Chevrolet Pickup C2500 (1988-2000) gauges fuse 4 Wiring diagrams

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID 3-2 CTRL SOLENOID 3-2 DOWNSHIFT SOL AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE FUSE 18 BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE DASH FUSE BLOCK DATA CLASS II DK BLU WIRE ECM 1 FUSE ECM-B FUSE ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE ENG 1 FUSE ENGINE COOLANT TEMP SENSOR (TOP RIGHT FRONT OF ENGINE) FRONT WHEEL LOCK FUEL PUMP, OIL PRESS SWITCH/ SENDER, FUEL PUMP RELAY GAUGES FUSE 4 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN OFF, RUN OR START HOT IN RUN HOT IN RUN OR START IGNITION IN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK PNK WIRE PNK WIRE PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL/WHT WIRE PRESS CTRL HI SOLENOID LO RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC PWM SOL TCC PWM SOLENOID TCC SOL TCC SOLENOID THROTTLE POSITION SENSOR (MOUNTED TO SIDE OF THROTTLE BODY) TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 20 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS RANGE SWITCHES TRANS TEMP SIG IN TRANSFER CASE CIRCUIT PNK WIRE TRANSFER CASE, AXLE SWITCHES UNDERHOOD FUSE/RELAY CENTER VEHICLE CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR VEHICLE SPEED SENSOR ADAPTOR VSS HI VSS LO WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID 3-2 CTRL SOLENOID 3-2 DOWNSHIFT SOL AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BLU WIRE BRAKE FUSE 18 BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE DASH FUSE BLOCK DATA CLASS II DK BLU WIRE ECM 1 FUSE ECM-B FUSE ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE ENG 1 FUSE ENGINE COOLANT TEMP SENSOR (TOP RIGHT FRONT OF ENGINE) FRONT WHEEL LOCK FUEL PUMP, OIL PRESS SWITCH/ SENDER, FUEL PUMP RELAY GAUGES FUSE 4 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN OFF, RUN OR START HOT IN RUN HOT IN RUN OR START IGNITION IN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK PNK WIRE PNK WIRE PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL/WHT WIRE PRESS CTRL HI SOLENOID LO RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN STOPLAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC PWM SOL TCC PWM SOLENOID TCC SOL TCC SOLENOID THROTTLE POSITION SENSOR (MOUNTED TO SIDE OF THROTTLE BODY) TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 20 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS RANGE SWITCHES TRANS TEMP SIG IN TRANSFER CASE CIRCUIT PNK WIRE TRANSFER CASE, AXLE SWITCHES UNDERHOOD FUSE/RELAY CENTER VEHICLE CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR VEHICLE SPEED SENSOR ADAPTOR VSS HI VSS LO WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID A/T ISS HI IN A/T ISS LO IN AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE FUSE 18 BRAKE SWITCH ASSEMBLY (ON BRAKE PEDAL BRACKET) BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE DATA CLASS II DK BLU WIRE ECM 1 FUSE ECM-B FUSE ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE ENG 1 FUSE FRONT WHEEL LOCK FUEL INJECTORS, IGNITION CONTROL MOUDULE, IGNITION COIL FUEL PUMP, OIL PRESS SWITCH/ SENDER, FUEL PUMP RELAY GAUGES FUSE 4 GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH PNK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LEFT REAR SIDE LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MAF SENSOR, HEATED OXYGEN SENSORS MALFUNCTION INDICATOR LAMP MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL/WHT WIRE PRESS CTRL HI SOLENOID LO RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN TAN WIRE TCC PWM SOL TCC PWM SOLENOID THROTTLE POSITION SENSOR (MOUNTED TO SIDE OF THROTTLE BODY) TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 20 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS RANGE SWITCHES TRANS TEMP SIG IN TRANSFER CASE, AXLE SWITCHES UNDERHOOD FUSE/RELAY CENTER VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR VEHICLE SPEED SENSOR ADAPTOR VSS HI VSS LO YEL WIRE YEL/BLK WIRE

ABS FUSE ABS IND. BATTERY PUMP MOTOR GROUND BLK WIRE BLK/WHT WIRE BRAKE FUSE 18 BRAKE IND BRAKE PRESSURE WARNING SWITCH (UNDERSIDE OF EBCM) BRAKE SW OUTPUT BRN WIRE DAYTIME RUNNING LAMP (DRL) MODULE (BEHIND LEFT SIDE OF DASH) DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) ENGINE CONTROLS SYSTEM FRONT AXLE ACTUATOR (ON RIGHT REAR OF FRONT DRIVE AXLE) FUSE/RELAY BLOCK (LEFT REAR OF ENGINE COMPT) GAUGES FUSE 4 HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) IGNITION ABS IND GROUND BRAKE SW INPUT INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE M/T NEAR BREAKOUT TO TRANSFER CASE RELAY) PNK WIRE PPL PPL DATA LINK CONNECTOR (DLC) (LEFT OF STEERING COLUMN) PPL PPL 1807 680 PPL SERIAL DATA PPL/WHT WIRE RED WIRE RIGHT FRONT WHEEL SPEED SENSOR SENSOR LOW SENSOR LOW SENSOR HIGH SENSOR HIGH 830 872 STOPLAMP SWITCH (TOP OF BRAKE PEDAL) TAN WIRE TAN/WHT WIRE TRANSFER CASE CONTROL MODULE (ON STEERING COLUMN SUPPORT BRACKET) TRANSMISSIONS SYSTEM VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (LEFT SIDE OF TRANSMISSION/ TRANSFER CASE) VEHICLE SPEED SIG VSS VSS SIG BRAKE LAMP IND OUT SERIAL DATA LINE BRAKE IND INPUT EBCM GROUND YEL WIRE YEL/BLK WIRE

39 1807 PNK PPL WIRE BLK WIRE BLK/WHT WIRE BRN WIRE DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH, LEFT OF STEERING COLUMN) PPL DIESEL DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC VARIABLE ORIFICE (EVO)/ PASSLOCK MODULE (UNDER CENTER OF DASH) EVO SOLENOID OUT EVO FEED SWS POSIT SIG VSS SIGNAL INPUT GAS GAUGES FUSE 4 GROUND IGNITION DATA SENSOR RETURN 5 VOLT REF BATTERY GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE BLOCK (UNDER LEFT SIDE OF DASH) LT BLU WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE SECURITY/STRG FUSE 21 SENSOR RETURN STEERING ASSIST CONTROL SOLENOID (PART OF POWER STEERING PUMP) STEERING HANDWHEEL SPEED SENSOR (ON STEERING COLUMN, NEAR FIREWALL) STEERING VOLT WHEEL POSIT REF SIGNAL VEHICLE CONTROL MODULE (ON LEFT SIDE OF ENGINE COMPARTMENT) VEHICLE SPEED SENSOR BUFFER (BEHIND RIGHT SIDE OF DASH) VSS SIG OUT WHT WIRE

1134 1134 39 10 10 PARK BRAKE SIG IND BULB CHK IGNITION LAMP FEED PNK WIRE 33 33 BRAKE IND CTRL BRAKE WARN IN 592 592 150 DRL RELAY CTRL BLK WIRE BLK/WHT WIRE BRN WIRE BULB TEST CONVENIENCE CENTER (UNDER LEFT SIDE OF DASH) DAYTIME RUNNING LAMP MODULE (BEHIND LEFT SIDE OF DASH) DAYTIME RUNNING LAMPS RELAY DIODE 203 DRL INDICATOR DRL-FOG FUSE 15 FOG LAMP RELAY FOG LAMP SWITCH GAUGES FUSE 4 GRN WIRE GROUND GRY WIRE HEAD OFF PARK HEAD- LAMP DIMMER SWITCH HEADLAMP, PANEL DIMMER SWITCH HIGH BEAM INDICATOR HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (LEFT SIDE OF DASH, IGNITION SWITCH ILLUM LAMP INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM (BRAKE WARNING INDICATOR) LEFT FOG LAMP LEFT HEAD- LAMP RIGHT HEAD- LAMP LIGHTING FUSE 8 LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OFF ON INDICATOR ORG/ WIRE PARK BRAKE WARNING SWITCH PK LPS FUSE 9 PNK WIRE PPL RED WIRE RIGHT FOG LAMP RUN WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (LEFT REAR OF ENGINE COMPT) W/ FOG LAMPS WHT WIRE YEL WIRE

260 (CROSS BODY HARNESS, 4 DOOR 4-DOOR 2-DOOR 640 (OR 540) 1576 (OR 56) 294 39 157 1455 150 195 156 BLK (OR BLK/WHT) WIRE BLK WIRE BLK/WHT WIRE CARGO DOOR JAMB SWITCH CARGO DOOR LOCK SWITCH (W/ CARGO DOORS) CIG LTR FUSE 13 CONVENIENCE CENTER (LEFT SIDE OF DASH) DATA LINK INTERIOR CONNECTOR LAMPS (UNDER LEFT SYSTEM SIDE OF DASH) DOOR LOCK CONTROL MODULE (FRONT OF LEFT REAR WHEELWELL) DOOR LOCK RELAY (UNDER CENTER OF DASH, NEAR REMOTE CONTROL DOOR LOCK RECEIVER) GAUGES FUSE 4 GROUND DOOR JAMB SW LOCK SIG UNLOCK SIG PPL GRY WIRE HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (LEFT SIDE OF DASH, LEFT FRONT DOOR JAMB SWITCH LEFT FRONT DOOR LOCK ACTUATOR LEFT FRONT DOOR LOCK SWITCH LEFT REAR DOOR JAMB SWITCH LEFT REAR DOOR LOCK ACTUATOR LOCK LT BLU WIRE LUXURY ORG/ WIRE ORG/BLK WIRE PNK WIRE PPL PWR-ACCY CIRCUIT BREAKER REAR CARGO DOOR LOCK ACTUATOR (CARGO DOORS) REMOTE CONTROL DOOR LOCK RECEIVER (BEHIND CENTER OF DASH) RIGHT FRONT DOOR JAMB SWITCH RIGHT FRONT DOOR LOCK ACTUATOR RIGHT FRONT DOOR LOCK SWITCH RIGHT REAR CARGO DOOR CONTACTOR (RIGHT REAR DOOR JAMB) RIGHT REAR DOOR JAMB SWITCH RIGHT REAR DOOR LOCK ACTUATOR RR DOOR SW BATT (B+) SEAT BELT SWITCH BREAKOUT) SUBURBAN/ UTILITY TAN WIRE TRUNK, TAIL- GATE, FUEL DOORS SYSTEM UNLOCK UTILITY W/ REAR CARGO DOORS UTILITY W/ REAR LIFTGATE W/ CARGO DOORS W/ LIFTGATE W/ CARGO DOORS W/O POWER WINDOWS W/ POWER WINDOWS WHT WIRE

BATT B BELT SWITCH BREAKOUT) BLK WIRE BLK/WHT WIRE CIG LTR FUSE 13 CONVENIENCE CENTER (LEFT SIDE OF DASH) DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) DOOR LOCK RELAY (UNDER CENTER OF DASH, NEAR REMOTE CONTROL DOOR LOCK RECEIVER) DRIVER DR UNLK UNLOCK OUT HORN SIGNAL GAUGES FUSE 4 GROUND GRY WIRE HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START I/P FUSE BLOCK (LEFT SIDE OF DASH, INTERIOR LAMPS SYSTEM LEFT DOOR LOCK SWITCH LEFT FRONT DOOR LOCK ACTUATOR LOCK LOCK OUT DOME LAMPS LT BLU WIRE ORG/ WIRE PASS DRS UNLK PNK IGNITION DOME LMP OFF PROGRAM SIG WIRE PNK WIRE PWR ACCY C.B. REMOTE CONTROL DOOR LOCK RECEIVER (UNDER CENTER OF DASH PANEL) RIGHT DOOR LOCK SWITCH RIGHT FRONT DOOR LOCK ACTUATOR SEAT BELT SWITCH BREAKOUT) TAN WIRE UNLOCK W/O POWER WINDOWS W/ POWER WINDOWS WHT WIRE

4.3L PNK WIRE 7.4L 6.5L 7.4L W/ CALIFORNIA EMISSIONS OTHERS A/C CLUTCH RELAY A/T M/T AIR BAG FUSE 10 AIR INJECTION REACTION SECONDARY RELAY BACKUP LAMP SWITCH BLK WIRE CAMSHAFT EXHAUST POSITION GAS SENSOR RECIRCULATION VALVE CONVENIENCE CENTER DAYTIME AUDIO RUNNING ALARM MODULE LAMPS RELAY DIESEL ONLY PNK WIRE EGR SOLENOID ELECTROCHROMATIC MIRROR W/ COMPASS ELECTRONIC INJECTION PUMP ENG-1 MINI FUSE EVAPORATIVE EMISSION CANISTER VENT EVAPORATIVE FUEL EMISSIONS PUMP CANISTER PURGE BALANCE SOLENOID VALVE RELAY FROM IGNITION SWITCH (DIAGRAM 2 OF 4) FUEL EGR GLOW WATER-IN- HEATER VENT PLUG FUEL SOLENOID CONTROL SENSOR MODULE FUEL FUEL FUEL INJECTOR INJECTOR INJECTOR FUEL FUEL INJECTOR INJECTOR FUEL INJECTOR FUEL PUMP BALANCE MODULE FUEL SOL MINI FUSE ECM 1 MINI FUSE FUEL TANK DAYTIME SENDER RUNNING I/P MODULE LAMPS CLUSTER MODULE (4.3L) GASOLINE DIESEL 5.0L, 5.7L 4.3L GAUGES FUSE 4 HEATED HEATED MASS OXYGEN OXYGEN AIRFLOW SENSOR 1 SENSOR 2 SENSOR HEATED HEATED OXYGEN OXYGEN SENSOR 4 SENSOR 3 I/P FUSE BLOCK IGN E MINI FUSE IGNITION CRANK- CONTROL SHAFT MODULE POSITION SENSOR IGNITION CRANK- FUEL CONTROL SHAFT INJECTOR MODULE POSITION SENSOR INFLATABLE RESTRAINT I/P MODULE ENABLE SWITCH INFLATABLE RESTRAINT SENSING AND DIAGNOSTIC MODULE M/T MASS AIR FLOW SENSOR NCA WIRE PNK WIRE POWER STEERING CONTROL MODULE POWERTRAIN CONTROL MODULE TRANSFER CASE CONTROL MODULE TURN B/U FUSE 16 TURN SIGNAL SWITCH UNDERHOOD FUSE-RELAY CENTER VEHICLE CONTROL MODULE VEHICLE IGNITION CONTROL COIL MODULE WASTEGATE SOLENOID YEL WIRE

16 PPL AUTOMATIC TRANSMISSION INPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) AUX TANK FUEL LVL SIG AUXILIARY FUEL TANK LEVEL SENSOR (IN FUEL TANK) BALANCE FUEL PUMP (ON INSIDE LEFT FRAME RAIL NEAR FRONT OF REAR TANK) BLK WIRE BLK/WHT WIRE BLU WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CONVENIENCE CENTER (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FUEL GAUGE INPUT FUEL PUMP BALANCE MODULE (INSIDE LEFT SIDE OF FRAME RAIL) FUEL PUMP BALANCE RELAY (ON FUEL PUMP BALANCE MODULE) FUEL PUMP MODULE (W/ DUAL FUEL TANKS) FUEL PUMP, SENDER (W/O DUAL FUEL TANKS) (IN FUEL TANK) FUEL TANK PRESSURE SENSOR (IN FUEL TANK) (CALIFORNIA) GAUGES FUSE 4 GRN WIRE GROUND GRY WIRE HOT IN OFF, RUN OR START HOT IN RUN OR START HOT IN RUN OR START UNDERHOOD FUSE/RELAY CENTER I/P FUSE BLOCK IGN E FUSE INPUT INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE SENSOR (IN AIR INTAKE DUCT) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP RIGHT FRONT OF ENGINE) MASS AIR FLOW SENSOR (IN AIR INTAKE DUCT) OUTPUT TO GAUGE PNK IGNITION WIRE PNK PNK PNK WIRE PNK WIRE PPL PPL/WHT WIRE PRIMARY TANK FUEL LVL SIG RED WIRE RED/BLK WIRE RELAY CTRL SERVICE ENGINE SOON INDICATOR SPEEDOMETER TACHOMETER TAN WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY ASSEMBLY) TRANS FUSE 20 W/ DUAL FUEL TANKS W/O DUAL FUEL TANK W/O DUAL FUEL TANK W/ DUAL FUEL TANKS W/O DUAL FUEL TANKS W/ DUAL FUEL TANK WHT (OR WIRE WHT WIRE YEL WIRE YEL/BLK WIRE