Chevrolet Malibu VIII facelift (2013-2016) transmissions system Wiring diagrams

1 VOLT 103 7543 HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM 278 5526 HEADLIGHTS SYSTEM TRANSMISSIONS SYSTEM 307 3287 HEADLIGHTS SYSTEM HORNS SYSTEM 5361 6817 EXTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM 664 94 EXTERIOR LIGHTS SYSTEM WIPER/WASHER SYSTEM ACC VOLT ACC VOLTAGE AMBIENT LIGHT SENSOR SIGNAL AMBIENT LIGHT SENSOR SIGNAL TAP UP/DOWN SW SIG ANTI-LOCK BRAKES SYSTEM ANTI-THEFT SYSTEM BATT POSITIVE VOLT BATTERY POSITIVE VOLTAGE BLK WIRE BLK/GRY WIRE BLU WIRE BLU/VIO WIRE BLU/WHT WIRE BODY CONTROL MODULE (BEHIND LEFT END OF DASH) BODY CONTROL MODULE (BEHIND LEFT SIDE OF DASH) BRAKE APPLY SENS LOW REF BRAKE APPLY SENS SPLY VOLT BRAKE APPLY SENSOR SIGNAL BRAKE APPLY SENSOR SIGNAL LED BACKLIGHT DIMMING CTRL BRN WIRE COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL, SOUND SYSTEMS CRUISE SET/COAST/ RESUME/ACC SW SIG DOOR LOCKS, ANTI-THEFT SYSTEM DOOR LOCKS, ANTI-THEFT SYSTEMS DRV DR LOCK SW LCK SIG DRV DR LOCK SW UNLCK SIG EXTERIOR LIGHTS, CRUISE CONTROL SYSTEMS FUSE 10 FUSE 23 FUSE 24 FUSE 24 FUSE 9 FUSE 23 FUSE 3 FUSE 8 FUSE 8 FUSE 3 FUSE 10 FUSE 9 GMLAN SER DATA GMLAN SER DATA (+) REMOTE FUNC ACT RECEIVE SIG GRN WIRE GRN/GRY WIRE GRN/VIO WIRE GRN/WHT WIRE GROUND GRY WIRE GRY/BLK WIRE GRY/GRN WIRE GRY/WHT WIRE HAZ LED DIMMING SIG HAZ SW RIGHT TURN SIG HAZ SW RIGHT TURN SIG WINDSHIELD WASHER SW SIG HAZARD SW LEFT TURN SIG HAZARD SWITCH SIGNAL HDLP DIMMER SW HI BEAM SIG HDLP SW FLASH TO PASS SIG HDLP SW FLASH TO PASS SIG HORN SWITCH SIGNAL HDLP SW HDLPS OFF SIG CTRL HEADLAMP SW PARK LAMP SIG HEADLAMP SWITCH ON SIGNAL HEADLAMP SWITCH ON SIGNAL HAZ LED DIMMING SIG HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM 4 3 HEADLIGHTS SYSTEM ANTI-LOCK BRAKES SYSTEM HEADLIGHTS SYSTEM HI SPD GMLAN SER DATA (+) REMOTE FUNCTION ACT SPLY HI SPD GMLAN SER DATA - HORN SWITCH SIGNAL HORNS SYSTEM HOT AT ALL TIMES IGN KEY RESISTOR SIG IGN MODE SW ACC LED SIG IGN MODE SW ACC LED SIG LIGHTNING CTRL SW SIG IGN MODE SW MODE SIG IGN MODE SW START LED SIG IGNITION SWITCH IGNITION VOLTAGE IMMOBILIZER RETURN IMMOBILIZER SUPPLY VOLTAGE INDICATOR DIMMING CTRL INSTRUMENT PANEL FUSE BLOCK INTERIOR LAMP DEFEAT SW SIG KEYLESS ENTRY CONTROL MODULE KEYLESS ENTRY CONTROL MODULE (BEHIND RIGHT SIDE LED BACKLIGHT DIMMING CTRL LIGHTING CTRL SW REF LIGHTNING CTRL SW SIG LIN NETWORK BUS 11 LOW SPEED GMLAN SERIAL DATA NAVIGATION SYSTEM NETWORK BUS 4 OF DASH) OFF OFF OFF OFF/RUN/CRANK VOLTAGE PARK BRK SW SIG PARK BRK SW SIG HDLP SW HDLPS