Chevrolet Silverado 2500 (2000-2004) pnk Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 TP SENSOR 1 SIG 15 14 SERIAL DATA SERIAL DATA ACCELERATION PEDAL POSITION SENSOR (BEHIND ACCELERATOR PEDAL) APP SENSOR 2 SIG LOW REF LOW REF APP SENSOR 1 SIG BLK WIRE BLK/WHT WIRE BRN WIRE COMPUTER DATA LINES SYSTEM CRUISE FUSE CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ETC/ECM FUSE GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, START IGN INSTRUMENT PANEL CLUSTER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOW REF (NOT USED) LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) OFF ON OFF ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ ACCEL CRUISE CONTROL ON/OFF SWITCH RESUME/ACCEL SERIAL DATA SERIAL DATA CLASS 2 DATA SET/ COAST STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) TAN WIRE THROTTLE ACTUATOR CONTROL MODULE (LEFT REAR OF ENGINE COMPT) TURN SIGNAL/ MULTIFUNCTION SWITCH UNDER- HOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1 2 6 8 16 GND TCC PWM PC SOL HI PC SOL LO 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID A/T FLUID PRESSURE MANUAL MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR (IN TRANSMISSION) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) EXCEPT SEO FLUID TEMP SENSOR FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START HOT IN RUN, START I/P RELAY BLOCK (BELOW LEFT SIDE OF DASH) INSTRUMENT CLUSTER INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (BELOW STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV RUN WIRE SEO SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TCC PWM SOLENOID TOW/HAUL SWITCH TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) PCM 1 FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR THE BATTERY) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 6 8 16 GND TCC PWM PC SOL HI PC SOL LO 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID A/T FLUID PRESSURE MANUAL MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR (IN TRANSMISSION) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRAKE FUSE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) EXCEPT SEO FLUID TEMP SENSOR FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, ACC, START HOT IN RUN, START I/P RELAY BLOCK (BELOW LEFT SIDE OF DASH) INSTRUMENT CLUSTER INSTRUMENT PANEL CLUSTER (IPC) IPC/DIC FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP OF TRANSMISSION) ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PCM B FUSE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (BELOW STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV RUN WIRE SEO SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TCC PWM SOLENOID TOW/HAUL SWITCH TRANSFER CASE) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) PCM 1 FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR THE BATTERY) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

ABS FUSE ANTI-LOCK IND BLK WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SW IN BRAKE FLUID LEVEL SWITCH (ON LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE IN BRAKE IND BRN WIRE BRN/WHT WIRE CLUTCH START SWITCH (M/T) (TOP OF CLUTCH CLUTCH ASSY) DEL TORQUE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) EXCEPT SEO GRY WIRE HOT AT ALL TIMES HOT IN RUN LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) BRAKE FUSE HOT IN RUN OR START IGN E FUSE IGNITION LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) DELIVERED TORQUE INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LOGIC LT BLU WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL PPL PPL/WHT WIRE RED WIRE REQ TORQUE RIGHT FRONT WHEEL SPEED SENSOR SEO SEO IGN FUSE STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC BRAKE SW TRACTION CONTROL IND (IF EQUIPPED) TRACTION CONTROL SWITCH TRANSFER CASE SHIFT CONTROL MODULE TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM (TRANSFER CASE CIRCUIT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT, NEAR BATTERY) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW VSS OUT YEL WIRE YEL/BLK WIRE

BLK WIRE HOT IN RUN AND START I/P RELAY BLOCK I/P RELAY BLOCK (NEAR LEFT KICK PANEL) LEFT FRONT SHOCK ABSORBER SOLENOID (PART OF LEFT FRONT SHOCK) LEFT REAR SHOCK ABSORBER SOLENOID (PART OF LEFT REAR SHOCK) NORMAL/ FIRM PNK WIRE RIGHT FRONT SHOCK ABSORBER SOLENOID (PART OF RIGHT FRONT SHOCK) RIGHT REAR SHOCK ABSORBER SOLENOID (PART OF RIGHT REAR SHOCK) SELECTABLE RIDE SWITCH SEO IGN FUSE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE

ACCESSORY VOLTAGE BLK WIRE DK BLU WIRE GROUND LSD GRY WIRE HI LO OFF HOT AT ALL TIMES HOT IN RUN AND ACC LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LO PULSE MIST MIST WASH OFF ORG/ WIRE PNK WIRE RED WIRE TAN WIRE TURN SIGNAL/ MULTI-FUNCTION SWITCH UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/S WASH FUSE W/S WASH RELAY W/S WIPER FUSE WINDSHIELD WASHER FLUID PUMP (ON WASHER FLUID RESERVOIR) WINDSHIELD WASHER RELAY CNTRL WINDSHIELD WIPER HIGH SIGNAL WINDSHIELD WIPER MOTOR MODULE (UNDER WINDSHIELD COWL) WINDSHIELD WIPER SUPPLY VOLTAGE WINDSHIELD WIPER SWITCH SIGNAL WINDSHIELD WIPER/ WASHER SWITCH YEL WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK GRN WIRE DSL(ECM) GAS (PCM) ELECTRONIC BRAKE CONTROL MODULE (ON LEFT SIDE OF INNER FRAME) EXCEPT SEO FRONT AXLE ACTUATOR FUSE GRY WIRE GRY/BLK WIRE HOT IN HOT IN RUN OR START IGN E FUSE INSTRUMENT PANEL CLUSTER LAMP LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LOGIC LT BLU WIRE MODULE (DIESEL) (LEFT FRONT OF ENGINE COMPT) PNK WIRE POWERTRAIN CONTROL MODULE (GAS ENGINES) OR ENGINE CONTROL PPL 2 RUN WIRE SEO SEO IGN FUSE SPLICE PACK TRANSFER CASE SHIFT CONTROL SWITCH (ON TOP OF TRANSFER CASE) TRANSMISSION CONTROL MODULE (W/ ALLISON TRANS) (LEFT FRONT OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT)

ANL/DRL DEFEAT AUTO BATTERY BATTERY BATTERY BATTERY GROUND BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BCM) (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) CREW CAB ONLY FUSE GROUND DISTRIBUTION SYSTEM GRY WIRE GRY/BLK WIRE HEAD PARK HEADLAMP SWITCH HOT AT ALL TIMES HOT IN ACC, RUN HOT IN ACC, RUN, START HOT IN RUN, START I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGNITION KEY ALARM SWITCH LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LEFT REAR DOOR LATCH ASSEMBLY LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PARK BRAKE SWITCH (PART OF PARK BRAKE ASSEMBLY) PNK WIRE POWER DISTRIBUTION SYSTEM RIGHT REAR DOOR AJAR SW LEFT REAR DOOR AJAR SW RIGHT REAR DOOR LATCH ASSEMBLY SERIAL DATA SERIAL DATA PARK LAMP ON SIGNAL GROUND DIMMING INPUT TBC ACCY FUSE TBC BATT FUSE TBC IGN 0 FUSE TBC IGN 1 FUSE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE YEL WIRE

3-2 SS CTRL REF LOW A/C SYSTEM BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW STEERING COLUMN) BRN WIRE BRN/WHT WIRE DATA LINK CONNECTOR (BELOW STEERING COLUMN) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE OIL LEVEL SWITCH (RIGHT SIDE OF OIL PAN) FUSE FUSE FUSE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START HOT IN RUN, START INJ 1 CTRL INJ 6 CTRL AFO ENABLE RLY CTRL GND KS SIGNAL KS SIGNAL CKP SIG LEFT I/P FUSE BLOCK IGN 0 FUSE LEV SW SIG LPL CTRL INJ 7 CTRL INJ 4 CTRL LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MOD STATUS B+ CLS 2 DATA CLS 2 DATA OIL LEV SW SIG SELECT SIG PRND B SIG CMP SIG ECT SIG IGN INJ 5 CTRL INJ 8 CTRL ORG/ WIRE ORG/BLK WIRE PCMB FUSE PNK 1 2 3 4 5 WIRE PNK PNK 6 7 8 9 10 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL/WHT WIRE PRND A SIG BRK SW SIG PRND P SIG PPL RANGE B RANGE C IGN B+ REF LOW RED WIRE RED/BLK WIRE REF LOW REF LOW (A/T) REF LOW REF LOW GND SERIAL DATA (-) SERIAL DATA (+) STARTING/ CHARGING SYSTEM TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

4 5 PNK WIRE BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COOLANT LEVEL SWITCH (IN COOLANT RESERVOIR) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (FRONT OF LEFT CYLINDER HEAD) FUEL PUMP RELAY FUEL PUMP, SENDER ASSEMBLY (PRIMARY) (IN FUEL TANK) GRY WIRE HEATED OXYGEN SENSOR (BANK 1 SENSOR 1) (LEFT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 1 SENSOR 2) (LEFT EXH PIPE, AFTER CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 1) (RIGHT EXH PIPE, BEFORE CONVERTER) HEATED OXYGEN SENSOR (BANK 2 SENSOR 2) (RIGHT EXH PIPE, AFTER CONVERTER) HOT AT ALL TIMES KNOCK SENSOR (UNDER INTAKE MANIFOLD) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PCM B FUSE FUSE PNK 1 2 3 4 5 WIRE PNK PNK 6 7 8 9 10 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL PPL PPL/WHT WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK WHT WIRE WHT/ BLK WIRE YEL WIRE YEL/BLK WIRE