Chevrolet Silverado 3500 (2002-2006) gry Wiring diagrams

A/T ISS SIG LOW VSS SIG LOW A/T SHIFT LEVER ALLISON TRANSMISSION BLK WIRE BLK/WHT WIRE BRAKE FUSE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CRNK FUSE DATA BUS H DATA BUS L DK BLU WIRE DK BLU/BLK WIRE DK GRN WIRE FLD PRESS SW SIG 4 TCC PCS LOW FLD PRESS SW SIG 2 TURB SPEED SW SIG GRD GRD B+ GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IGN 0 FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN MALFUNC IND LAMP NCA WIRE ORG/ WIRE ORG/WHT WIRE PNK 10 11 12 WIRE PNK 7 8 9 WIRE PNK FLD PRESS SW SIG 1 VSS SIG HIGH WIRE PNK IGN 0 VOLT WIRE PNK PNK PNK WIRE PNK PPL WIRE PNK WIRE PPL PPL CRANK VOLT PPL PPL 1 2 PPL/WHT WIRE PRESS CONTROL SOLE 2 PTO SIG RANGE SW SIG A MAIN PRESS SOLENOID RED WIRE RED/BLK WIRE RUN WIRE SERIAL DATA DATA BUS L SHIFT SOLENOIDS SOLENOIDS STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TAN/WHT WIRE TCC PSC TR SW SIG B TFT SENSOR SIG TR SW SIG C TR SW SIG P TURB SPEED SW UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) TCM B FUSE WHT WIRE YEL WIRE YEL/BLK WIRE

56 39 PNK IGNITION PARK/NEUTRAL SIG WIRE ALLISON TRANSMISSION BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DATA LINK CONNECTOR DK BLU WIRE DK BLU/BLK WIRE DK GRN WIRE ENGINE CONTROLS SYSTEM EXCEPT SEO FUSE GRY WIRE HOT AT ALL TIMES INPUT SPEED SENSOR (IN TRANSMISSION) INSTRUMENT PANEL CLUSTER (IPC) INTERNAL MODE SWITCH IPC/DIC FUSE LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE P/N PNK 10 11 12 WIRE PNK 7 8 9 WIRE PNK WIRE PNK/BLK WIRE PPL PPL PPL PPL PPL 1 2 PPL/BLK WIRE PPL/WHT WIRE PRESSURE SWITCH MANIFOLD PTO STATUS RED WIRE RED/BLK WIRE SEO SPLICE PACK TAN WIRE TAN/WHT WIRE TFT SENSOR TOW/HAUL SWITCH TRANSFER CASE) TURBINE SPEED SENSOR (IN TRANSMISSION) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) BATTERY) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

A/T ISS SIG LOW VSS SIG LOW A/T SHIFT LEVER ALLISON TRANSMISSION BLK WIRE BLK/WHT WIRE BRAKE FUSE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CRNK FUSE DATA BUS H DATA BUS L DK BLU WIRE DK BLU/BLK WIRE DK GRN WIRE FLD PRESS SW SIG 4 TCC PCS LOW FLD PRESS SW SIG 2 TURB SPEED SW SIG GRD GRD B+ GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IGN 0 FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN MALFUNC IND LAMP NCA WIRE ORG/ WIRE ORG/WHT WIRE PNK 10 11 12 WIRE PNK 7 8 9 WIRE PNK FLD PRESS SW SIG 1 VSS SIG HIGH WIRE PNK IGN 0 VOLT WIRE PNK PNK PNK WIRE PNK PPL WIRE PNK WIRE PPL PPL CRANK VOLT PPL PPL 1 2 PPL/WHT WIRE PRESS CONTROL SOLE 2 PTO SIG RANGE SW SIG A MAIN PRESS SOLENOID RED WIRE RED/BLK WIRE RUN WIRE SERIAL DATA DATA BUS L SHIFT SOLENOIDS SOLENOIDS STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TAN/WHT WIRE TCC PSC TR SW SIG B TFT SENSOR SIG TR SW SIG C TR SW SIG P TURB SPEED SW UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) TCM B FUSE WHT WIRE YEL WIRE YEL/BLK WIRE

AUXILIARY BATTERY RELAY (RIGHT REAR OF ENG COMPT) BATTERY BATTERY NOT CHARGING BLK WIRE BLK/WHT WIRE BRN WIRE CHARGE INDICATOR CONTROL CLASS 2 SERIAL DATA COMPUTER DATA LINES DK GRN WIRE DRIVER INFO CENTER ENGINE CONTROL MODULE (ECM) (ON LEFT FRONT OF ENGINE COMPARTMENT) FUSIBLE LINK 1 (8 GA- FUSIBLE LINK 2 (8 GA- FUSIBLE LINK 5 (5 GA- FUSIBLE LINK 6 (5 GA- GENERATOR 2 GENERATOR FIELD DUTY CYCLE SIGNAL GROUND GRY WIRE HOT IN RUN, START I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN 1 VOLT IGN E FUSE INSTRUMENT PANEL CLUSTER LEFT BATTERY LEFT GENERATOR LOGIC MEGA FUSE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE RIGHT BATTERY RIGHT BATTERY (W/AUX BATTERY) RIGHT GENERATOR SEO IGN FUSE SERIAL DATA CLASS 2 STARTER UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT) VOLTS W/ SEO W/AUX BATTERY W/DUAL BATTERIES W/O SEO WRECKER OPTION

ALLISON TRANSMISSION B/U LMP VLT BATTERY BLK WIRE BLUNT CUT (W/ CAMPER BODY CONTROL MODULE (BCM) (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE COMPUTER DATA LINES SYSTEM DIESEL ENGINE CONTROL MODULE (AT LEFT FRONT OF ENGINE COMPT) FUSE GRN WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) LEFT BACK-UP LAMP LT BACK-UP ALARM LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PRESS SW PRESSURE SWITCH MANIFOLD REAR LAMPS JUNCTION BLOCK REV SIG RIGHT BACK-UP LAMP SERIAL DATA TRAILER CONNECTOR TRAILER WIRING PROVISIONAL) TRANSMISSION CONTROL MODULE (AT LEFT FRONT OF ENGINE COMPT) TRLR B/U FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) YEL WIRE

B/U LMP VLT B/U LMPS SIG B/U LP FUSE BLK WIRE BLUNT CUT (W/ CAMPER BODY CONTROL MODULE (BCM) (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) GRN WIRE GRY WIRE GRY/BLK WIRE HOT IN RUN OR START LEFT BACK-UP LAMP LT BACK-UP ALARM LT GRN WIRE PARK/NEUTRAL POSITION (PNP) SWITCH (LEFT SIDE OF TRANSMISSION) PNK A/T WIRE PNK M/T WIRE PNK WIRE REAR LAMPS JUNCTION BLOCK RIGHT BACK-UP LAMP TRAILER CONNECTOR TRAILER WIRING PROVISIONAL) TRLR B/U FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT)

2 3 4 5 6 7 8 PNK WIRE 9 10 11 12 13 PNK WIRE AXLE SW SIG BACKUP VOLT BLK WIRE BLK/WHT WIRE BLUNT CUT) BODY RELAY BLOCK BRN WIRE CKP SENSOR SIG CLUTCH PEDAL POSITION SWITCH (TOP OF PEDAL BRACKET) DK BLU WIRE DK BLU/WHT WIRE ECM FUSE ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) FRP SENSOR SIG FUEL PRESSURE REGULATOR GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ACC, RUN, START HOT IN RUN BRAKE FUSE HOT IN RUN, START I/P FUSE BLOCK I/P FUSE BLOCK IGN 0 FUSE IGN 1 INJ 1 INJ 2 INTAKE AIR HEATER FUSE INTAKE AIR TEMPERATURE (IAT) SENSOR 2 INTAKE AIR TEMPERATURE (IAT)/ MASS AIRFLOW (MAF) SENSOR (IN AIR INDUCTION TUBE) LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK 1 2 WIRE PNK 23 24 25 26 27 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 28 29 30 31 PPL/WHT WIRE RED WIRE RED/BLK WIRE STOPLAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TRANSMISSION SYSTEM TUR VAN POS UNDER- HOOD FUSE BLOCK WATER IN FUEL WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

12 13 14 PNK WIRE 2 3 4 5 6 7 8 PNK WIRE 20 21 PPL 9 10 11 12 13 PNK WIRE ACTUATOR FUSE BLK WIRE BLK/WHT WIRE BRN WIRE CLOSED BELOW 8 DEG C (46 DEG F) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ECM RELAY ECM-B FUSE ECU FUSE F/ PUMP RELAY FUEL HEATER (TOP OF FUEL FILTER ELEMENT) FUEL HTR FUSE FUEL INJECTORS FUEL RAIL PRESSURE SENSOR (UNDER INTAKE MANIFOLD SHIELD, ON FUEL RAIL) GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK 23 24 25 26 27 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL 28 29 30 31 PPL/WHT WIRE RED/BLK WIRE TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLUNT CUT) BRN WIRE BRN/WHT WIRE CRANKSHAFT POSITION SENSOR (RIGHT SIDE OF ENGINE) CRUISE CONTROL SYSTEM CRUISE FUSE DK BLU WIRE DK GRN/WHT WIRE FOG LP FUSE FUEL PUMP (AUXILIARY TANK (LEFT SIDE FRAME RAIL) GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN I/P FUSE BLOCK IND LOGIC LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR NCA WIRE OFF ON ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE POWER TAKE OFF RELAY (NEAR UNDERHOOD FUSE BLOCK) POWER TAKE OFF SWITCH PPL PPL/WHT WIRE SET- TAN WIRE TURBOCHARGER VANE POSITION SENSOR UNDERHOOD FUSE BLOCK WHT WIRE WHT/BLK WIRE YEL WIRE

1827 121 1020 2500 822 ANTI-LOCK BRAKES SYSTEM 23 1786 420 STARTING/ CHARGING SYSTEM 3 4 PNK WIRE 439 1320 25 2524 EXTERIOR LIGHTS SYSTEM STARTING/ CHARGING SYSTEM 5764 470 380 1589 INSTRUMENT CLUSTER SYSTEM 6-SPEED M/T 5-SPEED A/T A/C SYSTEM A/C SYSTEM INSTRUMENT CLUSTER SYSTEM ALLISON TRANSMISSION BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CLASS 2 SERIAL COMPUTER DATA LINES SYSTEM DATA BUS - VSS SIG DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EGR MOTOR HIGH LOW REF A/C REFRIG SIG FUEL LEVEL SENSOR SIG ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) EXC SEO FUEL PUMP LOW REF FUEL RAIL TEMPERATURE (FRT) SENSOR FUSE GENERATOR SIG PARK/NEUTRAL SIG TCC BRAKE SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES IND INSTRUMENT CLUSTER SYSTEM INSTRUMENT PANEL CLUSTER INTERNAL MODE SWITCH IPC/DIC FUSE LOW REF MIL CONTROL A/C COMPRESS LT BLU WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE ORG/BLK WIRE PNK IGN 1 + CHMSL + CHARGE IND GENERATOR 2 SIG WIRE PNK PNK WIRE PNK WIRE PPL PPL 5 6 7 8 PPL PTO CONTROL ECM RELAY PPL/BLK WIRE PPL/WHT WIRE RED/BLK WIRE RPM OUT SEO TAN WIRE TAN/WHT WIRE TRANSMISSION CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) UNDERHOOD FUSE BLOCK VEHICLE SPEED SENSOR (LEFT REAR SIDE OF TRANS) VEHICLE SPEED SIG VEHICLE SPEED SIG ENG SPEED SIG IGN 0 + DATA BUS + VSS LOW SIG WAIT TO WAIT TO START WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE