Chevrolet Silverado 3500 (2002-2006) blk/wht Wiring diagrams

ANTI-LOCK BRAKE SYSTEM AUXILIARY BATTERY RELAY (RIGHT REAR OF ENG COMPT) BATTERY BATTERY NOT CHARGING BLK WIRE BLK/WHT WIRE BRN WIRE CHARGE INDICATOR CONTROL COMPUTER DATA LINES DK BLU WIRE DK GRN WIRE DRIVER INFO CENTER FUSIBLE LINK 1 (8 GA- FUSIBLE LINK 5 (5 GA- FUSIBLE LINK 6 (5 GA- GENERATOR GENERATOR FIELD DUTY CYCLE SIGNAL GROUND GRY WIRE HOT IN RUN, START I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN 1 VOLT IGN E FUSE INSTRUMENT PANEL CLUSTER LASS 2 SERIAL DATA LEFT BATTERY LOGIC MEGA FUSE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPARTMENT) RED WIRE RIGHT BATTERY RIGHT BATTERY (W/AUX BATTERY) SEO IGN FUSE SERIAL DATA CLASS 2 STARTER UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT) VOLTS W/ SEO W/AUX BATTERY W/DUAL BATTERIES W/O SEO WRECKER OPTION

AUXILIARY BATTERY RELAY (RIGHT REAR OF ENG COMPT) AUXILIARY GENERATOR BATTERY BLK WIRE BLK/WHT WIRE BRN WIRE CHARGE INDICATOR CONTROL COMPUTER DATA LINES DK GRN WIRE ENGINE CONTROL MODULE (ECM) (ON LEFT FRONT OF ENGINE COMPARTMENT) FUSE HOLDER FUSIBLE LINK GENERATOR 2 GENERATOR FIELD DUTY CYCLE SIGNAL GROUND GRY WIRE HOT IN RUN, START I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN 1 VOLT IGN E FUSE INSTRUMENT PANEL CLUSTER IPC CLASS 2 SERIAL DATA LEFT BATTERY LOGIG PNK WIRE POWER DISTRIBUTION SYSTEM PRIMARY GENERATOR RED WIRE RIGHT BATTERY RIGHT BATTERY (W/AUX BATTERY) SEO IGN FUSE SERIAL DATA CLASS 2 STARTER UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT) UPFITTER OPTION VOLTS W/ SEO W/AUX BATTERY W/DUAL BATTERIES W/O SEO

40 12 17 MIL CONTROL SIGNAL HIGH - FRONT PTO STATUS 73 36 GROUND GROUND 9 18 15 2 1 GROUND IGNITION CLASS 2 SERIAL DATA CAN DATA LO CAN DATA HI ALLISON TRANSMISSION TCC PWM SOLENOID SOLENOID BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM CAN DATA LO DATA LINK CONNECTOR DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROLS SYSTEM (IN ENGINE HARNESS) EXCEPT SEO FUSE GRN DK WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) PCM B FUSE HOT IN HOT IN RUN, ACC, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN 0 FUSE INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LINE PRES 12 VOLT REF TCC SOL MALFUNCTION INDICATOR LAMP MIL SIGNAL OF TRANSMISSION) ON/OFF SOLENOIDS ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE P/N PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PARK/NEUTRAL SIG PNK 1049 2362 2361 WIRE PNK 451 2522 420 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PPL PPL/WHT WIRE PRESSURE SWITCH MANIFOLD VEHICLE SPEED SENSOR RED WIRE RED/BLK WIRE REV RUN WIRE SEO SIG HI-FRONT COMPUTER DATA LINES SYSTEM 2361 2470 CAN DATA HI CLASS 2 DATA SPLICE PACK STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TFT SENSOR TRIM SOLENOIDS TFT SIGNAL TOW/HAUL SWITCH (IF EQUIPPED) TRANS MIL REQUEST TRANSFER CASE) TRANSMISSION CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) TURBINE SPEED SENSOR (IN TRANSMISSION) INPUT SPEED SENSOR (IN TRANSMISSION) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VSS ADAPTER WHT WIRE YEL WIRE YEL/BLK WIRE

AUXILIARY BATTERY RELAY (RIGHT REAR OF ENG COMPT) BATTERY BATTERY NOT CHARGING BLK WIRE BLK/WHT WIRE BRN WIRE CHARGE INDICATOR CONTROL CLASS 2 SERIAL DATA COMPUTER DATA LINES DK GRN WIRE DRIVER INFO CENTER ENGINE CONTROL MODULE (ECM) (ON LEFT FRONT OF ENGINE COMPARTMENT) FUSIBLE LINK 1 (8 GA- FUSIBLE LINK 2 (8 GA- FUSIBLE LINK 5 (5 GA- FUSIBLE LINK 6 (5 GA- GENERATOR 2 GENERATOR FIELD DUTY CYCLE SIGNAL GROUND GRY WIRE HOT IN RUN, START I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN 1 VOLT IGN E FUSE INSTRUMENT PANEL CLUSTER LEFT BATTERY LEFT GENERATOR LOGIC MEGA FUSE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE RIGHT BATTERY RIGHT BATTERY (W/AUX BATTERY) RIGHT GENERATOR SEO IGN FUSE SERIAL DATA CLASS 2 STARTER UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT) VOLTS W/ SEO W/AUX BATTERY W/DUAL BATTERIES W/O SEO WRECKER OPTION

ABS FUSE AUDIO AMPLIFIER AUXILIARY BATTERY RELAY (RIGHT REAR OF ENGINE COMPT) BATTERY (LEFT) BATTERY (RIGHT) BATTERY (RIGHT) (W/AUX BATTERY) BATTERY CABLE JUNCTION BLOCK BLK WIRE BLK/WHT WIRE BLUNT CUT) BODY CONTROL MODULE BRN WIRE CIG LTR FUSE CIGAR LIGHTER DATA LINK CONNECTOR DIGITAL RADIO RECEIVER RADIO ELECTRONIC BRAKE CONTROL MODULE EMERGENCY VEHICLE ROOF LAMP RELAY EVAPORATIVE EMISSIONS CANISTER VENT SOLENOID EXCEPT LUXURY FUSE FUSIBLE LINK 1 FUSIBLE LINK 2 FUSIBLE LINK 3 (8 GA- FUSIBLE LINK 4 FUSIBLE LINK 5 GENERATOR (LEFT) GENERATOR (RIGHT) GLOW PLUG CONTROL MODULE (GPCM) GLOW PLUG FUSE HD TRAILERING EQUIPMENT PROVISION (BLUNT CUT) I/P JUNCTION BLOCK (RIGHT SIDE OF DASH) I/P RELAY BLOCK (LEFT OF STEERING COLUMN) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN A FUSE STUD 2 FUSE IGN B FUSE INTAKE AIR HEATER (IAH) MODULE INTAKE AIR HEATER FUSE LUXURY MEGA FUSE MOBILE RADIO FUSE BLOCK (BEHIND RIGHT SIDE OF DASH) NCA WIRE NOT USED NOT USED ORG/ WIRE RADIO AMP FUSE RADIO FUSE REAR SEAT AUDIO (RSA) CONTROLLER REAR SEAT AUDIO (RSA) CONTROLLER DIGITAL RADIO RECEIVER RADIO RED WIRE RELAY RELAY/ FUSE RTD FUSE S/ROOF FUSE RR WIPER FUSE EAP FUSE STARTER STARTER RELAY STUD 1 FUSE SUNROOF CONTROL MODULE TBC BATT FUSE TO IGNITION SWITCH (DIAGRAM 4 OF 5) TO IGNITION SWITCH (DIAGRAM 5 OF 5) TRAILER CONNECTOR (7 WAY) VSES/ ECAS FUSE FUSE W/ AUX BATTERY W/ WRECKER EMERGENCY LAMP WHEEL TRAILER WIRING PROVISION (BLUNT CUT) WRECKER RELAY

ANTI-LOCK BRAKE SYSTEM AUXILIARY BATTERY RELAY (RIGHT REAR OF ENG COMPT) BATTERY BATTERY NOT CHARGING BLK WIRE BLK/WHT WIRE BRN WIRE CHARGE INDICATOR CONTROL COMPUTER DATA LINES DK BLU WIRE DK GRN WIRE DRIVER INFO CENTER FUSIBLE LINK 1 (8 GA- FUSIBLE LINK 5 (5 GA- FUSIBLE LINK 6 (5 GA- GENERATOR GENERATOR FIELD DUTY CYCLE SIGNAL GROUND GRY WIRE HOT IN RUN, START I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN 1 VOLT IGN E FUSE INSTRUMENT PANEL CLUSTER LASS 2 SERIAL DATA LEFT BATTERY LOGIC MEGA FUSE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPARTMENT) RED WIRE RIGHT BATTERY RIGHT BATTERY (W/AUX BATTERY) SEO IGN FUSE SERIAL DATA CLASS 2 STARTER UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT) VOLTS W/ SEO W/AUX BATTERY W/DUAL BATTERIES W/O SEO WRECKER OPTION

80 13 45 21 14 33 43 41 58 15 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER MOTOR (RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BLWR FUSE BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND GROUND TEMP SEN ASS CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) I/P RELAY BLOCK (LEFT SIDE OF DASH) INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LOWER LEFT AIR TEMPERATURE SENSOR (LEFT END OF HVAC MODULE) LOWER RIGHT AIR TEMPERATURE SENSOR (BOTTOM OF HVAC MODULE) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UPPER LEFT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) UPPER RIGHT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL) WHT WIRE WHT/BLK WIRE YEL WIRE

8600 GVW OR LESS GREATER THAN 8600 GVW AUDIO AMPLIFIER (W/ LUXURY PACKAGE) (UNDER REAR OF CENTER CONSOLE) BASE OR UPLEVEL BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE CIG LTR FUSE CLASS 2 SERIAL DATA DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH, BELOW STEERING COLUMN) DIGITAL RADIO RECEIVER DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER'S DOOR MODULE (DDM) (IN LEFT FRONT DOOR) ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) FRONT PASSENGER DOOR MODULE (FPDM) (IN RIGHT FRONT DOOR) GAS DIESEL GENERATOR BATTERY CONTROL MODULE (LEFT FRONT CORNER OF ENGINE COMPT) GRN/BLK WIRE GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HYBRID CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (UNDER RIGHT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) INFLATABLE RESTRAINT SENSING/DIAGNOSTIC MODULE (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER (IPC) LT BLU WIRE LT GRN WIRE LUXURY MEMORY SEAT MODULE (UNDERSIDE OF DRIVER SEAT) ORG/ WIRE ORG/BLK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE REAR SEAT AUDIO (RSA) CONTROLLER (UNDER REAR OF CENTER CONSOLE) REAR SEAT ENTERTAINMENT (RSE) ASSEMBLY (AT CENTER OF HEADLINER) REMOTE PLAYBACK DEVICE-CD PLAYER (CENTER OF DASH, BELOW RADIO) SPLICE PACK TAN WIRE TAN/WHT WIRE TIRE PRESSURE MONITOR (TPM) MODULE (BEHIND DASH ABOVE BRAKE PEDAL ASSEMBLY) TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSMISSION CONTROL MODULE (AT LEFT FRONT OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) (BEHIND PASSENGER AIR BAG MODULE) WHT WIRE YEL WIRE

80 13 45 21 14 33 43 41 58 15 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT DEF GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) I/P RELAY BLOCK (LEFT SIDE OF DASH) INST LAMP DIM CTRL GROUND LEFT TEMP CONTROL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE CONTROL MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF OFF BLOW MT CTRL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RECIRC SWITCH RED WIRE RED/BLK WIRE RIGHT TEMP CONTROL RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE WHT/BLK WIRE YEL WIRE

2-HI IND 4 HI 4 LO 4-HI IND 4-LO IND AXLE SW SIG BLK WIRE BLK/WHT WIRE BRAKE CONTROL BRN WIRE BRN/WHT WIRE CLASS II DATA AXLE CTRL AWD IND 4-LO IND 4-HI IND CONTROL MODULE CTRL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK GRN WIRE DK GRN/WHT WIRE ENCODER ENCODER LOW GROUND ENCODER SIG EXCEPT SEO FRONT AXLE ACTUATOR FRONT PROPSHAFT SPEED SENSOR FUSE GROUND BATTERY MOTOR CTRL A MOTOR CTRL B GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) SEO IGN FUSE I/P RELAY BLOCK (UNDER LEFT SIDE OF DASH) IGN E FUSE ILLUMINATION INSTRUMENT PANEL CLUSTER LAMP LOCK SOL CTRL 2-HI IND NEUTRAL IND LOGIC LT BLU WIRE LT GRN/BLK WIRE NEUTRAL IND ORG/ WIRE PNK WIRE PPL PPL FT SHAFT LO FT SHAFT HI PPL/WHT WIRE REAR PROPSHAFT SPEED SENSOR RED WIRE RR SHAFT HI RR SHAFT LO RUN WIRE SEO SHIFT MOTOR SPLICE PACK TAN WIRE TAN/BLK WIRE TRANSFER CASE ENCODER MOTOR TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSFER CASE SHIFT CONTROL SWITCH TREC FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) YEL WIRE