Chevrolet RV Cutaway G3500 (1997-2013) cruise ind Wiring diagrams

BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF ORG/BLK WIRE PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) THROTTLE ACTUATOR CONTROL (TAC) MODULE (AT LEFT REAR OF ENGINE COMPARTMENT) TURN SIGNAL/ MULTIFUNCTION SWITCH UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA SERIAL DATA 14 58 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSS HIGH WHT WIRE YEL WIRE

BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF ORG/BLK WIRE PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) THROTTLE ACTUATOR CONTROL (TAC) MODULE (AT LEFT REAR OF ENGINE COMPARTMENT) TURN SIGNAL/ MULTIFUNCTION SWITCH UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA SERIAL DATA 14 58 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSS HIGH WHT WIRE YEL WIRE

BLK WIRE BODY FUSE BLOCK (BELOW LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF ORG/BLK WIRE PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) THROTTLE ACTUATOR CONTROL (TAC) MODULE (AT LEFT REAR OF ENGINE COMPARTMENT) TURN SIGNAL/ MULTIFUNCTION SWITCH UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA SERIAL DATA 14 58 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSS HIGH WHT WIRE YEL WIRE

40 21 STOPLAMP SW INPUT IGNITION 44 57 22 54 2 4 6 HI SPD GMLAN + HI SPD GMLAN - TCC BRK SW VSS 61 34 10 CRUISE ON INPUT SET/COAST SIG RESUME/ACCEL SIG ANTI-LOCK BRAKE SYSTEM BLK WIRE BLK/WHT WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE ECM/TCM GLO PLUG MDL FUSE 38 ENGINE CONTROL MODULE (ECM) FOH/ECM TCM BATT FUSE 2 GROUND GROUND GROUND 1551 1551 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF PNK WIRE PPL PPL 420 1827 PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT CORNER OF ENGINE COMPT) TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) WHT WIRE YEL WIRE YEL/BLK WIRE

40 21 STOPLAMP SW INPUT IGNITION 44 57 22 54 2 4 6 HI SPD GMLAN + HI SPD GMLAN - TCC BRK SW VSS 61 34 10 CRUISE ON INPUT SET/COAST SIG RESUME/ACCEL SIG ANTI-LOCK BRAKE SYSTEM BLK WIRE BLK/WHT WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE ECM/TCM GLO PLUG MDL FUSE 38 ENGINE CONTROL MODULE (ECM) FOH/ECM TCM BATT FUSE 2 GROUND GROUND GROUND 1551 1551 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF PNK WIRE PPL PPL 420 1827 PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT CORNER OF ENGINE COMPT) TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) WHT WIRE YEL WIRE YEL/BLK WIRE

14 13 15 5 BRAKE LOW REF BRAKE SENS SIG 15 5 38 45 61 11 54 26 42 FUEL TEM SIG BRAKE APPLY SEN SIG LOW REF 43 44 28 27 SER DATA BUS(+) SER DATA BUS(-) 6.6L 53 57 40 59 32 16 3 65 35 63 5 6 ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) APP SEN 1 SIG LOW REF APP SEN 2 SIG LOW REF PPL AUTOMATIC TRANSMISSION (6 SPEED A/T) AUTOMATIC TRANSMISSION OUTPUT SHAFT SPEED (OSS) SENSOR AUTOMATIC TRANSMISSION OUTPUT SHAFT SPEED (OSS) SENSOR ASSEMBLY BATT + BCM 2 FUSE 58 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY CRUISE CONTROL IND DIMMING SIG CRUISE CONTROL SWITCH SIGNAL CRUISE IND CRUISE SWITCH DATA BUS - DATA BUS + VSS LOW SIG VSS HIGH SIG DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ENGINE CONTROL MODULE (ECM) GMLAN GROUND GRY WIRE HI SPD GMLAN SER DATA BUS- HOT AT ALL TIMES HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (AT TOP OF STEERING COLUMN) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT STEERING WHEEL CONTROL SWITCH LOGIC LT BLU WIRE LT GRN/BLK WIRE PNK WIRE PPL PPL/WHT WIRE RED WIRE RED/WHT WIRE RES+ SET- TAN WIRE TAN/BLK WIRE THROTTLE BODY (EXCEPT 6.6L) TP SENS 1 SIG LOW REF TP SENS 2 SIG TAC MOTOR CTRL 2 TAC MOTOR CTRL 1 TRANS- MISSIONS SYSTEM TRANSMISSION CONTROL MODULE (4 SPEED A/T) TRANSMISSION CONTROL MODULE (TCM) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

BLK WIRE BODY FUSE BLOCK (BELOW LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF ORG/BLK WIRE PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) THROTTLE ACTUATOR CONTROL (TAC) MODULE (AT LEFT REAR OF ENGINE COMPARTMENT) TURN SIGNAL/ MULTIFUNCTION SWITCH UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA SERIAL DATA 14 58 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSS HIGH WHT WIRE YEL WIRE

23 3 SERIAL DATA BELT SW 7 63 5 VOLT REF LOW REF ABS IND. AIR BAG IND BATTERY IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (LOWER RIGHT SIDE OF DASH) BRAKE IND BRAKE WARNING IND CONTROL BATT VOLTAGE GROUND GROUND IGN VOLTAGE SERIAL DATA BRN WIRE BRN/WHT WIRE CHECK GAGES IND. CLASS 2 (BCM) CLASS 2 (EBCM) CLASS 2 (PCM) CLASS 2 (SDM) COMPUTER DATA LINES SYSTEM CRUISE IND DIMMING DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRL IND ECT SENS ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMP ENGINE COOLANT TEMPERATURE SENSOR (LEFT SIDE OF ENGINE) ENGINE OIL LEVEL SWITCH (4.8L, 5.3L, 6.0L) (RIGHT SIDE OF OIL PAN) ENGINE OIL PRESSURE SENSOR (TOP REAR OF ENGINE) FUEL GAUGE FUEL PUMP/ SENDER ASSEMBLY (IN FUEL TANK) GROUND GRY WIRE HIGH BEAM IND HOT AT ALL TIMES HOT IN RUN OR START IGN IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN CLASS 2 (PCM) IGN VOLT SIG IGN E FUSE 22 ILLUMINATION (6 BULBS) INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER IPC FUSE 31 LCD DISPLAY 000000 TRIP LEFT FRONT SEAT BELT SWITCH (IN LEFT FRONT SEAT BELT LATCH) LEFT TURN IND LH FRT TURN SIG SUP VOLT LOW REF LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION IND LAMP MIL CTRL MIL SIGNAL OFF OIL PRESS OIL PRESS (RIGHT REAR OF ENGINE) OIL PRESSURE OIL PRESSURE IND P R N D 3 2 1 PARK BRAKE PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PNK WIRE POWER BRAKE BOOSTER FLUID PRESSURE ALARM SWITCH (IN BOOSTER INLET HOSE) POWERTRAIN CONTROL MODULE (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL FUEL LEVEL RED/WHT WIRE RH FRT TURN SIG SUP VOLT RIGHT TURN IND SEAT BELT IND SECURITY IND SERIAL DATA SPEEDOMETER SPLICE PACK TAN WIRE TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND'S TRIP RESET SWITCH TRIP RESET SWN SIGNAL GROUND UNDERHOOD FUSE BLOCK (IN ENGINE COMPT, ATTACHED TO LEFT FRONT FENDER) VOLTMETER W/ PWR SEAT W/O PWR SEAT YEL WIRE

ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRANK RELAY 15 ENERGIZED IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IP CLSTR FUSE 10 IP CLSTR FUSE 23 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL LOW ENGINE OIL PRESSURE GAUGE LOW TIRE PRESSURE IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

6 7 8 9 PPL PNK WIRE ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRANK RELAY 15 ENERGIZED I/P CLUSTER FUSE 23 IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL PRESSURE GAUGE LOW FUEL IND LOW OIL LOW STABILITY IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PASSENGER SEAT BELT IND PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND PRND 321 RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TIRE PRESSURE IND TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ BRAKE WARNING INDICATOR SYSTEM W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE