Chevrolet Silverado 2500 HD (2002-2012) computer data lines system Wiring diagrams

10 11 13 14 2500 2501 2501 2500 DATA BUS + DATA BUS - DATA BUS - DATA BUS + ACCELERATOR PEDAL POSITION (APP) SENSOR (ABOVE ACCELERATOR PEDAL) APP SEN 1 SIG LOW REF APP SEN 2 SIG LOW REF VSS LO SIG VSS HI SIG PPL AUTOMATIC TRANSMISSION BATT + BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRN WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY CRUISE CONTROL IND DIMMING SIG CRUISE CONTROL SWITCH SIGNAL CRUISE IND CRUISE SWITCH DK BLU WIRE DK GRN WIRE ECM BATT FUSE 12 ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) GRN WIRE GRN/WHT WIRE GROUND GRY WIRE HI SPD GMLAN SER DATA BUS- HOT AT ALL TIMES HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH) DIM FUSE 7 HOT W/ RUN/CRNK RELAY ENERGIZED INFLATABLE PNK RESTRAINT STEERING WHEEL MODULE COIL (BEHIND STEERING WHEEL) WIRE INPUT SHAFT SPEED SENSOR (ISS) INPUT SPEED SENSOR (ISS) SIGNAL INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 46 ISS/OSS SUPPLY VOLTAGE LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT STEERING WHEEL CONTROL SWITCH ASSEMBLY LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MISC-IGN FUSE 43 ORG/WHT WIRE OUTPUT SHAFT SPEED SENSOR (OSS) OUTPUT SPEED SENSOR (OSS) SIGNAL PNK PNK WIRE PNK STEERING WHEEL CNTRL SUP VOLT WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL PPL BRAKE SW SIG PPL/WHT WIRE RED WIRE RED/WHT WIRE RES+ SER DATA SET- SOUND SYSTEMS STOP LAMP SWITCH (TOP OF BRAKE PEDAL ASSEMBLY) TAN WIRE TAN/BLK WIRE TP SENS 1 SIG LOW REF TP SENS 2 SIG TAC MOTOR CTRL 2 TAC MOTOR CTRL 1 TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) W/ TWO SPEED PUSH BUTTON, ELECTRIC SHIFT CONTROL TRANSFER CASE W/O TWO SPEED PUSH BUTTON, ELECTRIC SHIFT CONTROL TRANSFER CASE WHT/BLK WIRE YEL WIRE

44 57 15 49 29 SER DATA BUS- SER DATA BUS+ 7 20 2 4 6 MOTOR CTRL 2 MOTOR CTRL-1 83 77 STOP LAMP SW SIG BATT + ACCELERATOR PEDAL POSITION (APP) SENSOR (ABOVE ACCELERATOR PEDAL) APP SEN 1 SIG LOW REF APP SEN 2 SIG LOW REF PPL BATT + BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRN WIRE COMPUTER DATA LINES SYSTEM CRUISE CONTROL IND DIMMING SIG CRUISE CONTROL SWITCH SIGNAL CRUISE IND CRUISE SWITCH DK BLU WIRE DK GRN WIRE ECM BATT FUSE 11 ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) GMLAN DATA BUS- GRN/WHT WIRE GROUND GROUND GROUND GROUND GRY WIRE HI SPD GMLAN SER DATA BUS- HOT AT ALL TIMES HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH) DIM FUSE HOT W/ RUN/CRNK RELAY ENERGIZED INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (BEHIND STEERING WHEEL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 43 LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT STEERING WHEEL CONTROL SWITCH ASSEMBLY LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MISC IGN FUSE 40 ORG/WHT WIRE PNK STEERING WHEEL CNTRL SUP VOLT WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL PPL BRAKE SW SIG PPL/WHT WIRE RED/WHT WIRE RES+ SER DATA SET- SOUND SYSTEMS STOP LAMP SWITCH (TOP OF BRAKE PEDAL ASSEMBLY) TAN WIRE TAN/BLK WIRE TP SENS SIG LOW REF TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (REAR OF TRANSMISSION) VSS HI SIG VSS LO SIG W/ TWO SPEED PUSH BUTTON, ELECTRIC SHIFT CONTROL TRANSFER CASE W/O TWO SPEED PUSH BUTTON, ELECTRIC SHIFT CONTROL TRANSFER CASE WHT/BLK WIRE YEL WIRE

12 13 PPL BRK SIG 16 17 19 GMLAN + GMLAN - COMM DATA ABS INDICATOR BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE BOOSTER VACUUM SENSOR (LEFT REAR OF ENGINE COMPT) BRAKE FLUID LEVEL SWITCH (ON MASTER CYLINDER) BRAKE INDICATOR COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE EXCEPT 4.3L, 5.3L (VIN O), 5.3L (VIN 3), 6.0L (VIN K) GRY WIRE GRY/WHT WIRE I/P MULTI-FUNCTION SWITCH INSTRUMENT PANEL CLUSTER (IPC) LOGIC LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) POWER BRAKE BOOSTER (LEFT REAR OF ENGINE COMPT) PPL PPL/WHT WIRE PRK BRK SW RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON RIGHT FRONT STEERING KNUCKLE) STEERING ANGLE SENSOR (ON STEERING COLUMN) STOP LAMP SWITCH (TOP OF BRAKE PEDAL ASSEMBLY) TAN WIRE TAN/BLK WIRE TRACTION SW YEL WIRE YEL/BLK WIRE

12 13 PPL BRK SIG 16 17 19 GMLAN + GMLAN - COMM DATA 6.0L ABS INDICATOR ABS PUMP MOTOR ABS-1 FUSE 61 FUSE 56 B+ GMLAN + GMLAN + BRK SNS BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE FLUID LEVEL SWITCH BRAKE INDICATOR COMM DATA VEH SPD SIG COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF FRAME ASSEMBLY) ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) EXCEPT 6.0L (VIN K) FUEL SYSTEM CONTROL MODULE (FSCM) (UNDER REAR OF VEHICLE) GRY WIRE GRY/WHT WIRE HEAVY DUTY ABS FUSE 59 FUSE 55 HOT AT ALL TIMES UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) INSTRUMENT PANEL CLUSTER (IPC) LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON LEFT FRONT STEERING KNUCKLE) LF WHL SNS LOGIC LOW REF GND GMLAN - GMLAN - VEH SPD SIG LT BLU WIRE NCA WIRE ORG/ WIRE ORG/WHT WIRE PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) POWER TAKE OFF (PTO) MODULE (OUTSIDE OF RIGHT FRONT CHASSIS FRAME) PPL PRK BRK SW RADIO RED WIRE RED/BLK WIRE RF WHL SNS RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON RIGHT FRONT STEERING KNUCKLE) STOP LAMP SWITCH (TOP OF BRAKE PEDAL ASSEMBLY) TAN WIRE TAN/BLK WIRE W/ LUXURY EDITION W/O LUXURY EDITION EXCEPT 6.6L 6.6L YEL WIRE YEL/BLK WIRE

1 2 3 4 1140 5060 B+ GMLAN COMPUTER DATA LINES SYSTEM 1 3 4 B+ SNS SIG SNS SIG 14 15 RR AJAR SW LR AJAR SW 18 24 23 HORN RLY PRL LP RLY HDLP RLY 1851 5060 COMPUTER DATA LINES SYSTEM 23 8 20 INTRUS SIG RF DR AJR SW DR KEY SW 28 45 HORNS SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM 3 10 B+ GMLAN 3 8 5531 109 PPL HOOD SW SIG HOOD AJAR SW SIG 4 6 B+ GRD ACC V AUXILIARY FUSE BLOCK B+ SNS SIG SNS SIG B+ VOLT GND GMLAN BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRN WIRE COAX ANT COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM GMLAN DDM FUSE 4 DIM FUSE 7 BCM FUSE 15 DISTRIBUTION SYSTEM POWER DK BLU WIRE DK GRN WIRE DLIS FUSE 35 FUSE 32 DOOR AJAR INDICATOR DRIVER DOOR LOCK SWITCH DRIVER DOOR LOCK/ WINDOW SWITCH DSM FUSE 25 EXCEPT 6.6L 6.6L 6.0L (VIN J) EXCEPT 6.0L (VIN J) FUSE 52 FUSE 49 GMLAN GROUND DISTRIBUTION (ON RIGHT FRONT CORNER OF HVAC MODULE) SYSTEM GROUND DISTRIBUTION SYSTEM GRY WIRE GRY/BLK WIRE HOOD AJAR SWITCH HOT AT ALL TIMES HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH) IGNITION SWITCH INSTRUMENT PANEL CLUSTER (IPC) INTERIOR LIGHTS SYSTEM COMPUTER DATA LINES SYSTEM INTERIOR LIGHTS SYSTEM RF AJAR SW KEYLESS ENTRY ANTENNA LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LF AJAR SW LOCK LOGIC LOGIC 4 6 B+ GRD LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OFF PASSENGER DOOR LOCK/ WINDOW SWITCH PDM FUSE 9 (W/ COMFORT, DECOR LEVEL 3 CONVENIENCE PACKAGE) PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWER DISTRIBUTION SYSTEM PPL PPL INTRUS SIG PPL SW SIG PPL/ PPL/ PPL/ RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (TOP REAR OF PASSENGER COMPT) RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RUN WIRE SEC IND SECURITY IND DRIVER INFORMATION CENTER (DIC) DISPLAY SECURITY INDICATOR LAMP SW SIG TAN WIRE TAN/WHT WIRE THEFT DETERRENT CONTROL MODULE (ON RIGHT SIDE OF STEERING COLUMN) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNLOCK VEHICLE INCLINATION SENSOR VEHICLE SHOCK SENSOR W/ INDIVIDUAL FRONT SEAT, POWER MIRROR W/ KEYLESS ENTRY, PTO W/ REMOTE KEYLESS ENTRY, PTO YEL WIRE

ACCESSORY WAKEUP SERIAL DATA ANTI-LOCK BRAKES, EXTERIOR LIGHTS SYSTEMS ANTI-THEFT SYSTEM BATTERY BCM FUSE 15 BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CRUISE CONTROL, SEATS SYSTEMS CRUISE CTRL IND DIM SIG CTSY FUSE 5 DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRL RELAY CTRL EXHAUST BRK SW SIG FOG LAMP RELAY CTRL FRONT FOG LAMP SW SIG/ENABLE GAS DIESEL GROUND GRY WIRE HEADLAMP HI BEAM RELAY CTRL HEADLIGHTS SYSTEM HI SPD GMLAN SERIAL DATA BUS + HOOD AJAR SW SIG HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE OF DASH, I/P LAMP DIMMER SW SIG INDICATOR DIM CTRL INSTRUMENT CLUSTER SYSTEM INTERIOR LIGHTS, EXTERIOR LIGHTS SYSTEMS IPC FUSE 46 FUSE 43 IS LPS FUSE 17 LED BACKLIGHT DIM CTRL LINER INTERCONNECT BUS LO SPD SERIAL DATA LOW REF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE LT STOP TRN FUSE 6 LT TRLR TURN SIG LAMP ORG/ WIRE ORG/WHT WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL/WHT WIRE RED WIRE RED/WHT WIRE RF TURN SIG LAMP SUPPLY RT STOP TRN FUSE 8 RT TRLR TURN SIG LAMP RUN/CRANK RELAY CTRL SECURITY IND CTRL SERIAL DATA COMM ENABLE STOP LAMPS FUSE 12 STP LP SW SIG TAN WIRE TAN/BLK WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK WASHER RELAY CTRL WHT WIRE WIPER MOTOR PARK SW SIG WIPER/WASHER SYSTEM YEL WIRE

2500 2501 COMPUTER DATA LINES SYSTEM 66 46 DATA BUS + DATA BUS - BLK WIRE BLK/WHT WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ECT SENS SIG ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) ENGINE COOLANT LEVEL SWITCH (ON BOTTOM OF SURGE TANK) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT CENTER OF ENGINE) ENGINE COOLING FAN (FRONT CENTER OF ENGINE COMPT) FAN FUSE 68 FAN RLY RELAY GMLAN L GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOGIC B+ GND LOW REF LT GRN WIRE MANUAL A/C AUTOMATIC A/C RLY SPD SIG SERIAL DATA SPD SIG SW SIG TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

7 3 SUPPLY VOLT LOW REF BATTERY BLK WIRE COMPUTER DATA LINES SYSTEM DDM FUSE DK GRN WIRE DRIVER DOOR SWITCH (DDS) FUSE BLOCK (I/P) (LEFT SIDE OF DASH) GROUND HOT AT ALL TIMES HVAC CONTROL MODULE JUNCTION BLOCK (RIGHT I/P) (IN RIGHT END OF DASH) LOW REF OUTSIDE REARVIEW MIRROR- DRIVER OUTSIDE REARVIEW MIRROR- PASSENGER PASSENGER DOOR SWITCH (PDS) PDM FUSE POWER DISTRIBUTION SYSTEM R DEF REAR DEFOG SWITCH RED WIRE RED/WHT WIRE SERIAL DATA SUPPLY VOLT WHT WIRE

2501 2500 7631 944 COMPUTER DATA LINES SYSTEM 2501 2500 COMPUTER DATA LINES SYSTEM B+ RLY ENABLE BLK RED/ WIRE BLK WIRE BRN WIRE COMM DATA COMPUTER DATA LINES SYSTEM DK BLU WIRE EXCEPT 10 SERIES EXCEPT 10 SERIES 10 SERIES EXCEPT 6.6L 6.6L W/O 10 SERIES FSCM FUSE 21 GMLAN - GMLAN + GMLAN - GMLAN + LOW REF RLY FEEDBACK HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY ENERGIZED UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) ITBC FUSE 6 FUSE 19 LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MISC IGN FUSE 43 FUSE 40 PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE RED/BLK WIRE RED/WHT WIRE STOP LAMP SWITCH (TOP OF BRAKE PEDAL ASSEMBLY) STUD 2 FUSE 63 FUSE 58 TAN WIRE TAN/BLK WIRE TCC BRK SIG TRAILER BRAKE (BLUNT CUT) TRAILER BRAKE CONTROL SWITCH TRAILER CONNECTOR (AT REAR OF VEHICLE) TRAILER) TRL BRK RLY IGN 1 VOLT TRL BRK SIG TRL BRK SIG RLY FEEDBACK W/ HEAVY DUTY TRAILER WHEEL HARNESS TRAILER WHEEL TRAILER CAMPER TRAILER PROVISION (BLUNT CUT) (ON LEFT REAR BODY MOUNT) WHT WIRE YEL WIRE YEL/BLK WIRE

6399 (OR 821) 71 72 73 VSS HIGH SIG VSS LO SIG GND A/C CL CTL A/C PRES SIG LO REF AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM AXL SW SIG BANK 1 SENSOR 2 (DOWNSTREAM OF LEFT CATALYTIC CONVERTER) BANK 2 SENSOR 2 (DOWNSTREAM OF RIGHT CATALYTIC CONVERTER) BLK WIRE BLK/WHT WIRE BRK SW SIG BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM COOLING FANS SYSTEM COOLING FANS SYSTEM COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) FUEL CTL FUEL CTL-SEC STRT RLY CTL FUEL LVL-SEC FUEL PMP RELAY FUEL PUMP FUSE 20 FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL PUMP, SENDER ASSEMBLY) GMLAN - GMLAN + GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN HOT AT ALL TIMES IAT SIG LO REF LO REF LO REF LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAF SIG MIL CTL PPL NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PNK WIRE PNK/BLK WIRE PPL PPL FUEL LVL-PRI CFAN HI CTL ACC SER DATA PPL LO REF FTP SIG PPL/WHT WIRE PRIMARY FUEL PUMP, REAR FUEL PUMP, SENDER ASSEMBLY (6.0L (VIN K)) (IN REAR FUEL TANK) RED/WHT WIRE SECONDARY FUEL PUMP (FP) RELAY (6.0L (VIN K)) (LEFT SIDE OF ENGINE COMPT) SENDER ASSEMBLY (INSIDE FUEL TANK) STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VSS CFAN LO CTL PWTN RLY CTL WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE