Chevrolet Malibu VIII facelift (2013-2016) sens sig Wiring diagrams

1 5 6 BATT POS VOLT BATT POS VOLT GROUND BLK WIRE BLK/GRY WIRE BLK/YEL WIRE BLU/BLK WIRE BRN/BLK WIRE BRN/BLU WIRE BRN/DK BLU WIRE BRN/VIO WIRE CIRCUIT BREAKER COMPUTER DATA LINES SYSTEM DK BLU/BLK WIRE DRIVER AIR CONDITIONING SWITCH DRIVER BACK SEAT HEATING ELEMENT DRIVER CUSHION SEAT HEATING ELEMENT DRIVER HEATED SEAT BACK ELEMENT CONTROL DRIVER HEATED SEAT SWITCH GRN WIRE GRN/BLU WIRE GRY/BLK WIRE HEATED SEAT CUSHION ELEMENT SUPPLY VOLTAGE HIGH HEAT IND HOT AT ALL TIMES HTD ST (EXCEPT 2.4L) HEATED SEAT FRT (2.4L) FUSE INSTRUMENT PANEL FUSE BLOCK (LEFT SIDE OF DASH) LIN BUS 10 LOGIC LOW HEAT IND LOW REF LOW SPEED GMLAN SERIAL DATA LT GRN WIRE MEDIUM HEAT IND NCA WIRE PASSENGER AIR CONDITIONING SWITCH PASSENGER BACK SEAT HEATING ELEMENT PASSENGER CUSHION SEAT HEATING ELEMENT PASSENGER HEATED SEAT BACK ELEMENT CONTROL PASSENGER HEATED SEAT ELEMENT SUPPLY VOLTAGE PASSENGER HEATED SEAT SWITCH RADIO CONTROLS RED WIRE RED/GRN WIRE RED/YEL WIRE SEAT MEMORY CONTROL MODULE (BELOW FRONT CENTER OF THE DRIVER SEAT) SEN SIG SENS SIG UNDERHOOD FUSE BLOCK (LEFT SIDE OF BATTERY) VIO/BLK WIRE WHT/GRY WIRE YEL WIRE YEL/GRY WIRE

185 893 419 WIPER/WASHER SYSTEM ABS IND. AIR BAG IND AMBIENT AIR TEMPERATURE SENSOR AMBIENT AIR TEMPERATURE SENSOR (LEFT SIDE OF LOWER GRILLE) BATTERY POS VOLT BLK WIRE BLK/BLU WIRE BLU WIRE BLU/GRY WIRE BLU/VIO WIRE BODY CONTROL MODULE (BEHIND LEFT END OF DASH) BODY CONTROL MODULE (BEHIND LEFT SIDE OF DASH) BRAKE WARNING IND LAMP BRN WIRE BRN/WHT WIRE BUS 2 CHARGE IND COIL COMPUTER DATA LINES SYSTEM CONTROL CRUISE IND DIM CTRL LED CTRL DIM CTRL LED CTRL WASHER FLUID IND CTRL DRV CENTER MENU SW SIG DPF IND DRIVER INFORMATION CENTER DISPLAY ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE IND CTRL FRONT FOG LAMP IND FUEL GAUGE FUEL IND FUSE 21 GRN WIRE GRN/BLU WIRE GROUND GROUND DISTRIBUTION SYSTEM GROUND DISTRIBUTION SYSTEM 3535 3885 NAVIGATION SYSTEM GRY WIRE GRY/VIO WIRE GRY/YEL WIRE HI SPD GMLAN SERIAL DATA + HI SPD GMLAN SERIAL DATA - HI SPD GMLAN SERIAL DATA + HI SPD GMLAN SERIAL DATA - 24 23 HIGH BEAM IND HOT AT ALL TIMES HOT W/ IGNITION MAIN RELAY ENERGIZED IGN 1 VOLT IGN 1 VOLT BATTERY POS ILLUMINATION IND INSTRUMENT CLUSTER INSTRUMENT PANEL FUSE BLOCK INSTRUMENT PANEL FUSE BLOCK (LEFT SIDE OF DASH) LANE DEPARTURE WARNING (LDW) LIGHT LEFT TURN IND LIFT GATE AJAR SW SIG LIGHTS ON IND LO SPD GMLAN SER DATA DRV INFORMATION SW SIG DRV LO REF LO SPD GMLAN SER DATA DRV INFORMATION SW SIG DRV LO REF SENS LO REF SENS SIG LOGIC LOW TIRE PRESSURE IND MALFUNCTION IND LAMP (MIL) MENU MIL IGN FUSE NAVIGATION SYSTEM NETWORK OIL LEVEL IND LAMP PARK BRAKE IND PARK BRAKE SERVICE IND PARK BRAKE SWITCH PARK BRAKE SWITCH (MOUNTED TO SHIFT LEVER BEZEL) PARK BRK SW SIG PARK IND PARK LIGHT INDICATOR POWER DISTRIBUTION SYSTEM RAP RELAY RAP RELAY COIL CTRL RED/GRY WIRE RIGHT TURN IND SEAT BELT IND LAMP SECURITY IND SENS LO REF SENS SIG SET- SPEEDOMETER TACHOMETER TRACTION CONTROL IND TRACTION OFF IND TRANSMISSION SHIFT LEVER POSITION INDICATOR TURN SIGNAL/ MULTI-FUNCTION SWITCH UNDERHOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (LEFT SIDE OF BATTERY) VDC IND VIO WIRE VIO/GRY WIRE VOLT W/ FRONT GRILL ACTIVE SHUTTERS WAIT TO START IND WAIT-TO START IND LOGIC WASHER FLUID IND CTRL DRV CENTER MENU SW SIG WATER IN FUEL IND WHT WIRE WHT/GRN WIRE WIPER/WASHER SYSTEM

1786 179 1174 TRANSMISSIONS SYSTEM 2.0L VIN X 2.5L VIN L 485 (OR 3630) 70 71 72 73 TP SENS SIG WASTE GATE AIR CONDITIONING SYSTEM AIR TEMP LOW REF AIR TEMP SENS SIG BANK 1 SENS (1) BANK 1 SENS (2) MAP SENS SIG BANK 1 SENS 1 BANK 1 SENS 2 BLK WIRE BLK/BRN WIRE BLK/DK BLU WIRE BLK/GRN WIRE BLK/GRY WIRE BLK/VIO WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE BRN/GRN WIRE BRN/RED WIRE BRN/WHT WIRE CHARGE IND CTRL CTRL BANK (1) CURRENT SENS SIG ENGINE COMPT) ENGINE CONTROL MODULE (ECM) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF FUEL RAIL PRESS SENS SIG FUEL RAIL PRESSURE SENSOR FUEL RAIL PRESSURE SENSOR (LEFT SIDE OF ENGINE) GENERATOR FIELD GRN WIRE GRN/BLU WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR 1 HEATED OXYGEN SENSOR 2 HI SIG BANK 1 SENS (1) HI SIG BANK 1 SENS (2) KNOCK SENS KNOCK SENS SIG KNOCK SENS SIG KNOCK SENS SIG KNOCK SENS TRANSMISSION PARK/ NEUTRAL SIGNAL (1) COMMAND SIG OIL LEVEL SW SIG KNOCK SENSOR #2 KNOCK SENSOR 1 KNOCK SENSOR 1 (RIGHT SIDE OF ENGINE) KNOCK SENSOR 2 (RIGHT SIDE OF ENGINE) LOW REF MAF SENS SIG MANIFOLD ABSOLUTE PRESSURE SENSOR MANIFOLD ABSOLUTE PRESSURE SENSOR (NEAR THROTTLE BODY) MAP LOW REF MAP LOW REF REF BANK (1) MAP SENS SIG MULTI-FUNCTION INTAKE AIR SENSOR NCA WIRE PURGE SOL CTRL REF BANK (1) RLY CTRL SENS SIG SENS SIG BANK (1) SENS SIG TAC CLOSE LOW REF STARTING/CHARGING SYSTEM TAC CLOSE TAC OPEN TAC OPEN CURRENT SENS SIG THROTTLE BODY (RIGHT SIDE OF ENGINE) TOP OF TRANSMISSION) TP SENS SIG WASTE GATE TRANSMISSIONS SYSTEM VIO/BLU WIRE VIO/GRY WIRE WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRY WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

5 VOLT REF AIR SHUTTER CTRL BLK WIRE BLK/BRN WIRE BLK/LT GRN WIRE BLK/VIO WIRE BLK/YEL WIRE BLU WIRE BLU/BRN WIRE BLU/YEL WIRE BRN/RED WIRE BRN/WHT WIRE CCM FUSE CHASSIS CONTROL MODULE (RIGHT OUTER BODY PANEL ABOVE WHEELWELL) COIL ODD FUSE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/BRN WIRE DK BLU/WHT WIRE DRAIN WIRE ECM IGN FUSE EMISSION 2 ECM FUSE FUSE ENGINE CONTROLS IGNITION RELAY ENGINE COOLANT TEMPERATURE SENSOR (RIGHT REAR OF ENGINE) EXHAUST CAMSHAFT POSITION ACTUATOR SOLENOID VALVE (TOP FRONT OF ENGINE) FUEL PRESSURE SENSOR (RIGHT SIDE OF FUEL TANK) FUEL PUMP GRY WIRE GRY/BLK WIRE GRY/DK BLU WIRE HOT AT ALL TIMES HOT IN RUN OR START HS GMLAN - IGN IGNITION MAIN RELAY LOGIC LOW REF LT GRN/DK BLU WIRE LT GRN/GRY WIRE NCA WIRE PRIMARY RLY CTRL PT RC IGN FUSE BDY RC IGN FUSE RED/VIO WIRE RELAY CTRL SENS SIG SRL DATA WAKEUP TO SECONDARY AIR INJECTION PUMP RELAY (DIAGRAM 5 OF 6) UNDERHOOD FUSE BLOCK (LEFT SIDE OF BATTERY) VIO/BLK WIRE VIO/DK BLU WIRE VIO/GRY WIRE VIO/LT GRN WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE YEL WIRE

1786 179 1174 TRANSMISSIONS SYSTEM 2.0L VIN X 2.5L VIN L 485 (OR 3630) 70 71 72 73 TP SENS SIG WASTE GATE AIR CONDITIONING SYSTEM AIR TEMP LOW REF AIR TEMP SENS SIG BANK 1 SENS (1) BANK 1 SENS (2) MAP SENS SIG BANK 1 SENS 1 BANK 1 SENS 2 BLK WIRE BLK/BRN WIRE BLK/DK BLU WIRE BLK/GRN WIRE BLK/GRY WIRE BLK/VIO WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE BRN/GRN WIRE BRN/RED WIRE BRN/WHT WIRE CHARGE IND CTRL CTRL BANK (1) CURRENT SENS SIG ENGINE COMPT) ENGINE CONTROL MODULE (ECM) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF FUEL RAIL PRESS SENS SIG FUEL RAIL PRESSURE SENSOR FUEL RAIL PRESSURE SENSOR (LEFT SIDE OF ENGINE) GENERATOR FIELD GRN WIRE GRN/BLU WIRE GRN/WHT WIRE GRY WIRE GRY/BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR 1 HEATED OXYGEN SENSOR 2 HI SIG BANK 1 SENS (1) HI SIG BANK 1 SENS (2) KNOCK SENS KNOCK SENS SIG KNOCK SENS SIG KNOCK SENS SIG KNOCK SENS TRANSMISSION PARK/ NEUTRAL SIGNAL (1) COMMAND SIG OIL LEVEL SW SIG KNOCK SENSOR #2 KNOCK SENSOR 1 KNOCK SENSOR 1 (RIGHT SIDE OF ENGINE) KNOCK SENSOR 2 (RIGHT SIDE OF ENGINE) LOW REF MAF SENS SIG MANIFOLD ABSOLUTE PRESSURE SENSOR MANIFOLD ABSOLUTE PRESSURE SENSOR (NEAR THROTTLE BODY) MAP LOW REF MAP LOW REF REF BANK (1) MAP SENS SIG MULTI-FUNCTION INTAKE AIR SENSOR NCA WIRE PURGE SOL CTRL REF BANK (1) RLY CTRL SENS SIG SENS SIG BANK (1) SENS SIG TAC CLOSE LOW REF STARTING/CHARGING SYSTEM TAC CLOSE TAC OPEN TAC OPEN CURRENT SENS SIG THROTTLE BODY (RIGHT SIDE OF ENGINE) TOP OF TRANSMISSION) TP SENS SIG WASTE GATE TRANSMISSIONS SYSTEM VIO/BLU WIRE VIO/GRY WIRE WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/BRN WIRE WHT/GRY WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE