Chevrolet Silverado 1500 HD (2001-2006) hot in run or start Wiring diagrams

ABS FUSE ABS IND. BLK WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH, NEAR KICK PANEL) BRAKE FLUID LEVEL SWITCH (ON LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE FUSE BRAKE IN BRAKE IND BRN WIRE BRN/WHT WIRE DEL TORQUE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) GAS DIESEL GROUND DISTRIBUTION SYSTEM GROUND MOTOR, SOLENOID PWR GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGN 1 FUSE IGNITION LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) DELIVERED TORQUE INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOGIC LOW TRACTION INDICATOR ILLUM LAMP LT BLU WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) ORG/BLK WIRE PNK PNK POWER DISTRIBUTION SYSTEM WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) PPL PPL 1122 832 PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL/WHT WIRE RED WIRE REQ TORQUE RIGHT FRONT WHEEL SPEED SENSOR SERVICE TRAC CNTL SIG SIDE OF TRANSMISSION) STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TRACTION CONTROL SWITCH TRACTION OFF INDICATOR UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW VSS OUT WHT WIRE YEL WIRE YEL/BLK WIRE

B/U LMP VLT B/U LMPS SIG B/U LP FUSE BLK WIRE BLUNT CUT (W/ CAMPER BODY CONTROL MODULE (BCM) (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) GRN WIRE GRY WIRE GRY/BLK WIRE HOT IN RUN OR START LEFT BACK-UP LAMP LT BACK-UP ALARM LT GRN WIRE PARK/NEUTRAL POSITION (PNP) SWITCH (LEFT SIDE OF TRANSMISSION) PNK A/T WIRE PNK M/T WIRE PNK WIRE REAR LAMPS JUNCTION BLOCK RIGHT BACK-UP LAMP TRAILER CONNECTOR TRAILER WIRING PROVISIONAL) TRLR B/U FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT)

AUTO HEAD BLK WIRE BLU WIRE BODY JUNCTION BLOCK (LEFT SIDE OF DASH) BODY JUNCTION BLOCK (LEFT SIDE OF DASH) RIGHT FRONT MARKER LAMP BRN WIRE CENTER HIGH MOUNT STOP LAMP/ CARGO LAMP DK CLEAR- ANCE LAMPS 3 BULBS ROOF MARKER LAMPS CRUISE CONTROL SYSTEM DK BLU WIRE FUSE BLOCK (LOWER LEFT SIDE OF DASH) FUSE BLOCK (UNDER LEFT SIDE OF DASH) TURN FUSE GRN WIRE GRY WIRE HAZ LP FUSE HAZARD NORMAL HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES HOT IN RUN OR START I/P JUNCTION BLOCK (LOWER RIGHT SIDE OF DASH) INSTRUMENT CLUSTER BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH) LT INT PRK FUSE LEFT FRONT MARKER LAMP LEFT FRONT PARK/ TURN LAMP LEFT LICENSE LAMP LEFT TAIL/ STOP- LAMP RIGHT TAIL/ STOP- LAMP LEFT OUTSIDE POWER MIRROR LEFT TURN IN LEFT TURN IND RIGHT TURN IND LT BLU WIRE LT DK LT DK TRAILER WIRING PROVISION LT LT LT LT DK DK LT PNK WIRE LT TURN FUSE FR PRK FUSE NCA WIRE ORG/ WIRE PARK PARK LAMP RELAY PARK LPS FUSE PNK WIRE PPL PUDDLE LAMP RELAY REAR LAMPS JUNCTION BLOCK (FRONT OF REAR BUMPER, ON CROSS- MEMBER) RIGHT FRONT PARK/ TURN LAMP RIGHT LEFT RIGHT LICENSE LAMP RIGHT OUTSIDE POWER MIRROR RIGHT REAR TURN LAMP LEFT REAR TURN LAMP RIGHT TURN IN PARK RLY CTRL PUDDLE RLY CTRL ROOF BEACON PROVISION ROOF BEACON RELAY (LEFT "B" PILLAR) ROOF BEACON SWITCH RR PRK FUSE RT TURN FUSE CHMSL FUSE SEO 1 FUSE SEO 2 FUSE STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) STOP LPS FUSE SEO 1 FUSE THROTTLE ACTUATOR CONTROL MODULE TRAILER CIRCUIT TURN/ HAZARD SWITCH TURN/HAZARD FLASHER UNDERHOOD JUNCTION BLOCK (LEFT SIDE OF ENG COMPT, NEAR BATTERY) UPLEVEL BASE VEH STOP FUSE LR PRK FUSE WHT WIRE YEL WIRE

A/C COMP RELAY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C FUSE A/C HIGH PRESSURE RECIRCULATION SWITCH (IN A/C MUFFLER HOSE) A/C HIGH PRESSURE SWITCH (REAR OF COMPRESSOR) A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C REQUEST A/C SWITCH AIR TEMPERATURE ACTUATOR (BOTTOM CENTER OF BLK WIRE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR RELAY ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BLOWER RELAY BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRN WIRE CTRL RECIRC DOOR DEFOGGER SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT HVAC FUSE GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL ASSEMBLY HVAC CONTROL MODULE (BEHIND CENTER OF DASH) IGN E FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LOW OFF LT BLU WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT FRONT OF ENGINE OF ENGINE COMPT) PPL PRESS SW A/C HIGH REAR DEFOG RLY IGN 3 VOL A/C REQUEST ACT POS SIG RECIRCULATION ACTUATOR (TOP OF HVAC MODULE) RED WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE YEL WIRE

11 11 17 17 (GASOLINE) (DIESEL) A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C FUSE A/C HIGH PRESS SW A/C HIGH PRESSURE RECIRCULATING SWITCH (IN A/C MUFFLER HOSE) A/C HIGH PRESSURE SWITCH (REAR OF COMPRESSOR) A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C REQUEST A/C SWITCH AIR TEMPERATURE ACTUATOR (BOTTOM CENTER OF BLK WIRE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BLOWER RELAY BRN WIRE DEFOGGER SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT HVAC FUSE GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC MODULE IGN E FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LO OFF LT BLU WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT FRONT OF ENGINE COMPT) PPL REAR DEFOG RLY IGN 3 VOL A/C REQUEST ACT POS SIG RECIRC DOOR CTRL RECIRCULATION ACTUATOR (TOP OF HVAC MODULE) RED WIRE RELAY CTRL A/C COMP RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE YEL WIRE

A/T SHIFT LOCK CONTROL SOLENOID (ON STEERING COLUMN) B/U LP FUSE BLK WIRE BTSI FUSE DK GRN WIRE HOT IN RUN OR START LT GRN WIRE PARK/ NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK WIRE STOPLAMP SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE

2-HI IND 4 HI 4 LO 4-HI IND 4-LO IND AXLE SW SIG BLK WIRE BLK/WHT WIRE BRAKE CONTROL BRN WIRE BRN/WHT WIRE CLASS II DATA AXLE CTRL AWD IND 4-LO IND 4-HI IND CONTROL MODULE CTRL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK GRN WIRE DK GRN/WHT WIRE ENCODER ENCODER LOW GROUND ENCODER SIG EXCEPT SEO FRONT AXLE ACTUATOR FRONT PROPSHAFT SPEED SENSOR FUSE GROUND BATTERY MOTOR CTRL A MOTOR CTRL B GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) SEO IGN FUSE I/P RELAY BLOCK (UNDER LEFT SIDE OF DASH) IGN E FUSE ILLUMINATION INSTRUMENT PANEL CLUSTER LAMP LOCK SOL CTRL 2-HI IND NEUTRAL IND LOGIC LT BLU WIRE LT GRN/BLK WIRE NEUTRAL IND ORG/ WIRE PNK WIRE PPL PPL FT SHAFT LO FT SHAFT HI PPL/WHT WIRE REAR PROPSHAFT SPEED SENSOR RED WIRE RR SHAFT HI RR SHAFT LO RUN WIRE SEO SHIFT MOTOR SPLICE PACK TAN WIRE TAN/BLK WIRE TRANSFER CASE ENCODER MOTOR TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSFER CASE SHIFT CONTROL SWITCH TREC FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) YEL WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (ON LEFT SIDE OF INNER FRAME) EXCEPT SEO FRONT AXLE ACTUATOR FUSE GAS (PCM) DIESEL (ECM) GRY WIRE GRY/BLK WIRE HOT IN HOT IN RUN OR START I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) IGN E FUSE INSTRUMENT PANEL CLUSTER LAMP LOGIC LT BLU WIRE MODULE (DIESEL) (LEFT FRONT OF ENGINE COMPT) PNK WIRE POWERTRAIN CONTROL MODULE (GAS ENGINES) OR ENGINE CONTROL PPL 2 RUN WIRE SEO SEO IGN FUSE SPLICE PACK TRANSFER CASE SHIFT CONTROL SWITCH (ON TOP OF TRANSFER CASE) TRANSMISSION CONTROL MODULE (W/ ALLISON TRANS) (LEFT FRONT OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT)

BASE BATTERY SERIAL DATA GROUND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE BODY JUNCTION BLOCK BODY WIRING HARNESS JUNCTION BLOCK (UNDER LEFT SIDE OF DASH, NEAR KICK PANEL) BRN WIRE CGO DR JMB SW IN CRUISE FUSE DK BLU WIRE DK GRN WIRE DOOR JAMB SW IN EXTERIOR LIGHTS FUSE BLOCK GRY WIRE HDLMP RLY CNTRL PARK LIGHTS IN KEY IN IGN HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES UNDERHOOD JUNCTION BLOCK TBC FUSE HOT IN RUN HOT IN RUN OR START HOT WITH PARK LIGHTS ON IGN 1 FUSE INSTRUMENT CLUSTER INT PRK FUSE KEY-IN IGNITION SWITCH LEFT CARGO DOOR AJAR SWITCH LEFT DOOR CONTACTOR LEFT LIFTGATE AJAR SWITCH LEFT MINI WEDGE SWITCH LEFT POWER WINDOW/ DOOR LOCK SWITCH LIFTGLASS AJAR SWITCH LOGIC LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE PNK IGNITION 1 IGNITION 3 SEAT BELT INPUT WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT FRONT OF ENGINE COMPARTMENT) REAR WINDOW WIPER MODULE RIGHT CARGO DOOR AJAR SWITCH RIGHT DOOR CONTACTOR RIGHT LIFTGATE AJAR SWITCH RIGHT TURN INPUT LEFT TURN INPUT GROUND SEAT BELT IND SEAT BELT SWITCH (ON DRIVER'S SEAT BELT BUCKLE) TAN WIRE TURN SIGNAL/ MULITFUNCTION SWITCH UNDERHOOD JUNCTION BLOCK UTILITY W/CARGO DOORS UTILITY W/O CARGO DOORS WHT WIRE

33 34 35 PNK WIRE 9 10 PNK WIRE ACT CNTRL APP SENS 1 APP SENS 2 AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR BLK WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL SYSTEM CRUISE REQ DATA DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECT/ECM FUSE FUEL COMPOSITION SENSOR (FLEX FUEL) FUSE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT IN RUN, START IGN LEFT I/P FUSE BLOCK LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NOT USED ORG/ WIRE ORG/BLK WIRE PNK 11 12 13 14 15 16 17 WIRE PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PPL PPL PNK PNK 28 29 WIRE PPL PNK PNK WIRE PPL/WHT WIRE R/A INPUT RED WIRE RED/BLK WIRE RED/WHT WIRE REF LOW S/C INPUT SIGNAL STP LP IN TAC CTRL TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE ACTUATOR CONTROL MODULE (REAR OF ENGINE COMPT) TP SENS 1 TP SENS 2 UNDERHOOD FUSE BLOCK VEH STOP FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE