Chevrolet Silverado 3500 (2002-2006) blk Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 TP SENSOR 1 SIG ACCELERATION PEDAL POSITION SENSOR (BEHIND ACCELERATOR PEDAL) APP SENSOR 1 SIG BLK WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL ON/OFF SWITCH CRUISE FUSE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ETC FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, START LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOW REF APP SENSOR 3 SIG LOW REF LOW REF APP SENSOR 2 SIG PPL LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) OFF ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ACCEL SERIAL DATA SET/COAST STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) TAN WIRE THROTTLE ACTUATOR CONTROL MOTOR (ON THROTTLE BODY) THROTTLE POSITION SENSOR (ON THROTTLE BODY ASSEMBLY) UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/T A/T M/T BLK WIRE BLK/WHT WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRAKE FUSE BRN WIRE BRN/WHT WIRE CLUTCH CRUISE CONTROL MODULE (LEFT REAR OF ENGINE COMPT, ON FIREWALL) CRUISE CONTROL ON/OFF SWITCH CRUISE ENGAGE IN CRUISE ENGAGE OUT SPEED SENSOR INPUT CRUISE FUSE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER SYSTEM LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE M/T M/T A/T NCA WIRE OFF ORG/ WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ACCEL SET/COAST SOUND SYSTEMS SPEED SENSOR OUT STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) SWITCH (TOP OF CLUTCH PEDAL) UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 TP SENSOR 1 SIG ACCELERATION PEDAL POSITION SENSOR (BEHIND ACCELERATOR PEDAL) APP SENSOR 1 SIG BLK WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL ON/OFF SWITCH CRUISE FUSE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ETC FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, START LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOW REF APP SENSOR 3 SIG LOW REF LOW REF APP SENSOR 2 SIG PPL LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) OFF ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ACCEL SERIAL DATA SET/COAST STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) TAN WIRE THROTTLE ACTUATOR CONTROL MOTOR (ON THROTTLE BODY) THROTTLE POSITION SENSOR (ON THROTTLE BODY ASSEMBLY) UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/T A/T M/T BLK WIRE BLK/WHT WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRAKE FUSE BRN WIRE BRN/WHT WIRE CLUTCH CRUISE CONTROL MODULE (LEFT REAR OF ENGINE COMPT, ON FIREWALL) CRUISE CONTROL ON/OFF SWITCH CRUISE ENGAGE IN CRUISE ENGAGE OUT SPEED SENSOR INPUT CRUISE FUSE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER SYSTEM LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE M/T M/T A/T NCA WIRE OFF ORG/ WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ACCEL SET/COAST SOUND SYSTEMS SPEED SENSOR OUT STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) SWITCH (TOP OF CLUTCH PEDAL) UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW WHT WIRE

AMBIENT LIGHT SENSOR (TOP CENTER OF DASH) ANTI-THEFT SYSTEM ANTI-THEFT SYSTEM DOOR LOCKS SYSTEM BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY RELAY BLOCK (NEAR LEFT KICK PANEL) BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRN WIRE CARGO LP SW INPUT INTERIOR LAMP CTRL FLASH TO PASS SW SIG DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DOOR LATCH SW SIG COURTESY LAMP PWR DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM DRIVER DOOR KEY SW SIG LF DR OPEN SW SIG FRONT FOG LP SW INT LP DEFEAT SW SIG DRL RLY COIL CLASS 2 DATA GROUND IGN 1 EXTERIOR LIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM FOG LP RLY CTRL EXTERIOR COURTESY LPS RLY CTRL GROUND BATTERY DOOR UNLOCK CTRL DOOR LOCK CTRL GRY WIRE GRY/BLK WIRE HEADLAMP SW INPUT LED DIM SIG VSS HEADLIGHTS SYSTEM COMPUTER DATA LINES SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM ENGINE CONTROLS SYSTEM HOT AT ALL TIMES TBC FUSE HOT IN RUN CRUISE FUSE HOT IN RUN, START IGN 1 FUSE IGN 3 PRK BK SW SIG LT SEAT BELT SW TOW/HAUL SW SIG IGNITION KEY ALARM SWITCH INST PANEL LP PWR AMBIENT LIGHT SEN SIG INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM KEY IN IGN SW SIG LEFT I/P FUSE BLOCK LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT TURN SIG LAMP PWR RT TURN SIG LAMP PWR NCA WIRE ORG/ WIRE ORG/BLK WIRE PARK BRAKE SWITCH PNK WIRE POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM (RAP) INTERIOR LIGHTS SYSTEM HORNS SYSTEM PPL PPL HIGH BEAM INPUT INTERIOR PARK LP PWR PPL/WHT WIRE RAP RELAY CTRL INADVERTENT PWR RLY CTRL HORN RLY CTRL RED/WHT WIRE SECURITY SYSTEM SEN SIG SERIAL DATA TAN WIRE TOW/HAUL SWITCH UNDERHOOD JUNCTION BLOCK WARNING SYSTEM WHT WIRE YEL WIRE

3 2 PPL BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY RELAY BLOCK BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH, NEAR KICK PANEL) BRN/WHT WIRE CIGAR FUSE DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH, BELOW STEERING COLUMN) DIESEL DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE (BEHIND CENTER OF DASH) INSTRUMENT PANEL CLUSTER (IPC) LT BLU WIRE LT GRN WIRE MEMORY SEAT MODULE (UNDERSODE OF DRIVER SEAT) 15 14 13 12 11 10 9 8 7 6 NEAR KICK PANEL) ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) SPLICE PACK TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSMISSION CONTROL MODULE (AT LEFT FRONT OF ENG COMPT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT, NEAR BATTERY) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE INTERFACE UNIT (BEHIND RIGHT SIDE OF DASH) WHT WIRE YEL WIRE

22 14 SERIAL DATA BATTERY 7 8 SUPPLY VOLT LOW REF BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DDM FUSE DRIVER DOOR MODULE (DDM) (IN DRIVER'S DOOR) DRIVER OUTSIDE REARVIEW MIRROR FRONT PASSENGER DOOR MODULE (FPDM) (IN RIGHT FRONT DOOR) GROUND HOT AT ALL TIMES HVAC CONTROL MODULE (IN CENTER OF DASH) I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) LOW REF ORG/ WIRE PASSENGER OUTSIDE REARVIEW MIRROR PDM FUSE R DEF REAR DEFOG SWITCH SERIAL DATA SUPPLY VOLT TAN WIRE WHT WIRE

BLK WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM HOT AT ALL TIMES HOT IN RUN, START HTR HVAC CONTROL MODULE (IN CENTER OF DASH) I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN LOGIC LT GRN WIRE PPL REAR DEFOG SWITCH REAR DEFOGGER RELAY REAR WINDOW DEFOGGER GRID RELAY CNTRL SERIAL DATA WHT WIRE

ANTI-LOCK BRAKE SYSTEM B+ CLS 2 DATA CLS 2 DATA SENS GND REF LOW BLK WIRE BLK/WHT WIRE BODY CONTROL THEFT DETERRENT MODULE (BELOW CONTROL STEERING MODULE COLUMN) BRN WIRE BRN/RED WIRE COOLANT LEV DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECMB FUSE ELECTRONIC SUSPENSION SYSTEM FUSE GND GND GRY WIRE HOT AT ALL TIMES HOT IN RUN, START HOT IN RUN, START LEFT I/P FUSE BLOCK IGN 0 FUSE INJA FUSE FUSE INJB FUSE INJECTORS KS SIGNAL KS SIGNAL CKP REQ TORQUE SERIAL DATA SERIAL DATA LIFT/DIVE SIG LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OIL LEV ORG/ WIRE ORG/BLK WIRE PNK PNK WIRE PNK PPL WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL SENS GND PPL/WHT WIRE PRND A BRK SW PRND P PPL PRND B CMP ECT SIG IGN RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE SENS GND SENS GND EGR INPUT SENS RTN TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK W/ REMOTE FUNCTION ACTUATOR W/O REMOTE FUNCTION ACTUATOR WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE BRN/RED WIRE COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ECM-B FUSE ENGINE COOLANT TEMPERATURE SENSOR (LEFT FRONT OF CYLINDER HEAD) ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUEL PUMP RELAY GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES KNOCK SENSOR (UNDER INTAKE MANIFOLD) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK PNK WIRE PNK PPL WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PNK WIRE PPL PPL PPL/WHT WIRE PRIMARY FUEL PUMP, SENDER ASSEMBLY (IN FUEL TANK) RED WIRE SECONDARY FUEL PUMP RELAY SECONDARY FUEL PUMP, SENDER ASSEMBLY (IN FUEL TANK) TAN WIRE TAN/WHT WIRE UNDER- HOOD FUSE BLOCK WHT WIRE WHT/ BLK WIRE YEL WIRE