Chevrolet Silverado 2500 HD (2002-2012) hot at all times Wiring diagrams

10 11 PNK SENS SIG WIRE 16 5 SER DATA RWD SIG 9 10 PPL FWD CTRL RWD CTRL BLK WIRE COMPUTER DATA LINES SYSTEM DK GRN WIRE DRIVER MEMORY/HEATED SEAT SWITCH DRIVER'S MEMORY SEAT CIRCUIT DSM FUSE 25 ELECTRONIC ADJUSTABLE PEDAL (EAP) ASSEMBLY (UNDER LEFT SIDE OF DASH) EXIT GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH, I/P MULTI-FUNCTION SWITCH LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LOGIC DRIVER DOOR LOCK/WINDOW SWITCH LOW REF MEMORY SEAT MODULE (MSM) (UNDER FRONT OF DRIVER'S SEAT) ORG/ WIRE ORG/BLK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL PPL SW SIG PPL/WHT WIRE RED/WHT WIRE SERIAL DATA SW SIG TAN WIRE YEL WIRE YEL/BLK WIRE

18 25 DOME LP SW DEFEAT SW PPL 3 2 B+ B+ 5 1 VOLT VOLT BCM FUSE BLK WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) CARGO LAMP/ CENTER HIGH MOUNTED STOP LAMP (CHMSL) DEF SW DK BLU/WHT WIRE DOME DOME SW FRONT COURTESY/ READING LAMPS GRY WIRE HEADLAMP AND PANEL DIMMER SWITCH HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH, IS LPS FUSE LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT VANITY MIRROR LAMP ORG/ WIRE PPL READING READING LAMPS REAR COURTESY READING LAMPS (W/ EXTENDED CREW CAB) RED/WHT WIRE RIGHT VANITY MIRROR LAMP VOLT WHT/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 PPL DOWN CTRL UP CTRL 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 PPL ELEMENT CTRL 1 2 3 4 5 6 GND ADJUSTABLE PEDALS CIRCUIT BLK WIRE BREAKOUT) BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DRIVER SEAT 2 CIRCUIT DRIVER SEAT ADJUSTER ASSEMBLY (ON DRIVER'S SEAT TRACK) DRIVER SEAT LUMBAR HORIZONTAL MOTOR (IN DRIVER'S SEAT BACK) DRIVER SEAT LUMBAR HORIZONTAL MOTOR POSITION SENSOR (IN DRIVER'S SEAT TRACK) DRIVER SEAT LUMBAR VERTICAL MOTOR (IN DRIVER'S SEAT BACK) DRIVER SEAT LUMBAR VERTICAL MOTOR POSITION SENSOR (IN DRIVER'S SEAT TRACK) DRIVER SEAT RECLINE MOTOR (LOWER RIGHT SIDE OF DRIVER SEAT BACK) DRIVER SEAT RECLINE POSITION SENSOR (IN DRIVER'S SEAT BACK) DSM FUSE 25 ELEMENT CTRL FWD CTRL RWD CTRL ELEMENT CTRL FWD CTRL RWD CTRL PNK PNK WIRE FWD CTRL RWD CTRL ELEMENT CTRL UP CTRL DOWN CTRL SPLY VOLT UP CTRL DOWN CTRL GND B+ B+ GRY WIRE HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH, LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LT BLU WIRE LT GRN WIRE MEMORY SEAT MODULE (UNDER FRONT OF DRIVER'S SEAT) ORG/BLK WIRE PNK SENS SIG WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL PPL FWD CTRL RWD CTRL PPL/WHT WIRE RED/WHT WIRE SEATS SYSTEM SENS SIG SENS SIG SENS SIG SENS SIG SENS SIG SENS SIG SPLY VOLT TAN WIRE TAN/BLK WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 L AUD+ R AUD+ 1 2 3 4 B+ LF SPK+ RF SPK+ VOICE SIG/ ANTENNA AUD SIG AUDIO W/ DVD NAVIGATION BLK WIRE BLUNT CUT) BRN WIRE BRN/WHT WIRE CELLULAR TELEPHONE MICROPHONE (IN OVERHEAD CONSOLE) CELLULAR/ NAVIGATION ANTENNA CELLULAR/ NAVIGATION, DIGITAL RADIO ANTENNA CELLULAR/NAVIGATION, DIGITAL RADIO ANTENNA (LEFT FRONT OF ROOF) COAX COAX COAX COMPUTER DATA LINES SYSTEM DIGITAL RADIO RECEIVER (BEHIND RIGHT END OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRAIN WIRE GMLAN GREEN LED GRY WIRE HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH, INFO FUSE 22 KEYPAD SIG L AUD - R AUD - DRAIN WIRE LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LOW REF LOW REF/ DRAIN WIRE 6 7 8 9 10 11 12 13 14 REM SIG LED CNTRL GND LF SPK- RF SPK- LR AUD + RR AUD + VOICE SIG LR AUD - RR AUD - LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM RADIO RDO FUSE 42 FUSE 39 RED LED WIRE RED/WHT WIRE SHIELD SUPPLY TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TELE SIG UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) USB CABLE USB RECEPTACLE (IF EQUIPPED) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) (BEHIND CENTER OF DASH) VOICE SIG WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRAIN WIRE GMLAN GRY WIRE HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH, INFRARED REF INFRARED V INSIDE REARVIEW MIRROR (ISRVM) L INFRARED LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/BLK WIRE PNK WIRE PPL/WHT WIRE R INFRARED REAR SEAT AUDIO (RSA) CONTROL (IF EQUIPPED) RED/WHT WIRE RIGHT I/P J/B (IN RIGHT END OF DASH) RSE FUSE 19 TAN WIRE W/ S-BAND DIGITAL AUDIO SYSTEM / VEHICLE COMUNICATION SYSTEM WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 367 368 2099 L AUD+ R AUD+ DRAIN WIRE 1 2 3 4 B+ LF AUD+ RF AUD+ VOICE SIG/ 1999 1946 659 LR AUD- RR AUD- LOW REF 372 388 1573 L AUD- R AUD- DRAIN WIRE 599 546 658 LR AUD+ RR AUD+ VOICE SIG AMP FUSE 41 FUSE 38 ANTENNA AUD SIG AUDIO W/ DVD NAVIGATION BLK WIRE BLUNT CUT) BRN WIRE BRN/WHT WIRE CELLULAR TELEPHONE MICROPHONE (IN OVERHEAD CONSOLE) CELLULAR/ NAVIGATION ANTENNA CELLULAR/ NAVIGATION, DIGITAL RADIO ANTENNA CELLULAR/NAVIGATION, DIGITAL RADIO ANTENNA (LEFT FRONT OF ROOF) COAX COAX COAX COMPUTER DATA LINES SYSTEM CUT) DIGITAL RADIO RECEIVER (BEHIND RIGHT END OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRAIN WIRE GMLAN GREEN LED GRY WIRE HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH, INFO FUSE 22 KEYPAD SIG LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LOW REF LT BLU/BLK WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM RADIO RED LED WIRE RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RSE FUSE 19 SHIELD SUPPLY TAN WIRE TAN/BLK WIRE TAN/WHT WIRE USB CABLE USB CABLE USB RECEPTACLE (IF EQUIPPED) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) (BEHIND CENTER OF DASH) VOICE SIG W/ ONSTAR W/ REAR SEAT ENTERTAINMENT PACKAGE WHT WIRE YEL WIRE YEL/BLK WIRE

6399 (OR 821) 71 72 73 VSS HIGH SIG VSS LO SIG GND A/C CL CTL A/C PRES SIG LO REF AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM AXL SW SIG BANK 1 SENSOR 2 (DOWNSTREAM OF LEFT CATALYTIC CONVERTER) BANK 2 SENSOR 2 (DOWNSTREAM OF RIGHT CATALYTIC CONVERTER) BLK WIRE BLK/WHT WIRE BRK SW SIG BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM COOLING FANS SYSTEM COOLING FANS SYSTEM COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) FUEL CTL FUEL CTL-SEC STRT RLY CTL FUEL LVL-SEC FUEL PMP RELAY FUEL PUMP FUSE 20 FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL PUMP, SENDER ASSEMBLY) GMLAN - GMLAN + GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN HOT AT ALL TIMES IAT SIG LO REF LO REF LO REF LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAF SIG MIL CTL PPL NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PNK WIRE PNK/BLK WIRE PPL PPL FUEL LVL-PRI CFAN HI CTL ACC SER DATA PPL LO REF FTP SIG PPL/WHT WIRE PRIMARY FUEL PUMP, REAR FUEL PUMP, SENDER ASSEMBLY (6.0L (VIN K)) (IN REAR FUEL TANK) RED/WHT WIRE SECONDARY FUEL PUMP (FP) RELAY (6.0L (VIN K)) (LEFT SIDE OF ENGINE COMPT) SENDER ASSEMBLY (INSIDE FUEL TANK) STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VSS CFAN LO CTL PWTN RLY CTL WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

ACCELERATOR PEDAL POSITION (APP) SENSOR (ABOVE ACCELERATOR PEDAL) BLK/WHT WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE ECM BATT FUSE 12 ECM-IGN FUSE 56 ECM/THROT CONT FUSE 5 ENG FUSE 4 FUEL INJECTORS (TOP OF LEFT CYLINDER BANK) FUEL INJECTORS (TOP OF RIGHT CYLINDER BANK) FUSE 18 (DIAGRAM 3 OF 4) HOT AT ALL TIMES HOT IN RUN OR START IAT INJ-A FUSE 24 INJ-B FUSE 13 LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE MAF ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE PPL PPL PNK PNK WIRE PWR/ TRN RELAY RED/WHT WIRE SNSR FUSE 8 TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCM- BATT FUSE 14 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1 2 PNK WIRE 22 23 24 25 PPL AXLE SW SIG BLK WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT OF ENGINE, ABOVE CRANK PULLEY) CKP SENSOR SIG CRANKSHAFT POSITION (CKP) SENSOR (FRONT OF ENGINE, RIGHT OF CRANK PULLEY) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EGT SENSOR SIG ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) FRP SENSOR SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE HOLDER (RIGHT SIDE OF FIREWALL) IGN 1 VOLT INJ 1 INJ 2 INTAKE AIR VALVE LOW REF LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE MEGA FUSE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK 8 9 10 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE PTO ENG OFF SIG RED WIRE RED/BLK WIRE RED/WHT WIRE SENS 2 SPLY VOL SIG TAN WIRE TAN/WHT WIRE TCC BRAKE SIG TP SENSOR SIG TRANSMISSIONS SYSTEM WATER IN FUEL WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE DSL ECM FUSE 12 ECM BATT FUSE 11 ECM IGN FUSE 53 ECM/ THROT CONT FUSE 17 ENG FUSE 3 FUEL HTR FUSE 8 FUEL INJECTOR 1 (TOP OF RIGHT CYLINDER BANK) FUEL INJECTOR 2 (ABOVE CYLINDER 2) FUEL INJECTOR 3 (TOP OF RIGHT CYLINDER BANK) FUEL INJECTOR 4 (ABOVE CYLINDER 4) FUEL INJECTOR 5 (TOP OF RIGHT CYLINDER BANK) FUEL INJECTOR 6 (ABOVE CYLINDER 6) FUEL INJECTOR 7 (TOP OF RIGHT CYLINDER BANK) FUEL INJECTOR 8 (ABOVE CYLINDER 8) FUEL PMP RELAY FUEL PUMP FUSE 18 FUSE 6 GRY WIRE HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY ENERGIZED LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWER TAKE OFF (PTO) MODULE (OUTSIDE OF RIGHT FRONT CHASSIS FRAME) POWER TAKE OFF (PTO) PROVISION (BLUNT CUT) PPL PPL 20 21 22 23 24 25 PWR/ TRN RELAY RED/WHT WIRE TAN WIRE TAN/WHT WIRE TRANS.) TRANSFER CASE) UNDER- HOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) W/ AUXILIARY FUEL TANK 31 SERIES WHT DK GRN/ WIRE WHT RED/ WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE