Chevrolet Malibu VI (2003-2006) tan Wiring diagrams

12 44 400 401 VSS HI (SIGNAL) VSS LO (GROUND) PPL 41 8 43 27 30 7 APP SENS SIG AUTOMATIC TRANSAXLE AUTOMATIC TRANSAXLE FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSAXLE FLUID TEMPERATURE SENSOR AUTOMATIC TRANSAXLE INPUT SHAFT SPEED SENSOR BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECT SENSOR IN ENGINE COOLANT TEMPERATURE SENSOR (TOP REAR OF ENGINE) ETC FUSE 2 FUSE 16 GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT WITH POWERTRAIN RELAY ENERGIZED INSTRUMENT CLUSTER LOW REF LOW REF APP SENS 1 SIG LT BLU WIRE LT BLU/ WHT WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PCM FUSE 13 PNK PPL WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (FRONT OF BATTERY) PPL PRESSURE CONTROL SOL RED WIRE RED/WHT WIRE REV,D,2,1 SERVICE ENGINE SOON INDICATOR TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC PWM SOL 2-3 SHIFT SOL 1-2 SHIFT SOL TCC RELEASE TR SW IN-B TRANS FUSE 4 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (REAR OF TRANSAXLE) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRAKE PEDAL POSITION SENS SIG BRAKE PEDAL POSITION SENSOR (ON BRAKE PEDAL SUPPORT) BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE GMLAN DATA GRY WIRE HOT IN RUN OR START LOW REF LT BLU WIRE PARK/NEUTRAL POSITION SWITCH (TOP OF TRANSAXLE) PNK WIRE PPL RUN/ CRANK FUSE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TAP ENABLE SIG TAP UP/ TAP DOWN SWITCH THROTTLE ACTUATOR CONTROL (TAC) MODULE (ON INTAKE MANIFOLD) WHT WIRE WHT/BLK WIRE YEL WIRE

1-2 SHIFT SOL 12 44 VSS HI (SIGNAL) VSS LO (GROUND) PPL AUTOMATIC TRANSAXLE AUTOMATIC TRANSAXLE FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSAXLE FLUID TEMPERATURE SENSOR AUTOMATIC TRANSAXLE INPUT SHAFT SPEED SENSOR BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECT SENSOR IN ENGINE COOLANT TEMPERATURE SENSOR (TOP REAR OF ENGINE) ETC FUSE 2 FUSE 16 GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT WITH POWERTRAIN RELAY ENERGIZED INSTRUMENT CLUSTER LOW REF LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PCM FUSE 13 PNK PPL WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (FRONT OF BATTERY) PPL PRESSURE CONTROL SOL RED WIRE RED/WHT WIRE REV,D,2,1 SERVICE ENGINE SOON INDICATOR TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC PWM SOL 2-3 SHIFT SOL TCC RELEASE TR SW IN-B TRANS FUSE 4 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (REAR OF TRANSAXLE) WHT LT BLU/ WIRE WHT WIRE WHT/ DK BLU WIRE YEL WIRE YEL/BLK WIRE

ACCELERATOR PEDAL POSITION (APP) SENSOR (ATTACHED TO ACCELERATOR PEDAL) APP SENS 1 APP SENS 2 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRAKE PEDAL POSITION SENS SIG BRAKE PEDAL POSITION SENSOR (ON BRAKE PEDAL SUPPORT) BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE GMLAN DATA GRY WIRE HOT IN RUN OR START LOW REF LT BLU WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (TOP OF TRANSAXLE) PNK WIRE PPL RUN/ CRANK FUSE SERIAL DATA STOP LP SW TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TAP ENABLE SIG TAP UP/ TAP DOWN SWITCH THROTTLE ACTUATOR CONTROL (TAC) MODULE (ON INTAKE MANIFOLD) WHT WIRE WHT/BLK WIRE YEL WIRE

1270 OHMS 348 OHMS 294 OHMS 475 OHMS 6980 OHMS 2370 OHMS 715 OHMS 1180 OHMS BLK WIRE BLU WIRE BRN WIRE DK BLU WIRE DK GRN WIRE GRY WIRE INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL LEFT FRONT DOOR SPEAKER LEFT FRONT DOOR TWEETER LEFT REAR SPEAKER (SEDAN) LEFT REAR DOOR SPEAKER (EXTENDED SEDAN) LEFT STEERING WHEEL CONTROLS LT BLU WIRE LT GRN WIRE RIGHT FRONT DOOR SPEAKER RIGHT FRONT DOOR TWEETER RIGHT REAR SPEAKER (SEDAN) RIGHT REAR DOOR SPEAKER (EXTENDED SEDAN) RIGHT STEERING WHEEL CONTROLS TAN WIRE WHT WIRE WHT/BLK WIRE YEL WIRE

2.2L 3.5L 3.5L, 2.2L B(+) CLASS 2 SERIAL DATA BATTERY BLK WIRE BLU WIRE CHARGE INDICATOR CLASS 2 SERIAL DATA COMPUTER DATA LINES SYSTEM DK GRN WIRE FUSIBLE LINK (12 GA- GENERATOR GENERATOR FIELD DUTY CYCLE SIGNAL GENERATOR TURN ON SIGNAL GRY WIRE HIGH SPEED GMLAN SERIAL DATA BUS + INSTRUMENT PANEL CLUSTER (IPC) LOW SPEED GMLAN SERIAL DATA LOW SPEED GMLAN SERIAL DATA ORG/ WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (FRONT OF BATTERY) PPL RED WIRE STARTER TAN WIRE TAN/BLK WIRE

2.2L 3.5L, 2.2L BATTERY BLK WIRE BLU WIRE COMPUTER DATA LINES SYSTEM DOOR LOCK LOCK/UNLOCK SIGNAL DOOR LOCKS SYSTEM ECM HIGH SPEED GMLAN SERIAL DATA BUS - FUSIBLE LINK (12 GA- GENERATOR HAZARD SWITCH SIGNAL HIGH SPEED GMLAN SERIAL DATA BUS + HOOD AJAR SWITCH HOOD AJAR SWITCH SIGNAL HOT AT ALL TIMES IGN 1 FUSE 3 IGNITION SENSOR FUSE IGNITION SWITCH KEY-IN IGNITION SWITCH LOCK LOGIC LT GRN WIRE NCA WIRE OFF/RUN CRANK VOLTAGE SIGNAL PARK/NEUTRAL POSITION (PNP) SWITCH (TOP OF TRANSMISSION) PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (FRONT OF BATTERY) PPL PPL PPL PPL/WHT WIRE RED WIRE RUN WIRE RUN/CRANK RELAY 32 RUN/CRANK RELAY COIL CONTROL SERIAL DATA STARTER STARTER FUSE 26 STARTER RELAY 31 STARTER RLY COIL CTRL STARTER RLY COIL SPLY VOLTAGE TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) WHT WIRE WHT/BLK WIRE YEL WIRE

AIRBAG (BATT) FUSE AIRBAG (IGN) FUSE BLK/WHT WIRE BODY CONTROL MODULE (UNDER FRONT END OF CENTER CONSOLE, UNDER DASH) BRN WIRE CASE GROUND COMPUTER DATA LINES SYSTEM DK GRN WIRE DRIVER SEAT BELT BUCKLE SWITCH DRIVER SEAT BELT PRETENSIONER DRIVER SEAT POSITION SENSOR GROUND SERIAL DATA IGNITION 1 GRY WIRE HIGH CONTROL LOW CONTROL HOT AT ALL TIMES HOT IN RUN OR START LOW REF SIGNAL LOW REF SIGNAL LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PASSENGER SEAT BELT PRETENSIONER PNK WIRE PPL RED/WHT WIRE SHORTING BAR SHORTING CLIP TAN WIRE TAN/ORG WIRE TAN/WHT WIRE TWISTED PAIR WIRES VOLTAGE SIGNAL SIGNAL VOLTAGE WHT WIRE YEL WIRE YEL/BLK WIRE

AIR BAG INDICATOR BODY CONTROL MODULE (UNDER FRONT END OF CENTER CONSOLE, UNDER DASH) BRN WIRE COMPUTER DATA LINES SYSTEM DK GRN WIRE GRY WIRE INFLATABLE RESTRAINT I/P MODULE INFLATABLE RESTRAINT STEERING WHEEL MODULE INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL SHORTING CLIP INSTRUMENT PANEL CLUSTER LOGIC ORG/ WIRE PNK WIRE PPL SERIAL DATA SERIAL DATA (-) SERIAL DATA (+) SHORTING BAR SHORTING CLIP STAGE 1 STAGE 2 TAN WIRE TWISTED PAIR WIRES VEHICLE COMMUNICATIONS INTERFACE MODULE (BEHIND RIGHT SIDE OF DASH) W/ VEHICLE COMMUNICATIONS W/O VEHICLE COMMUNICATIONS WHT WIRE YEL WIRE

16 18 TRNK REL RLY CTRL RR COMPT LID AJAR SW TRUNK REL SW PWR LFTGT REL SW SIG 37 38 LO SPD GMLAN SER DATA LO SPD GMLAN SER DATA AJAR BLK WIRE BLU WIRE BODY CONTROL MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DK GRN WIRE EXTERIOR REAR COMPARTMENT LID RELEASE SWITCH HOT AT ALL TIMES LO SPD GMLAN SER DATA LO SPD GMLAN SER DATA LOGIC LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE RADIO REAR COMPARTMENT LID LATCH REAR COMPARTMENT/ LIFTGATE RELEASE SWITCH REAR FUSE BLOCK (LEFT REAR QUARTERPANEL) REMOTE CONTROL DOOR LOCK RECEIVER (ON REAR PACKAGE SHELF) SERIAL DATA TAN WIRE TRUNK AJAR TRUNK FUSE 22 TRUNK RELAY 36 WHT WIRE