Chevrolet Silverado 3500 (2002-2006) gry Wiring diagrams

1 2 6 8 16 GND TCC PWM PC SOL HI PC SOL LO 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID A/T FLUID PRESSURE MANUAL MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR (IN TRANSMISSION) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) EXCEPT SEO FLUID TEMP SENSOR FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START HOT IN RUN, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE P/N PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (BELOW STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV RUN WIRE SEO SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TCC PWM SOLENOID TOW/HAUL SWITCH TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) PCM 1 FUSE VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

1 40 75 10 9 GROUND GROUND IGNITION CAN LOW CAN HIGH 46 12 21 1 40 MIL CONTROL TRANS MIL REQUEST SIGNAL HIGH - FRONT GROUND GROUND 58 34 CLASS 2 SERIAL DATA PARK/NEUTRAL SIG ALLISON TRANSMISSION SOLENOID BLK WIRE BLK/WHT WIRE BRAKE FUSE BRN WIRE BRN/WHT WIRE CAN LOW CAN LOW CLASS 2 DATA DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EXCEPT SEO FUEL INJECTOR CONTROL MODULE (UNDER ENG IAR INTAKE DUCT) FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START IGN 0 FUSE INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LINE PRES 12 VOLT REF TCC SOL MALFUNCTION INDICATOR LAMP MIL SIGNAL OF TRANSMISSION) ON/OFF SOLENOIDS ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE P/N PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL DATA LINK CONNECTOR (BELOW STEERING COLUMN) PPL PPL PPL TCC BRAKE SW PPL/WHT WIRE PRESSURE SWITCH MANIFOLD VEHICLE SPEED SENSOR RED WIRE RED/BLK WIRE REV RUN WIRE SEO SIG HI-FRONT SPLICE PACK STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TCC PWM SOLENOID TFT SENSOR TRIM SOLENOIDS TFT SIGNAL TRANSFER CASE) TRANSMISSION CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) TSS SIGNAL TSS RETURN VSS HIGH VSS LOW ISS HIGH ISS LOW TURBINE SPEED SENSOR (IN TRANSMISSION) INPUT SPEED SENSOR (IN TRANSMISSION) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) PCM B FUSE VSS ADAPTER WHT WIRE YEL WIRE YEL/BLK WIRE

2467 1694 TRQ RESPONSE ALLISON TRANSMISSION TCC PWM SOLENOID SOLENOID BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE CLASS 2 DATA DATA LINK CONNECTOR DELIVD TORQUE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROLS SYSTEM (POWER TAKE OFF SWITCH) (IN ENGINE HARNESS) EXCEPT SEO FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN 0 FUSE INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LINE PRES 12 VOLT REF TCC SOL MALFUNCTION INDICATOR LAMP MIL SIGNAL OF TRANSMISSION) ON/OFF SOLENOIDS ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE P/N PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK 451 2522 420 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PPL PPL/WHT WIRE PRESSURE SWITCH MANIFOLD RED WIRE RED/BLK WIRE REQST TORQUE REV TFT SENSOR TRIM SOLENOIDS RUN WIRE SEO SIG HI-FRONT SPLICE PACK STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TFT SIGNAL TOW/HAUL SWITCH TRANSFER CASE) TRANSMISSION CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) TURBINE SPEED SENSOR (IN TRANSMISSION) INPUT SPEED SENSOR (IN TRANSMISSION) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) BATTERY) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) PCM B FUSE VEHICLE SPEED SENSOR VSS ADAPTER WHT WIRE YEL WIRE YEL/BLK WIRE

10 11 12 13 14 15 16 AUD OUT - DRAIN WIRE AUDIO AMPLIFIER BARE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COAX ANTENNA COMPUTER DATA LINES SYSTEM DIGITAL RADIO ANTENNA DIGITAL RADIO RECEIVER DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE GROUND GROUND R SPK OUT+ GRY WIRE HOT AT ALL TIMES I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) L SPK OUT- L SPK OUT+ LEFT FRONT DOOR SPEAKER LEFT FRONT TWEETER SPEAKER LEFT REAR SPEAKER (EXTENDED CAB) LEFT REAR DOOR SPEAKER (EXCEPT EXTENDED CAB) LF AUD + RT AUD + LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MIC SUP VOLT MIC SIG RF AUD SIG- LF AUD SIG- LF AUD SIG+ RF AUD SIG+ DRAIN WIRE NCA WIRE NOISE COMPENSATION MICROPHONE ORG/ WIRE ORG/BLK WIRE R SPK OUT- B+ RADIO AMP FUSE RIGHT FRONT DOOR SPEAKER RIGHT FRONT TWEETER SPEAKER RIGHT REAR SPEAKER (EXTENDED CAB) RIGHT REAR DOOR SPEAKER (EXCEPT EXTENDED CAB) SERIAL DATA SUBWOOFER SPEAKER TAN WIRE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPARTMENT) YEL WIRE

1362 (OR 353) 349 1834 2306 (OR 371) ALO: W/ FRONT PASSENGER/ CHILD PRESENCE DETECTOR BLK WIRE BLK/WHT WIRE BRN WIRE CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE GROUND GRY WIRE HOT IN RUN OR START I/P JUNCTION BLOCK (RIGHT SIDE OF DASH, BEHIND ACCESS PANEL) I/P MODULE DISABLE SWITCH SIGNAL I/P MODULE SUPPRESSION INDICATOR CONTROL I/P RELAY BLOCK IGNITION 1 VOLTAGE INFLATABLE RESTRAINT I/P MODULE DISABLE SWITCH INFLATABLE RESTRAINT SENSING/DIAGNOSTIC MODULE (UNDER LEFT FRONT SEAT) INFLATABLE RESTRAINT STEERING WHEEL MODULE INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL KEY SWITCH LOGIC LT BLU WIRE LT GRN WIRE NCA WIRE OFF ON-W/O ALO AUTO-W/ ALO ORG/ WIRE OTHERS OTHERS PNK WIRE PNK (OR TAN/BLK) WIRE PNK 1 2 3 4 5 6 7 WIRE PNK W/ FRONT PASSENGER/ CHILD PRESENCE DETECTOR WIRE PNK WIRE PPL PPL PPL RED (OR PNK) WIRE RED WIRE RIGHT INFLATABLE RESTRAINT SIDE IMPACT SENSOR RIGHT SIGNAL HIGH CONTROL LOW CONTROL GROUND LOW CONTROL HIGH CONTROL RIGHT VOLTAGE HIGH CONTROL LOW CONTROL LOW REFERENCE LOW CONTROL HIGH CONTROL SHORTING BAR SHORTING BAR SHORTING BAR SIGNAL SIGNAL LOW REFERENCE LOW REFERENCE SIR FUSE STAGE 1 INFLATABLE RESTRAINT I/P MODULE (BEHIND RIGHT SIDE OF DASH) STAGE 2 TAN WIRE TAN/BLK WIRE TWISTED PAIR WIRES UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT, NEAR BATTERY) W/ FRONT PASSENGER/ CHILD PRESENCE DETECTOR WHT WIRE YEL WIRE

AIR BAG BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CLASS 2 SERIAL DATA DATA LINK CONNECTOR (LOWER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVER SEAT BELT SWITCH FRONT PASSENGER SEAT BELT SWITCH GRY WIRE I/P RELAY BLOCK (BELOW LEFT SIDE OF DASH, LEFT OF STEERING COLUMN) IGN IGNITION 1 VOLTAGE INFLATABLE RESTRAINT PASSENGER AIR BAG ON/OFF INDICATOR INFLATABLE RESTRAINT PASSENGER PRESENCE SYSTEM SENSOR INFLATABLE RESTRAINT PASSENGER SEAT BELT TENSION RETRACTOR SENSOR INSIDE REARVIEW MIRROR INSTRUMENT INSTRUMENT PANEL CLUSTER IPC CLASS 2 SERIAL DATA LEFT INFLATABLE RESTRAINT SEAT POSITION SWITCH LT BLU WIRE LT GRN WIRE MEMORY SYSTEMS OFF PASS SEAT BELT TENS LO REF PPS SENS LO REF PASS SEAT BELT TENS SIG GROUND PPS SENS SIG PNK 1 2 3 4 5 6 7 WIRE PNK I/P MOD DISABLE SW SIG WIRE PPL RED WIRE RIGHT INFLATABLE RESTRAINT SEAT POSITION SWITCH SPLICE PACK TAN WIRE WHT WIRE YEL WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (ON LEFT SIDE OF INNER FRAME) EXCEPT SEO FRONT AXLE ACTUATOR FUSE GAS (PCM) DIESEL (ECM) GRY WIRE GRY/BLK WIRE HOT IN HOT IN RUN OR START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IGN E FUSE INSTRUMENT PANEL CLUSTER LAMP LOGIC LT BLU WIRE MODULE (DIESEL) (LEFT FRONT OF ENGINE COMPT) PNK WIRE POWERTRAIN CONTROL MODULE (GAS ENGINES) OR ENGINE CONTROL PPL 2 RUN WIRE SEO SEO IGN FUSE SPLICE PACK TRANSFER CASE SHIFT CONTROL SWITCH (ON TOP OF TRANSFER CASE) TRANSMISSION CONTROL MODULE (W/ ALLISON TRANS) (LEFT FRONT OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT)

2-HI IND 4 HI 4 LO 4-HI IND 4-LO IND AXLE SW SIG BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLASS II DATA AXLE CTRL AWD IND 4-LO IND 4-HI IND CONTROL MODULE DIESEL: ENGINE CONTROL MODULE CTRL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DIESEL (ECM) DK GRN WIRE DK GRN/WHT WIRE ENCODER ENCODER LOW GROUND ENCODER SIG EXCEPT SEO FRONT AXLE ACTUATOR FT SHAFT LO FT SHAFT HI FUSE GAS (PCM) GROUND BATTERY MOTOR CTRL A MOTOR CTRL B GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) SEO IGN FUSE I/P RELAY BLOCK (UNDER LEFT SIDE OF DASH) IGN E FUSE ILLUMINATION INSTRUMENT PANEL CLUSTER LAMP LOCK SOL CTRL 2-HI IND NEUTRAL IND LOGIC LT BLU WIRE LT GRN/BLK WIRE NEUTRAL IND ORG/ WIRE PNK WIRE PPL PPL/WHT WIRE RED WIRE RR SHAFT HI RR SHAFT LO RUN WIRE SEO SHIFT MOTOR SPLICE PACK TAN/BLK WIRE TRANSFER CASE ENCODER MOTOR TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSFER CASE SHIFT CONTROL SWITCH TRANSMISSION SYSTEM TREC FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT)

ANL/DRL DEFEAT AUTO BATTERY BATTERY BATTERY BATTERY GROUND BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BCM) (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) CREW CAB ONLY FUSE GROUND DISTRIBUTION SYSTEM GRY WIRE GRY/BLK WIRE HEAD PARK HEADLAMP SWITCH HOT AT ALL TIMES HOT IN ACC, RUN HOT IN ACC, RUN, START HOT IN RUN, START I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGNITION KEY ALARM SWITCH LEFT REAR DOOR LATCH ASSEMBLY LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PARK BRAKE SWITCH (PART OF PARK BRAKE ASSEMBLY) PARK LAMP ON SIGNAL GROUND DIMMING INPUT PNK WIRE POWER DISTRIBUTION SYSTEM RIGHT REAR DOOR AJAR SW LEFT REAR DOOR AJAR SW RIGHT REAR DOOR LATCH ASSEMBLY SERIAL DATA TAN WIRE TBC ACCY FUSE TBC BATT FUSE TBC IGN 0 FUSE TBC IGN 1 FUSE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE YEL WIRE

22 3 11 SERIAL DATA LEFT SEAT BELT LOW REFERENCE 22 3 18 SERIAL DATA LOW REFERENCE LEFT DOOR AJAR SW 22 5 20 SERIAL DATA DOOR AJAR SWITCH LOW REFERENCE BASE BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVER DOOR LATCH ASSEMBLY DRIVER DOOR MODULE (DDM) (IN DRIVER'S DOOR) DRIVER SEAT BELT SWITCH FRONT PASSENGER DOOR LATCH ASSEMBLY FRONT PASSENGER DOOR MODULE (FPDM) (IN RIGHT FRONT DOOR) GROUND DISTRIBUTION SYSTEM GRY WIRE GRY/BLK WIRE I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (RIGHT SIDE OF DASH, BEHIND ACCESS PANEL) IGN INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER (IPC) LEFT TURN LOGIC LT BLU WIRE LT GRN WIRE ORG/ WIRE PNK 1045 1044 WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPARTMENT) PPL PPL 1132 1036 1037 1047 1046 RADIO RIGHT TURN SEAT BELT SERIAL DATA SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE W/CONVENIENCE PACKAGE COMFORT, DECOR LEVEL 3 W/MEMORY SEATS WHT WIRE YEL WIRE