Chevrolet Pickup C2500 (1988-2000) hot in run, bulb test or start Wiring diagrams

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID A/T ISS HI IN A/T ISS LO IN AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE FUSE 18 BRAKE SWITCH ASSEMBLY (ON BRAKE PEDAL BRACKET) BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE DATA CLASS II DK BLU WIRE ECM 1 FUSE ECM-B FUSE ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE ENG 1 FUSE FRONT WHEEL LOCK FUEL INJECTORS, IGNITION CONTROL MOUDULE, IGNITION COIL FUEL PUMP, OIL PRESS SWITCH/ SENDER, FUEL PUMP RELAY GAUGES FUSE 4 GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH PNK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LEFT REAR SIDE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAF SENSOR, HEATED OXYGEN SENSORS MALFUNCTION INDICATOR LAMP MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL/WHT WIRE PRESS CTRL HI SOLENOID LO RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN TAN WIRE TCC PWM SOL TCC PWM SOLENOID THROTTLE POSITION SENSOR (MOUNTED TO SIDE OF THROTTLE BODY) TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 20 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS RANGE SWITCHES TRANS TEMP SIG IN TRANSFER CASE, AXLE SWITCHES UNDERHOOD FUSE/RELAY CENTER VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR VEHICLE SPEED SENSOR ADAPTOR VSS HI VSS LO YEL WIRE YEL/BLK WIRE

39 (OR 1020) 7.4L VIN J ONLY 900 419 507 389 12 5 15 4 FUEL RET MIL IND UPSHIFT IND SPEEDO ACCY ANTI- LOCK BRAKES IND ANTI-LOCK BRAKES SYSTEM ANTI-THEFT SYSTEM BAT IND HI BEAM IND BLK WIRE BLK/WHT WIRE BRAKE IND BRAKE PRESSURE WARNING SWITCH (ON UNDERSIDE OF ELECTRONIC BRAKE CONTROL MODULE) BRN WIRE BRN/WHT WIRE CHECK GAUGES IND CHECK GAUGES LAMP DRIVER CONVENIENCE CENTER DAYTIME RUNNING LAMPS IND AIR BAG IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF ENGINE COMPT) ENGINE CONTROLS SYSTEM (FUEL PUMP BALANCE RELAY) FUEL GAUGE FUEL PUMP BALANCE MODULE (INSIDE LEFT SIDE OF FRAME RAIL) FUEL PUMP, SENDER (IN FUEL TANK) GRN WIRE GRY WIRE HEADLIGHTS SYSTEM HOT IN RUN OR START I/P FUSE BLOCK GAUGES FUSE 4 HOT IN RUN, BULB TEST OR START IGN IGN E MINI FUSE IGN SW BRAKE IND BRAKE PSI PK BRAKE 33 33 IGNITION COIL (TOP LEFT REAR OF ENGINE) IGNITION SWITCH ILLUMINATION INSTRUMENT CLUSTER LED DIMMING LEFT TURN IND LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE M/T A/T PNK WIRE MALFUNC- TION INDICATOR LAMP NCA WIRE PARITY PRNDL PARK BRAKE SWITCH (ON PARK BRAKE PEDAL BRACKET) PNK WIRE PPL PPL 9 29 30 FUEL VSS VSS PPL/WHT WIRE PRNDL PRNDL A PRNDL B PRNDL C RIGHT TURN IND RUN WIRE SAFETY BELT IND SECONDARY FUEL GAUGE SENDER (IN REAR FUEL TANK) SECURITY IND SENS RTRN FUEL IN SERVICE ENGINE SOON SINGLE FUEL TANK DUAL FUEL TANKS SPEEDOMETER STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TACH TAN WIRE TAN/WHT WIRE TEMP GAUGE OIL GAUGE TRANS FUSE 20 TRANSMISSION RANGE SWITCH TWISTED PAIR UNDERHOOD FUSE BLOCK UPSHIFT IND (M/T ONLY) VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION, LEFT SIDE OF TRAN- VEHICLE SPEED SENSOR (VSS) ADAPTER VOLTMETER WARNING SYSTEMS WHT WIRE YEL WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID A/T ISS HI IN A/T ISS LO IN AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE FUSE 18 BRAKE SWITCH ASSEMBLY (ON BRAKE PEDAL BRACKET) BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE DATA CLASS II DK BLU WIRE ECM 1 FUSE ECM-B FUSE ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE ENG 1 FUSE FRONT WHEEL LOCK FUEL INJECTORS, IGNITION CONTROL MOUDULE, IGNITION COIL FUEL PUMP, OIL PRESS SWITCH/ SENDER, FUEL PUMP RELAY GAUGES FUSE 4 GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH PNK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LEFT REAR SIDE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAF SENSOR, HEATED OXYGEN SENSORS MALFUNCTION INDICATOR LAMP MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL/WHT WIRE PRESS CTRL HI SOLENOID LO RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN TAN WIRE TCC PWM SOL TCC PWM SOLENOID THROTTLE POSITION SENSOR (MOUNTED TO SIDE OF THROTTLE BODY) TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 20 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS RANGE SWITCHES TRANS TEMP SIG IN TRANSFER CASE, AXLE SWITCHES UNDERHOOD FUSE/RELAY CENTER VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR VEHICLE SPEED SENSOR ADAPTOR VSS HI VSS LO YEL WIRE YEL/BLK WIRE

BLK WIRE CARGO LAMP CTRL CTSY FUSE 3 DOME DEFEAT DOME DEFEAT IGN SW DOOR JAMB FRONT DOME AND READING LAMP GRY WIRE HEADLAMP AND PANEL DIMMER SWITCH DOME LAMP DEFEAT COURTESY LAMPS HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START I/P COMPARTMENT BOX LAMP I/P FUSE BLOCK I/P FUSE BLOCK GAGES FUSE 4 IGN SW INTERIOR LAMP CONTROL MODULE (UNDER CENTER OF DASH) LAMP OUT LEFT I/P COURTESY LAMP LEFT ILLUMINATED VANITY MIRROR MIRRORS SYSTEM NCA WIRE ORG/ WIRE PNK WIRE PPL (NOT USED) PPL PPL REMOTE CONTROL DOOR LOCK RECEIVER (BEHIND CENTER OF DASH) RIGHT FRONT DOOR JAMB SWITCH LEFT FRONT DOOR JAMB SWITCH RIGHT I/P COURTESY LAMP RIGHT ILLUMINATED VANITY MIRROR UNDERHOOD FUSE-RELAY CENTER HORN FUSE UNDERHOOD LAMP UNDERHOOD REEL LAMP W/ RKE W/O RKE WHT WIRE

1134 1134 39 10 10 PARK BRAKE SIG IND BULB CHK IGNITION LAMP FEED PNK WIRE 33 33 BRAKE IND CTRL BRAKE WARN IN 592 592 150 DRL RELAY CTRL BLK WIRE BLK/WHT WIRE BRN WIRE BULB TEST CONVENIENCE CENTER (UNDER LEFT SIDE OF DASH) DAYTIME RUNNING LAMP MODULE (BEHIND LEFT SIDE OF DASH) DAYTIME RUNNING LAMPS RELAY DIODE 203 DRL INDICATOR DRL-FOG FUSE 15 FOG LAMP RELAY FOG LAMP SWITCH GAUGES FUSE 4 GRN WIRE GROUND GRY WIRE HEAD OFF PARK HEAD- LAMP DIMMER SWITCH HEADLAMP, PANEL DIMMER SWITCH HIGH BEAM INDICATOR HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (LEFT SIDE OF DASH, IGNITION SWITCH ILLUM LAMP INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM (BRAKE WARNING INDICATOR) LEFT FOG LAMP LEFT HEAD- LAMP RIGHT HEAD- LAMP LIGHTING FUSE 8 LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OFF ON INDICATOR ORG/ WIRE PARK BRAKE WARNING SWITCH PK LPS FUSE 9 PNK WIRE PPL RED WIRE RIGHT FOG LAMP RUN WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT REAR OF ENGINE COMPT) W/ FOG LAMPS WHT WIRE YEL WIRE

BATT B BELT SWITCH BREAKOUT) BLK WIRE BLK/WHT WIRE CIG LTR FUSE 13 CONVENIENCE CENTER (LEFT SIDE OF DASH) DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DOOR LOCK RELAY (UNDER CENTER OF DASH, NEAR REMOTE CONTROL DOOR LOCK RECEIVER) DRIVER DR UNLK UNLOCK OUT HORN SIGNAL GAUGES FUSE 4 GROUND GRY WIRE HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (LEFT SIDE OF DASH, INTERIOR LAMPS SYSTEM LEFT DOOR LOCK SWITCH LEFT FRONT DOOR LOCK ACTUATOR LOCK LOCK OUT DOME LAMPS LT BLU WIRE ORG/ WIRE PASS DRS UNLK PNK IGNITION DOME LMP OFF PROGRAM SIG WIRE PNK WIRE PWR ACCY C.B. REMOTE CONTROL DOOR LOCK RECEIVER (UNDER CENTER OF DASH PANEL) RIGHT DOOR LOCK SWITCH RIGHT FRONT DOOR LOCK ACTUATOR SEAT BELT SWITCH BREAKOUT) TAN WIRE UNLOCK W/O POWER WINDOWS W/ POWER WINDOWS WHT WIRE

AUDIO ALARM MODULE (ON CONVENIENCE CENTER) BLK WIRE BLK/WHT WIRE DIESEL GAS GAUGES FUSE 4 GRY WIRE HOT AT ALL TIMES HOT IN PARK OR HEADLIGHT HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) ILLUM FUSE 14 INSTRU- MENT CLUSTER SAFETY BELTS INDICATOR KEY-IN WARNING BUZZER SWITCH LEFT FRONT DOOR JAMB SWITCH LIGHTS ON INPUT POWER INPUT KEY-IN WARNING LT GRN WIRE ORG/ WIRE PNK IGNITION ON INPUT WIRE PNK WIRE SEAT BELT INPUT GROUND FASTEN BELTS OUT SEAT BELT SWITCH (ON DRIVER'S SEAT BELT BUCKLE) STOP/HAZ FUSE 1 SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE YEL WIRE