Chevrolet RV Cutaway G3500 (1997-2013) hot w/ run/crank relay 15 energized Wiring diagrams

27 28 2501 2500 44 43 COMPUTER DATA LINES SYSTEM DATA BUS (-) DATA BUS (+) 4.3L 4.3L/5.3L 4.8L/6.0L BATTERY BATTERY CURRENT SENSOR (4.3L/5.3L) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE CHARGE IND COMPUTER DATA LINES SYSTEM CURRENT SENSOR SIG DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) EXCEPT 4.3L FUSIBLE LINK 3 GENERATOR GENERATOR FIELD DUTY CYCLE SIG GENERATOR TURN ON SIG GMLAN SERIAL DATA GRY WIRE HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LOGIC LOW REF LOW SPEED GMLAN SERIAL DATA PNK WIRE ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE STARTING CIRCUIT TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

27 28 2501 2500 44 43 COMPUTER DATA LINES SYSTEM DATA BUS (-) DATA BUS (+) 4.3L 4.3L/5.3L 4.8L/6.0L BATTERY BATTERY CURRENT SENSOR (4.3L/5.3L) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE CHARGE IND COMPUTER DATA LINES SYSTEM CURRENT SENSOR SIG DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) EXCEPT 4.3L FUSIBLE LINK 3 GENERATOR GENERATOR FIELD DUTY CYCLE SIG GENERATOR TURN ON SIG GMLAN SERIAL DATA GRY WIRE HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LOGIC LOW REF LOW SPEED GMLAN SERIAL DATA PNK WIRE ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE STARTING CIRCUIT TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

27 28 2501 2500 44 43 COMPUTER DATA LINES SYSTEM DATA BUS (-) DATA BUS (+) 4.3L 4.3L/5.3L 4.8L/6.0L BATTERY BATTERY CURRENT SENSOR (4.3L/5.3L) BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE CHARGE IND COMPUTER DATA LINES SYSTEM CURRENT SENSOR SIG DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROL MODULE (ECM) EXCEPT 4.3L FUSIBLE LINK 3 GENERATOR GENERATOR FIELD DUTY CYCLE SIG GENERATOR TURN ON SIG GMLAN SERIAL DATA GRY WIRE HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LOGIC LOW REF LOW SPEED GMLAN SERIAL DATA PNK WIRE ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE STARTING CIRCUIT TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

AUXILIARY BATTERY AUXILIARY GENERATOR GENERATOR BATTERY BLK WIRE CHARGE IND COMPUTER DATA LINES SYSTEM DK GRN WIRE DRIVER INFORMATION CENTER (DIC) ENGINE CONTROL MODULE (ECM) FUSIBLE LINK 3 FUSIBLE LINK 5 GENERATOR FIELD DUTY CYCLE SIG GENERATOR TURN ON SIG GRY WIRE HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LOGIC ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED WIRE SER DATA BUS - SERIAL DATA STARTER MOTOR TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) UNDERHOOD JUNCTION BLOCK W/ DUAL GENERATOR W/ DUAL GENERATOR, AMBULANCE UPFITTER

14 13 15 5 BRAKE LOW REF BRAKE SENS SIG 15 5 38 45 61 11 54 26 42 FUEL TEM SIG BRAKE APPLY SEN SIG LOW REF 43 44 28 27 SER DATA BUS(+) SER DATA BUS(-) 6.6L 53 57 40 59 32 16 3 65 35 63 5 6 ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) APP SEN 1 SIG LOW REF APP SEN 2 SIG LOW REF PPL AUTOMATIC TRANSMISSION (6 SPEED A/T) AUTOMATIC TRANSMISSION OUTPUT SHAFT SPEED (OSS) SENSOR AUTOMATIC TRANSMISSION OUTPUT SHAFT SPEED (OSS) SENSOR ASSEMBLY BATT + BCM 2 FUSE 58 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY CRUISE CONTROL IND DIMMING SIG CRUISE CONTROL SWITCH SIGNAL CRUISE IND CRUISE SWITCH DATA BUS - DATA BUS + VSS LOW SIG VSS HIGH SIG DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ENGINE CONTROL MODULE (ECM) GMLAN GROUND GRY WIRE HI SPD GMLAN SER DATA BUS- HOT AT ALL TIMES HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (AT TOP OF STEERING COLUMN) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT STEERING WHEEL CONTROL SWITCH LOGIC LT BLU WIRE LT GRN/BLK WIRE PNK WIRE PPL PPL/WHT WIRE RED WIRE RED/WHT WIRE RES+ SET- TAN WIRE TAN/BLK WIRE THROTTLE BODY (EXCEPT 6.6L) TP SENS 1 SIG LOW REF TP SENS 2 SIG TAC MOTOR CTRL 2 TAC MOTOR CTRL 1 TRANS- MISSIONS SYSTEM TRANSMISSION CONTROL MODULE (4 SPEED A/T) TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

22 27 21 6.6L 4.3L EXCEPT 4.3L 55 43 44 9 28 27 BRAKE SIG SER DATA BUS(+) SER DATA BUS(-) 66 46 6.6L 53 57 40 59 32 16 3 65 35 63 5 6 ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) APP SEN 1 SIG LOW REF APP SEN 2 SIG LOW REF PPL BATT + BCM 2 FUSE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE APPLY SEN SIG BRAKE LOW REF BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BRAKE SENS SIG BRAKE SIG BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CRUISE CONTROL IND DIMMING SIG CRUISE CONTROL SWITCH SIGNAL CRUISE IND DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE ENGINE CONTROL MODULE (ECM) GMLAN SER DATA GROUND GRY WIRE HI SPD GMLAN SER DATA BUS- HOT AT ALL TIMES HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN INFLATABLE RESTRAINT STEERING WHEEL INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LOGIC LOW REF LOWER RIGHT FRONT OF ENGINE) LT BLU WIRE LT BLU/WHT WIRE MODULE COIL (AT TOP OF STEERING COLUMN) PNK WIRE PPL RED/WHT WIRE SPLY VOLT TAN WIRE TAN/BLK WIRE THROTTLE BODY (EXCEPT 6.6L) (4.8L, 5.3L, 6.0L: ON LEFT SIDE OF THROTTLE BODY) TP SENS 1 SIG LOW REF TP SENS 2 SIG TAC MOTOR CTRL 2 TAC MOTOR CTRL 1 UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

16 CM FROM UNDERHOOD 4 SPEED A/T 6 SPEED A/T AUTOMATIC TRANSMISSION AUX STOP LAMP FUSE BLK WIRE BLK/WHT WIRE BREAKOUT TOWARDS INSTRUMENT PANEL CLUSTER) BREAKOUT) BRK SW FUSE BRN WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY CUTAWAY DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) EXCEPT 4.3L 4.3L HEAD PARK AUTO HEADLAMP, PANEL DIMMER HOT AT ALL TIMES HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE LEFT FRONT SIDE MARKER LAMP LEFT PARK/ TURN SIGNAL LAMP LEFT TURN IND LOGIC LT BLU WIRE LT BLU/WHT WIRE OFF PNK WIRE PROVISIONAL RIGHT RIGHT PARK/ FRONT SIDE TURN MARKER SIGNAL LAMP LAMP RIGHT TURN IND SER DATA STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) STOP LAMPS PCB RELAY SWITCH TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT CORNER OF ENGINE COMPT) UNDERHOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IP CLSTR FUSE 10 IP CLSTR FUSE 23 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL LOW ENGINE OIL PRESSURE GAUGE LOW TIRE PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

6 7 8 9 PPL PNK WIRE ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRANK RELAY 15 ENERGIZED I/P CLUSTER FUSE 23 IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL PRESSURE GAUGE LOW FUEL IND LOW OIL LOW STABILITY IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PASSENGER SEAT BELT IND PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND PRND 321 RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TIRE PRESSURE IND TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ BRAKE WARNING INDICATOR SYSTEM W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

4.8L, 4.3L 5.3L, 6.0L BATT POS VOLT BCM 3 FUSE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE COMPUTER DATA LINES SYSTEM DK GRN WIRE DRIVER INFORMATION CENTER DISPLAY ENGINE CONTROL MODULE HOOD AJAR SWITCH (W/ REMOTE ENGINE START) HOT AT ALL TIMES HOT AT ALL TIMES BODY FUSE IGN SW BLOCK (UNDER LEFT FUSE 22 FRONT SEAT) HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT IGN VOLT LO SPD DATA IGNITION SWITCH IPC FUSE LO SPD DATA LOCK LOGIC INSTRUMENT CLUSTER NCA WIRE PNK 19 1 WIRE PNK WIRE PNK/BLK WIRE PPL PPL CLOSED SW SIGNAL RED WIRE RED/WHT WIRE RUN WIRE SECURITY IND SERIAL DATA SERIAL DATA BUS- SW SIGNAL TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE