Chevrolet Silverado 2500 (2000-2004) blk Wiring diagrams

80 51 45 28 14 68 43 34 58 58 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN A/C MUFFLER HOSE ASSEMBLY) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND TEMP SEN ASS CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LOWER LEFT AIR TEMPERATURE SENSOR (IN LOWER LEFT FLOOR DUCT ASSEMBLY) LOWER RIGHT AIR TEMPERATURE SENSOR (BOTTOM CENTER OF HVAC BOX, IN FLOOR DUCT) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UPPER LEFT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL, IN UPPER DUCT) UPPER RIGHT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL, IN UPPER DUCT) WHT WIRE WHT/BLK WIRE YEL WIRE

11 12 PPL AMBIENT LIGHT SENS LO REF AMBIENT LIGHT SENS SIG RIGHT SUNLOAD SENSOR SIG LEFFT SUNLOAD SENSOR SIG AMBIENT LIGHT SENSOR BLK WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE GRY WIRE LEFT AIR TEMPERATURE ACTUATOR (TOP CENTER OF HVAC CONTROL ASSEMBLY) LEFT SOLAR SENSOR LOGIC LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) PPL RECIRCULATION ACTUATOR (TOP CENTER OF HVAC MODULE) RIGHT AIR TEMPERATURE ACTUATOR (TOP CENTER OF HVAC CONTROL ASSEMBLY) RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT SOLAR SENSOR SUNLOAD SENSOR (TOP CENTER OF DASH) TAN WIRE WHT WIRE WHT/BLK WIRE YEL WIRE

80 51 45 28 14 68 43 34 58 58 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN A/C MUFFLER HOSE ASSEMBLY) BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT DEF GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE CONTROL MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF OFF BLOW MT CTRL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RECIRC SWITCH RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE WHT/BLK WIRE YEL WIRE

AMBIENT LIGHT SENS LO REF AMBIENT LIGHT SENS SIG AMBIENT LIGHT SENSOR (TOP CENTER OF DASH) BLK WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN WIRE CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE LEFT AIR TEMPERATURE ACTUATOR (TOP CENTER OF HVAC CONTROL ASSEMBLY) LOGIC LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) RECIRCULATION ACTUATOR (TOP CENTER OF HVAC MODULE) RIGHT AIR TEMPERATURE ACTUATOR (TOP CENTER OF HVAC CONTROL ASSEMBLY) RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) TAN WIRE WHT WIRE WHT/BLK WIRE YEL WIRE

4 5 RF + GROUND 6 7 8 9 10 DIMMER I/P LAMP ANTENNA BLK WIRE BODY RELAY BLOCK BRN WIRE DATA LINK CONNECTOR DK BLU WIRE DK GRN WIRE GRY WIRE HOT AT ALL TIMES HOT WITH RAP RELAY ENERGIZED IGNITION BATTERY LEFT FRONT DOOR SPEAKER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LEFT REAR DOOR SPEAKER LF+ LR (-) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE RADIO RADIO FUSE RDO I FUSE RF+ RIGHT FRONT DOOR SPEAKER RIGHT REAR DOOR SPEAKER RR (-) SERIAL DATA TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) YEL WIRE

19 20 LR - LR + 4 5 6 7 8 9 10 RF + GROUND DIMMER I/P LAMP ANTENNA BARE BLK WIRE BLK/WHT WIRE BODY JUNCTION BLOCK (NEAR LEFT KICK PANEL) BODY RELAY BLOCK BRN WIRE BRN/WHT WIRE CD PLAYER- REMOTE PLAY- BACK DEVICE CRUISE CONTROL MODULE DATA LINK CONNECTOR DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRY WIRE HOT AT ALL TIMES HOT WITH RAP RELAY ENERGIZED IGNITION BATTERY INSTRUMENT CLUSTER LEFT FRONT DOOR SPEAKER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LEFT REAR DOOR SPEAKER (CREW CAB) LEFT REAR SPEAKER (EXCEPT CREW CAB) LF+ LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) RADIO RADIO FUSE RADIO ON SIG DIM SIG IN DRAIN RT OUTPUT RDO I FUSE RF+ RIGHT FRONT DOOR SPEAKER RIGHT REAR DOOR SPEAKER (CREW CAB) RIGHT REAR SPEAKER (EXCEPT CREW CAB) RR (-) SERIAL DATA VSS SIGNAL RR - TAN WIRE UNDERHOOD JUNCTION BLOCK (ON LEFT SIDE OF ENGINE COMPT) VEHICLE INTERFACE UNIT (IN THE RIGHT SIDE OF I/P NEAR THE INSTRUMENT CLUSTER) VSS SIGNAL YEL WIRE

19 20 LR - LR + 4 5 6 7 8 9 10 RF + GROUND DIMMER I/P LAMP ANTENNA BARE BLK WIRE BLK/WHT WIRE BODY JUNCTION BLOCK (NEAR LEFT KICK PANEL) BODY RELAY BLOCK BRN WIRE BRN/WHT WIRE CD PLAYER- REMOTE PLAY- BACK DEVICE CRUISE CONTROL MODULE DATA LINK CONNECTOR (ON LEFT LOWER DASH BELOW THE STEERING COLUMN) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRY WIRE HOT AT ALL TIMES HOT WITH RAP RELAY ENERGIZED IGNITION BATTERY INSTRUMENT CLUSTER LEFT FRONT DOOR SPEAKER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LEFT REAR DOOR SPEAKER (CREW CAB) LEFT REAR SPEAKER (EXCEPT CREW CAB) LF+ LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) RADIO RADIO FUSE RDO I FUSE RF+ RIGHT FRONT DOOR SPEAKER RIGHT REAR DOOR SPEAKER (CREW CAB) RIGHT REAR SPEAKER (EXCEPT CREW CAB) RR (-) SERIAL DATA VSS SIGNAL RR - TAN WIRE UNDERHOOD JUNCTION BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS SIGNAL YEL WIRE

2-HI IND 4-HI IND 4-LO IND ATC FUSE AUTO AUXILIARY BATTERY RELAY B+ MOTOR (CCW) MOTOR (CW) GND BLK WIRE BLK/WHT WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRAKE CONTROL BRN WIRE BRN/WHT WIRE CONTROL MODULE CTRL DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENCODER LOGIC ENCODER MOTOR ENCODER RTN FRONT AXLE ACTUATOR FRONT PROP- SHAFT SPEED SENSOR FT SHAFT SIG FT SHAFT RTN FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, START ILLUMINATION LAMP (2) INSTRUMENT PANEL CLUSTER LAMP LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LOCK SOL OUT LOGIC LT BLU WIRE LT GRN/BLK WIRE MODULE GND 4-LO IND 4-HI IND NEUTRAL IND FT AXLE CTRL RR SHAFT SIG RR SHAFT RTN NCA WIRE NEUTRAL IND ORG/ WIRE PNK WIRE PPL PPL/WHT WIRE REAR PROP- SHAFT SPEED SENSOR RED WIRE RED/WHT WIRE REF RUN WIRE SHIFT MOTOR SOLID STATE SPLICE PACK TAN WIRE TAN/BLK WIRE TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSFER CASE SHIFT CONTROL SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) YEL WIRE YEL/BLK WIRE

AUXILIARY BATTERY RELAY BLK WIRE BLK/WHT WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRN WIRE DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK GRN WIRE DSL(ECM) GAS (PCM) ELECTRONIC BRAKE CONTROL MODULE (ON LEFT SIDE OF INNER FRAME) FRONT AXLE ACTUATOR FUSE GRY WIRE GRY/BLK WIRE HOT IN HOT IN RUN, START INSTRUMENT PANEL CLUSTER LAMP LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LOGIC LT BLU WIRE MODULE (DIESEL) (LEFT FRONT OF ENGINE COMPT) PNK WIRE POWERTRAIN CONTROL MODULE (GAS ENGINES) OR ENGINE CONTROL PPL RUN WIRE SPLICE PACK TRANSFER CASE SHIFT SWITCH (LEFT FRONT OF TRANSFER CASE) TRANSMISSION CONTROL MODULE (W/ ALLISON TRANS) (LEFT FRONT OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY)

BLK WIRE DK GRN WIRE GRY WIRE HI MIST MIST OFF OFF LO LO PULSE PULSE HIGH MUX 1 MUX 2 HOT IN ACC, RUN LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) MIST NCA WIRE OFF LO PULSE PNK WIRE PPL RED WIRE UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPARTMENT, NEAR BATTERY) W/S WIPER FUSE WASH WASH WINDSHIELD WASHER FLUID PUMP (IN WASHER FLUID RESERVOIR) WINDSHIELD WIPER MOTOR MODULE (ON FIREWALL) WINDSHIELD WIPER/ WASHER SWITCH YEL WIRE