Chevrolet RV Cutaway G3500 (1997-2013) instrument panel cluster Wiring diagrams

ABS FUSE ABS PUMP ABS/TCC SW ANTI-LOCK IND BLK WIRE BODY FUSE BLOCK (BELOW LEFT FRONT SEAT) BRAKE FLUID LEVEL SW IN LEFT FRONT SENSOR (+) RIGHT FRONT SENSOR (-) VSS INPUT BRAKE FLUID LEVEL SWITCH (HEAVY DUTY) (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE IND BRKS FUSE BRN WIRE CRUISE CONTROL SYSTEM DK GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGN E FUSE INSTRUMENT PANEL CLUSTER LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) BRAKE INPUT LEFT FRONT WHEEL SPEED SENSOR LOGIC LT BLU WIRE NCA WIRE OF TRANSMISSION) PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENG COMP, ON LEFT INNER FENDER) PPL PPL DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) RED/BLK WIRE RIGHT FRONT WHEEL SPEED SENSOR SERIAL DATA IGNITION STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TCC BRAKE SW UINDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENG COMPT) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENG COMPT) VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW VSS OUTPUT YEL WIRE YEL/BLK WIRE

ABS IND. BLK WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE IND BRAKE PRESSURE DIFFERENTIAL SWITCH (ON BRAKE VALVE, NEAR FRONT OF EBCM) BRN WIRE CAUTION IND DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE GROUND GRY WIRE HEAVY DUTY HOT IN RUN OR START IGN 3 VOLTAGE INSTRUMENT PANEL CLUSTER LIGHT DUTY LOGIC LOW REF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NOT READY IND ORG/BLK WIRE PCM IGN 1 FUSE 38 PNK 1 2 WIRE PNK WIRE PPL SENSOR SELF TEST SIG CIR STEERING WHEEL POS MARKER PULSE SIG STEERING WHEEL POSITION SENS SIG 1 STEERING WHEEL POSITION SIG A STEERING WHEEL POSITION SIG B STEERING WHEEL SPEED/ POSITION SENSOR (AT BASE OF STEERING COLUMN) TRACTION CONTROL SWITCH UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE YAW RATE FREQUENCY YAW, LATERAL ACCELERATION SENSOR (UNDER FRONT PASSENGER SEAT) YEL WIRE

1140 1037 812 1835 351 B+ SERIAL DATA BLK/WHT WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DATA SERIAL DIESEL DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (ON LEFT FRAME RAIL NEAR CENTER OF VEHICLE) ENGINE CONTROL MODULE (LEFT INNER FENDER) FUSE 46 GASOLINE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR ACC HOT IN RUN OR START HOT IN RUN, ACC OR START INSTRUMENT PANEL CLUSTER LT BLU WIRE LT GRN WIRE ORG/WHT WIRE PASSLK SENS GROUND PASSLOCK SENSOR (INSIDE TOP OF STEERING COLUMN) PASSLOCK SIGNAL PNK 39 343 1020 IGN 1 VOLT ACC VOLT IGN 0 VOLT WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT INNER FENDER) PPL RED/WHT WIRE SECURITY INDICATOR SENS RET GROUND SENSOR RETURN SERIAL DATA TAN WIRE TBC ACCY (GAS) TBC/TCM ACCY (DIESEL) TBC FUSE 19 TBC IGN 0 FUSE 6 TBC IGN 1 FUSE 24 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) W/ ACTIVE BRAKE CONTROL W/O ACTIVE BRAKE CONTROL YEL WIRE

1 2 6 8 20 21 22 23 24 40 42 47 48 51 62 63 GND TCC PWM CTRL PC SOL HI CTRL 1 8 17 18 19 20 24 27 GND AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE SENSOR (ON LEFT SIDE OF ENGINE) FROM UNDERHOOD PASS- THROUGH GROMMET BREAKOUT) LT GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START HOT IN RUN, START IGN 0 FUSE 6 INSTRUMENT PANEL CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PC SOL LO CTRL PPL FRONT LOW SIG FRONT HIGH SIG PCM BATT FUSE 2 PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PRNDL INDICATOR RANGE B RANGE C IGN B+ GND GND RED/WHT WIRE SERIAL DATA TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE POSITION SENSOR (ON LEFT SIDE OF THROTTLE BODY) TOW/ HAUL SWITCH TOW/HAUL INDICATOR TOW/HAUL SWITCH UNDER- HOOD FUSE BLOCK VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLU WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRN WIRE BRN/WHT WIRE CENTER HIGH MOUNTED STOP LAMP STOP LAMP SUPPLY VOLTAGE CRUISE CONTROL SYSTEM DIESEL DK BLU WIRE DK BLU/WHT WIRE DK DK DK GRN WIRE DK GRN/WHT WIRE DRIVER'S OUTSIDE REAR VIEW MIRROR DRL ON/OFF SIG DRV PWR TRN MIR FUSE 14 FRONT TURN SIGNAL LAMP SUPPLY VOLTAGE FRT PRK FUSE 22 GRN WIRE H.D. W/ GAS EARLY PRODUCTION HAZARD SWITCH HEAD OFF HEADLAMP AND PANEL DIMMER SWITCH HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER LEFT LEFT TURN SIGNAL IND LOGIC LEFT TURN SIGNAL LAMP LR PKR FUSE 18 LT BLU WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE NCA WIRE NOT USED PARK PARK LAMP RELAY 29 PARK LAMP RLY CTRL HAZARD SW SIG DRL LOW CONTROL PARK LAMP SW ON SIG PASS TRN MIR FUSE 19 PASSENGER'S OUTSIDE REAR VIEW MIRROR PNK WIRE PROVISIONAL RED/WHT WIRE RIGHT RIGHT TURN SIGNAL IND RIGHT TURN SIGNAL LAMP RR PKR FUSE 20 SPLICE PACK STOP/ CHMSL FUSE 8 SUPPLEMENTAL RESTRAINTS SYSTEM TRAILER WIRING (BLUNT CUT) TRLR PRK FUSE 21 TURN SIGNAL SWITCH TURN SIGNAL/ MULTIFUNCTION SWITCH TURN SIGNAL/HAZARD FLASHER MODULE (BEHIND LEFT CENTER OF DASH) UPFTR PRK LAMPS FUSE 16 W/ OUTSIDE REAR VIEW MIRROR TURN SIGNAL INDICATORS WHT WIRE YEL WIRE YEL/BLK WIRE

ASSEMBLY BREAKOUT) BACKUP LIGHTS CIRCUIT BLK WIRE BLU WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CENTER HIGH MOUNTED STOP LAMP CHMSL/ STOP LAMP SUPPLY VOLTAGE CRUISE CONTROL SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER'S OUTSIDE REAR VIEW MIRROR DRV PWR TRN MIR FUSE 14 FRONT TURN SIGNAL LAMP SUPPLY VOLTAGE FRT PRK FUSE 22 FUSE BLOCK- BODY (UNDER LEFT FRONT SEAT) FUSE BLOCK- BODY (UNDER LEFT FRONT SEAT) STOP/ CHMSL FUSE 8 GRN WIRE H.D. W/ GAS EARLY PRODUCTION HAZARD SWITCH HEAD HEADLAMP AND PANEL DIMMER SWITCH HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER LEFT LEFT TURN SIGNAL IND LOGIC LEFT TURN SIGNAL LAMP LICENSE LAMP LT BLU WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE LT REAR PARK FUSE 18 LT REAR STOP/ TURN FUSE 3 NCA WIRE NOT USED OFF PARK PARK LAMP RELAY 29 PARK LAMP RLY CTRL HAZARD SW SIG DRL LOW CONTROL PARK LAMP SW ON SIG PASS TRN MIR FUSE 19 PASSENGER'S OUTSIDE REAR VIEW MIRROR PNK 8 9 WIRE PNK WIRE PROVISIONAL RED/WHT WIRE RIGHT RIGHT TURN SIGNAL IND RIGHT TURN SIGNAL LAMP RT REAR PARK FUSE 20 RT REAR STOP/ TURN FUSE 6 SPLICE PACK SUPPLEMENTAL RESTRAINTS SYSTEM TAIL/STOP, TURN SIGNAL LAMP (LEFT) TAIL/STOP, TURN SIGNAL LAMP (RIGHT) TRAILER WIRING (BLUNT CUT) TRLR PRK FUSE 21 TURN SIGNAL SWITCH TURN SIGNAL/ MULTIFUNCTION SWITCH TURN SIGNAL/HAZARD FLASHER MODULE (BEHIND LEFT CENTER OF DASH) UPFTR PRK LAMPS FUSE 16 W/ OUTSIDE REAR VIEW MIRROR TURN SIGNAL INDICATORS WHT WIRE YEL WIRE YEL/BLK WIRE

23 3 SERIAL DATA BELT SW 7 63 5 VOLT REF LOW REF ABS IND. AIR BAG IND BATTERY IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER RIGHT SIDE OF DASH) BRAKE IND BRAKE WARNING IND CONTROL BATT VOLTAGE GROUND GROUND IGN VOLTAGE SERIAL DATA BRN WIRE BRN/WHT WIRE CHECK GAGES IND. CLASS 2 (BCM) CLASS 2 (EBCM) CLASS 2 (PCM) CLASS 2 (SDM) COMPUTER DATA LINES SYSTEM CRUISE IND DIMMING DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRL IND ECT SENS ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMP ENGINE COOLANT TEMPERATURE SENSOR (LEFT SIDE OF ENGINE) ENGINE OIL LEVEL SWITCH (4.8L, 5.3L, 6.0L) (RIGHT SIDE OF OIL PAN) ENGINE OIL PRESSURE SENSOR (TOP REAR OF ENGINE) FUEL GAUGE FUEL PUMP/ SENDER ASSEMBLY (IN FUEL TANK) GROUND GRY WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN OR START IGN IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN VOLT SIG IGN E FUSE 22 ILLUMINATION (6 BULBS) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER IPC FUSE 31 LCD DISPLAY 000000 TRIP LEFT FRONT SEAT BELT SWITCH (IN LEFT FRONT SEAT BELT LATCH) LEFT TURN IND LH FRT TURN SIG SUP VOLT LOW REF LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION IND LAMP MIL CTRL MIL SIGNAL OFF OIL PRESS OIL PRESS (RIGHT REAR OF ENGINE) OIL PRESSURE OIL PRESSURE IND P R N D 3 2 1 PARK BRAKE PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PNK WIRE POWER BRAKE BOOSTER FLUID PRESSURE ALARM SWITCH (IN BOOSTER INLET HOSE) POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL FUEL LEVEL RED/WHT WIRE RH FRT TURN SIG SUP VOLT RIGHT TURN IND SEAT BELT IND SECURITY IND SERIAL DATA SPEEDOMETER SPLICE PACK TAN WIRE TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND'S TRIP RESET SWITCH TRIP RESET SWN SIGNAL GROUND UNDERHOOD FUSE BLOCK (IN ENGINE COMPT, ATTACHED TO LEFT FRONT FENDER) VOLTMETER W/ PWR SEAT W/O PWR SEAT YEL WIRE

4.3L A/C RELAY AUTOMATIC TRANSMISSION BODY CONTROL MODULE (BCM) BRN WIRE CRANK FUSE 27 CRUISE CONTROL ON/OFF SWITCH ENG 1 FUSE 23 ENG 2 FUSE 21 EVAPORATIVE EMISSIONS (EVAP) CANISTER PURGE SOLENOID EXCEPT 4.3L 4.3L FR WPR FUSE 47 FROM IGNITION SWITCH (DIAGRAM 3 OF 6) FROM UNDERHOOD FUSE BLOCK (SIR FUSE 37) (DIAGRAM 3 OF 6) FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 6 FUEL INJECTOR 6 FUEL INJECTOR 7 (EXCEPT 4.3L) FUEL INJECTOR 8 (EXCEPT 4.3L) IGN 0 FUSE 6 IGN E FUSE 22 IGNITION COIL IGNITION COIL 1 IGNITION COIL 2 IGNITION COIL 3 IGNITION COIL 5 IGNITION COIL 7 IGNITION COIL 8 IGNITION COIL 4 IGNITION COIL 6 IGNITION COIL MODULE INSTRUMENT PANEL CLUSTER MASS AIR FLOW (MAF SENSOR) PARK/ NEUTRAL POSITION (PNP) SWITCH PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) PPL STOP LAMP SWITCH TBC ACC FUSE 46 TURN SIGNAL SWITCH TURN SIGNAL/ MULTIFUNCTION SWITCH WHT WIRE WINDSHIELD WIPER MOTOR YEL WIRE

1 2 3 4 BATTERY B+ SERIAL DATA PNK WIRE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CARGO DOOR LATCH ASSEMBLY CARGO UNLK FUSE 5 CARGO UNLK RELAY 27 DK BLU WIRE DOOR LKS FUSE 15 DOOR LKS RELAY 30 DOOR LOCK CTRL UNLOCK CTRL DRIVER DOOR LATCH ASSEMBLY DRIVER DOOR LOCK SWITCH DRV LKS FUSE 7 DRV UNLK RELAY 28 FRONT PASSENGER DOOR LATCH ASSEMBLY FRONT PASSENGER DOOR LOCK SWITCH GROUND GRY WIRE HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER LEFT REAR SIDE DOOR LOCK ACTUATOR LEFT SIDE DOOR CONTACT PLATE (LEFT "B" PILLAR) LT BLU WIRE LT GRN WIRE PASS UNLK RELAY 31 REAR CARGO DOOR LOCK SWITCH RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (BEHIND CENTER OF DASH) RIGHT REAR SIDE DOOR LOCK ACTUATOR RIGHT SIDE DOOR CONTACT PLATE (RIGHT "B" PILLAR) SERIAL DATA SERIAL DATA UNLOCK RLY CTRL SW UNLOCK CTRL SW LOCK CTRL RELEASE RLY CTRL SPLICE SPLICE PACK TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) RFA FUSE 20 WHT WIRE

21 22 23 24 25 26 27 28 PPL 29 30 31 PNK WIRE 5.3L A/C REQUEST A/C SYSTEM (W/ FRONT MANUAL CONTROLS) ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CRANK FUSE 27 CTRL DEL TORQ SIG PC SOL HI CTRL DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EVAP CANP CTRL EVAP VENT CTRL MIL CTRL 2-3 SS CTRL 1-2 SS CTRL VSS GEN CYCLE SIG GEN TURN ON GRY WIRE HOT IN RUN, START HOT IN START IAT SIG IC 1 CTRL IC 7 CTRL IC 6 CTRL IC 4 CTRL PPL IC 8 CTRL IC 2 CTRL IC 5 CTRL IC 3 CTRL IGN IGNITION COILS INSTRUMENT PANEL CLUSTER LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SIG MAP SIG MALFUNCTION INDICATOR LAMP NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PC SOL LO CTRL PMP RLY CTRL PCM IGN 1 FUSE 38 PNK 1 2 3 4 5 6 WIRE PNK 7 8 WIRE PNK WIRE POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL FRONT LOW SIG FRONT HIGH SIG AT ISS HIGH SIG AT ISS LOW SIG PPL FUEL LEV SIG A/C LOW PRESS PPL PNK PNK WIRE PPL/WHT WIRE RED WIRE REF LO SPARK PLUG STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC SOL CTRL CLUT RLY CTRL TFT SENS SIG PPL UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPARTMENT) W/ ACTIVE BRAKE CONTROL WHT WIRE YEL WIRE YEL/BLK WIRE