OFF SIG CTRL POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM 5720 7555 1134 306 RED/BLU WIRE RED/BRN WIRE RED/GRY WIRE RED/VIO WIRE RED/WHT WIRE REMOTE FUNC ACT RECEIVE SIG REMOTE FUNC ACT TRANSMIT SIG REMOTE FUNCTION ACT RTN RUN WIRE RUN/CRANK RUN/CRANK 1 VOLT SECURITY INDICATOR CONTROL SHIFT INTERLOCK SYSTEM STEERING WHEEL RESISTOR LADDER SIG 1 TAP UP/DOWN SW SIG TRACTION CTRL SW SIG TRANSMISSIONS SYSTEM VIO WIRE VIO/BLK WIRE VIO/YEL WIRE W/ KEYLESS ENGINE START W/O KEYLESS ENGINE START WHT WIRE WINDSHIELD WASHER SW SIG WINDSHIELD WIPER SW HI SIG WINDSHIELD WIPER SW LO SIG WINDSHIELD WIPER SW LOW REF WIPER/WASHER SYSTEM WIPER/WASHER SYSTEM HEADLIGHTS SYSTEM YEL WIRE YEL/GRN WIRE

"CHECK ENGINE" IND CTRL 2.0L VIN X 2.5L VIN L 63 64 65 66 67 68 69 70 71 72 73 STARTER ENABLE RLY CTRL 6386 (OR 4325) 6386 (OR 4325) STARTING/ CHARGING SYSTEM 7330 7331 (OR 3200) (OR 3201) A/C COMPRESSOR CLUTCH RLY CTRL A/C REFRIGERANT PRESS SENS LO REF A/C REFRIGERANT PRESS SENS LO REF SENS 2 LOW REF A/C REFRIGERANT PRESSURE A/C REFRIGERANT PRESSURE SENS SIG A/C REFRIGERANT PRESSURE SENSOR ACCESSORY WAKEUP SERIAL DATA AIR CONDITIONING SYSTEM AIR PRESSURE SIG APP LO REF APP LOW REF APP SENS SIG (2) APP SENS SIG 1 BATT POS VOL BLK WIRE BLK/BLU WIRE BLK/BRN WIRE BLK/GRN WIRE BLK/GRY WIRE BLK/VIO WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/GRN WIRE BLU/WHT WIRE BRAKE PEDAL POSITION SENSOR BRK POS SEN SIG BRK POS SENS LOW REF BRN WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM COOLANT TEMP SENS SIG 2 COOLING FANS SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM COOLING FANS SYSTEM CRUISE/ETC/TCC BRK SIG DK BLU WIRE DK BLU/BRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE CONTROL MODULE (ECM) (TOP OF TRANSMISSION) EVAP CANISTER VENT SOL CTRL EVAPORATIVE EMISSION VENT SOLENOID VALVE EVAPORATIVE EMISSION VENT SOLENOID VALVE (RIGHT SIDE OF FUEL TANK) FUEL LEVEL SENS LO REF FUEL LEVEL SENS SIG FUEL LEVEL SENS SIG FUEL LEVEL SENS LO REF FUEL LINE PRESSURE SENS LO REF FUEL LINE PRESSURE SENS SIG FUEL PRESSURE SENSOR FUEL PRESSURE SENSOR (RIGHT SIDE OF FUEL TANK) FUEL PUMP CONTROLLER DATA OUT SIG FUEL TANK PRESSURE SENS SIG FUEL TANK PRESSURE SENSOR FUEL TANK PRESSURE SENSOR (TOP OF FUEL TANK) GRN WIRE GRN/BRN WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/RED WIRE HI SPD COOLING FAN RLY CTRL HI SPD GMLAN SERIAL DATA HI SPD GMLAN SERIAL DATA + HI SPD GMLAN SERIAL DATA - LOW REF LOW SPEED COOLING FAN RLY CTRL LT GRN/DK BLU WIRE MAIN RELAY FUSED SPLY POWERTRAIN MAIN RLY FUSED SPLY 1 POWERTRAIN RLY COIL CTRL POWERTRAIN RLY COIL CTRL POWERTRAIN MAIN RLY FUSED SPLY (1) PRE-THROTTLE AIR PRESS TEMP SIG RED BRN/ WIRE RED WIRE RED/BLU WIRE RED/BRN WIRE RLY CTRL RUN/CRANK IGN 1 VOL RUN/CRANK IGN 1 VOL BATT POS VOL APP LOW REF SENS 2 LOW REF SENSOR (RIGHT SIDE OF A/C CONDENSER) STARTER ENABLE RLY CTRL STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM TURBO CHARGER BOOST/INTAKE AIR TEMPERATURE SENSOR UNDERHOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (LEFT SIDE OF BATTERY) VIO/BLU WIRE VIO/DK BLU WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/RED WIRE VIO/YEL WIRE WHT WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/GRY WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/RED WIRE YEL/WHT WIRE

1786 179 1174 TRANSMISSIONS SYSTEM 2.0L VIN X 2.5L VIN L 485 (OR 3630) 70 71 72 73 TP SENS SIG WASTE GATE AIR CONDITIONING SYSTEM AIR TEMP LOW REF AIR TEMP SENS SIG BANK 1 SENS (1) BANK 1 SENS (2) MAP SENS SIG BANK 1 SENS 1 BANK 1 SENS 2 BLK WIRE BLK/BRN WIRE BLK/DK BLU WIRE BLK/GRN WIRE BLK/GRY WIRE BLK/VIO WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE BRN/GRN WIRE BRN/RED WIRE BRN/WHT WIRE CHARGE IND CTRL CTRL BANK (1) CURRENT SENS SIG ENGINE COMPT) ENGINE CONTROL MODULE (ECM) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF FUEL RAIL PRESS SENS SIG FUEL RAIL PRESSURE SENSOR FUEL RAIL PRESSURE SENSOR (LEFT SIDE OF ENGINE) GENERATOR FIELD GRN WIRE GRN/BLU WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR 1 HEATED OXYGEN SENSOR 2 HI SIG BANK 1 SENS (1) HI SIG BANK 1 SENS (2) KNOCK SENS KNOCK SENS SIG KNOCK SENS SIG KNOCK SENS SIG KNOCK SENS TRANSMISSION PARK/ NEUTRAL SIGNAL (1) COMMAND SIG OIL LEVEL SW SIG KNOCK SENSOR #2 KNOCK SENSOR 1 KNOCK SENSOR 1 (RIGHT SIDE OF ENGINE) KNOCK SENSOR 2 (RIGHT SIDE OF ENGINE) LOW REF MAF SENS SIG MANIFOLD ABSOLUTE PRESSURE SENSOR MANIFOLD ABSOLUTE PRESSURE SENSOR (NEAR THROTTLE BODY) MAP LOW REF MAP LOW REF REF BANK (1) MAP SENS SIG MULTI-FUNCTION INTAKE AIR SENSOR NCA WIRE PURGE SOL CTRL REF BANK (1) RLY CTRL SENS SIG SENS SIG BANK (1) SENS SIG TAC CLOSE LOW REF STARTING/CHARGING SYSTEM TAC CLOSE TAC OPEN TAC OPEN CURRENT SENS SIG THROTTLE BODY (RIGHT SIDE OF ENGINE) TOP OF TRANSMISSION) TP SENS SIG WASTE GATE TRANSMISSIONS SYSTEM VIO/BLU WIRE VIO/GRY WIRE WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRY WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

AIR TEMP SENS SIG BANK 1 SENS (1) BANK 1 SENS (2) MAP SENS SIG BANK 1 SENS 1 BANK 1 SENS 2 BLK/BLU WIRE BLK/BRN WIRE BLK/DK BLU WIRE BLK/LT GRN WIRE BLK/VIO WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/WHT WIRE BRN/RED WIRE BRN/WHT WIRE COOL CTRL COOLING FANS SYSTEM DK BLU/WHT WIRE ENGINE COMPT) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF FUEL RAIL PRESS SENS SIG FUEL RAIL PRESSURE SENSOR (LEFT SIDE OF ENGINE) GRY WIRE GRY/RED WIRE GRY/WHT WIRE KNOCK SENS REF KNOCK SENS SIG KNOCK SENSOR (REAR OF ENGINE NEAR EXHAUST MANIFOLD) LOW REF LOW REF TPS SIG LT GRN/DK BLU WIRE LT GRN/WHT WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (NEAR THROTTLE BODY) MASS AIR FLOW/ INTAKE AIR TEMPERATURE SENSOR (ON UPPER AIR CLEANER ASSEMBLY) NCA WIRE PURGE SOL CTRL MAF SENS SIG TAC CLOSE LOW REF TAC OPEN THROTTLE BODY (LEFT SIDE OF ENGINE) TRANSMISSION PARK/ NEUTRAL SIGNAL TRANSMISSIONS SYSTEM VIO/BLU WIRE VIO/DK BLU WIRE VIO/GRY WIRE WHT/BLK WIRE WHT/BRN WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/YEL WIRE YEL WIRE

"CHECK ENGINE" IND CTRL 2.0L VIN X 2.5L VIN L 63 64 65 66 67 68 69 70 71 72 73 STARTER ENABLE RLY CTRL 6386 (OR 4325) 6386 (OR 4325) STARTING/ CHARGING SYSTEM 7330 7331 (OR 3200) (OR 3201) A/C COMPRESSOR CLUTCH RLY CTRL A/C REFRIGERANT PRESS SENS LO REF A/C REFRIGERANT PRESS SENS LO REF SENS 2 LOW REF A/C REFRIGERANT PRESSURE A/C REFRIGERANT PRESSURE SENS SIG A/C REFRIGERANT PRESSURE SENSOR ACCESSORY WAKEUP SERIAL DATA AIR CONDITIONING SYSTEM AIR PRESSURE SIG APP LO REF APP LOW REF APP SENS SIG (2) APP SENS SIG 1 BATT POS VOL BLK WIRE BLK/BLU WIRE BLK/BRN WIRE BLK/GRN WIRE BLK/GRY WIRE BLK/VIO WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/GRN WIRE BLU/WHT WIRE BRAKE PEDAL POSITION SENSOR BRK POS SEN SIG BRK POS SENS LOW REF BRN WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM COOLANT TEMP SENS SIG 2 COOLING FANS SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM COOLING FANS SYSTEM CRUISE/ETC/TCC BRK SIG DK BLU WIRE DK BLU/BRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE CONTROL MODULE (ECM) (TOP OF TRANSMISSION) EVAP CANISTER VENT SOL CTRL EVAPORATIVE EMISSION VENT SOLENOID VALVE EVAPORATIVE EMISSION VENT SOLENOID VALVE (RIGHT SIDE OF FUEL TANK) FUEL LEVEL SENS LO REF FUEL LEVEL SENS SIG FUEL LEVEL SENS SIG FUEL LEVEL SENS LO REF FUEL LINE PRESSURE SENS LO REF FUEL LINE PRESSURE SENS SIG FUEL PRESSURE SENSOR FUEL PRESSURE SENSOR (RIGHT SIDE OF FUEL TANK) FUEL PUMP CONTROLLER DATA OUT SIG FUEL TANK PRESSURE SENS SIG FUEL TANK PRESSURE SENSOR FUEL TANK PRESSURE SENSOR (TOP OF FUEL TANK) GRN WIRE GRN/BRN WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/RED WIRE HI SPD COOLING FAN RLY CTRL HI SPD GMLAN SERIAL DATA HI SPD GMLAN SERIAL DATA + HI SPD GMLAN SERIAL DATA - LOW REF LOW SPEED COOLING FAN RLY CTRL LT GRN/DK BLU WIRE MAIN RELAY FUSED SPLY POWERTRAIN MAIN RLY FUSED SPLY 1 POWERTRAIN RLY COIL CTRL POWERTRAIN RLY COIL CTRL POWERTRAIN MAIN RLY FUSED SPLY (1) PRE-THROTTLE AIR PRESS TEMP SIG RED BRN/ WIRE RED WIRE RED/BLU WIRE RED/BRN WIRE RLY CTRL RUN/CRANK IGN 1 VOL RUN/CRANK IGN 1 VOL BATT POS VOL APP LOW REF SENS 2 LOW REF SENSOR (RIGHT SIDE OF A/C CONDENSER) STARTER ENABLE RLY CTRL STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM TURBO CHARGER BOOST/INTAKE AIR TEMPERATURE SENSOR UNDERHOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (LEFT SIDE OF BATTERY) VIO/BLU WIRE VIO/DK BLU WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/RED WIRE VIO/YEL WIRE WHT WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/GRY WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/RED WIRE YEL/WHT WIRE

1786 179 1174 TRANSMISSIONS SYSTEM 2.0L VIN X 2.5L VIN L 485 (OR 3630) 70 71 72 73 TP SENS SIG WASTE GATE AIR CONDITIONING SYSTEM AIR TEMP LOW REF AIR TEMP SENS SIG BANK 1 SENS (1) BANK 1 SENS (2) MAP SENS SIG BANK 1 SENS 1 BANK 1 SENS 2 BLK WIRE BLK/BRN WIRE BLK/DK BLU WIRE BLK/GRN WIRE BLK/GRY WIRE BLK/VIO WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE BRN/GRN WIRE BRN/RED WIRE BRN/WHT WIRE CHARGE IND CTRL CTRL BANK (1) CURRENT SENS SIG ENGINE COMPT) ENGINE CONTROL MODULE (ECM) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF FUEL RAIL PRESS SENS SIG FUEL RAIL PRESSURE SENSOR FUEL RAIL PRESSURE SENSOR (LEFT SIDE OF ENGINE) GENERATOR FIELD GRN WIRE GRN/BLU WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR 1 HEATED OXYGEN SENSOR 2 HI SIG BANK 1 SENS (1) HI SIG BANK 1 SENS (2) KNOCK SENS KNOCK SENS SIG KNOCK SENS SIG KNOCK SENS SIG KNOCK SENS TRANSMISSION PARK/ NEUTRAL SIGNAL (1) COMMAND SIG OIL LEVEL SW SIG KNOCK SENSOR #2 KNOCK SENSOR 1 KNOCK SENSOR 1 (RIGHT SIDE OF ENGINE) KNOCK SENSOR 2 (RIGHT SIDE OF ENGINE) LOW REF MAF SENS SIG MANIFOLD ABSOLUTE PRESSURE SENSOR MANIFOLD ABSOLUTE PRESSURE SENSOR (NEAR THROTTLE BODY) MAP LOW REF MAP LOW REF REF BANK (1) MAP SENS SIG MULTI-FUNCTION INTAKE AIR SENSOR NCA WIRE PURGE SOL CTRL REF BANK (1) RLY CTRL SENS SIG SENS SIG BANK (1) SENS SIG TAC CLOSE LOW REF STARTING/CHARGING SYSTEM TAC CLOSE TAC OPEN TAC OPEN CURRENT SENS SIG THROTTLE BODY (RIGHT SIDE OF ENGINE) TOP OF TRANSMISSION) TP SENS SIG WASTE GATE TRANSMISSIONS SYSTEM VIO/BLU WIRE VIO/GRY WIRE WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRY WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE