELOW CONTROL STEERING MODULE COLUMN) BRN WIRE BRN/RED WIRE COOLANT LEV DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECMB FUSE ELECTRONIC SUSPENSION SYSTEM FUSE GND GND GRY WIRE HOT AT ALL TIMES HOT IN RUN, START HOT IN RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE INJA FUSE FUSE INJB FUSE INJECTORS KS SIGNAL KS SIGNAL CKP REQ TORQUE SERIAL DATA SERIAL DATA LIFT/DIVE SIG LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OIL LEV ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK PPL WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL SENS GND PPL/WHT WIRE PRND A BRK SW PRND P PPL PRND B CMP ECT SIG IGN RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE SENS GND SENS GND EGR INPUT SENS RTN TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK W/ REMOTE FUNCTION ACTUATOR W/O REMOTE FUNCTION ACTUATOR WHT WIRE YEL WIRE YEL/BLK WIRE

ANTI-LOCK BRAKE SYSTEM B+ CLS 2 DATA CLS 2 DATA SENS GND REF LOW BLK WIRE BLK/WHT WIRE BODY CONTROL THEFT DETERRENT MODULE (BELOW CONTROL STEERING MODULE COLUMN) BRN WIRE BRN/RED WIRE COOLANT LEV DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECMB FUSE ELECTRONIC SUSPENSION SYSTEM FUSE GND GND GRY WIRE HOT AT ALL TIMES HOT IN RUN, START HOT IN RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE INJA FUSE FUSE INJB FUSE INJECTORS KS SIGNAL KS SIGNAL CKP REQ TORQUE SERIAL DATA SERIAL DATA LIFT/DIVE SIG LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OIL LEV ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK PPL WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL SENS GND PPL/WHT WIRE PRND A BRK SW PRND P PPL PRND B CMP ECT SIG IGN RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE SENS GND SENS GND EGR INPUT SENS RTN TAN WIRE UNDER- HOOD FUSE BLOCK W/ REMOTE FUNCTION ACTUATOR W/O REMOTE FUNCTION ACTUATOR WHT WIRE YEL WIRE YEL/BLK WIRE

28 29 PPL 508 84 439 440 1868 87 CRUISE CONTROL SYSTEM BATTERY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LEFT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CAN-LOW CAN-HIGH CCP SW CKP SIGNAL CMP SIG ECT SIG OFF/RUN/CRK CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE SENSOR (NEXT TO OIL FILLER TUBE) FUSE GEN 2 TO GROUND LOW REF GRY WIRE GRY/BLK WIRE HOT IN OFF, RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE HOT IN RUN, START IA HTR COOL LEV LOW REF LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE OIL LEV SW ORG/ WIRE ORG/BLK WIRE PLUG SIG PNK WIRE PNK/BLK WIRE PPL PPL IA HTR FICM RELAY LOW REF PPL LOW REF LOW REF RED/BLK WIRE SPLICE PACK STARTING/ CHARGING SYSTEM TAN WIRE UNDER- HOOD FUSE BLOCK VACUUM SENSOR VACUUM SIG WATER IN FUEL SENSOR (ATTACHED TO FUEL FILTER) WATER IN FUEL SET/COAST IGN 1 BATT LOW REF RES/ACC WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BATTERY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LEFT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CAN-LOW CAN-HIGH CCP SW CKP SIGNAL CMP SIG ECT SIG OFF/RUN/CRK COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) CRANKSHAFT POSITION SENSOR (RIGHT SIDE OF HARMONIC BALANCER) CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE SENSOR (NEXT TO OIL FILLER TUBE) ENGINE OIL LEVEL SWITCH (LEFT REAR OF OIL PAN) FUSE GEN 2 TO GROUND LOW REF GRY WIRE GRY/BLK WIRE HOT IN OFF, RUN, START HOT IN RUN, START IA HTR DIAG 1 COOL LEV IGN 0 FUSE LEFT I/P FUSE BLOCK LOW REF LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE OIL LEV SW ORG/ WIRE ORG/BLK WIRE PLUG SIG PNK WIRE PNK/BLK WIRE PPL PPL 28 29 PPL IA HTR RLY FICM RELAY LOW REF PPL LOW REF LOW REF RED/BLK WIRE SPLICE PACK STARTING/ CHARGING SYSTEM TAN WIRE UNDER- HOOD FUSE BLOCK WATER IN FUEL SENSOR (ATTACHED TO FUEL FILTER) WATER IN FUEL SET/COAST IGN 1 BATT LOW REF RES/ACC WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

B+ CLS 2 DATA CLS 2 DATA SENS RTN REF LOW BLK WIRE BLK/WHT WIRE BLUNT CUT) BODY CONTROL MODULE (BELOW STEERING COLUMN) BRN WIRE BRN/RED WIRE CMP ECT SIG IGN COOLANT LEV DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECMB FUSE FUSE GND SENS GND PPL GRY WIRE HOT AT ALL TIMES HOT IN RUN, START HOT IN RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE INJA FUSE FUSE INJB FUSE INJECTORS KS SIGNAL CKP REQ TORQUE SERIAL DATA SERIAL DATA KS SIGNAL PTO STATUS LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OIL LEV PTO ENG KILL ORG/ WIRE ORG/BLK WIRE PNK IGN B+ REF LOW PTO ENABLE SENS GND WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL BRK SW P/N SW CLUTCH SW PPL PPL PPL PTO ENGAGE PPL/WHT WIRE RED/BLK WIRE SENS GND EGR INPUT TAN WIRE TRANSMISSION CONTROL SYSTEM UNDER- HOOD JUNCTION BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE