Chevrolet Silverado 3500 (2002-2006) left i/p fuse block Wiring diagrams

AMBIENT LIGHT SENSOR (TOP CENTER OF DASH) ANTI-THEFT SYSTEM ANTI-THEFT SYSTEM DOOR LOCKS SYSTEM BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY RELAY BLOCK (NEAR LEFT KICK PANEL) BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRN WIRE CARGO LP SW INPUT INTERIOR LAMP CTRL FLASH TO PASS SW SIG DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DOOR LATCH SW SIG COURTESY LAMP PWR DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM DRIVER DOOR KEY SW SIG LF DR OPEN SW SIG FRONT FOG LP SW INT LP DEFEAT SW SIG DRL RLY COIL CLASS 2 DATA GROUND IGN 1 EXTERIOR LIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM FOG LP RLY CTRL EXTERIOR COURTESY LPS RLY CTRL GROUND BATTERY DOOR UNLOCK CTRL DOOR LOCK CTRL GRY WIRE GRY/BLK WIRE HEADLAMP SW INPUT LED DIM SIG VSS HEADLIGHTS SYSTEM COMPUTER DATA LINES SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM ENGINE CONTROLS SYSTEM HOT AT ALL TIMES TBC FUSE HOT IN RUN CRUISE FUSE HOT IN RUN, START IGN 1 FUSE IGN 3 PRK BK SW SIG LT SEAT BELT SW TOW/HAUL SW SIG IGNITION KEY ALARM SWITCH INST PANEL LP PWR AMBIENT LIGHT SEN SIG INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM KEY IN IGN SW SIG LEFT I/P FUSE BLOCK LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT TURN SIG LAMP PWR RT TURN SIG LAMP PWR NCA WIRE ORG/ WIRE ORG/BLK WIRE PARK BRAKE SWITCH PNK WIRE POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM (RAP) INTERIOR LIGHTS SYSTEM HORNS SYSTEM PPL PPL HIGH BEAM INPUT INTERIOR PARK LP PWR PPL/WHT WIRE RAP RELAY CTRL INADVERTENT PWR RLY CTRL HORN RLY CTRL RED/WHT WIRE SECURITY SYSTEM SEN SIG SERIAL DATA TAN WIRE TOW/HAUL SWITCH UNDERHOOD JUNCTION BLOCK WARNING SYSTEM WHT WIRE YEL WIRE

ACT CNTRL APP SENS 1 APP SENS 2 APP SENS 3 BLK WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL SYSTEM CRUISE REQ DATA DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECT FUSE FUSE GROUND GRY WIRE GRY/BLK WIRE HOT IN RUN OR START HOT IN RUN, START IAT SENSOR INTAKE AIR TEMPERATURE/ MASS AIRFLOW SENSOR (IN AIR INTAKE DUCT) IGN LEFT I/P FUSE BLOCK LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PPL PPL PNK PNK WIRE PPL/WHT WIRE R/A INPUT RED WIRE RED/BLK WIRE S/C INPUT SENS 1 GRD SENS 2 GRD SENS 3 GRD SENS GRD SIGNAL STP LP IN TAN WIRE THROTTLE POSITION SENSOR (W/ ELECTRONIC THROTTLE CONTROL) (ON THROTTLE BODY) TP SENS 1 TP SENS 2 UNDERHOOD FUSE BLOCK VEH STOP FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C CLU A/C REQ A/C SYSTEM A/C SYSTEM 1310 419 1223 1222 1827 ANTI-LOCK BRAKE SYSTEM ANTI-LOCK BRAKE SYSTEM (SPEED SIGNAL) AUTOMATIC TRANS- MISSION INPUT SHAFT SPEED SENSOR BLK WIRE BLK/ GRY WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE ENG CTRL DELIVERED TORQ PC SOL HI EGR CTRL PC SOL LO FUEL PMP RPM OUT RECIRC SW DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EVAP VENT MIL CTRL 2-3 SS 1-2 SS VSS OUT VSS OUT TFT SENS SIG GEN F FUSE GEN L GRY WIRE GRY/BLK WIRE HOT IN RUN, START IAC COIL HI IAC COIL LO IAC COIL LO IAC COIL HI IDLE AIR CONTROL VALVE (TOP OF THROTTLE BODY) IGN IGN CTRL IGN CTRL IGN CTRL IGN CTRL IGN FEED GND EGR GND IGNITION COILS INSTRUMENT CLUSTER SYSTEMS (SPEED SIGNAL) INSTRUMENT PANEL CLUSTER MALFUNCTION INDICATOR LAMP LEFT I/P FUSE BLOCK LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MAF SIG MAP SIG RECIRC DOOR EVAP CANP NCA WIRE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL FUEL LEV CYC SW IN PPL PNK PNK WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE REF LO REF LOW REF LOW PRND C TRANS RNG A FUEL SIG CTRL RPM OUT SEC FUEL LVL SENS GND SPARK PLUG SPARK SPARK PLUG PLUG STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TP SIG IAT SIG IGN CTRL IGN CTRL IGN CTRL IGN CTRL TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLIGHT SWITCH) UNDERHOOD FUSE BLOCK VSS LOW VSS HIGH WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SOL 2-3 SOL A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSAXLE BLK WIRE BLU WIRE BODY RELAY BLOCK BRAKE FUSE BRN WIRE BRN/RED WIRE CAMSHAFT POSITION SENSOR (TOP CENTER REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EVAP CANISTER PURGE SOLENOID (TOP RIGHT REAR OF ENGINE) EVAP CANISTER VENT SOLENOID (RIGHT FRONT SIDE OF FUEL TANK) EXHAUST GAS RECIRCULATION VALVE (TOP RIGHT FRONT OF ENGINE) FUEL TANK PRESSURE SENSOR (IN FUEL TANK) GRY DK GRN WIRE GRY WIRE HOT IN RUN HOT IN RUN, START LEFT I/P FUSE BLOCK LT BLU WIRE LT BLU/WHT WIRE LT GRN GRY WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP REAR OF ENGINE) ORG/ WIRE ORG/BLK WIRE PC SOL VALVE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PNK WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE REV STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) STOP LPS FUSE TAN WIRE TCC PWM SOL TFT SENSOR UNDER- HOOD FUSE BLOCK VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR ADAPTER WHT WIRE YEL WIRE YEL/BLK WIRE

ACT CNTRL APP SENS 1 APP SENS 2 APP SENS 3 BLK WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL SYSTEM CRUISE REQ DATA DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECT FUSE FUSE GROUND GRY WIRE GRY/BLK WIRE HOT IN RUN OR START HOT IN RUN, START IAT SENSOR INTAKE AIR TEMPERATURE/ MASS AIRFLOW SENSOR (IN AIR INTAKE DUCT) IGN LEFT I/P FUSE BLOCK LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PPL PPL PNK PNK WIRE PPL/WHT WIRE R/A INPUT RED WIRE RED/BLK WIRE S/C INPUT SENS 1 GRD SENS 2 GRD SENS 3 GRD SENS GRD SIGNAL STP LP IN TAN WIRE THROTTLE POSITION SENSOR (W/ ELECTRONIC THROTTLE CONTROL) (ON THROTTLE BODY) TP SENS 1 TP SENS 2 UNDERHOOD FUSE BLOCK VEH STOP FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 PNK PNK WIRE 29 30 31 PNK WIRE A/C CLU A/C REQ A/C SYSTEM A/C SYSTEM 1310 419 1223 1222 1827 ANTI-LOCK BRAKE SYSTEM ANTI-LOCK BRAKE SYSTEM (SPEED SIGNAL) AUTOMATIC TRANS- MISSION INPUT SHAFT SPEED SENSOR BLK WIRE BLK/ GRY WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE ENG CTRL DELIVERED TORQ PC SOL HI EGR CTRL PC SOL LO FUEL PMP RPM OUT RECIRC SW DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EVAP VENT MIL CTRL 2-3 SS 1-2 SS VSS OUT VSS OUT TFT SENS SIG GEN F FUSE GEN L GRY WIRE GRY/BLK WIRE HOT IN RUN, START IAC COIL HI IAC COIL LO IAC COIL LO IAC COIL HI IDLE AIR CONTROL VALVE (TOP OF THROTTLE BODY) IGN IGN CTRL IGN CTRL IGN CTRL IGN CTRL IGN FEED GND EGR GND IGNITION COILS INSTRUMENT CLUSTER SYSTEMS (SPEED SIGNAL) INSTRUMENT PANEL CLUSTER MALFUNCTION INDICATOR LAMP LEFT I/P FUSE BLOCK LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MAF SIG MAP SIG RECIRC DOOR EVAP CANP NCA WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL FUEL LEV CYC SW IN PPL PNK PNK WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE REF LO REF LOW REF LOW PRND C TRANS RNG A FUEL SIG CTRL RPM OUT SEC FUEL LVL SENS GND SPARK PLUG SPARK SPARK PLUG PLUG STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TP SIG IAT SIG IGN CTRL IGN CTRL IGN CTRL IGN CTRL TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLIGHT SWITCH) UNDERHOOD FUSE BLOCK VSS LOW VSS HIGH WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 GROUND EGR SOL 12 V REDF GROUND LOW REF FUEL PRES REG 5 VOLT REF A/C SYSTEM A/C SYSTEM A/C SYSTEM ANTI-LOCK BRAKE SYSTEM BARO SENS MAF SENS BLK/WHT WIRE BLU WIRE BODY RELAY BLOCK BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION SWITCH (TOP OF PEDAL BRACKET) CRUISE CONTROL SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EGR EGR VALVE VALVE VENT THROTTLE SOLENOID SOLENOID EGR VALVE SOLENOID ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ENGINE SPEED FUEL PRES REG LOW REF F PMP RLY CTRL ENGINE SPD A/C HI PRES APP SENS 3 FUEL LEV SENS FUEL RAIL PRESSURE REGULATOR FUEL TEMPERATURE SENSOR (UNDER UPPER INTAKE SHIELD) FUSE GLOW PLUG RLY GRY WIRE GRY/BLK WIRE HOT IN RUN BRAKE FUSE HOT IN RUN, START IA HTR INSTRUMENT CLUSTER SYSTEM (FUEL LEVEL) INSTRUMENT PANEL CLUSTER LEFT I/P FUSE BLOCK LOW REF APP SENS 1 FUEL TEMP SIG LOW REF FP SENS TCC BRAKE LOW REF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/BLK WIRE PNK IGN 1 VOLT WIRE PNK PNK WIRE PNK WIRE PPL PPL/WHT WIRE RECIRC DOOR A/C CLU RLY RED WIRE SOUND SYSTEM STARTING SYSTEM STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TRANS. SYSTEM TRANSMISSION CONTROL MODULE (LEFT FRONT OF ENG COMPT) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANS) VEHICLE SPEED SENSOR ADAPTER WAIT TO RPM OUT WAIT TO START WHT WIRE YEL WIRE YEL/BLK WIRE

BATTERY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LEFT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CAN-LOW CAN-HIGH CCP SW CKP SIGNAL CMP SIG ECT SIG OFF/RUN/CRK COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) CRANKSHAFT POSITION SENSOR (RIGHT SIDE OF HARMONIC BALANCER) CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE SENSOR (NEXT TO OIL FILLER TUBE) ENGINE OIL LEVEL SWITCH (LEFT REAR OF OIL PAN) FUSE GEN 2 TO GROUND LOW REF GRY WIRE GRY/BLK WIRE HOT IN OFF, RUN, START HOT IN RUN, START IA HTR DIAG 1 COOL LEV IGN 0 FUSE LEFT I/P FUSE BLOCK LOW REF LOW REF LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE OIL LEV SW ORG/ WIRE ORG/BLK WIRE PLUG SIG PNK WIRE PNK/BLK WIRE PPL PPL 28 29 PPL IA HTR RLY FICM RELAY LOW REF PPL LOW REF LOW REF RED/BLK WIRE SPLICE PACK STARTING/ CHARGING SYSTEM TAN WIRE UNDER- HOOD FUSE BLOCK WATER IN FUEL SENSOR (ATTACHED TO FUEL FILTER) WATER IN FUEL SET/COAST IGN 1 BATT LOW REF RES/ACC WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 GROUND 12 V REDF GROUND LOW REF FUEL PRES REG 5 VOLT REF A/C SYSTEM A/C SYSTEM A/C SYSTEM ANTI-LOCK BRAKE SYSTEM BARO SENS MAF SENS BLK/WHT WIRE BLU WIRE BODY RELAY BLOCK BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION SWITCH (TOP OF PEDAL BRACKET) CRUISE CONTROL SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ENGINE SPEED FUEL PRES REG LOW REF F PMP RLY CTRL ENGINE SPD A/C HI PRES APP SENS 3 FUEL LEV SENS FUEL RAIL PRESSURE REGULATOR FUEL TEMPERATURE SENSOR (UNDER UPPER INTAKE SHIELD) FUSE GLOW RLY CTRL GRY WIRE GRY/BLK WIRE HOT IN RUN BRAKE FUSE HOT IN RUN, START IA HTR DIAG 2 INSTRUMENT CLUSTER SYSTEM (FUEL LEVEL) INSTRUMENT PANEL CLUSTER LEFT I/P FUSE BLOCK LOW REF APP SENS 1 FUEL TEMP SIG LOW REF FP SENS TCC BRAKE LOW REF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CTRL NCA WIRE ORG/BLK WIRE PNK IGN 1 VOLT WIRE PNK WIRE PPL PPL/WHT WIRE RECIRC DOOR A/C CLU RLY RED WIRE SOUND SYSTEM STARTING SYSTEM STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TRANS. SYSTEM TRANSMISSION CONTROL MODULE (LEFT FRONT OF ENG COMPT) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANS) VEHICLE SPEED SENSOR ADAPTER VSS VSS IAT SENS GEN F TCM MIL FUEL LEV SENS A/C LOW WAIT TO RPM OUT WAIT TO START WHT WIRE YEL WIRE YEL/BLK WIRE

18 19 PPL PNK PNK WIRE A/T BLK WIRE BLK/WHT WIRE BLUNT CUT) BODY JUNCTION BLOCK BRAKE FUSE BRN WIRE BRN/RED WIRE CAMSHAFT POSITION SENSOR (LEFT SIDE OF TIMING COVER) CLUTCH PEDAL POSITION SWITCH (TOP OF PEDAL BRACKET) CRUISE CONTROL SYSTEM CRUISE FUSE DEL TORQUE DK BLU WIRE DK BLU/WHT WIRE DK GRN GRY WIRE DK GRN WIRE DK GRN/WHT WIRE EVAP CANISTER PURGE VALVE (TOP RIGHT REAR OF ENGINE) EXHAUST GAS RECIRCULATION VALVE (TOP REAR OF ENGINE) FOG LAMPS FUSE FUEL TANK PRESSURE SENSOR (IN FUEL TANK) GRY LT GRN WIRE GRY WIRE HOT IN HOT IN RUN, START IND LOGIC LEFT I/P FUSE BLOCK LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE M/T MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP REAR OF ENGINE) MIL REQ OFF ON SET ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE POWER TAKE OFF RELAY (UNDER- HOOD JUNCTION BLOCK) POWER TAKE OFF SWITCH PPL PPL PNK PNK WIRE PPL/WHT WIRE RED WIRE RED/WHT WIRE REQ TORQUE RUN WIRE STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) STOP LPS FUSE TAN WIRE TAN/BLK WIRE UNDER- HOOD JUNC- TION BLOCK UNM TOR VSS VSS ADAPTER (LEFT SIDE OF TRANS) VSS SIG WHT WIRE YEL WIRE