Chevrolet RV Cutaway G3500 (1997-2013) splice pack Wiring diagrams

2 3 SERIAL DATA SERIAL DATA 5.3L 6.6L 4.8L, 5.3L, 6.0L 4.3L ACC WAKE UP SERIAL DATA 11 15 19 7 6 38 37 5985 2501 2500 2500 2501 2500 2501 ACC WAKE-UP SERIAL DATA BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER CHIME MODULE (BEHIND LEFT CENTER OF DASH) CONTROL EXCEPT 6.6L W/O ACTIVE BRAKE CONTROL COOLANT HEATER (6.6L) DATA BUS+ DATA BUS+ DATA BUS- DATA BUS- DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DATA LINK RESISTOR DK BLU WIRE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) ELECTRONIC CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXCEPT 5.3L EXCEPT 6.6L W/ ACTIVE BRAKE FUEL PUMP FLOW CONTROL MODULE (5.3L) (AT REAR OF GLOW PLUG CONTROL MODULE (GPCM) (6.6L) HOT AT ALL TIMES INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER (IPC) LIGHT DUTY W/O RECREATIONAL VEHICLE, UPFITTER SALES PACKAGE LTR/DLC FUSE 38 RADIO RED WIRE RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (IF EQUIPPED) (BEHIND CENTER OF DASH) SERIAL DATA SPLICE PACK TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) UNDERHOOD PASS THROUGH GROMMET) VEHICLE, ATTACHED TO LEFT REAR FRAME RAIL) W/ AUXILIARY FUEL FIRED HEATER W/ RADIO PROVISIONS W/O AUXILIARY FUEL FIRED HEATER W/O RADIO PROVISIONS WHT WIRE

2 3 11 13 DATA BUS (-) DATA BUS (+) 2 3 DATA BUS (+) DATA BUS (-) 2 3 SERIAL DATA SERIAL DATA 5 4 6 7 157 147 167 177 DATA BUS (+) DATA BUS (-) DATA BUS (-) DATA BUS (+) 6 5 DATA BUS (-) DATA BUS (+) 6.6L 4.8L, 5.3L, 6.0L 4.3L 65 45 DATA BUS (+) DATA BUS (-) ACC WAKE-UP SERIAL DATA BLK/WHT WIRE CHIME MODULE (BEHIND LEFT CENTER OF DASH) CUTAWAY DATA DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DATA LINK RESISTOR DIGITAL RADIO RECEIVER (S-BAND DIGITAL AUDIO SYSTEM) (LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) HOT AT ALL TIMES INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT CLUSTER LIGHT DUTY W/O RECREATIONAL VEHICLE, UPFITTER SALES PACKAGE LT GRN WIRE LTR/DLC FUSE 73 NITROGEN OXIDES SENSOR 1 (TOP LEFT REAR SIDE OF ENGINE) NITROGEN OXIDES SENSOR 2 (MIDDLE OF DIESEL PARTICULATE FILTER) RADIO REAR PARKING ASSIST CONTROL MODULE (IF EQUIPPED) RED WIRE RED/WHT WIRE REDUCTANT SENSOR MODULE (ABOVE REDUCTANT TANK) REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (IF EQUIPPED) (BEHIND CENTER OF DASH) SERIAL SERIAL DATA SPLICE PACK TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/O RADIO W/O W/ UYS UYS WHT WIRE

BLK WIRE BLU WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRN WIRE BRN/WHT WIRE CENTER HIGH MOUNTED STOP LAMP STOP LAMP SUPPLY VOLTAGE CRUISE CONTROL SYSTEM DIESEL DK BLU WIRE DK BLU/WHT WIRE DK DK DK GRN WIRE DK GRN/WHT WIRE DRIVER'S OUTSIDE REAR VIEW MIRROR DRL ON/OFF SIG DRV PWR TRN MIR FUSE 14 FRONT TURN SIGNAL LAMP SUPPLY VOLTAGE FRT PRK FUSE 22 GRN WIRE H.D. W/ GAS EARLY PRODUCTION HAZARD SWITCH HEAD OFF HEADLAMP AND PANEL DIMMER SWITCH HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER LEFT LEFT TURN SIGNAL IND LOGIC LEFT TURN SIGNAL LAMP LR PKR FUSE 18 LT BLU WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE NCA WIRE NOT USED PARK PARK LAMP RELAY 29 PARK LAMP RLY CTRL HAZARD SW SIG DRL LOW CONTROL PARK LAMP SW ON SIG PASS TRN MIR FUSE 19 PASSENGER'S OUTSIDE REAR VIEW MIRROR PNK WIRE PROVISIONAL RED/WHT WIRE RIGHT RIGHT TURN SIGNAL IND RIGHT TURN SIGNAL LAMP RR PKR FUSE 20 SPLICE PACK STOP/ CHMSL FUSE 8 SUPPLEMENTAL RESTRAINTS SYSTEM TRAILER WIRING (BLUNT CUT) TRLR PRK FUSE 21 TURN SIGNAL SWITCH TURN SIGNAL/ MULTIFUNCTION SWITCH TURN SIGNAL/HAZARD FLASHER MODULE (BEHIND LEFT CENTER OF DASH) UPFTR PRK LAMPS FUSE 16 W/ OUTSIDE REAR VIEW MIRROR TURN SIGNAL INDICATORS WHT WIRE YEL WIRE YEL/BLK WIRE

ASSEMBLY BREAKOUT) BACKUP LIGHTS CIRCUIT BLK WIRE BLU WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CENTER HIGH MOUNTED STOP LAMP CHMSL/ STOP LAMP SUPPLY VOLTAGE CRUISE CONTROL SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER'S OUTSIDE REAR VIEW MIRROR DRV PWR TRN MIR FUSE 14 FRONT TURN SIGNAL LAMP SUPPLY VOLTAGE FRT PRK FUSE 22 FUSE BLOCK- BODY (UNDER LEFT FRONT SEAT) FUSE BLOCK- BODY (UNDER LEFT FRONT SEAT) STOP/ CHMSL FUSE 8 GRN WIRE H.D. W/ GAS EARLY PRODUCTION HAZARD SWITCH HEAD HEADLAMP AND PANEL DIMMER SWITCH HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER LEFT LEFT TURN SIGNAL IND LOGIC LEFT TURN SIGNAL LAMP LICENSE LAMP LT BLU WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE LT REAR PARK FUSE 18 LT REAR STOP/ TURN FUSE 3 NCA WIRE NOT USED OFF PARK PARK LAMP RELAY 29 PARK LAMP RLY CTRL HAZARD SW SIG DRL LOW CONTROL PARK LAMP SW ON SIG PASS TRN MIR FUSE 19 PASSENGER'S OUTSIDE REAR VIEW MIRROR PNK 8 9 WIRE PNK WIRE PROVISIONAL RED/WHT WIRE RIGHT RIGHT TURN SIGNAL IND RIGHT TURN SIGNAL LAMP RT REAR PARK FUSE 20 RT REAR STOP/ TURN FUSE 6 SPLICE PACK SUPPLEMENTAL RESTRAINTS SYSTEM TAIL/STOP, TURN SIGNAL LAMP (LEFT) TAIL/STOP, TURN SIGNAL LAMP (RIGHT) TRAILER WIRING (BLUNT CUT) TRLR PRK FUSE 21 TURN SIGNAL SWITCH TURN SIGNAL/ MULTIFUNCTION SWITCH TURN SIGNAL/HAZARD FLASHER MODULE (BEHIND LEFT CENTER OF DASH) UPFTR PRK LAMPS FUSE 16 W/ OUTSIDE REAR VIEW MIRROR TURN SIGNAL INDICATORS WHT WIRE YEL WIRE YEL/BLK WIRE

+BC BLK WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) CLASS 2 SERIAL DATA COMPOSITE SEALED COMPOSITE+ DIMMER SWITCH SIGNAL DK GRN WIRE FLASH TO PASS SIGNAL FTP FUSIBLE LINK 2 GRY WIRE HDLP- HI BEAM RELAY HDLP- LO BEAM RELAY HEAD HEADLAMP DIMMER SWITCH HEADLAMP ON IND HEADLAMP ON SIGNAL HEADLAMP, PANEL DIMMER SWITCH HIGH BEAM INDICATOR HIGH BEAM RELAY CONTROL HOT AT ALL TIMES IGN CLASS 2 INSTRUMENT PANEL CLUSTER LED DIMMING SIGNAL LEFT HI BEAM FUSE 44 LEFT HIGH BEAM HEADLAMP LEFT HEADLAMP LEFT LO BEAM FUSE 43 LEFT LOW BEAM HEADLAMP LOGIC CLASS 2 SERIAL DATA LOW BEAM RELAY CONTROL LT GRN WIRE OFF PARK PNK HEADLAMP ON IND CONTROL WIRE PNK WIRE PNK/WHT WIRE PPL/WHT WIRE RED WIRE RIGHT HEADLAMP RIGHT HI BEAM FUSE 45 RIGHT HIGH BEAM HEADLAMP RIGHT LO BEAM FUSE 42 RIGHT LOW BEAM HEADLAMP SEALED SPLICE PACK TAN WIRE TAN/WHT WIRE TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

23 3 SERIAL DATA BELT SW 7 63 5 VOLT REF LOW REF ABS IND. AIR BAG IND BATTERY IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER RIGHT SIDE OF DASH) BRAKE IND BRAKE WARNING IND CONTROL BATT VOLTAGE GROUND GROUND IGN VOLTAGE SERIAL DATA BRN WIRE BRN/WHT WIRE CHECK GAGES IND. CLASS 2 (BCM) CLASS 2 (EBCM) CLASS 2 (PCM) CLASS 2 (SDM) COMPUTER DATA LINES SYSTEM CRUISE IND DIMMING DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRL IND ECT SENS ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMP ENGINE COOLANT TEMPERATURE SENSOR (LEFT SIDE OF ENGINE) ENGINE OIL LEVEL SWITCH (4.8L, 5.3L, 6.0L) (RIGHT SIDE OF OIL PAN) ENGINE OIL PRESSURE SENSOR (TOP REAR OF ENGINE) FUEL GAUGE FUEL PUMP/ SENDER ASSEMBLY (IN FUEL TANK) GROUND GRY WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN OR START IGN IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN VOLT SIG IGN E FUSE 22 ILLUMINATION (6 BULBS) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER IPC FUSE 31 LCD DISPLAY 000000 TRIP LEFT FRONT SEAT BELT SWITCH (IN LEFT FRONT SEAT BELT LATCH) LEFT TURN IND LH FRT TURN SIG SUP VOLT LOW REF LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION IND LAMP MIL CTRL MIL SIGNAL OFF OIL PRESS OIL PRESS (RIGHT REAR OF ENGINE) OIL PRESSURE OIL PRESSURE IND P R N D 3 2 1 PARK BRAKE PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PNK WIRE POWER BRAKE BOOSTER FLUID PRESSURE ALARM SWITCH (IN BOOSTER INLET HOSE) POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL FUEL LEVEL RED/WHT WIRE RH FRT TURN SIG SUP VOLT RIGHT TURN IND SEAT BELT IND SECURITY IND SERIAL DATA SPEEDOMETER SPLICE PACK TAN WIRE TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND'S TRIP RESET SWITCH TRIP RESET SWN SIGNAL GROUND UNDERHOOD FUSE BLOCK (IN ENGINE COMPT, ATTACHED TO LEFT FRONT FENDER) VOLTMETER W/ PWR SEAT W/O PWR SEAT YEL WIRE

1 2 3 4 BATTERY B+ SERIAL DATA PNK WIRE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CARGO DOOR LATCH ASSEMBLY CARGO UNLK FUSE 5 CARGO UNLK RELAY 27 DK BLU WIRE DOOR LKS FUSE 15 DOOR LKS RELAY 30 DOOR LOCK CTRL UNLOCK CTRL DRIVER DOOR LATCH ASSEMBLY DRIVER DOOR LOCK SWITCH DRV LKS FUSE 7 DRV UNLK RELAY 28 FRONT PASSENGER DOOR LATCH ASSEMBLY FRONT PASSENGER DOOR LOCK SWITCH GROUND GRY WIRE HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER LEFT REAR SIDE DOOR LOCK ACTUATOR LEFT SIDE DOOR CONTACT PLATE (LEFT "B" PILLAR) LT BLU WIRE LT GRN WIRE PASS UNLK RELAY 31 REAR CARGO DOOR LOCK SWITCH RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (BEHIND CENTER OF DASH) RIGHT REAR SIDE DOOR LOCK ACTUATOR RIGHT SIDE DOOR CONTACT PLATE (RIGHT "B" PILLAR) SERIAL DATA SERIAL DATA UNLOCK RLY CTRL SW UNLOCK CTRL SW LOCK CTRL RELEASE RLY CTRL SPLICE SPLICE PACK TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) RFA FUSE 20 WHT WIRE