Chevrolet Malibu VIII facelift (2013-2016) hi spd gmlan serial data Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 BATTERY POSITIVE VOLTAGE ABS PUMP FUSE ABS VALVE FUSE BATT POS VOLT BLK WIRE BLK/BLU WIRE BLK/GRY WIRE BLK/VIO WIRE BLK/YEL WIRE BLU WIRE BLU/WHT WIRE BLU/YEL WIRE BRAKE BOOSTER VACUUM SENSOR BRAKE BOOSTER VACUUM SENSOR (W/O STOP/START SYSTEM) (ON BRAKE BOOSTER) BRAKE FLUID LEVEL SWITCH BRAKE PRESSURE MODULATOR BRAKE VACUUM SENS SIG BRK VAC PUMP FUSE BRN WIRE COMBINED VEH INERTIAL COMBINED VEH INERTIAL SENS SPLY VOLT COMBINED VEH INERTIAL SENS SPLY VOLT 5 VOLT REF COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEMS ELECTRONIC BRAKE CONTROL MODULE ELECTRONIC BRAKE CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) FR WSS SIG FRONT WHEEL) FUSE 21 FUSE 8 GRN/BRN WIRE GRN/GRY WIRE GROUND GRY WIRE HI SPD GMLAN SERIAL DATA HI SPD GMLN SERIAL DATA (+) HOT AT ALL TIMES INSTRUMENT PANEL FUSE BLOCK LEFT FRONT WHEEL SPEED SENSOR LEFT FRONT WHEEL SPEED SENSOR (WSS) (AT LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR LEFT REAR WHEEL SPEED SENSOR (WSS) (AT LEFT REAR WHEEL) LEVEL SENS SIG LF WSS LOW REF LF WSS SIG LOW REF LR WSS LOW REF LR WSS LOW REF LR WSS SIGNAL LR WSS SIG RED WIRE RED/BLU WIRE RED/GRY WIRE RED/WHT WIRE RED/YEL WIRE RF WSS LOW REF RF WSS SIG RF WSS SIG RF WSS LOW REF HI SPD GMLAN SERIAL DATA + HI SPD GMLAN SERIAL DATA - RIGHT FRONT WHEEL SPEED SENSOR RIGHT FRONT WHEEL SPEED SENSOR (WSS) (AT RIGHT RIGHT REAR WHEEL SPEED SENSOR RIGHT REAR WHEEL SPEED SENSOR (WSS) (AT RIGHT REAR WHEEL) RR WSS LOW REF RR WSS LOW REF FR WSS SIG SENS SPLY VOLT SERIAL DATA COMMUNICATION ENABLE STEERING WHEEL ANGLE SENSOR (FORWARD OF THE STEERING WHEEL) STEERING WHEEL ANGLE SENSOR (TOP OF STEERING COLUMN) UNDERHOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (LEFT SIDE OF BATTERY) VIO WIRE WHT WIRE WHT/BLU WIRE YEL WIRE YEL/RED WIRE YEL/VIO WIRE

1 3 5 HI SPD GMLAN SERIAL DATA - HI SPD GMLAN SERIAL DATA + 2.0L 2.5L 2.4L 36 37 HI SPD GMLAN SERIAL DATA + HI SPD GMLAN SERIAL DATA - 7493 7494 COMPUTER DATA LINES SYSTEM ABS IND. BATT POS VOLT BLK WHT/GRN WIRE BLK WIRE BLK/BRN WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/VIO WIRE BLU/YEL WIRE BODY CONTROL MODULE (BEHIND LEFT END OF DASH) BODY CONTROL MODULE (BEHIND LEFT SIDE OF DASH) BRAKE BOOSTER VACUUM SENSOR (W/ STOP/START SYSTEM) (ON BRAKE BOOSTER) BRAKE IND BRAKE PEDAL POSITION SENSOR BRAKE PEDAL POSITION SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BRK APPLY SENS LOW REF BRK APPLY SENS SIG BRK APPLY SENS SPLY VOLT BRK POSITION SENS SIG BRK VACUUM SENS SIG BRN WIRE COMBINED VEH INERTIAL SENS SPLY VOLT COMPUTER DATA LINES SYSTEM CRUISE/ETC/TCC BRK SIG DRIVER INFORMATION CENTER DISPLAY ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE CONTROL MODULE (ECM) (TOP OF TRANSMISSION) FUSE 21 GRN WIRE GRN/BRN WIRE GROUND GROUND DISTRIBUTION SYSTEM HI SPD GMLAN SERIAL DATA HOT AT ALL TIMES HYBRID/EV BATTERY PACK (BEHIND REAR SEATS IN LUGGAGE COMPT) HYBRID/EV POWERTRAIN CONTROL MODULE INSTRUMENT CLUSTER INSTRUMENT PANEL FUSE BLOCK (LEFT SIDE OF DASH) INSTRUMENT PANEL MULTI- FUNCTION SWITCH LOGIC LOW REF LOW REF BRK POSITION SENS SIG LOW REF BRK VACUUM SENS SIG CRUISE/ETC/TCC BRK SIG MULTI-AXIS ACCELERATION SENSOR (BELOW FLOOR CONSOLE) PARK BRAKE SW SIG PARK BRAKE SWITCH PARK BRAKE SWITCH (MOUNTED TO SHIFT LEVER BEZEL) RED/GRY WIRE RED/WHT WIRE STARTER/GENERATOR CONTROL MODULE TCS IND TCS OFF IND TRACTION CONTROL SWITCH TRACTION CTRL SW SIG VDC IND WHT WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/RED WIRE YEL/VIO WIRE

1 2 17 9 OIL PRES SENS SIG 5 VOLT REF SENS LOW REF OIL PRESS 1 2 NETWORK BUS 4 AJAR SW SIG 29 5 6 BRK FLUID LVL SW SIG HI SPD SERIAL DATA + HI SPD SERIAL DATA - 5 6 NETWORK BUS 3 AJAR SW SIG 5 VOLT REF 6 4 AJAR SW SIG NETWORK BUS 3 6 5 AJAR SW SIG NETWORK BUS 3 AJAR AJAR SW SIG BLK WIRE BLK/GRN WIRE BLK/VIO WIRE BLK/WHT WIRE BLU WIRE BLU/GRN WIRE BRAKE FLUID LEVEL SWITCH BRAKE FLUID LEVEL SWITCH (TOP OF THE BRAKE FLUID RESERVOIR) BRK FLUID LVL SW SIG BRN/GRN WIRE COMPUTER DATA LINES SYSTEM DRIVER DOOR LATCH ASSEMBLY DRIVER WINDOW MOTOR DRIVER WINDOW SWITCH ELECTRONIC BRAKE CONTROL MODULE (LEFT REAR OF ENGINE COMPT) ELECTRONIC BRAKE CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) ENGINE CONTROL MODULE (ECM) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE CONTROLS SYSTEM ENGINE OIL LEVEL SWITCH ENGINE OIL LEVEL SWITCH (EXCEPT 2.4L) (RIGHT SIDE OF OIL PAN) ENGINE OIL PRESSURE SENSOR ENGINE OIL PRESSURE SENSOR (2.4L) (LEFT SIDE OF ENGINE) ENGINE OIL PRESSURE SENSOR (EXCEPT 2.4L) (RIGHT SIDE OF ENGINE) FUEL LEVEL SENS LOW REF FUEL LEVEL SENSOR FUEL PUMP, LEVEL SENSOR ASSEMBLY FUEL PUMP, LEVEL SENSOR ASSEMBLY (TOP OF FUEL TANK) GRN/GRY WIRE GRN/YEL WIRE GRY WIRE HI SPD GMLAN SERIAL DATA HI SPD SERIAL DATA + LEFT REAR DOOR LATCH LEFT REAR DOOR LATCH ASSEMBLY LEFT REAR WINDOW SWITCH LOGIC LOGIC DRIVER WINDOW SWITCH LOGIC LEFT REAR WINDOW SWITCH LOGIC RIGHT REAR WINDOW SWITCH NETWORK BUS 3 NETWORK BUS 4 OIL LEVEL SW SIG OIL PRES SENS SIG PASSENGER DOOR LATCH ASSEMBLY PASSENGER WINDOW SWITCH PRIMARY FUEL SENS SIG REAR COMPARTMENT LID LATCH REAR COMPARTMENT LID LATCH (BOTTOM OF REAR COMPT LID) RIGHT REAR DOOR LATCH RIGHT REAR DOOR LATCH ASSEMBLY RIGHT REAR WINDOW SWITCH SENS LOW REF TOP OF TRANSMISSION) VIO WIRE W/ EXPRESS UP/DOWN W/O EXPRESS UP/DOWN WHT WIRE WHT/RED WIRE YEL/BLK WIRE YEL/BRN WIRE

"CHECK ENGINE" IND CTRL 2.0L VIN X 2.5L VIN L 63 64 65 66 67 68 69 70 71 72 73 STARTER ENABLE RLY CTRL 6386 (OR 4325) 6386 (OR 4325) STARTING/ CHARGING SYSTEM 7330 7331 (OR 3200) (OR 3201) A/C COMPRESSOR CLUTCH RLY CTRL A/C REFRIGERANT PRESS SENS LO REF A/C REFRIGERANT PRESS SENS LO REF SENS 2 LOW REF A/C REFRIGERANT PRESSURE A/C REFRIGERANT PRESSURE SENS SIG A/C REFRIGERANT PRESSURE SENSOR ACCESSORY WAKEUP SERIAL DATA AIR CONDITIONING SYSTEM AIR PRESSURE SIG APP LO REF APP LOW REF APP SENS SIG (2) APP SENS SIG 1 BATT POS VOL BLK WIRE BLK/BLU WIRE BLK/BRN WIRE BLK/GRN WIRE BLK/GRY WIRE BLK/VIO WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/GRN WIRE BLU/WHT WIRE BRAKE PEDAL POSITION SENSOR BRK POS SEN SIG BRK POS SENS LOW REF BRN WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM COOLANT TEMP SENS SIG 2 COOLING FANS SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM COOLING FANS SYSTEM CRUISE/ETC/TCC BRK SIG DK BLU WIRE DK BLU/BRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE CONTROL MODULE (ECM) (TOP OF TRANSMISSION) EVAP CANISTER VENT SOL CTRL EVAPORATIVE EMISSION VENT SOLENOID VALVE EVAPORATIVE EMISSION VENT SOLENOID VALVE (RIGHT SIDE OF FUEL TANK) FUEL LEVEL SENS LO REF FUEL LEVEL SENS SIG FUEL LEVEL SENS SIG FUEL LEVEL SENS LO REF FUEL LINE PRESSURE SENS LO REF FUEL LINE PRESSURE SENS SIG FUEL PRESSURE SENSOR FUEL PRESSURE SENSOR (RIGHT SIDE OF FUEL TANK) FUEL PUMP CONTROLLER DATA OUT SIG FUEL TANK PRESSURE SENS SIG FUEL TANK PRESSURE SENSOR FUEL TANK PRESSURE SENSOR (TOP OF FUEL TANK) GRN WIRE GRN/BRN WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/RED WIRE HI SPD COOLING FAN RLY CTRL HI SPD GMLAN SERIAL DATA HI SPD GMLAN SERIAL DATA + HI SPD GMLAN SERIAL DATA - LOW REF LOW SPEED COOLING FAN RLY CTRL LT GRN/DK BLU WIRE MAIN RELAY FUSED SPLY POWERTRAIN MAIN RLY FUSED SPLY 1 POWERTRAIN RLY COIL CTRL POWERTRAIN RLY COIL CTRL POWERTRAIN MAIN RLY FUSED SPLY (1) PRE-THROTTLE AIR PRESS TEMP SIG RED BRN/ WIRE RED WIRE RED/BLU WIRE RED/BRN WIRE RLY CTRL RUN/CRANK IGN 1 VOL RUN/CRANK IGN 1 VOL BATT POS VOL APP LOW REF SENS 2 LOW REF SENSOR (RIGHT SIDE OF A/C CONDENSER) STARTER ENABLE RLY CTRL STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM TURBO CHARGER BOOST/INTAKE AIR TEMPERATURE SENSOR UNDERHOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (LEFT SIDE OF BATTERY) VIO/BLU WIRE VIO/DK BLU WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/RED WIRE VIO/YEL WIRE WHT WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/GRY WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/RED WIRE YEL/WHT WIRE

"CHECK ENGINE" IND CTRL 2.0L VIN X 2.5L VIN L 63 64 65 66 67 68 69 70 71 72 73 STARTER ENABLE RLY CTRL 6386 (OR 4325) 6386 (OR 4325) STARTING/ CHARGING SYSTEM 7330 7331 (OR 3200) (OR 3201) A/C COMPRESSOR CLUTCH RLY CTRL A/C REFRIGERANT PRESS SENS LO REF A/C REFRIGERANT PRESS SENS LO REF SENS 2 LOW REF A/C REFRIGERANT PRESSURE A/C REFRIGERANT PRESSURE SENS SIG A/C REFRIGERANT PRESSURE SENSOR ACCESSORY WAKEUP SERIAL DATA AIR CONDITIONING SYSTEM AIR PRESSURE SIG APP LO REF APP LOW REF APP SENS SIG (2) APP SENS SIG 1 BATT POS VOL BLK WIRE BLK/BLU WIRE BLK/BRN WIRE BLK/GRN WIRE BLK/GRY WIRE BLK/VIO WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/GRN WIRE BLU/WHT WIRE BRAKE PEDAL POSITION SENSOR BRK POS SEN SIG BRK POS SENS LOW REF BRN WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM COOLANT TEMP SENS SIG 2 COOLING FANS SYSTEM CRUISE CONTROL SYSTEM CRUISE CONTROL SYSTEM COOLING FANS SYSTEM CRUISE/ETC/TCC BRK SIG DK BLU WIRE DK BLU/BRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE CONTROL MODULE (ECM) (TOP OF TRANSMISSION) EVAP CANISTER VENT SOL CTRL EVAPORATIVE EMISSION VENT SOLENOID VALVE EVAPORATIVE EMISSION VENT SOLENOID VALVE (RIGHT SIDE OF FUEL TANK) FUEL LEVEL SENS LO REF FUEL LEVEL SENS SIG FUEL LEVEL SENS SIG FUEL LEVEL SENS LO REF FUEL LINE PRESSURE SENS LO REF FUEL LINE PRESSURE SENS SIG FUEL PRESSURE SENSOR FUEL PRESSURE SENSOR (RIGHT SIDE OF FUEL TANK) FUEL PUMP CONTROLLER DATA OUT SIG FUEL TANK PRESSURE SENS SIG FUEL TANK PRESSURE SENSOR FUEL TANK PRESSURE SENSOR (TOP OF FUEL TANK) GRN WIRE GRN/BRN WIRE GRN/VIO WIRE GRN/WHT WIRE GRY WIRE GRY/RED WIRE HI SPD COOLING FAN RLY CTRL HI SPD GMLAN SERIAL DATA HI SPD GMLAN SERIAL DATA + HI SPD GMLAN SERIAL DATA - LOW REF LOW SPEED COOLING FAN RLY CTRL LT GRN/DK BLU WIRE MAIN RELAY FUSED SPLY POWERTRAIN MAIN RLY FUSED SPLY 1 POWERTRAIN RLY COIL CTRL POWERTRAIN RLY COIL CTRL POWERTRAIN MAIN RLY FUSED SPLY (1) PRE-THROTTLE AIR PRESS TEMP SIG RED BRN/ WIRE RED WIRE RED/BLU WIRE RED/BRN WIRE RLY CTRL RUN/CRANK IGN 1 VOL RUN/CRANK IGN 1 VOL BATT POS VOL APP LOW REF SENS 2 LOW REF SENSOR (RIGHT SIDE OF A/C CONDENSER) STARTER ENABLE RLY CTRL STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TRANSMISSIONS SYSTEM TURBO CHARGER BOOST/INTAKE AIR TEMPERATURE SENSOR UNDERHOOD FUSE BLOCK UNDERHOOD FUSE BLOCK (LEFT SIDE OF BATTERY) VIO/BLU WIRE VIO/DK BLU WIRE VIO/GRN WIRE VIO/GRY WIRE VIO/RED WIRE VIO/YEL WIRE WHT WIRE WHT/BLU WIRE WHT/GRN WIRE WHT/GRY WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/RED WIRE YEL/WHT WIRE