Chevrolet Silverado 3500 (2002-2006) blk/wht Wiring diagrams

2467 1694 TRQ RESPONSE ALLISON TRANSMISSION TCC PWM SOLENOID SOLENOID BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE CLASS 2 DATA DATA LINK CONNECTOR DELIVD TORQUE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROLS SYSTEM (POWER TAKE OFF SWITCH) (IN ENGINE HARNESS) EXCEPT SEO FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN 0 FUSE INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAIN LINE PRES 12 VOLT REF TCC SOL MALFUNCTION INDICATOR LAMP MIL SIGNAL OF TRANSMISSION) ON/OFF SOLENOIDS ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE P/N PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK 451 2522 420 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PPL PPL/WHT WIRE PRESSURE SWITCH MANIFOLD RED WIRE RED/BLK WIRE REQST TORQUE REV TFT SENSOR TRIM SOLENOIDS RUN WIRE SEO SIG HI-FRONT SPLICE PACK STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TFT SIGNAL TOW/HAUL SWITCH TRANSFER CASE) TRANSMISSION CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) TURBINE SPEED SENSOR (IN TRANSMISSION) INPUT SPEED SENSOR (IN TRANSMISSION) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) BATTERY) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) PCM B FUSE VEHICLE SPEED SENSOR VSS ADAPTER WHT WIRE YEL WIRE YEL/BLK WIRE

61 33 (DIESEL) (GAS) 46 49 ABS FUSE ANTI-LOCK IND BLK WIRE BLK/WHT WIRE BRAKE IND BRN WIRE BRN/WHT WIRE CLUTCH START SWITCH (M/T) (TOP OF CLUTCH CLUTCH ASSY) CPP SW SIG DEL TORQUE SIG DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) EXCEPT SEO GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) BRAKE FUSE IGN E FUSE IGNITION INSTRUMENT CLUSTER LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) BRAKE INPUT LEFT FRONT WHEEL SPEED SENSOR LOGIC LT BLU WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) ORG/BLK WIRE PNK WIRE POWERTRAIN OR ENGINE CONTROL MODULE (PCM OR ECM) (ON LEFT FRONT OF ENG COMPT) PPL PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL PPL PPL/WHT WIRE RED WIRE SEO SEO IGN FUSE STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC BRAKE SW TRACTION CONTROL IND (IF EQUIPPED) TRACTION CONTROL SWITCH TRANSFER CASE SHIFT CONTROL MODULE TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM (TRANSFER CASE CIRCUIT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW VSS OUTPUT YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 HALL A SIG HALL B SIG SENS GND POS 2 SIG 5 VOLT REF B+ VOLT B+ VOLT SERIAL DATA BASE BASE CASE GND GND B+ VOLT BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CASE GROUND COMPUTER DATA LINES SYSTEM CRUISE FUSE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUSE GRY WIRE HALL A SIG HALL B SIG SENS GND HALL C SIG HALL C SIG RLY VOLT SENS GND POS 1 SIG 5 VOLT REF HOT AT ALL TIMES HOT IN HOT IN RUN LEFT I/P FUSE BLOCK IGN 3 FUSE I/P RELAY BLOCK (LOWER LEFT SIDE OF DASH) INSTRUMENT CLUSTER SYSTEM LOW REF LT BLU WIRE LT GRN WIRE MEGA FUSE MODE IND CTRL LAT ACCEL SIG ORG/ WIRE PHASE A CTRL PHASE B CTRL PHASE C CTRL PNK PNK WIRE PNK WIRE POS A SIG POS B SIG POWER DISTRIBUTION SYSTEM PPL PULSE SIG REAR WHEEL POSITION SENSOR (LEFT REAR OF VEHICLE) REAR WHEEL STEERING CONTROL MODULE (NEAR SPARE TIRE BRACKET) REAR WHEEL STEERING MODE SELECT SWITCH RED WIRE RLY GND RUN WIRE SENS SIG STEERING GEAR MOTOR ASSEMBLY (NEAR SPARE TIRE BRACKET) STEERING WHEEL SPEED/ POSITION SENSOR (ON STEERING COLUMN) TAN WIRE UNDERHOOD FUSE BLOCK UNDERHOOD FUSE HOLDER VSS IGN 3 VOLT YAW SENS SIG MODE SW SIG WHT WIRE YEL WIRE

ANL/DRL DEFEAT AUTO BATTERY BATTERY BATTERY BATTERY GROUND BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BCM) (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) CREW CAB ONLY FUSE GROUND DISTRIBUTION SYSTEM GRY WIRE GRY/BLK WIRE HEAD PARK HEADLAMP SWITCH HOT AT ALL TIMES HOT IN ACC, RUN HOT IN ACC, RUN, START HOT IN RUN, START I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGNITION KEY ALARM SWITCH LEFT REAR DOOR LATCH ASSEMBLY LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PARK BRAKE SWITCH (PART OF PARK BRAKE ASSEMBLY) PARK LAMP ON SIGNAL GROUND DIMMING INPUT PNK WIRE POWER DISTRIBUTION SYSTEM RIGHT REAR DOOR AJAR SW LEFT REAR DOOR AJAR SW RIGHT REAR DOOR LATCH ASSEMBLY SERIAL DATA TAN WIRE TBC ACCY FUSE TBC BATT FUSE TBC IGN 0 FUSE TBC IGN 1 FUSE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE YEL WIRE

22 3 11 SERIAL DATA LEFT SEAT BELT LOW REFERENCE 22 3 18 SERIAL DATA LOW REFERENCE LEFT DOOR AJAR SW 22 5 20 SERIAL DATA DOOR AJAR SWITCH LOW REFERENCE BASE BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVER DOOR LATCH ASSEMBLY DRIVER DOOR MODULE (DDM) (IN DRIVER'S DOOR) DRIVER SEAT BELT SWITCH FRONT PASSENGER DOOR LATCH ASSEMBLY FRONT PASSENGER DOOR MODULE (FPDM) (IN RIGHT FRONT DOOR) GROUND DISTRIBUTION SYSTEM GRY WIRE GRY/BLK WIRE I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (RIGHT SIDE OF DASH, BEHIND ACCESS PANEL) IGN INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER (IPC) LEFT TURN LOGIC LT BLU WIRE LT GRN WIRE ORG/ WIRE PNK 1045 1044 WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPARTMENT) PPL PPL 1132 1036 1037 1047 1046 RADIO RIGHT TURN SEAT BELT SERIAL DATA SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE W/CONVENIENCE PACKAGE COMFORT, DECOR LEVEL 3 W/MEMORY SEATS WHT WIRE YEL WIRE

2524 806 1786 STARTING SYSTEM 28 29 PPL 508 84 439 440 1868 87 CRUISE SYSTEM 632 1324 CRUISE CONTROL SYSTEM BATTERY CLASS 2 DATA CLASS 2 DATA BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LEFT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CAN-LOW CAN-HIGH CKP SIGNAL COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) CRANK FUSE CRUISE SYSTEM DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUSE GROUND LOW REF GRY WIRE GRY/BLK WIRE HOT IN HOT IN OFF, RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE HOT IN RUN, START IA HTR SPLY COOL LEV SIG IND CTRL SET/COAST SIG IGN 1 BATT LOW REF RES/ACC SIG INJ 1 CTRL INJ 4 CTRL INJ 8 CTRL INJ 3 CTRL LEV SW SIG PTO ENABLE LOW REF LOW REF LOW REF LOW REF SPLY VOLT LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH PLUG SIG PNK WIRE PNK/BLK WIRE PPL PPL LOW REF APP SENS SIG RED/BLK WIRE SPLICE PACK TAN WIRE TURN ON SIG CRANK VOLT P/N SIG CCP SW SIG INJ 2 CTRL INJ 5 CTRL PPL UNDER- HOOD FUSE BLOCK VACUUM SENSOR VACUUM SIG WATER IN FUEL SENSOR (ON FUEL FILTER ELEMENT) WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

28 29 PPL 30 SERIES 20 SERIES APP 1 APP 3 APP 2 ACCELERATOR PEDAL POSITION SENSOR (BEHIND ACCELERATOR PEDAL) BATTERY BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (FRONT OF ENGINE) DK BLU WIRE DK BLU/RED WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/RED WIRE DK GRN/WHT WIRE ECMPRV FUSE EDU RELAY FUEL HEATER (TOP OF FUEL FILTER ELEMENT) FUEL PUMP (AUXILIARY TANK (LEFT SIDE FRAME RAIL) FUEL PUMP RELAY FUSE HOLDER FUSIBLE LINK GLOW PLUG CONTROLLER GLOW PLUGS GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES BATTERY FUSE HOT IN RUN, START UNDERHOOD FUSE BLOCK FUEL HT FUSE IGN 1 INTAKE AIR HEATER INTAKE AIR HEATER RELAY LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PCMB FUSE PLUG 1 V+ PLUG 2 V+ PLUG 3 V+ PLUG 4 V+ PLUG 5 V+ PLUG 6 V+ PLUG 7 V+ PLUG 8 V+ PLUG SIG PNK 18 19 WIRE PNK WIRE PNK/BLK WIRE PNK/YEL WIRE PPL RED WIRE RED/BLK WIRE RED/GRN WIRE RED/WHT WIRE RELAY CTRL TAN WIRE WHT/BLK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/GRN WIRE BLK/WHT WIRE BLK/YEL WIRE CAN HI CAN LOW DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE SPD FUEL INJECTOR CONTROL MODULE (UNDER AIR INTAKE DUCT) FUEL INJECTORS GROUND GRY WIRE HOT IN RUN, START IGN IGN 2,3,5,8 IGN POS INJ 1 CTRL INJ 2 CTRL INJ 3 CTRL INJ 4 CTRL INJ 5 CTRL INJ 6 CTRL INJ 7 CTRL INJ 8 CTRL INJB FUSE LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/GRN WIRE LT GRN/ORG WIRE LT GRN/PPL WIRE LT GRN/RED WIRE LT GRN/WHT WIRE ORG/BLK WIRE ORG/WHT WIRE PNK PNK 11 12 13 WIRE PNK WIRE PNK/BLK WIRE RED WIRE RED/BLK WIRE TAN WIRE UNDERHOOD FUSE BLOCK WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 GROUND EGR SOL CTRL 12 V REF GROUND LOW REF FUEL PRES REG 5 VOLT REF A/C SYSTEM A/C SYSTEM (BLUNT CUT) A/C SYSTEM A/C SYSTEM ANTI-LOCK BRAKES SYSTEM BARO SENS SIG MAF SENS SIG BLK/WHT WIRE BODY RELAY BLOCK BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION SWITCH (TOP OF PEDAL BRACKET) CRUISE CONTROL SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EGR THROTTLE VALVE VACUUM CONTROL SOLENOID EGR VALVE VACUUM CONTROL SOLENOID EGR VACUUM VENT SOLENOID ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ENGINE SPEED SIG SOL CTRL LOW REF EXC SEO EXTERIOR LIGHTS SYSTEM TRANSMISSIONS SYSTEM FUEL LEV SENS SIG FUEL RAIL PRESSURE REGULATOR (ON FUEL RAIL) FUEL TEMPERATURE SENSOR FUSE GLOW RLY CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN LEFT I/P FUSE BLOCK BRAKE FUSE HOT IN RUN, START IA HTR DIAG 2 IND CTRL PTO ENGAGE SIG PPL INSTRUMENT CLUSTER SYSTEM INSTRUMENT CLUSTER SYSTEM (FUEL LEVEL) INSTRUMENT PANEL CLUSTER IPC/DIC FUSE LOW REF APP SENS 1 SIG FUEL TEMP SIG LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PNK IGN 1 VOLT WIRE PNK PNK 14 15 WIRE PNK WIRE PPL PPL/WHT WIRE RECIRC DOOR CTRL A/C CLU RLY CTRL RED WIRE SEO STARTING/CHARGING SYSTEM STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK VEHICLE SPEED SENSOR (LEFT SIDE OF TRANS) WAIT TO MIL RPM OUT WHT WIRE YEL WIRE YEL/BLK WIRE

2524 806 1786 STARTING SYSTEM 508 84 439 440 1868 87 CRUISE SYSTEM 632 1324 CRUISE CONTROL SYSTEM BATTERY CLASS 2 DATA CLASS 2 DATA BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LEFT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CAN-LOW CAN-HIGH CKP SIGNAL COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) CRANK FUSE CRUISE SYSTEM DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUSE GROUND LOW REF GRY WIRE GRY/BLK WIRE HOT IN HOT IN OFF, RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE HOT IN RUN, START IA HTR SPLY COOL LEV SIG IND CTRL SET/COAST SIG IGN 1 BATT LOW REF RES/ACC SIG INJ 1 CTRL INJ 4 CTRL INJ 8 CTRL INJ 3 CTRL LEV SW SIG PTO ENABLE LOW REF LOW REF LOW REF LOW REF SPLY VOLT LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH PLUG SIG PNK WIRE PNK/BLK WIRE PPL PPL 28 29 PPL LOW REF APP SENS SIG RED/BLK WIRE SPLICE PACK TAN WIRE TURN ON SIG CRANK VOLT P/N SIG CCP SW SIG INJ 2 CTRL INJ 5 CTRL PPL UNDER- HOOD FUSE BLOCK WATER IN FUEL SENSOR (ON FUEL FILTER ELEMENT) WHT/BLK WIRE YEL WIRE YEL/BLK WIRE