Chevrolet Pickup C3500 (1988-2000) blk/wht Wiring diagrams

A/C A/C HIGH COMP- PRESSURE RESSOR CUTOUT CLUTCH SWITCH # 2 A/C CONTROLLER ALL EXCEPT DRL ASH TRAY LAMPS AUDIO ALARM MODULE AUXILIARY BATTERY RELAY BLK WIRE BLK/WHT WIRE BLOWER MOTOR CENTER GLOW HIGH PLUG MOUNT CONTROL STOPLAMP MODULE RELAY CENTER HIGH MOUNT STOPLAMP (CHMSL) CIGARETTE LIGHTER ASSEMBLY CONVENIENCE CENTER CONVENIENCE DATA CENTER LINK CONNECTOR COOLANT LEVEL FUEL SENSOR HEATER CRUISE CONTROL MODULE DAYTIME RUNNING LAMPS MODULE DAYTIME RUNNING LAMPS RELAY DIESEL ENGINE ONLY DIODE EGR ELECTRONIC VACUUM FUEL REGULATOR PUMP SOLENOID AND VALVE SENDER ENGINES FOUR- WHEEL DRIVE INDICATOR FROM LEFT HIGH (OR HIGH/LOW) BEAM HEADLAMP FUEL PUMP RELAY GRA I/P COMP- ARTMENT BOX LAMP INSTRUMENT CLUSTER LEFT DOOR JAMB SWITCH LOW COOLANT WARNING LAMP MODULE MODULE NCA WIRE ORG/ WIRE PANEL DIMMER SWITCH (ASSEMBLY) PICKUP ONLY POWER LOCKS POWER WINDOWS POWER SEAT POWERTRAIN CONTROL MODULE (PCM) PUMP MOTOR RADIO REAR AUXILLIARY HEATER CONTROL REAR DEFOGGER SWITCH REAR WASHER PUMP MOTOR REAR WIPER/ WASHER SWITCH RED/WHT WIRE RIGHT DOOR JAMB SWITCH ROOF MARKER LAMPS RWAL MODULE SAFETY BELT RETRACTOR SWITCH SUBURBAN, UTILITY ONLY TAN WIRE TAN/WHT WIRE TURN FLASHER VEHICLE PARK/ SPEED NEUTRAL SENSOR POSITION BUFFER SWITCH W/ DIESEL ENGINES ONLY W/ HD AUTOMATIC TRANSMISSION WATER IN-FUEL SENSOR WHT/ BLK WIRE WIPER MOTOR AND HEATED MODULE OXYGEN (FRONT) SENSOR

BLK WIRE BLK/WHT WIRE BRN WIRE CHASSIS CAB CONVENIENCE CENTER DATA LINK CONNECTOR ENDGATE ENDGATE CLEARANCE LAMPS EVRV ELECTRONIC VACUUM REGULATOR VALVE SOLENOID FUEL PUMP FUEL PUMP RELAY HEAVY DUTY TRAILER HOT FUEL HANDLING MODULE KNOCK SENSOR MODULE LEFT CARGO DOOR DEFOGGER GRID LEFT DOOR CONTACT SWITCH LEFT FRONT CLEARANCE LAMP LEFT LICENSE LAMP LEFT REAR CENTER TAIL, STOP, HIGH LICENSE, MOUNT TURN AND STOPLAMP BACKUP LAMPS LEFT REAR CLEARANCE LAMP LEFT REAR FENDER LEFT REAR TAIL, STOP, TURN AND BACKUP LAMPS LEFT TAIL/ STOP, TURN AND BACKUP LAMP ORN/ PARK/ NEUTRAL POSITION SWITCH PICKUP (W/O DUAL REAR WHEELS), SUBURBAN AND UTILITY PICKUP WITH DUAL REAR WHEELS POWERTRAIN CONTROL MODULE (PCM) REAR DOOR W/ AUXILLIARY JAMB SWITCH HEATER, AIR CONDITIONING REAR ENDGATE LIFTGATE WINDOW WINDOW DEFOGGER RELEASE GRID SOLENOID REAR WIPER MOTOR MODULE RIGHT CARGO DOOR DEFOGGER GRID RIGHT DOOR CONTACT SWITCH RIGHT FRONT CLEARANCE LAMP RIGHT GAS STRUT CYLINDER RIGHT LEFT LICENSE LICENSE LAMP LAMP RIGHT LICENSE LAMP RIGHT REAR CLEARANCE LAMP RIGHT REAR FENDER RIGHT REAR TAIL, STOP, LICENSE, TURN AND BACKUP LAMPS RIGHT REAR TAIL, STOP, TURN AND BACKUP LAMPS RIGHT TAIL/ STOP, TURN AND BACKUP LAMP SUBURBAN, UTILITY NON-BASE VEHICLE SUBURBAN, UTILITY W/ AUTOMATIC TRANSMISSIONS SUBURBAN/ UTILITY TAN WIRE TAN/WHT WIRE TEMPER- ATURE BLOWER MODE MODE DOOR MOTOR DOOR (REAR) RELAY MOTOR TRAILER) VEHICLE SPEED SENSOR BUFFER W/ REAR AUXILLIARY HEATER ONLY W/HD AUTOMATIC TRANSMISSION) WHT WIRE WHT/ BLK WIRE WITH ENDGATE

A/T ACCY AIR BAG ANTI-LOCK BRAKES ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRAKE PRESSURE WARNING SWITCH (ON REAR OF BRAKE PRESSURE MODULATOR VALVE BODY) BRAKE/ BRN WIRE BRN/WHT WIRE BULB TEST CHECK GAUGES CHECK GAUGES LAMP DRIVER CONVENIENCE CENTER (BEHIND LEFT SIDE OF I/P) DAYTIME RUNNING LAMPS DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC PRNDL DISPLAY MODULE ENG-I MINI FUSE ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM SOUND SYSTEMS ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENDER (FRONT OF LEFT CYLINDER HEAD) FUEL GAUGE FUEL PUMP, SENDER (IN FUEL TANK) GAUGES FUSE 4 GEN WAIT TO GRY WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM (DRL) HI BEAM HOT IN RUN OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IGNITION SWITCH ILLUM INSTRUMENT CLUSTER LEFT TURN LOCK OFF W/ DRL ONLY LOW COOLANT LOW COOLANT LEVEL SENDER (IN COOLANT RESERVOIR) LOW ENGINE COOLANT LEVEL INDICATOR MODULE (UNDER CENTER OF I/P) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE M/T PNK WIRE NCA WIRE OIL PRESS OIL PRESSURE SWITCH/SENDER (LEFT REAR TOP OF ENGINE) PARK BRAKE WARNING SWITCH (LEFT END OF I/P) PNK WIRE PPL PPL/WHT WIRE RIGHT TURN RUN WIRE SAFETY BELT SERVICE ENGINE SOON SERVICE THROTTLE SOON UP- SHIFT SPEED- OMETER STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TACH VOLT- METER TAN WIRE TAN/ WHT WIRE TAN/BLK WIRE TAN/WHT WIRE TEMP GAUGE TRANS FUSE 20 TRANSMISSSION RANGE SELECTOR TRUNK, TAILGATE, FUEL DOORS SYSTEM TRUNK/TAIL- GATE/FUEL DOORS SYSTEM UNDERHOOD FUSE/RELAY CENTER (LEFT REAR OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (BEHIND RIGHT END OF I/P) W/O DRL ONLY WARNING SYSTEMS WATER IN FUEL WATER-IN FUEL SENSOR (TOP REAR OF ENGINE) WHT TAN/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C SIG AIR CONDITIONING SYSTEM APP 3 SENS SIG FUEL TEMP SIG IAT SIG B/H BARO SENSOR (VIN F) (UPPER LEFT SIDE OF COWL) BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE EGR CONTROL PRESSURE/ BARO SENSOR (VIN P, S) (UPPER LEFT SIDE OF COWL) FUEL HEATER (TOP REAR OF ENGINE) FUEL PUMP IN-LINE FUSE FUEL PUMP OIL PRESSURE SWITCH FUEL PUMP RELAY (RIGHT UPPER COWL) FUEL PUMP/SENDER (IN FUEL TANK) FUSE BLOCK FUSIBLE LINK FUSIBLE LINKS GAUGES FUSE GLOW PLUG CONTROL RELAY (RIGHT REAR TOP OF ENGINE) GLOW PLUG SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES STOP FUSE ECM-IGN FUSE HOT IN RUN, BULB TEST OR START HOT IN START OR RUN GLO PLUG FUSE IGNITION FEED INSTRUMENT CLUSTER INSTRUMENT CLUSTERS SYSTEM LEFT BANK GLOW PLUGS LT BLU/BLK WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TURBO ONLY) (LEFT REAR ENGINE COMPT, AT COWL) ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL/WHT WIRE RED WIRE RED/BLK WIRE RIGHT BANK GLOW PLUGS SERVICE ENGINE SOON LAMP SOL FUSE TAN WIRE TAN/BLK WIRE TCC/ BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) VIN P ONLY WAIT LAMP "SERVICE THROTTLE" LAMP WASTEGATE SOL CTRL EGR VENT SOL CTRL "SERVICE THROTTLE" LAMP WHT WIRE WHT/BLK WIRE YEL (OR WHT) WIRE YEL WIRE YEL/BLK WIRE

4 WHEEL DRIVE LOW SWITCH 983 474 PPL 999 998 961 452 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCELERATOR BRACKET) ANTI-LOCK BRAKES SYSTEM APP 1 SENSOR APP 3 SENSOR APP 2 SENSOR BATTERY FEED BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/WHT WIRE BOOST SIG ECT SIG TRANS FLUID TEMP SIG BRN WIRE BRN/WHT WIRE CKP SIG OPTICAL SENS GND OPTICAL SENS CAM SIG CLUTCH PEDAL POSITION SWITCH CONVEN- IENCE CENTER CRK FUSE CRUISE CONTROL SYSTEM CRUISE ON/OFF SIG DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) ENGINE SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) F/SOL FUSE FUEL INJ CTRL FUEL INJ CTRL EGR SOL CTRL ENG SHUT-OFF CTRL FUEL SOLENOID (TOP FRONT OF ENGINE) FUEL SOLENOID DRIVER (TOP FRONT OF ENGINE) FUSE FUSE BLOCK FUSIBLE LINK GLOW PLUG RLY CTRL SERIAL DATA TRANS OUTPUT SPD SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN CRANK HOT IN RUN HOT IN START OR RUN LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE OPTICAL SENSOR AND FUEL TEMPER- ATURE SENSOR (TOP FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL/WHT WIRE RED WIRE RESUME/ACCEL SIG SET/COAST SIG SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) SYSTEM GND CLOSURE GND APP 2 SENS GND APP 1 SENS GND APP 3 SENS GND SENSOR GND SYSTEM GND FUEL INJ SIG APP SENS 2 SIG APP SENS 1 SIG EGR CTRL/BARO SIG TAN WIRE TAN/WHT WIRE TCC BRAKE SW TRANS OUTPUT VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VSS VSS HI RESOLUTION SIG VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C SIG AIR COND- ITIONING SYSTEM APP 3 SENS SIG FUEL TEMP SIG IAT SIG B/H BARO SENSOR (VIN F ONLY) (UPPER LEFT SIDE OF COWL) BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE EGR CONTROL PRESSURE/ BARO SENSOR (VIN P, S) (UPPER LEFT SIDE OF COWL) FUEL HEATER (TOP REAR OF ENGINE) FUEL PUMP IN-LINE FUSE FUEL PUMP OIL PRESSURE SWITCH FUEL PUMP RELAY (RIGHT SIDE OF SAFETY WALL) FUEL PUMP/SENDER (IN FUEL TANK) FUSE BLOCK FUSIBLE LINK FUSIBLE LINKS GAUGES FUSE GLOW PLUG CONTROL RELAY (RIGHT REAR TOP OF ENGINE) GLOW PLUG SIG GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES STOP FUSE ECM-IGN FUSE HOT IN RUN, BULB TEST OR START HOT IN START OR RUN GLO PLUG FUSE IGNITION FEED INSTRUMENT CLUSTER INSTRUMENT CLUSTERS SYSTEM LEFT BANK GLOW PLUGS LT BLU/BLK WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (VIN F, S) (LEFT REAR ENGINE COMPT, AT COWL) ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL PPL 15 16 PPL/WHT WIRE RED WIRE RED/BLK WIRE RIGHT BANK GLOW PLUGS SERVICE ENGINE SOON LAMP SOL FUSE TAN WIRE TAN/BLK WIRE TCC/ BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) WAIT LAMP "SERVICE THROTTLE" LAMP WASTEGATE SOL CTRL EGR VENT SOL CTRL "SERVICE THROTTLE" LAMP WHT WIRE WHT/BLK WIRE YEL (OR WHT) WIRE YEL WIRE YEL/BLK WIRE

AIR CONDITION- ING SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COOLANT TEMP. SENSOR DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DLC THROTTLE POSITION SENSOR IN LO SIDE INJ A EGR VALVE SOLENOID ELEC FUEL PUMP IN MAP SENSOR IN ENG-I MINI FUSE EVAP CANISTER PURGE CTRL EVAPORATIVE CANISTER PURGE SOLENOID (RIGHT SIDE OF ENGINE) FUEL PUMP RELAY CTRL PCM TRANS FORCE MTR LO GRY WIRE GRY/BLK WIRE HOT IN RUN OR START IDLE AIR CONTROL UNIT (RIGHT REAR OF TBI UNIT) IGNITION BYPASS KNOCK SENSOR IN LINEAR EGR POSITION IN LINEAR EGR REGULATOR SOLENOID VALVE (LEFT REAR OF ENGINE) LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/ WIRE OXYGEN SENSOR LO PCM TO TRANS TEMP SENSOR PCM TRANS RANGE A TRANS INPUT SPEED IN HI TRANS INPUT SPEED IN LO PCM TRANS RANGE B PCM TRANS RANGE C MIL INDICATOR CTRL PCM TRANS SHIFT SOL B PCM TRANS SHIFT SOL A PNK PNK PNK 25 26 27 WIRE PNK WIRE POWERTRAIN CONTROL MODULE (UNDER RIGHT SIDE OF I/P) PPL PPL 1 2 3 4 PPL 22 23 PPL/WHT WIRE RED WIRE RED/BLK WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE ACTUATOR SOL CTRL TCC CLUTCH CTRL A/C ON SIGNAL IN BRAKE SW TO PCM THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) TRANSMISSION INPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANS- MISSION) TRANSMISSIONS SYSTEM WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BRN WIRE DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM-B MINI FUSE FUEL PUMP AND SENDER FUEL PUMP OIL PRESSURE SWITCH/SENDER (LEFT LOWER FRONT OF ENGINE, NEAR DAMPER) FUEL PUMP PRIME CONN- ECTOR FUEL PUMP RELAY (UNDERHOOD FUSE/RELAY CENTER) GRY WIRE HEAVY DUTY ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IDLE SPEED CONTROL ACTUATOR (ON THROTTLE BODY UNIT) INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OIL PRESS IN ORG/ WIRE OXYGEN SENSOR (EXHAUST PIPE NEAR CROSSOVER) PNK WIRE PPL PPL/WHT WIRE PRESSURE CONTROL SOLENOID RANGE MODE SELECTOR RED WIRE RED/BLK WIRE SHIFT SOLENOID 1-2 SHIFT SOLENOID 2-3 TORQUE CONVERTER CLUTCH SOLENOID TACH IN TAN WIRE TRANS FUSE 20 TRANS- MISSION TEMP SENSOR UNDERHOOD FUSE/RELAY CENTER (LEFT REAR OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VSS IN WHT WIRE WHT/BLK WIRE YEL/BLK WIRE

7.4L ONLY A/C ON SIGNAL IN AIR CONDITION- ING SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COOLANT TEMP. SENSOR CRUISE CONTROL SYSTEM CRUISE IND REG GRD DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DLC SERIAL DATA DLC THROTTLE POSITION SENSOR IN LO SIDE INJ A ECM-I MINI FUSE EGR VALVE SOLENOID (4.3L ONLY) (RIGHT SIDE OF ENGINE) EGR VALVE SOLENOID SHIFT LAMP CONTROL ELEC FUEL PUMP IN MAP SENSOR IN ENG-I MINI FUSE EVAP CANISTER PURGE CTRL EVAPORATIVE CANISTER PURGE SOLENOID (7.4L ONLY) (RIGHT SIDE OF ENGINE) FUEL PUMP RELAY CTRL GRY WIRE HOT IN RUN OR START IDLE AIR CONTROL UNIT (RIGHT REAR OF TBI UNIT) IDLE SPEED CONTROL IGNITION BYPASS IGNITION CONTROL (IC) VSS BUFFER SIGNAL VSS BUFFER SIGNAL KNOCK SENSOR IN PINTLE POSITION SIGNAL LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MIL INDICATOR CTRL ORG/ WIRE OXYGEN SENSOR LO PNK WIRE POWERTRAIN CONTROL MODULE (UNDER RIGHT SIDE OF I/P) PPL PPL 1 2 3 4 PPL/WHT WIRE RED/BLK WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) UNDERHOOD FUSE/RELAY CENTER (LEFT REAR OF ENGINE COMPT) WHT DK GRN/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE

4.3L ONLY BLK WIRE BLK/WHT WIRE BRN WIRE DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM-B MINI FUSE FUEL PUMP AND SENDER FUEL PUMP OIL PRESSURE SWITCH (TOP REAR OF ENGINE NEAR DISTRIBUTOR) FUEL PUMP PRIME CONN- ECTOR FUEL PUMP RELAY (UNDERHOOD FUSE/RELAY CENTER) GRY WIRE HEATED OXYGEN SENSOR (IN EXHAUST Y-PIPE) HOT AT ALL TIMES IDLE SPEED CONTROL ACTUATOR SOLENOID (7.4L ONLY) (SIDE OF THROTTLE BODY UNIT) INSTRUMENT CLUSTER LT GRN/BLK WIRE OIL PRESS IN ORG/ WIRE PNK WIRE PPL PPL/WHT WIRE RED WIRE TACH IN TAN WIRE UNDERHOOD FUSE/RELAY CENTER (LEFT REAR OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT END OF I/P) VSS IN WHT WIRE WHT/BLK WIRE