Chevrolet Silverado 3500 (2002-2006) computer data lines system Wiring diagrams

40 12 17 MIL CONTROL SIGNAL HIGH - FRONT PTO STATUS 73 36 GROUND GROUND 9 18 15 2 1 GROUND IGNITION CLASS 2 SERIAL DATA CAN DATA LO CAN DATA HI ALLISON TRANSMISSION TCC PWM SOLENOID SOLENOID BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM CAN DATA LO DATA LINK CONNECTOR DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROLS SYSTEM (IN ENGINE HARNESS) EXCEPT SEO FUSE GRN DK WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) PCM B FUSE HOT IN HOT IN RUN, ACC, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN 0 FUSE INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LINE PRES 12 VOLT REF TCC SOL MALFUNCTION INDICATOR LAMP MIL SIGNAL OF TRANSMISSION) ON/OFF SOLENOIDS ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE P/N PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PARK/NEUTRAL SIG PNK 1049 2362 2361 WIRE PNK 451 2522 420 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PPL PPL/WHT WIRE PRESSURE SWITCH MANIFOLD VEHICLE SPEED SENSOR RED WIRE RED/BLK WIRE REV RUN WIRE SEO SIG HI-FRONT COMPUTER DATA LINES SYSTEM 2361 2470 CAN DATA HI CLASS 2 DATA SPLICE PACK STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TFT SENSOR TRIM SOLENOIDS TFT SIGNAL TOW/HAUL SWITCH (IF EQUIPPED) TRANS MIL REQUEST TRANSFER CASE) TRANSMISSION CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) TURBINE SPEED SENSOR (IN TRANSMISSION) INPUT SPEED SENSOR (IN TRANSMISSION) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VSS ADAPTER WHT WIRE YEL WIRE YEL/BLK WIRE

AUX HTR PUMP FUSE AUX HTR PUMP RELAY AUXILIARY WATER PUMP BLK WIRE BLU WIRE COMPUTER DATA LINES SYSTEM COOL PUMP FUSE COOL/ FAN RELAY 1 COOL/ FAN RELAY 2 COOL/ FAN RELAY 3 COOL/FAN FUSE DK (IN FORWARD LAMP HARNESS) GRN WIRE GRY WIRE HOT AT ALL TIMES HYBRID CONTROL MODULE (HCM) IGN B FUSE LEFT COOLING FAN ORG/ WIRE PNK PNK PNK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) PPL PWR MAINT FUSE PWR MAINT RELAY RED WIRE RIGHT COOLING FAN SECONDARY UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) (HYBRID) SGCM COOL PMP/FAN RELAY STARTER GENERATOR CONTROL MODULE (SGCM) STARTER/GENERATOR CONTROL MODULE COOLANT PUMP STUD 1 FUSE TAN WIRE UNDERHOOD COOLING FAN FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

AUX HTR PUMP FUSE AUX HTR PUMP RELAY AUXILIARY WATER PUMP BLK WIRE BLU WIRE COMPUTER DATA LINES SYSTEM COOL PUMP FUSE COOL/ FAN RELAY 1 COOL/ FAN RELAY 2 COOL/ FAN RELAY 3 COOL/FAN FUSE DK (IN FORWARD LAMP HARNESS) GRN WIRE GRY WIRE HOT AT ALL TIMES HYBRID CONTROL MODULE (HCM) IGN B FUSE LEFT COOLING FAN ORG/ WIRE PNK PNK PNK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) PPL PWR MAINT FUSE PWR MAINT RELAY RED WIRE RIGHT COOLING FAN SECONDARY UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) (HYBRID) SGCM COOL PMP/FAN RELAY STARTER/GENERATOR CONTROL MODULE (SGCM) STARTER/GENERATOR CONTROL MODULE COOLANT PUMP STUD 1 FUSE TAN WIRE UNDERHOOD COOLING FAN FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

2 3 BATTERY GROUND 22 14 CLASS 2 SERIAL DATA BATTERY 4 2 GROUND BATTERY 5 10 11 PNK MEM 2 SW SIG MEM 1 SW SIG SPLY VOLTAGE WIRE 8 7 4 3 PNK LOW REF MIR SIGNAL MIR SENS LOW REF MIR HTR LOW REF WIRE BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DDM FUSE DK BLU WIRE DK GRN WIRE DRIVER DOOR MODULE (IN DRIVER'S DOOR) DRIVER OUTSIDE REARVIEW MIRROR ELECTRO- CHROMIC EXIT FOLDING MOTOR FRONT PASSENGER DOOR MODULE (IN PASSENGER'S DOOR) GRY WIRE HEATING ELEMENT HOT AT ALL TIMES HOT AT ALL TIMES I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) I/P JUNCTION BLOCK (RIGHT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) LEFT UP HORIZONTAL LEFT UP HORIZONTAL VERTICAL LT BLU WIRE LT DOORS CIRCUIT BREAKER LT GRN WIRE MEM 1 MEM 2 MEMORY/ HEATED SEAT SWITCH ORG/ WIRE PASSENGER OUTSIDE REARVIEW MIRROR PDM FUSE PNK WIRE PPL PPL/WHT WIRE RED WIRE RED/WHT WIRE RT DOOR CIRCUIT BREAKER TAN WIRE VERTICAL WHT WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 BATT (+) 1150 (OR 1250) GND 1257 1258 TORSO BOLSTER IN CTRL TORSO BOLSTER OUT CTRL PPL 1523 1521 1520 HORIZ RWD SW SIG REAR VERT DN SW SIG FRT VERT DN SW SIG 2407 5701 1269 LUM MTR FWD CTRL TORSO BLSTR IN SW SIG RECLINE FWD SW SIG 2408 5702 LUM MTR RWD CTRL TORSO BLSTR OUT SW SIG RECLINE RWD SW SIG 2425 1048 SEATS SYSTEM HEATED SEAT TEMP SIG CLASS 2 SERIAL DATA 610 610 PNK PNK WIRE 940 1985 2432 5 VOLT REF 5 VOLT REF HTD SEAT BACK PWR BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER'S SEAT ADJUSTER SWITCH FRT UP GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES I/P RELAY BLOCK (NEAR LEFT KICK PANEL) SEAT CIRCUIT BREAKER LT BLU WIRE LT GRN WIRE LUM MTR FWD CTRL LUM MTR RWD CTRL LUM MTR RWD CTRL MEMORY SEAT MODULE (UNDER LEFT FRONT SEAT) NOT USED NOT USED ORG/ WIRE PNK WIRE PNK/ SEATS SYSTEM WIRE PPL PPL TRSO BLSTR POS SENS SIG REC FWD REC RWD RECLINE MTR POS SEN SIG RED/WHT WIRE RR DWN RR UP FRT DWN RWD FWD SEATS SYSTEM SEATS SYSTEM HEATED SEAT TEMP SIG SEATS SYSTEM HTD SEAT BACK PWR TAN WIRE TAN/BLK WIRE WHT WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

11 10 5 SPLY VOLTAGE MEM 1 SW SIG MEM 2 SW SIG BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLASS 2 SERIAL DATA COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVER DOOR MODULE (IN DRIVER'S DOOR) DRIVER SEAT BOLSTER MOTOR POSITION SENSOR DRIVER SEAT BOLSTER/ LUMBAR SWITCH DRIVER SEAT FRONT VERTICAL MOTOR DRIVER SEAT FRONT VERTICAL POSITION SENSOR DRIVER SEAT HORIZ- ONTAL MOTOR DRIVER SEAT HORIZ- ONTAL POSITION SENSOR DRIVER SEAT LUMBAR MOTOR POSITION SENSOR DRIVER SEAT REAR VERTICAL MOTOR DRIVER SEAT REAR VERTICAL POSITION SENSOR DRIVER SEAT RECLINER MOTOR DRIVER SEAT RECLINER MOTOR POSITION SENSOR EXIT GRY/RED WIRE IN OUT LT BLU WIRE LT GRN WIRE MEM 1 MEM 2 MEMORY/ HEATED SEAT SWITCH ORG/ WIRE OUT PNK WIRE PNK/BLK WIRE PPL PPL/WHT WIRE RED WIRE TAN WIRE TAN/WHT WIRE WHT WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

2061 2062 1792 2 1 8 VOICE LOW REF VOICE SIGNAL DRAIN WIRE 511 1947 1946 546 1851 LF SPK OUT+ LF SPK OUT- RR AUD SIG+ RR AUD SIG- GROUND 599 1547 1546 512 LR SPK OUT + LR SPK OUT - RF SPK OUT - RF SPK OUT + ANTENNA BARE BARE DRAIN WIRE BCM CLASS 2 SERIAL DATA BLK WIRE BLK/WHT WIRE BLUNT CUT) BODY CONTROL MODULE (BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE COAX COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROLS SYSTEM VSS SIGNAL GRN WIRE GRY/BLK WIRE I/P RELAY BLOCK (NEAR LEFT KICK PANEL) INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK RADIO ON SIG WIRE PNK WIRE PNK/BLK WIRE PPL PPL ENABLE SIG PROG VOICE RADIO RADIO MUTE REMOTE RADIO CONTROL SIGNAL REMOTE RADIO CONTROL SUPPLY VOLTAGE SEEK UP SEEK DN SERIAL DATA SOURCE DN SOURCE UP TAN WIRE UPPER LEFT STEERING WHEEL CONTROL SWITCH ASSEMBLY UPPER RIGHT STEERING WHEEL CONTROL SWITCH ASSEMBLY VEHICLE COMMUNICATION INTERFACE MODULE (BEHIND PASSENGER AIR BAG MODULE) VOL UP VOL DN WHT WIRE

12 11 10 9 8 7 6 5 4 3 2 1 COM AUD SIG BARE BLK/WHT WIRE BRN/WHT WIRE CELLULAR/ NAVIGATION, DIGITAL RADIO ANTENNA COAX ANTENNA COMPUTER DATA LINES SYSTEM DATA LINES DIGITAL RADIO RECEIVER (IF EQUIPPED) (BEHIND RIGHT SIDE OF INSTRUMENT PANEL) DK GRN WIRE DK GRN/WHT WIRE GROUND AUD OUT - DRAIN WIRE GROUND LT AUD SIG RT AUD SIG LF AUD + RT AUD + LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE REAR SEAT ENTERTAINMENT ASSEMBLY (IF EQUIPPED) SERIAL DATA W/ DIGITAL RADIO RECEIVER W/ REAR ENTERTAINMENT ASSEMBLY W/O DIGITAL RADIO RECEIVER W/O REAR ENTERTAINMENT ASSEMBLY WHT WIRE

2061 2062 1792 2 1 8 VOICE LOW REF VOICE SIGNAL DRAIN WIRE 511 1947 1946 546 1851 LF SPK OUT+ LF SPK OUT- RR AUD SIG+ RR AUD SIG- GROUND 599 1547 1546 512 LR SPK OUT + LR SPK OUT - RF SPK OUT - RF SPK OUT + ANTENNA BARE BARE DRAIN WIRE BCM CLASS 2 SERIAL DATA BLK WIRE BLK/WHT WIRE BLUNT CUT) BODY CONTROL MODULE (BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE COAX COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRAIN WIRE ENGINE CONTROLS SYSTEM VSS SIGNAL GRN WIRE GROUND GRY/BLK WIRE I/P RELAY BLOCK (NEAR LEFT KICK PANEL) INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL LR AUD SIG+ LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK RADIO ON SIG WIRE PNK WIRE PNK/BLK WIRE PPL PPL ENABLE SIG PROG VOICE RADIO RADIO MUTE REAR SEAT AUDIO CONTROLLER (ON REAR OF CENTER CONSOLE) REMOTE RADIO CONTROL SIGNAL REMOTE RADIO CONTROL SUPPLY VOLTAGE RR AUD SIG+ SEEK UP SEEK DN SERIAL DATA SOURCE DN SOURCE UP TAN WIRE UPPER LEFT STEERING WHEEL CONTROL SWITCH ASSEMBLY UPPER RIGHT STEERING WHEEL CONTROL SWITCH ASSEMBLY VEHICLE COMMUNICATION INTERFACE MODULE (BEHIND PASSENGER AIR BAG MODULE) VOL UP VOL DN WHT WIRE

12 11 10 9 8 7 6 5 4 3 2 1 COM AUD SIG BARE BLK/WHT WIRE BRN/WHT WIRE CELLULAR/ NAVIGATION, DIGITAL RADIO ANTENNA COAX ANTENNA COMPUTER DATA LINES SYSTEM DATA LINES DIGITAL RADIO RECEIVER (IF EQUIPPED) (BEHIND RIGHT SIDE OF INSTRUMENT PANEL) DK GRN WIRE DK GRN/WHT WIRE GROUND AUD OUT - DRAIN WIRE GROUND LT AUD SIG RT AUD SIG LF AUD + RT AUD + LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE REAR SEAT ENTERTAINMENT ASSEMBLY (IF EQUIPPED) SERIAL DATA W/ DIGITAL RADIO RECEIVER W/ REAR ENTERTAINMENT ASSEMBLY W/O DIGITAL RADIO RECEIVER W/O REAR ENTERTAINMENT ASSEMBLY WHT WIRE