Chevrolet RV Cutaway G3500 (1997-2013) gry Wiring diagrams

1 2 6 8 20 21 22 23 40 42 47 48 51 62 63 GND TCC PWM CTRL PC SOL HI CTRL AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE SENSOR (ON LEFT SIDE OF ENGINE) FROM UNDERHOOD PASS- THROUGH GROMMET BREAKOUT) GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, START HOT IN RUN, START IGN 0 FUSE 6 INSTRUMENT PANEL CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PC SOL LO CTRL PPL FRONT LOW SIG FRONT HIGH SIG PCM BATT FUSE 2 PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PRNDL INDICATOR RED/WHT WIRE SERIAL DATA TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TOW/ HAUL SWITCH TOW/HAUL INDICATOR TOW/HAUL SWITCH SIG UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPARTMENT) VEHICLE SPEED SENSOR WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SOL 2-3 SOL 3-2 SOL A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION BLK WIRE BLU WIRE BRN WIRE DK BLU WIRE GRY WIRE HOT IN RUN, START IGN E FUSE 22 LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PC SOL VALVE PNK WIRE PPL RED WIRE REV STOP LAMP SWITCH (ABOVE BRAKE PEDAL) TAN (OR BLK) WIRE TAN WIRE TAN/BLK WIRE TCC PWM SOL TCC SOL TFT SENSOR UNDERHOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE YEL WIRE YEL/BLK WIRE

A/T INPUT SHAFT SPEED ACCESSORY VOLT AT ISS HI SIG BLK WIRE BLK/WHT WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE ECM/TCM GLOW PLUG CNTRL MDL IGN 1 FUSE 38 FOH/ECM TCM BATT FUSE 2 GMLAN DATA (+) VSS LOW PC SOL LOW PPL GMLAN DATA (-) 2-3 SHIFT SOL GMLAN DATA (-) GMLAN DATA (+) TR SW P SIG PC SOL HI VSS HI SIG STOP LMP VOLT GRY WIRE HOT AT ALL TIMES HOT IN ACC OR RUN HOT IN ACC RUN AND START HOT IN RUN OR START IGN 0 FUSE 6 LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE P/N PARK/NEUTRAL POSITION (PNP) SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE PPL REAR HI SIG GMLAN DATA (+) GMLAN DATA (-) RED/WHT WIRE SENSOR (A/T ISS) (LEFT SIDE OF TRANSMISSION STOP LAMP FUSE 7 STOP LAMP SWITCH (ABOVE BRAKE PEDAL) STOP/CHMSL FUSE 8 TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TBC/TCM ACCY FUSE 46 TFP SW B SIG TFT SENS SIG TR SW A SIG LOW REF IGN 1 VOLT BATTERY TFP SW C SIG TR SW B SIG TR SW C SIG TFP SW A SIG PNK WIRE TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT CORNER OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (RIGHT SIDE OF TRANSMISSION) WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL VALVE 2-3 SHIFT SOL VALVE 30 45 39 9 44 57 MIL IND CTRL REAR HI SIG A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CLASS 2 CLASS 2 DATA CLASS 2 MIL SIG COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) GRY WIRE IGN INSTRUMENT PANEL CLUSTER LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE P/N SIG CLASS 2 DATA GMLAN (-) GMLAN (+) PNK WIRE PPL PRESSURE CONTROL A/T FLUID SOLENOID TEMP VALVE SENSOR RED WIRE REV TAN WIRE TAN/BLK WIRE TCC PWM SOL VALVE TOW/ HAUL IND TOW/ HAUL SWITCH TOW/HL SW YEL WIRE YEL/BLK WIRE

68 47 28 4 SENS SIG LOW REF CLUTCH CTRL SPEED SIG BLK WIRE BRN/WHT WIRE DK BLU WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP OF ENGINE, NEAR THERMOSTAT HOUSING) ENGINE COOLING FAN (BEHIND RADIATOR) FAN CLTCH (D) FUSE 58 FAN CLTCH (D) RELAY 75 GRY WIRE HOT W/ PWR/TRN RELAY ENERGIZED LOW REF TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

2 6 3 1 CAN BUS HI LO REF CAN BUS LO 3 21 DIMMING CTRL TRACTION SW 5.3L, 4.8L, 6.0L 4.3L 6 16 TCC BRAKE SIG PRK BRK SW ABS IND. ABS MDL FUSE 2 ABS MTR FUSE 1 BLK WIRE BLK/PPL WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE IND BREAKOUT TOWARDS INSTRUMENT PANEL CLUSTER) BRK SW FUSE 13 BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FUSE 29 GRY WIRE GRY/BLK WIRE HI SPD GMLAN DATA + HI SPD GMLAN DATA + B+ HI SPD GMLAN DATA- HI SPD GMLAN DATA- GND HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED IGN VOLT IGN VOLT STEERING SENS A STEERING SENS C INSTRUMENT PANEL CLUSTER (IPC) IP CLSTR FUSE 10 LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR (WSS) (AT LEFT REAR WHEEL HUB) LF WHEEL SPD SENS LOW REF LOW REF LO SPD GMLAN LOGIC LOGIC STEERING WHEEL SPEED/ POSITION SENSOR (AT BASE OF STEERING COLUMN) LOW REF RF WHEEL SPD SENS LOW STABILITY IND LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PARK BRAKE SWITCH (UNDER LEFT PNK 7 3 5 6 2 4 1 8 WIRE PNK WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF RIGHT FRONT WHEEL) RIGHT REAR WHEEL SPEED SENSOR (WSS) (AT RIGHT REAR WHEEL HUB) SERIAL DATA SERIAL DATA ENABLE B+ SIDE OF DASH) STEERING ANGLE SENS CAN BUS LO DATA STEERING SENS B STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) STR/WHL SNSR (G) TAN WIRE TAN/BLK WIRE TRACTION CONTROL SWITCH UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VDC IND VEHICLE SPD SIG CAN BUS HI DATA VEHICLE SPEED SIGNAL WHT WIRE WHT/BLK WIRE YAW, LATERAL ACCELERATION SENSOR (UNDER FRONT PASSENGER SEAT) YEL WIRE YEL/BLK WIRE

1 2 3 4 B+ SERIAL DATA COMPUTER DATA LINES SYSTEM 8 9 2500 2501 SERIAL DATA BUS + SERIAL DATA BUS - BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) CARGO DOOR UNLOCK RELAY CARGO DR UNLCK FUSE 33 CHIME MODULE (BEHIND LEFT CENTER OF DASH) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DOOR LOCK RELAY DOOR UNLOCK RELAY DRIVER DOOR UNLATCH RELAY DVR DR UNLCK FUSE 36 FRT DR LCK FUSE 31 FRT PASS DR UNLCK FUSE 34 GROUND GRY WIRE GRY/BLK WIRE HOOD AJAR SWITCH (W/ REMOTE ENGINE START) HOT AT ALL TIMES BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) HOT AT ALL TIMES UNDERHOOD LEFT REAR SIDE DOOR JAM SWITCH (W/ HINGED DOOR) (AT LEFT "B" PILLAR) LIFTGATE AJAR SW SIG LO SPD GMLAN SERIAL DATA LO SPD SERIAL DATA LT BLU WIRE LT GRN WIRE MEGA FUSE FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) NCA WIRE ORG/BLK WIRE PNK/BLK WIRE PPL PPL CLOSED SW SIG RADIO REAR DR LCK FUSE 32 REAR OPEN SW REAR PASS DR UNLCK FUSE 35 RED/BLK WIRE RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (BEHIND CENTER OF DASH) RFA/TPM FUSE 21 RIGHT REAR SIDE DOOR JAM SWITCH (W/ CARGO PASSENGER) (AT RIGHT "B" PILLAR) SW SIG TAN WIRE TAN/BLK WIRE TAN/WHT WIRE W/ COMMERCIAL TRADESMAN W/ HINGED DOOR W/O COMMERCIAL TRADESMAN WHT WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BREAKOUT) CARGO DOOR LATCH ASSEMBLY (W/ CARGO/PASSENGER) (IN RIGHT REAR CARGO DOOR) CARGO/ PASSENGER COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DRIVER DOOR LATCH ASSEMBLY (AT REAR OF DRIVER DOOR) DRIVER DOOR LOCK SWITCH DRIVER INFORMATION CENTER (DIC) DISPLAY GRY WIRE GRY/BLK WIRE INSTRUMENT CLUSTER (IPC) LEFT BODY SLIDING DOOR JAMB CONTACT PLATE (AT LEFT "B" PILLAR) LOGIC LOW SPD GMLAN SERIAL DATA LT BLU WIRE LT GRN WIRE ORG/BLK WIRE PASSENGER DOOR LATCH ASSEMBLY (AT REAR OF FRONT PASSENGER DOOR) PASSENGER DOOR LOCK SWITCH PNK/BLK WIRE REAR CARGO DOOR LOCK SWITCH RIGHT BODY SLIDING DOOR JAMB CONTACT PLATE (AT RIGHT "B" PILLAR) SECURITY INDICATOR TAN WIRE TAN/BLK WIRE TAN/WHT WIRE W/ HINGED DOOR W/ HINGED DOORS

A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK WIRE BLK/WHT WIRE BREAKOUT) BRK SW FUSE 32 BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 54 ECM IGN FUSE 48 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) GMLAN DATA- GMLAN DATA+ APP SENS 1 SIG LOW REF LOW REF APP SENS 2 SIG GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 69 ENERGIZED IAT SENS SIG LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF SENS SIG NCA WIRE ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL LOW REF PRESS SENS SIG PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4.8L/6.0L 5.3L BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH RLY CTRL CNSTR VENT SOL FUSE 17 COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ECM PWR/TRN FUSE 50 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EVAP SOL CTRL EVAPORATIVE EMISSION (EVAP) CANISTER VENT SOLENOID (NEAR FRONT OF FUEL TANK) EVEN IGN/ INJ FUSE 52 FUEL PUMP RELAY 72 (4.8L/6.0L) FUEL/PUMP FUSE 2 GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES IC 1 CTRL IC 2 CTRL IC 3 CTRL IC 4 CTRL IC 5 CTRL IC 6 CTRL IC 7 CTRL IC 8 CTRL IGN INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF/ CNSTR VENT FUSE 49 MALFUNCTION INDICATOR LAMP MIL CTRL ODD IGN/INJ FUSE 55 ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 7 (OR PNK) WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL/WHT WIRE PWR/TRN RELAY 76 RED WIRE RED/WHT WIRE SNSR 1 FUSE 46 SNSR 2 FUSE 56 TOS SIG TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE WHT WIRE YEL WIRE