Chevrolet Malibu VI facelift (2006-2008) dk blu Wiring diagrams

4 SPOKE 3 SPOKE ACCELERATOR PEDAL POSITION SENSOR (APP) (ATTACHED TO ACCELERATOR PEDAL) APP SENSOR 1 APP SENSOR 2 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (UNDER FRONT OF CENTER CONSOLE) BRAKE PEDAL POSITION SENS SIG BRAKE PEDAL POSITION SENSOR (ON BRAKE PEDAL SUPPORT) BRN WIRE CANCEL SWITCH CLUSTER/THEFT FUSE COMPUTER DATA LINES SYSTEM CRUISE CONTROL CANCEL SIGNAL CRUISE CONTROL SWITCH SIGNAL CRUISE ON/OFF SWITCH DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (LEFT SIDE OF ENGINE COMPARTMENT, FORWARD OF BATTERY) GMLAN GMLAN - GMLAN + GROUND GRY WIRE HIGH SIG HOT AT ALL TIMES HOT W/ RUN/CRANK RELAY ENERGIZED IBCM 2 FUSE IGN B+ CRUISE INDICATOR LOGIC INSTRUMENT PANEL CLUSTER INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL INTERIOR LIGHTS FUSE LEFT STEERING WHEEL CONTROLS LOGIC LOW SIG LOW SPEED GMLAN SERIAL DATA LT BLU WIRE LT GRN WIRE PNK WIRE PPL PPL TP SEN 2 SIG LOW REF TP SEN 1 SIG 5 VOLT REF 2 RED/BLK WIRE RED/WHT WIRE RESUME + SWITCH RUN/CRANK FUSE SERIAL DATA SET SWITCH STOP LAMP STOP LAMP SWITCH SIGNAL SW SIG SWITCH SIGNAL TAN WIRE TAN/BLK WIRE THROTTLE ACTUATOR CONTROL (TAC) MODULE (ON UPPER INTAKE MANIFOLD) TRANSMISSION CONTROL MODULE (LEFT REAR OF ENGINE COMPT, NEAR STRUT TOWER) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) IBCM (R/C) FUSE VEHICLE SPEED SENSOR (VSS) WHT WIRE WHT/BLK WIRE YEL WIRE

3.5L PPL 4 SPOKE 3 SPOKE ACCELERATOR PEDAL POSITION SENSOR (APP) (ATTACHED TO ACCELERATOR PEDAL) APP SENSOR 1 APP SENSOR 2 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (UNDER FRONT OF CENTER CONSOLE) BRAKE PEDAL POSITION SENS SIG BRAKE PEDAL POSITION SENSOR (ON BRAKE PEDAL SUPPORT) BRN WIRE CANCEL SWITCH CLUSTER/THEFT FUSE COMPUTER DATA LINES SYSTEM CRUISE CONTROL CANCEL SIGNAL CRUISE CONTROL SWITCH SIGNAL CRUISE ON/OFF SWITCH DK BLU WIRE DK GRN WIRE GMLAN GMLAN - GMLAN + GROUND GRY WIRE HIGH SIG HOT AT ALL TIMES HOT W/ RUN/CRANK RELAY ENERGIZED IBCM 2 FUSE IGN B+ CRUISE INDICATOR LOGIC INSTRUMENT PANEL CLUSTER INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL INTERIOR LIGHTS FUSE LEFT STEERING WHEEL CONTROLS LOGIC LOW SIG LOW SPEED GMLAN SERIAL DATA LT BLU WIRE LT GRN WIRE PNK WIRE PPL RED/BLK WIRE RED/WHT WIRE RESUME + SWITCH RUN/CRANK FUSE SERIAL DATA SET SWITCH STOP LAMP STOP LAMP SWITCH SIGNAL STP SIG SW SIG SWITCH SIGNAL TAN WIRE TAN/BLK WIRE THROTTLE BODY (3.5L) THROTTLE BODY ASSEMBLY (3.9L) TRANSMISSION CONTROL MODULE (LEFT REAR OF ENGINE COMPT, NEAR STRUT TOWER) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) IBCM (R/C) FUSE VEHICLE SPEED SENSOR (VSS) WHT WIRE WHT/BLK WIRE YEL WIRE

A/C CLU FUSE 1 A/C CLUTCH RELAY 34 A/C COMPRESSOR CLUTCH (LOWER RIGHT FRONT OF ENGINE) A/C REQUEST IND A/C REQUEST SWITCH BATTERY POSITIVE VOLTAGE BLK WIRE BLK/WHT WIRE BLOWER MOTOR (BELOW RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL MODULE (RIGHT SIDE OF DASH, ON REAR OF HVAC CASE) BLOWER MOTOR SWITCH BLR MTR SPD CTRL BLR SPD REQ SIG BRN WIRE COMPUTER DATA LINES SYSTEM COOL FAN 1 FUSE 17 COOL FAN 2 FUSE 18 COOL/ FAN 1 RELAY 28 COOL/ FAN 2 RELAY 30 COOL/FAN SER/PAR RELAY 29 DEFOG IND DEFOG SWITCH DISPLAY AMBIENT AIR TEMPERATURE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION DISPLAY GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START HVAC CONTROL MODULE (CENTER OF DASH) IGNITION 3 VOLTAGE INSIDE AIR TEMPERATURE SENSOR LEFT COOLING FAN LMP SPLY VOLTAGE LOGIC LOW COOLANT LOW REFERENCE LOW REFERENCE RECIRC DR CTRL A MODE DR CTRL B AIR TEMP DR CTRL B LOW SPEED GMLAN SERIAL DATA LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MODE SWITCH PNK/WHT WIRE PPL RADIO RECIRCULATION IND FRESH AIR IND RED/BLK WIRE RED/WHT WIRE RIGHT COOLING FAN (ON FRONT OF ENGINE COMPT) SPLY VOLTAGE TAN WIRE TEMPERATURE CONTROL RECIRCULATION SWITCH WHT WIRE YEL WIRE

12 34 13 63 58 17 28 27 25 65 8 30 5 49 43 44 SENS SIG 2.2L 22 21 4 58 LOW REF ECT SENS SIG AIR TEMPERATURE ACTUATOR (ON TOP RIGHT SIDE OF DASH) AMBIENT AIR TEMPERATURE SENSOR SIG AMBIENT LIGHT/SUNLOAD SENSOR (ON TOP OF DASH TRIM PAD) BLK WIRE BODY CONTROL MODULE (BCM) (UNDER FRONT OF CENTER CONSOLE) BRN WIRE COMPUTER DATA LINES SYSTEM COOLANT LEVEL SW COOLANT LEVEL SWITCH COOLANT TEMP IND DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH, NEAR STEERING COLUMN) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR EXCEPT 2.2L FORWARD OF BATTERY) GRY WIRE HIGH SPEED GM LAN SERIAL DATA HOT AT ALL TIMES HVAC CTRL (BATT) FUSE HVAC CTRL (IGN) FUSE INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOGIC LOW SPEED GMLAN SERIAL DATA LOW REF LOW SPEED GM LAN SERIAL DATA LOW SPEED GMLAN SERIAL DATA LOWER AIR TEMPERATURE SENSOR LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE ACTUATOR (ON LEFT SIDE OF HVAC CASE) ORG/BLK WIRE PNK/WHT WIRE RECIRCULATION ACTUATOR (ON RIGHT SIDE OF HVAC CASE) RED/BLK WIRE RED/WHT WIRE RELAY RESERVOIR) RUN RLY CTRL RUN WIRE SERIAL DATA IGN SUN LOAD SENSOR SIG SUN LOAD SENSOR SIG TAN WIRE TAN/BLK WIRE UPPER AIR DUCT TEMPERATURE SENSOR (ON UPPER DUCT, ABOVE ACCELERATOR PEDAL) YEL WIRE YEL/BLK WIRE

A/T SHIFT LCK CTRL SOL SPLY VOLTAGE AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM BATTERY BLK WIRE BODY CONTROL MODULE (BCM) (UNDER FRONT OF CENTER CONSOLE) BRN/WHT WIRE COMPUTER DATA LINES SYSTEM EXTERIOR LIGHTS SYSTEM COOLANT LEVEL SW SIG COOLING FANS SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DOOR LOCKS FUSE DOOR LOCKS SYSTEM DRIVER DOOR KEY SW SIG DRL RELAY CONTROL AMBIENT AIR TEMP SENS SIG EXTENDED SEDAN EXTERIOR LIGHTS SYSTEM DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM EXTERIOR LIGHTS SYSTEM TRUNK, TAILGATE, FUEL DOORS SYSTEM GROUND HORN RLY CTRL GRY/BLK WIRE HEADLAMP HI BEAM RLY CTRL HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM AIR CONDITIONING SYSTEM HORNS SYSTEM HOT AT ALL TIMES INTERIOR LIGHTS FUSE LF DOOR AJAR SW SIG LOGIC LOW REFERENCE LOW SPD GMLAN SER DATA LEFT DRL/TURN SUPPLY VOLTAGE LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/BLK WIRE PARK LAMP RELAY CTRL DOOR LOCK/UNLOCK SIGNAL DOOR LOCK/UNLOCK SIGNAL PNK WIRE PNK/BLK WIRE PPL REAR COMPT LID AJAR SW SIG FOG LAMP RLY CTRL REV LAMP RLY CTRL TRUNK RELEASE RLY CTRL SEDAN SHIFT INTERLOCK SYSTEM STOP LAMP SUPPLY VOLTAGE STOP LAMP VOLTAGE TAN WIRE TAN/WHT WIRE TRACTION CTRL SW SIG TRUNK KEY SWITCH SIG LIFT GATE REL SW SIG TRUNK, TAILGATE, FUEL DOORS SYSTEM TRUNK, TAILGATE, FUEL DOORS SYSTEM HEADLIGHTS SYSTEM WHT WIRE WHT/BLK WIRE WINDSHIELD WIPER MOTOR PARK SW SIG WINDSHIELD WIPER SW SIG 2 WIPER/WASHER SYSTEM YEL WIRE

ACCESSORY VOLTAGE ACCESSORY VOLTAGE BATTERY ACCESSORY VOLTAGE IGNITION 1 VOLTAGE BATTERY BATTERY BATTERY BATTERY BODY CONTROL MODULE (BCM) (UNDER FRONT OF CENTER CONSOLE) BRN WIRE COURTESY LAMPS SUPPLY VOLTAGE DOOR LOCK ACTUATOR LOCK CTRL DK BLU WIRE DK GRN WIRE DOOR LOCK ACTUATOR LOCK CTRL DOOR LOCK ACTUATOR UNLOCK CTRL DOOR LOCK ACTUATOR UNLOCK CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT W/ RUN/ CRANK RELAY ENERGIZED IBCM (R/C) FUSE 21 IBCM 1 FUSE 20 IBCM 2 FUSE 25 IGNITION 1 VOLTAGE LOGIC ORG/ WIRE PARK LAMP SUPPLY VOLTAGE PNK IGNITION 1 VOLTAGE WIRE PNK WIRE POWER DISTRIBUTION, POWER WINDOWS SYSTEMS POWER DISTRIBUTION, SEATS SYSTEMS POWER DISTRIBUTION, SEATS SYSTEMS POWER DISTRIBUTION, SHIFT INTERLOCK SYSTEMS POWER DISTRIBUTION, SUPPLEMENTAL RESTRAINTS SYSTEMS POWER WINDOW MASTER SW LOCKOUT SIG I/P LAMP SUPPLY VOLTAGE POWER WINDOW MASTER SW LOCKOUT SIG WINDSHIELD WASHER PUMP CTRL POWER WINDOWS SYSTEM INTERIOR LIGHTS SYSTEM POWER WINDOWS SYSTEM WIPER/WASHER SYSTEM RED/BLK WIRE RED/WHT WIRE RUN RLY FUSE 19 SUPPLEMENTAL RESTRAINTS SYSTEMS TAN WIRE TRANSMISSIONS SYSTEM ENGINE CONTROLS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPARTMENT) YEL WIRE

ACCESSORY VOLTAGE AIR CONDITIONING SYSTEM EXTERIOR LIGHTS SYSTEM BATTERY BATTERY BATTERY BLOWER MTR SUPPLY VOLTAGE BLK WIRE BLOWER MTR SUPPLY VOLTAGE BODY CONTROL MODULE (BCM) (UNDER FRONT OF CENTER CONSOLE) BRN WIRE DK BLU WIRE GROUND GRY WIRE HIGH BLOWER MTR CTRL PARK LAMP SUPPLY VOLTAGE I/P LAMP SUPPLY VOLTAGE IGNITION 3 VOLTAGE INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM LOGIC ORG/ WIRE PNK IGNITION 1 VOLTAGE WIRE PNK PNK PPL IGNITION 1 VOLTAGE WIRE POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION, AIR CONDITIONING SYSTEMS POWER DISTRIBUTION, ANTI-THEFT SYSTEMS POWER DISTRIBUTION, ANTI-THEFT SYSTEMS POWER DISTRIBUTION, CRUISE CONTROL SYSTEMS POWER DISTRIBUTION, ELECTRONIC POWER STEERING SYSTEMS POWER DISTRIBUTION, SEATS SYSTEMS POWER DISTRIBUTION, SEATS SYSTEMS POWER DISTRIBUTION, SOUND SYSTEMS POWER DISTRIBUTION, WIPER/WASHER SYSTEMS RED/BLK WIRE RED/WHT WIRE WINDSHIELD WASHER PUMP CTRL I/P LAMP SUPPLY VOLTAGE IGNITION 3 VOLTAGE YEL WIRE

17 58 49 5 HIGH SPD RLY CTRL LOW SPD RLY CTRL 4 58 22 21 LOW REF ECT SENS SIG BLK WIRE COMPT) COMPUTER DATA LINES SYSTEM COOL FAN 1 FUSE 17 COOL FAN 2 FUSE 18 COOL/ FAN 1 RELAY 28 COOL/ FAN 2 RELAY 30 COOL/ FAN SER/ PAR RELAY 29 COOLANT LEVEL SWITCH (ON ENGINE COOLANT SURGE TANK) COOLANT TEMP IND DK BLU WIRE DK GRN WIRE DRIVER INFORMATION DISPLAY ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT, FORWARD OF BATTERY) ENGINE COOLANT TEMPERATURE (ECT) SENSOR EXCEPT 2.2L 2.2L GRY WIRE HOT AT ALL TIMES IGN INSTRUMENT PANEL CLUSTER (IPC) LEFT COOLING FAN (ON FRONT OF ENGINE COMPT) LOGIC BODY CONTROL MODULE (BCM) (UNDER FRONT OF CENTER CONSOLE) LOGIC LOW SPEED GMLAN SERIAL DATA LOGIC RADIO LOW COOLANT LOW SPEED GMLAN SERIAL DATA LOW SPEED GMLAN SERIAL DATA LOW SPEED GMLAN SERIAL DATA LT BLU WIRE LT GRN WIRE RIGHT COOLING FAN (ON FRONT OF ENGINE COMPT) SERIAL DATA TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE WHT WIRE YEL WIRE

A/C CLU FUSE 1 A/C CLUTCH RELAY 34 A/C COMPRESSOR CLUTCH (LOWER RIGHT FRONT OF ENGINE) A/C REQUEST IND DEFOG IND A/C REQUEST SWITCH BLK WIRE BLK/WHT WIRE BLOWER MOTOR RESISTOR ASSEMBLY (RIGHT SIDE OF DASH, ON REAR OF HVAC CASE) BLOWER MOTOR SWITCH BRN WIRE COMPUTER DATA LINES SYSTEM COOL FAN 1 FUSE 17 COOL FAN 2 FUSE 18 COOL/ FAN 1 RELAY 28 COOL/ FAN 2 RELAY 30 COOL/FAN SER/PAR RELAY 29 DEFOG SWITCH DEFOGGER SYSTEM DISPLAY AMBIENT AIR TEMPERATURE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION DISPLAY FRESH AIR IND GROUND GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START HVAC CONTROL MODULE (CENTER OF DASH) IGN 3 A/C REQ SIG LEFT COOLING FAN LMP SPLY VOLTAGE LOGIC LOW COOLANT LOW OFF LOW SPEED GMLAN SERIAL DATA LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE MODE SWITCH TEMPERATURE CONTROL SWITCH ORG/ WIRE PNK/WHT WIRE POSITION SWITCH) RADIO REAR DEF IND REAR DEFOG SW SIG RECIRC DR CTRL A MODE DR CTRL A AIR TEMP DR CTRL A RECIRC DR CTRL B MODE DR CTRL B AIR TEMP DR CTRL B PK LMP SPLY RECIRCULATION IND RECIRCULATION SWITCH RED/WHT WIRE RIGHT COOLING FAN (ON FRONT OF ENGINE COMPT) TAN WIRE WHT WIRE YEL WIRE

2.2L 25 65 8 30 5 49 43 44 12 34 13 63 58 17 28 27 SENS SIG 4 58 22 21 LOW REF ECT SENS SIG A/C REFRIGERANT PRESSURE SENSOR (LEFT OF RIGHT FRONT STRUT TOWER) A/C REQ SIG LOW REF GND ABOVE TRANSMISSION) (3.9L: IN REAR OF LEFT CYLINDER HEAD) AFTER BLOW AIR TEMPERATURE ACTUATOR (ON TOP RIGHT SIDE OF DASH) BLK WIRE BLOWER MOTOR (BELOW RIGHT SIDE OF DASH) BODY CONTROL MODULE (BCM) (UNDER FRONT OF CENTER CONSOLE) BRN WIRE COMPUTER DATA LINES SYSTEM COOLANT LEVEL SW COOLANT LEVEL SWITCH COOLANT TEMP IND DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH, NEAR STEERING COLUMN) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT, FORWARD OF BATTERY) EXCEPT 2.2L GRY WIRE HOT AT ALL TIMES HVAC BLOWER HIGH RELAY HVAC CTRL (BATT) FUSE HVAC CTRL (IGN) FUSE HVAC BLOWER FUSE INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOGIC LOW SPEED GMLAN SERIAL DATA LOW REF CLU RLY CTRL LOW SPD RLY CTRL HIGH SPD RLY CTRL DATA BUS+ DATA BUS- LOW SPEED GM LAN SERIAL DATA AMBIENT AIR TEMP SENSOR SIGNAL LOW SPEED GMLAN SERIAL DATA LT GRN WIRE LT GRN/BLK WIRE MODE ACTUATOR (ON LEFT SIDE OF HVAC CASE) ORG/ WIRE ORG/BLK WIRE PNK/WHT WIRE PPL RECIRCULATION ACTUATOR (ON RIGHT SIDE OF HVAC CASE) RED/WHT WIRE RELAY RLY CTRL RUN WIRE SERIAL DATA IGN TAN WIRE TAN/BLK WIRE YEL WIRE