Chevrolet Silverado 2500 HD (2002-2012) computer data lines system Wiring diagrams

4.3L EXCEPT 4.3L BLK WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRN WIRE CHARGE IND SIG CHARGE INDICATOR COMPUTER DATA LINES SYSTEM CURRENT SPLY DATA BUS - DK GRN WIRE DRIVER INFORMATION CENTER (DIC) ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT) GENERATOR B+ GENERATOR SIG GRY WIRE HOT AT ALL TIMES IGN INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 46 LOGIC LOW REF MEGA FUSE MEGA FUSE (RIGHT REAR OF ENGINE COMPT) PNK WIRE POWER DISTRIBUTION SYSTEM POWER SUPPLY RED WIRE RED/WHT WIRE RIGHT BATTERY SENS SIG SERIAL DATA TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNDERHOOD FUSE HOLDER (ON POSITIVE BATTERY TERMINAL) VOLT W/ 10 SERIES WHT WIRE

2 MODE HYBRID 6 SPEED A/T 4.3L EXCEPT 4.3L 6.6L ALLISON TRANSMISSION 6 SPEED A/T AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION FLUID PRESSURE (TFP) MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION INTERNAL MODE SWITCH (IMS) BLK WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY DATA BUS - ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT) HEAD IGN IGNITION SWITCH LOCK MEGA FUSE ORG/ WIRE ORG/BLK WIRE PARK/ NEUTRAL POSITION (PNP) SWITCH (ON LEFT REAR SIDE OF TRANSMISSION) PARK/NEUTRAL SIGNAL PNK/BLK WIRE POWER DISTRIBUTION SYSTEM POWER SUPPLY PPL RED WIRE RED/BLK WIRE RIGHT BATTERY RUN WIRE STARTER MOTOR STRT RLY CTRL STRTR FUSE 62 (EXCEPT 6.6L) FUSE 57 (6.6L) TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) STRTR RELAY WHT WIRE YEL WIRE YEL/BLK WIRE

AUXILIARY GENERATOR (W/ DUAL GENERATOR) BLK WIRE BRN WIRE CHARGE IND SIG CHARGE INDICATOR COMPUTER DATA LINES SYSTEM DATA BUS - DK GRN WIRE DRIVER INFORMATION CENTER (DIC) ENGINE COMPT) ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF GENERATOR B+ GENERATOR SIG GRY WIRE HOT AT ALL TIMES IGN INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 43 LOGIC MEGA FUSE POWER DISTRIBUTION SYSTEM RED WIRE RED/WHT WIRE RIGHT BATTERY TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNDERHOOD FUSE HOLDER (RIGHT SIDE OF FIREWALL) VOLT W/ DUAL GENERATOR WHT WIRE

2 MODE HYBRID 6 SPEED A/T 4.3L EXCEPT 4.3L 6.6L ALLISON TRANSMISSION 6 SPEED A/T AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION FLUID PRESSURE (TFP) MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION INTERNAL MODE SWITCH (IMS) BLK WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY DATA BUS - ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT) HEAD IGN IGNITION SWITCH LOCK MEGA FUSE ORG/ WIRE ORG/BLK WIRE PARK/ NEUTRAL POSITION (PNP) SWITCH (ON LEFT REAR SIDE OF TRANSMISSION) PARK/NEUTRAL SIGNAL PNK/BLK WIRE POWER DISTRIBUTION SYSTEM POWER SUPPLY PPL RED WIRE RED/BLK WIRE RIGHT BATTERY RUN WIRE STARTER MOTOR STRT RLY CTRL STRTR FUSE 62 (EXCEPT 6.6L) FUSE 57 (6.6L) TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) STRTR RELAY WHT WIRE YEL WIRE YEL/BLK WIRE

12 VOLT REF 12-VOLT REF ANGLE SENSOR PHASE B CAN BUS LOW SERIAL DATA 12-VOLT REF LF WHEEL SPD SENS SIG 16 17 2500 2501 COMPUTER DATA BUS + DATA BUS - DATA LINES SYSTEM 2501 2501 COMPUTER DATA LINES SYSTEM 3 5 SENS PHASE A SENS PHASE C 5-VOLT REF VEHICLE SPEED SIGNAL CAN BUS HIGH SERIAL DATA ABS INDICATOR ABS-1 FUSE 61 (GAS) FUSE 56 (DIESEL) BLK WIRE BLK/ WHT WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE PRESSURE MODULATOR VALVE BRAKE WARNING INDICATOR BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF FRAME ASSEMBLY) EXCEPT LUXURY GAS GROUND GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HI SERIAL DATA HOT AT ALL TIMES I/P MULTI-FUNCTION SWITCH INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT REAR WHEEL SPEED SENSOR (WSS) (ON LEFT REAR BRAKE BACKING PLATE) LO SERIAL DATA LOGIC LOW REF 12-VOLT REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LUXURY NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PARK BRAKE SW SIG PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) POWER DISTRIBUTION SYSTEM PPL PPL BRAKE SW SIG RED/BLK WIRE RED/WHT WIRE RIGHT REAR WHEEL SPEED SENSOR (WSS) (ON RIGHT REAR BRAKE BACKING PLATE) SENS PHASE B SERIAL DATA SERIAL DATA BATTERY POSITIVE VOLTAGE SERIAL DATA BUS (+) SERIAL DATA BUS (+) BATTERY POSITIVE VOLTAGE SERIAL DATA BUS- SERIAL DATA BUS- GROUND SIG TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRACTION CONTROL SWITCH SIGNAL TRACTION CTRL SW SIG VEHICLE SPD SIG RADIO YAW RATE, LATERAL ACCELERATION SENSOR (UNDER CENTER CONSOLE TRIM PANEL) YEL WIRE YEL/BLK WIRE

12 VOLT REF 12-VOLT REF RF WHEEL SPD SENS SIG GROUND ABS INDICATOR ABS-1 FUSE 61 (GAS) FUSE 56 (DIESEL) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE PRESSURE MODULATOR VALVE BRAKE WARNING INDICATOR COMPUTER DATA LINES SYSTEM DATA BUS - DIESEL GAS DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF FRAME ASSEMBLY) ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT) EXCEPT LUXURY GAS GRY WIRE GRY/WHT WIRE HEAVY DUTY ABS FUSE 59 (GAS) FUSE 55 (DIESEL) HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON LEFT FRONT STEERING KNUCKLE) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LOGIC LT BLU WIRE LT BLU/BLK WIRE LUXURY NCA WIRE NEAR FAN SHROUD) ORG/ WIRE ORG/WHT WIRE PARK BRAKE SW SIG PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) POWER DISTRIBUTION SYSTEM PPL PPL BRAKE SW SIG RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON RIGHT FRONT STEERING KNUCKLE) SERIAL DATA SIG TAN WIRE TAN/BLK WIRE VEHICLE SPD SIG VEHICLE SPD SIG RADIO YEL WIRE YEL/BLK WIRE

12-VOLT REF 12-VOLT REF LR SIG WHEEL SPD SENS 12-VOLT REF LF WHEEL SPD SENS SIG 16 17 2500 2501 COMPUTER DATA LINES SYSTEM DATA BUS + DATA BUS - 2 4 3 1 SERIAL DATA 12-VOLT SERIAL DATA LOW REF 2150 2501 2501 COMPUTER DATA LINES SYSTEM 2500 2500 COMPUTER DATA LINES SYSTEM 3 4 5 6 SENS PHASE A SENS PHASE B SENS PHASE C 35 36 37 38 SERIAL DATA 6032 (OR 817) ABS INDICATOR ABS-1 FUSE 61 ABS-2 FUSE 9 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) BRAKE BOOSTER VACUUM SENSOR (LEFT REAR OF ENGINE COMPT) BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE PRESSURE MODULATOR VALVE BRAKE WARNING INDICATOR BRN WIRE CAN BUS HIGH SERIAL DATA GROUND COMPUTER DATA LINES SYSTEM DATA SERIAL DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF FRAME ASSEMBLY) EXCEPT 4.3L EXCEPT LUXURY GAS GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT AT ALL TIMES UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) I/P MULTI-FUNCTION SWITCH (W/ ACTIVE BRAKE CONTROL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON LEFT FRONT STEERING KNUCKLE) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LEFT REAR WHEEL SPEED SENSOR (WSS) (ON LEFT REAR BRAKE BACKING PLATE) LF WHEEL SPD SENS SIG LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LUXURY NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PARK BRAKE SWITCH (ON PARK BRAKE PEDAL ASSEMBLY) PARK BRK SW POWER DISTRIBUTION SYSTEM PPL RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RF SIG WHEEL SPD SENS RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON RIGHT FRONT STEERING KNUCKLE) SENSOR PHASE A 5-VOLT REF BOOSTER VACUUM SENS SIG SIG STEERING ANGLE SENS SIG STOP LAMP SWITCH (TOP OF BRAKE PEDAL ASSEMBLY) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRACTION CONTROL SWITCH SIGNAL TRACTION CTRL SW SIG 12 13 812 7062 12-VOLT REF PPL BRAKE SW SIG VEH SPD SIGNAL VEHICLE SPD SIG VEHICLE SPD SIG LOW REF GROUND SERIAL DATA BUS- SERIAL DATA BUS- W/ ACTIVE BRAKE CONTROL W/O ACTIVE BRAKE CONTROL WHT WIRE YAW RATE, LATERAL ACCELERATION SENSOR (W/ ACTIVE BRAKE CONTROL) YEL WIRE YEL/BLK WIRE

1 2 3 4 9 10 BATTERY (+) BATTERY (+) BATTERY (+) BATTERY (+) GROUND BATTERY (+) 14 15 RIGHT REAR DOOR AJAR SW LEFT REAR DOOR AJAR SW 5 4 13 9 LOW REF LF OPEN SIG LF AJAR SIG LO SPD DATA 9 5 13 LO SPD DATA LOW REF RF AJAR SIG BCM FUSE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CREW CAB CTSY FUSE DIM FUSE DK GRN WIRE DOOR) PNK WIRE DRIVER DOOR LATCH ASSEMBLY (IN REAR OF DRIVER FRONT DRIVER DOOR LOCK/ WINDOW SWITCH FRONT DOOR) GRY/BLK WIRE HEAD HEAD OFF AUTO PARK HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE IS LPS FUSE LEFT REAR DOOR LATCH ASSEMBLY (REAR OF LEFT REAR DOOR) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT STOP TRN FUSE OF DASH) OFF AUTO PARK PARK BRAKE SW SIGNAL PASSENGER DOOR LATCH ASSEMBLY (IN REAR OF PASSENGER PASSENGER DOOR LOCK/ WINDOW SWITCH PNK IGN III WIRE POWER DISTRIBUTION SYSTEM RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RIGHT REAR DOOR LATCH ASSEMBLY (REAR OF RIGHT REAR DOOR) RT STOP TRN FUSE STOP LAMPS FUSE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE WHT WIRE YEL WIRE

1 2 3 4 9 10 BATTERY (+) BATTERY (+) BATTERY (+) BATTERY (+) GROUND BATTERY (+) BCM FUSE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) COMPUTER DATA LINES SYSTEM CREW CAB CTSY FUSE DIM FUSE DK GRN WIRE DRIVER DOOR LATCH ASSEMBLY (REAR OF DRIVER'S DOOR) GRY WIRE GRY/BLK WIRE HEAD HEAD OFF AUTO PARK HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES I/P FUSE BLOCK (LEFT SIDE I/P FUSE BLOCK (LEFT SIDE OF DASH, IS LPS FUSE LEFT REAR DOOR LATCH ASSEMBLY (REAR OF LEFT REAR DOOR) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT STOP TRN FUSE OF DASH) OFF AUTO PARK PARK BRAKE SW SIGNAL PASSENGER DOOR LATCH ASSEMBLY (REAR OF PASSENGER'S DOOR) PNK IGN III WIRE PNK WIRE POWER DISTRIBUTION RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) RIGHT REAR DOOR LATCH ASSEMBLY (REAR OF RIGHT REAR DOOR) RT STOP TRN FUSE STOP LAMPS FUSE SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE W/ ELECTRIC DOOR LOCK CONTROL W/O ELECTRIC DOOR LOCK CONTROL W/ POWER WINDOWS WHT WIRE

6399 (OR 821) 71 72 73 VSS HIGH SIG VSS LO SIG GND A/C CL CTRL A/C PRESS SIG LO REF AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM AXL SW SIG BANK 1 SENSOR 2 (DOWNSTREAM OF LEFT CATALYTIC CONVERTER) BANK 2 SENSOR 2 (DOWNSTREAM OF RIGHT CATALYTIC CONVERTER) BLK WIRE BLK/WHT WIRE BRK SW SIG BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM COOLING FANS SYSTEM COOLING FANS SYSTEM COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT OF ENGINE COMPT, NEAR FAN SHROUD) FRONT FUEL PUMP, FUEL CTRL FUEL CTL-SEC STRT RLY CTRL FUEL LVL-SEC FUEL PMP RELAY FUEL PUMP FUSE 20 FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL PUMP, SENDER ASSEMBLY) GMLAN - GMLAN + GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HEATED OXYGEN HOT AT ALL TIMES IAT SIG LO REF IGN 1 VOLT LO REF LO REF LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAF SIG MIL CTRL PPL NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PNK WIRE PNK/BLK WIRE PPL PPL FUEL LVL-PRI CFAN HI CTL ACC SER DATA PPL LO REF FTP SIG PPL/WHT WIRE PWTN RLY CTRL RED/WHT WIRE SENDER ASSEMBLY (IN FRONT FUEL TANK) STARTING/ CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VSS CFAN LO CTRL W/ 10 SERIES W/ 31 SERIES W/O 10 SERIES WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE