Chevrolet RV Cutaway G3500 (1997-2013) ign e fuse 22 Wiring diagrams

ABS/TCC SWITCH ABS/TCS CLASS 2 SERIAL DATA YAW RATE SENSOR LO REF WHEEL POS SENS LOW REF ABS/VSES FUSE 48 AUXILIARY 1 FUSE 32 BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IN BRKS FUSE 11 BRN WIRE DEL TORQUE DK BLU WIRE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) GRY WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START IGN E FUSE 22 IGNITION 3 VOLT LATERAL ACCELEROMETER SIG LEFT FRONT WHEEL SPEED SENSOR (ON INSIDE OF LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR (AT LEFT REAR OF WHEEL HUB) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/BLK WIRE PNK 1 2 WIRE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (IN ENG COMPT, ON LEFT INNER FENDER) PPL PPL UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) PPL/WHT WIRE PRECHARGE MOTOR LO BATTERY (+) GND PRECHARGE MOTOR HI PRECHARGE PUMP (AT LEFT FRONT OF FRAME RAIL) RED WIRE REQ TORQUE REQUEST TORQUE SIGNAL DELIVERED TORQUE SIGNAL RIGHT FRONT WHEEL SPEED SENSOR (ON INSIDE OF RIGHT FRONT WHEEL) RIGHT REAR WHEEL SPEED SENSOR (AT RIGHT REAR OF WHEEL HUB) RUN WIRE STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSES MOTOR VSS HIGH VSS LOW VSS OUTPUT WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SOL 2-3 SOL 3-2 SOL A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION BLK WIRE BLU WIRE BRN WIRE DK BLU WIRE GRY WIRE HOT IN RUN, START IGN E FUSE 22 LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PC SOL VALVE PNK WIRE PPL RED WIRE REV STOP LAMP SWITCH (ABOVE BRAKE PEDAL) TAN (OR WHT) WIRE TAN WIRE TAN/BLK WIRE TCC PWM SOL TCC SOL TFT SENSOR UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

BATTERY BATTERY IND BLK WIRE CLASS 2 SERIAL DATA DK GRN WIRE FUSIBLE LINK C GENERATOR GENERATOR FIELD DUTY CYCLE SIG GENERATOR TURN ON SIG GRY WIRE HOT IN RUN, START UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENG COMPT) IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LOGIC IGN VOLT ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (IN ENG COMPT, ON LEFT INNER FENDER) RED WIRE STARTING/CHARGING SYSTEM (STARTER MOTOR)

330 OHMS BATTERY POSITIVE VOLTAGE BLK WIRE BLU WIRE BRN WIRE BTSI BCK/UP FUSE 36 DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUSE BLOCK- UNDERHOOD (LEFT SIDE OF ENGINE COMPARTMENT) FUSE BLOCK- UNDERHOOD (LEFT SIDE OF ENGINE COMPARTMENT) RT DRL/ TURN FUSE 9 GRN WIRE GROUND HAZRD FUSE 14 HOT AT ALL TIMES HOT IN RUN OR START IGN E FUSE 22 LT BLU WIRE LT DRL/ TURN FUSE 10 LT REAR STOP/ TRN FUSE 4 MARKER LAMP (LF) MARKER LAMP (RF) NOT USED PARK/ TURN SIGNAL LAMP (LF) PARK/ TURN SIGNAL LAMP-RF PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE RED WIRE RED/WHT WIRE RESISTOR RT REAR STOP/ TRN FUSE 6 STOP LAMP FUSE 7 STOP LAMP SWITCH (ABOVE BRAKE PEDAL) TRAILER AUXILIARY SUPPLY VOLTAGE TRAILER BACKUP LAMPS SUPPLY VOLTAGE TRAILER WIRING (BLUNT CUT) TRLR BCK/UP FUSE 5 TRLR FUSE 13 TRLR FUSE 50 WHT WIRE YEL WIRE YEL/BLK WIRE

BATTERY POSITIVE VOLTAGE BLK WIRE BLU WIRE BRN WIRE BTSI BCK/UP FUSE 36 DK BLU WIRE DK DK LT DK GRN WIRE FUSE BLOCK- UNDERHOOD (ON LEFT SIDE OF ENGINE COMPARTMENT) FUSE BLOCK- UNDERHOOD (ON LEFT SIDE OF ENGINE COMPARTMENT) RT DRL/ TURN FUSE 9 GRN WIRE GROUND HAZRD FUSE 14 HOT AT ALL TIMES HOT IN RUN OR START IGN E FUSE 22 LT BLU WIRE LT DRL/ TURN FUSE 10 LT REAR STOP/ TRN FUSE 3 TRLR STOP/ TRN FUSE 17 LT GRN WIRE MARKER LAMP (LF) MARKER LAMP (RF) ORG/ WIRE PARK/ TURN SIGNAL LAMP (LF) PARK/ TURN SIGNAL LAMP-RF PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK 8 9 WIRE PNK WIRE RED WIRE RED/WHT WIRE RT REAR STOP/ TRN FUSE 4 STOP LAMP FUSE 7 STOP LAMP SWITCH (ABOVE BRAKE PEDAL) TRAILER AUXILIARY SUPPLY VOLTAGE TRAILER BACKUP LAMPS SUPPLY VOLTAGE TRAILER PARK LAMPS SUPPLY VOLTAGE TRAILER STOP/ TURN RELAY- LEFT TRAILER STOP/ TURN RELAY- RIGHT TRAILER WIRING (BLUNT CUT) TRLR BCK/UP FUSE 5 TRLR FUSE 13 TRLR FUSE 50 WHT WIRE YEL WIRE

23 3 SERIAL DATA BELT SW 7 63 5 VOLT REF LOW REF ABS IND. AIR BAG IND BATTERY IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER RIGHT SIDE OF DASH) BRAKE IND BRAKE WARNING IND CONTROL BATT VOLTAGE GROUND GROUND IGN VOLTAGE SERIAL DATA BRN WIRE BRN/WHT WIRE CHECK GAGES IND. CLASS 2 (BCM) CLASS 2 (EBCM) CLASS 2 (PCM) CLASS 2 (SDM) COMPUTER DATA LINES SYSTEM CRUISE IND DIMMING DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRL IND ECT SENS ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMP ENGINE COOLANT TEMPERATURE SENSOR (LEFT SIDE OF ENGINE) ENGINE OIL LEVEL SWITCH (4.8L, 5.3L, 6.0L) (RIGHT SIDE OF OIL PAN) ENGINE OIL PRESSURE SENSOR (TOP REAR OF ENGINE) FUEL GAUGE FUEL PUMP/ SENDER ASSEMBLY (IN FUEL TANK) GROUND GRY WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN OR START IGN IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN VOLT SIG IGN E FUSE 22 ILLUMINATION (6 BULBS) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER IPC FUSE 31 LCD DISPLAY 000000 TRIP LEFT FRONT SEAT BELT SWITCH (IN LEFT FRONT SEAT BELT LATCH) LEFT TURN IND LH FRT TURN SIG SUP VOLT LOW REF LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION IND LAMP MIL CTRL MIL SIGNAL OFF OIL PRESS OIL PRESS (RIGHT REAR OF ENGINE) OIL PRESSURE OIL PRESSURE IND P R N D 3 2 1 PARK BRAKE PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PNK WIRE POWER BRAKE BOOSTER FLUID PRESSURE ALARM SWITCH (IN BOOSTER INLET HOSE) POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL FUEL LEVEL RED/WHT WIRE RH FRT TURN SIG SUP VOLT RIGHT TURN IND SEAT BELT IND SECURITY IND SERIAL DATA SPEEDOMETER SPLICE PACK TAN WIRE TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND'S TRIP RESET SWITCH TRIP RESET SWN SIGNAL GROUND UNDERHOOD FUSE BLOCK (IN ENGINE COMPT, ATTACHED TO LEFT FRONT FENDER) VOLTMETER W/ PWR SEAT W/O PWR SEAT YEL WIRE

A/C COMPRESSOR CLUTCH A/C FUSE 32 A/C LOW PRESSURE SWITCH (ON SIDE OF ACCUMULATOR) A/C RELAY 54 AUXILIARY BLOWER MOTOR (IF EQUIPPED) AUXILIARY BLOWER MOTOR RESISTOR BLK WIRE BRN WIRE CLUTCH RLY CTRL DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE HARN, 32 CM FROM HOT AT ALL TIMES HOT IN RUN OR START IGN E FUSE 22 LOW PRESS SIG LT BLU WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT INNER FENDER) PROVISIONAL RED/WHT WIRE REQUEST SIG UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

A/C COMPRESSOR CLUTCH A/C FUSE 32 A/C LOW PRESSURE SWITCH (ON SIDE OF ACCUMULATOR) A/C RELAY 54 AUXILIARY AIR TEMPERATURE ACTUATOR AUXILIARY BLOWER MOTOR (LEFT REAR OF PASSENGER AUXILIARY BLOWER MOTOR RESISTOR AUXILIARY MODE ACTUATOR (LEFT REAR OF PASSENGER COMPT) BLK WIRE BRN WIRE CLUTCH RLY CTRL COMPT, ON AUXILIARY HVAC ASSEMBLY) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRY WIRE HARN, 32 CM FROM HOT AT ALL TIMES HOT IN RUN OR START IGN E FUSE 22 LOW PRESS SIG LT BLU WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT INNER FENDER) PROVISIONAL RED/WHT WIRE REQUEST SIG UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

4.3L A/C RELAY AUTOMATIC TRANSMISSION BODY CONTROL MODULE (BCM) BRN WIRE CRANK FUSE 27 CRUISE CONTROL ON/OFF SWITCH ENG 1 FUSE 23 ENG 2 FUSE 21 EVAPORATIVE EMISSIONS (EVAP) CANISTER PURGE SOLENOID EXCEPT 4.3L 4.3L FR WPR FUSE 47 FROM IGNITION SWITCH (DIAGRAM 3 OF 6) FROM UNDERHOOD FUSE BLOCK (SIR FUSE 37) (DIAGRAM 3 OF 6) FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 6 FUEL INJECTOR 6 FUEL INJECTOR 7 (EXCEPT 4.3L) FUEL INJECTOR 8 (EXCEPT 4.3L) IGN 0 FUSE 6 IGN E FUSE 22 IGNITION COIL IGNITION COIL 1 IGNITION COIL 2 IGNITION COIL 3 IGNITION COIL 5 IGNITION COIL 7 IGNITION COIL 8 IGNITION COIL 4 IGNITION COIL 6 IGNITION COIL MODULE INSTRUMENT PANEL CLUSTER MASS AIR FLOW (MAF SENSOR) PARK/ NEUTRAL POSITION (PNP) SWITCH PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) PPL STOP LAMP SWITCH TBC ACC FUSE 46 TURN SIGNAL SWITCH TURN SIGNAL/ MULTIFUNCTION SWITCH WHT WIRE WINDSHIELD WIPER MOTOR YEL WIRE

1-2 SOL 13 14 PNK WIRE 15 16 17 18 19 20 21 22 PPL 16 17 18 19 20 21 22 23 PPL 2-3 SOL 24 25 26 PNK WIRE 3-2 SOL A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH ACCELERATOR PEDAL POSITION SENSOR (UNDER LEFT SIDE OF DASH) APPS 1 SIG APPS 2 SIG AUTOMATIC TRANSAXLE BLK WIRE BLU WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (TOP CENTER REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE OIL PRESSURE (EOP) SENSOR (TOP REAR OF ENGINE) FUEL TANK PRESSURE SENSOR (ON FUEL TANK) GRY DK GRN WIRE GRY WIRE HOT IN RUN, START IGN E FUSE 22 LOW REF LT BLU WIRE LT BLU/WHT WIRE LT GRN GRY WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP REAR OF ENGINE) ORG/ WIRE ORG/BLK WIRE PC SOL VALVE PNK WIRE PNK/BLK WIRE PPL PPL PNK PNK WIRE PPL/WHT WIRE RED WIRE REV SENSOR 1 SENSOR 2 STOP LAMP SWITCH (ABOVE BRAKE PEDAL) TAN (OR BLK) WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC PWM SOL TCC SOL TFT SENSOR THROTTLE ACTUATOR CONTROL MODULE (AT LEFT REAR OF ENGINE COMPT) UNDERHOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE