Chevrolet Silverado 1500 (2000-2012) hvac control module Wiring diagrams

335 5128 54 41 MED SPD FAN RLY HI SPD FAN RLY PPL AUXILIARY FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) BLK WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE ENG FUSE 4 ENGINE CONTROL MODULE (ECM) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON TOP OF ENGINE) FAN 1 FUSE FAN CNTRL RELAY FAN HI RELAY FAN LO RELAY FAN MID 1 RELAY FAN MID 2 RELAY FAN RESISTOR FAN-2 FUSE GMLAN L GRY WIRE HOT AT ALL TIMES HOT W/ PWR/TRN RELAY ENERGIZED HVAC CONTROL MODULE LEFT COOLING FAN (LEFT FRONT OF ENGINE COMPT) LEFT ENGINE COOLING FAN RESISTOR LOGIC LT BLU WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL RIGHT COOLING FAN (RIGHT FRONT OF ENGINE COMPT) RIGHT ENGINE COOLING TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) YEL WIRE

2 OR MORE OF W/ ONSTAR, AUDIO AMPLIFIER (IF EQUIPPED) (UNDER REAR OF CENTER CONSOLE) BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER LEFT SIDE OF DASH) CHIME MODULE (CENTER OF DASH, BEHIND RADIO) DATA LINK CONNECTOR (DLC) (LOWER LEFT SIDE OF DASH) DIGITAL RADIO RECEIVER (BEHIND RIGHT END OF DASH) DIGITAL RADIO RECEIVER (IF EQUIPPED) (BEHIND RIGHT END OF DASH) DIGITAL RADIO, REAR SEAT, DK GRN WIRE DRIVER DOOR LOCK/WINDOW SWITCH DRIVER'S SEAT EARPHONE JACKS RADIO CONTROL GROUND DISTRIBUTION SYSTEM HEATED SEAT CONTROL MODULE (W/ SPO HEATED SEATS) HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P JUNCTION BLOCK (LOWER LEFT SIDE OF DASH) LOW SPD GMLAN SER DATA LOW SPEED GMLAN SERIAL DATA LOW SPEED SERIAL DATA LTR FUSE 53 (EXCEPT 6.6L) FUSE 50 (6.6L) MEMORY SEAT MODULE (W/ INDIVIDUAL FRONT SEAT) (UNDER FRONT OF NOT USED NOT USED PASSENGER DOOR LOCK/WINDOW SWITCH POWER DISTRIBUTION SYSTEM RADIO REAR OBJECT SENSOR CONTROL MODULE (AT REAR CARGO AREA, BEHIND TRIM PANEL) REAR SEAT AUDIO (RSA) CONTROL REAR SEAT AUDIO (RSA) CONTROL (IF EQUIPPED) RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (TOP REAR OF PASSENGER COMPT) RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) TAN WIRE TAN/BLK WIRE THEFT DETERRENT CONTROL MODULE (TDM) (ON RIGHT SIDE OF STEERING COLUMN) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) (BEHIND CENTER OF DASH) W/ DIGITAL RADIO W/ DIGITAL RADIO, REAR SEAT, ONSTAR, EARPHONE JACKS RADIO CONTROL W/ FRONT SEAT, REMOTE CONTROL W/ INDIVIDUAL FRONT SEAT W/ LUXURY EDITION W/ ONSTAR W/ RADIO PROVISIONS W/ REAR SEAT, EARPHONE JACKS RADIO CONTROL W/ REMOTE KEYLESS ENTRY W/O INDIVIDUAL FRONT SEAT W/O LUXURY EDITION W/O LUXURY EDITION, W/ ODOMETER SECURITY PROVISIONS W/O RADIO PROVISIONS WHT WIRE

7 3 SUPPLY VOLT LOW REF BATTERY BLK WIRE COMPUTER DATA LINES SYSTEM DDM FUSE 4 DK GRN WIRE DRIVER DOOR LOCK/ WINDOW SWITCH DRIVER OUTSIDE REARVIEW MIRROR GRN WIRE GROUND HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, LOGIC LOW REF ORG/ WIRE PASSENGER DOOR LOCK/WINDOW SWITCH PASSENGER OUTSIDE REARVIEW MIRROR PDM FUSE 9 POWER DISTRIBUTION SYSTEM REAR DEFOGGER IND REAR DEFOGGER SWITCH RED WIRE RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) SERIAL DATA SUPPLY VOLT WHT WIRE

7 3 SUPPLY VOLT LOW REF BATT POS VOLT BLK WIRE COMPUTER DATA LINES SYSTEM DDM FUSE 4 DK GRN WIRE DRIVER DOOR LOCK/ WINDOW SWITCH DRIVER OUTSIDE REARVIEW MIRROR GRN WIRE GROUND GROUND DISTRIBUTION SYSTEM HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, LOGIC LOW REF ORG/ WIRE PASSENGER DOOR LOCK/WINDOW SWITCH PASSENGER OUTSIDE REARVIEW MIRROR PDM FUSE 9 POWER DISTRIBUTION SYSTEM REAR DEFOGGER IND REAR DEFOGGER SWITCH RED WIRE RED/WHT WIRE RIGHT I/P JUNCTION BLOCK (IN RIGHT END OF DASH) SERIAL DATA SUPPLY VOLT WHT WIRE

1 2 4 10 5 7 RETRACT CTRL EXTEND CTRL SENS SIG LOW REF SENS SIG 2 6 1 7 3 9 4 POSITION CTRL MTR COMM POSITION CTRL SPLY VOLT LOW REF 4 6 B+ GND 5 14 SW SIG 9 2 12 SERIAL DATA PNK WIRE AUTOMATIC DAY/NIGHT MIRROR BLK WIRE BLK/WHT WIRE BRN WIRE COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM ELECTROCHROMIC DDM FUSE 4 DEFOGGER SWITCH DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DOWN L/R SELECT DRIVER DOOR LOCK/ WINDOW SWITCH DRIVER MEMORY/HEATED SEAT SWITCH DRIVER OUTSIDE REARVIEW MIRROR EXIT EXTEND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, L/R SELECT SW PWR LEFT LOGIC LOGIC DRIVER DOOR LOCK/WINDOW SWITCH LT BLU WIRE LT BLU/WHT WIRE MIRROR CIRCUIT ORG/ WIRE ORG/BLK WIRE OUTSIDE REARVIEW MIRROR SWITCH PNK WIRE RED/WHT WIRE RETRACT RIGHT SERIAL DATA WHT WIRE YEL WIRE

2 OF 7) PDM FUSE 9 (W/ COMFORT, DECOR LEVEL 3 CONVENIENCE PACKAGE) AIR BAG BATT FUSE 45 ALC/COMP FUSE 58 AMP FUSE 41 AUDIO AMPLIFIER (PREMIUM PERFORMANCE ENHANCED AUDIO SPEAKER SYSTEM) AUTOMATIC A/C AUTOMATIC TRANSMISSION AUXILIARY FLUID PUMP CONTROL MODULE AUX PWR FUSE BLK WIRE BODY CONTROL MODULE (BCM) CENTER CONSOLE ACCESSORY POWER OUTLET CENTER CONSOLE COMPARTMENT ACCESSORY POWER OUTLET (ON LOWER RIGHT "B" PILLAR) CHIME POWER MODULE TAKE OFF (PTO) RELAY CREW CAB W/ INDIVIDUAL FRONT SEAT AUX RSE PWR 2 FUSE 19 FUSE 2 ESC/ALC EXH FUSE 2 FROM AUXILIARY BATTERY RUN RELAY (DIAGRAM 1 OF 7) FROM FSCM FUSE 21 (DIAGRAM 2 OF 7) FROM LT DR CIRCUIT BREAKER (DIAGRAM FRONT SEAT W/ INDIVIDUAL FRONT SEAT GARAGE DOOR OPENER (GDO) HVAC CONTROL MODULE I/P 2 ACCESSORY POWER OUTLET INFO FUSE 22 LBEC 2 FUSE 72 LEFT I/P J/B (LOWER LEFT SIDE OF DASH) LGM FUSE 71 LOCK/UNLOCK PCB RELAY MANUAL A/C NCA WIRE ORG/ WIRE PASSENGER DOOR LOCK/ WINDOW SWITCH FROM LEFT I/P J/B (DIAGRAM 2 OF 7) POWER LOCKS W/O INDIVIDUAL FRONT SEAT, POWER MIRROR POWER TAKE OFF (BLUNT CUT) PTO FUSE 47 RADIO RDO FUSE 42 REAR SEAT DIGITAL AUDIO (RSA) RADIO CONTROL RECEIVER (IF (IF EQUIPPED) EQUIPPED) RED WIRE RED/ WHT WIRE RED/BLK WIRE RED/WHT WIRE RIGHT I/P J/B (IN RIGHT END OF DASH) CENTER SEAT ACCESSORY POWER OUTLET STOP IS LPS FUSE 17 LT STOP TRN FUSE 6 LAMPS FUSE TO BODY CONTROL MODULE (DIAGRAM 4 OF 7) TO DLIS FUSE 35 (DIAGRAM 4 OF 7) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNLOCK PCB LOCK PCB RELAY RELAY VEHICLE COMMUNICATION INTERFACE MODULE (VCIM) VIDEO DISPLAY W/ AUX- ILIARY BATTERY W/ CUSTOM FRONT COMPARTMENT FLOOR CONSOLE W/ FULL FEATURE CENTER SEAT W/ INDIVIDUAL FRONT SEAT, POWER MIRROR W/ LUXURY W/ REAR SEAT ENTERTAIN- MENT PACKAGE W/ UNIVERSAL GARAGE DOOR OPENER W/ W/O LUXURY LUXURY W/O AUX- ILIARY BATTERY W/O INDIVIDUAL W/O LUXURY, RADIO W/O RADIO W/O W/ LUXURY LUXURY W/ONSTAR WHT RED/ WIRE WHT WIRE WINDSHIELD WASHER SOLVENT HEATER (IF EQUIPPED)

1 2 4 10 5 7 RETRACT CTRL EXTEND CTRL SENS SIG LOW REF SENS SIG 2 6 1 7 3 9 4 POSITION CTRL MTR COMM POSITION CTRL SPLY VOLT LOW REF 4 6 B+ GND 9 2 12 SERIAL DATA PNK WIRE AUTOMATIC DAY/NIGHT MIRROR BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM ELECTROCHROMIC DDM FUSE 4 DEFOGGER SWITCH DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DOWN L/R SELECT DRIVER DOOR LOCK/ WINDOW SWITCH DRIVER OUTSIDE REARVIEW MIRROR EXTEND GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, L/R SELECT SW PWR LEFT LOGIC LT BLU WIRE MIRROR CIRCUIT OUTSIDE REARVIEW MIRROR SWITCH PNK WIRE RED/WHT WIRE RETRACT RIGHT WHT WIRE YEL WIRE

1 2 4 10 5 7 RETRACT CTRL EXTEND CTRL SENS SIG LOW REF SENS SIG 2 6 1 7 3 9 4 POSITION CTRL MTR COMM POSITION CTRL SPLY VOLT LOW REF 4 6 B+ GND 9 2 12 SERIAL DATA PNK WIRE AUTOMATIC DAY/NIGHT MIRROR BLK WIRE BLK/WHT WIRE BRN WIRE COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM ELECTROCHROMIC DDM FUSE 4 DEFOGGER SWITCH DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DOWN L/R SELECT DRIVER DOOR LOCK/ WINDOW SWITCH DRIVER OUTSIDE REARVIEW MIRROR EXTEND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HVAC CONTROL MODULE I/P FUSE BLOCK (LEFT SIDE OF DASH, L/R SELECT SW PWR LEFT LOGIC LT BLU WIRE LT BLU/WHT WIRE MIRROR CIRCUIT ORG/BLK WIRE OUTSIDE REARVIEW MIRROR SWITCH PNK WIRE RED/WHT WIRE RETRACT RIGHT WHT WIRE YEL WIRE