Chevrolet Malibu VI (2003-2006) instrument panel cluster Wiring diagrams

ABS FUSE 15 ABS FUSE 24 ABS IND. BAT BAT IGN 1 VOLTAGE BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (LEFT FRONT OF ENGINE COMPT) HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT PANEL CLUSTER LEFT FRONT WHEEL SPEED SENSOR LEFT REAR WHEEL SPEED SENSOR LOGIC LOW SPEED GMLAN LOW SPEED GMLAN SERIAL DATA LOW TRACTION IND LT BLU WIRE NCA WIRE ORG/ WIRE PNK WIRE RED/BLK WIRE RIGHT FRONT WHEEL SPEED SENSOR RIGHT REAR WHEEL SPEED SENSOR SERIAL DATA SIG GRD SIG GRD TAN WIRE TAN/BLK WIRE TRACTION OFF IND BRAKE IND UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

1 2 3 4 5 6 ACC VOLT SIG BATTERY 5 VOLT REF ACC VOLT AJAR AJAR SWITCH SIGNAL BLK WIRE BLK/WHT WIRE BRN WIRE CLUSTER/ THEFT FUSE CNTRL BEAM REL COMPUTER DATA LINES SYSTEM CONTROL BODY MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK GRN WIRE DOOR LOCK FUSE DOOR LOCK LCK/UNLCK DR DOOR KEY CYL RESISTOR 620 OHMS DRIVER DOOR LOCK ACTUATOR DRIVER DOOR LOCK SWITCH GROUND LOW SPD SERIAL LOW SPD SERIAL GRY WIRE GRY/BLK WIRE HEADLIGHT SYSTEM HEADLP HIGH HIGH SPD GMLAN SERIAL DATA HORN RELAY CONTROL HORNS SYSTEM HOT AT ALL TIMES HVAC CONTROL MODULE IGNITION SWITCH INSTRUMENT PANEL CLUSTER KEY-IN IGNITION SWITCH LEFT REAR DOOR LOCK ACTUATOR LOCK LOGIC LOW SPD LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OFF OFF/RUN/ CRANK SIG ORG/BLK WIRE PARK LP RELAY CNTRL PASSENGER LOCK ACTUATOR PASSENGER LOCK SWITCH PPL PPL UNLOCK 8 6 RADIO REAR FUSE BLOCK RED/WHT WIRE RELEASE SYSTEM REMOTE CONTROL DOOR LOCK RECEIVER (ON REAR PACKAGE SHELF) RIGHT REAR DOOR LOCK ACTUATOR RUN WIRE SECURITY IND SERIAL DATA SERIAL DATA GMLAN SIGNAL SIGNAL KEY SWITCH DRVR DR SW SIG LID AJAR RR COMPT TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THEFT DETERRENT CONTROL MODULE (ATTACHED TO IGNITION KEY CYLINDER) THEFT RESISTOR UNLOCK VEHICLE COMMUNICATIONS INTERFACE MODULE W/ AUTO AIR CONDITIONING W/ VEHICLE COMMUNI- CATIONS W/O AUTO AIR CONDITIONING W/O VEHICLE COMMUNI- CATIONS WHT WIRE WHT/BLK WIRE

BLK WIRE BODY CONTROL MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) C/FAN 1 FUSE 17 C/FAN 2 FUSE 18 COMPUTER DATA LINES SYSTEM COOL LEV SW SIG COOL SER/ PAR RELAY 29 COOL/ FAN 1 RELAY 28 COOL/ FAN 2 RELAY 30 COOLANT LEVEL SWITCH (ON ENG COOLANT SURGE TANK) COOLANT TEMP IND DK BLU WIRE DK GRN WIRE DRIVER INFORMATION CENTER GRY WIRE HIGH SPEED COOLING FAN RELAY CTRL HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER LEFT COOLING FAN LOW COOLANT LOW SPD DATA LOW SPD DATA LOW SPD DATA LOW SPEED COOLING FAN RELAY CTRL LT BLU WIRE LT GRN WIRE RADIO RIGHT COOLING FAN UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE

5-VOLT REFERENCE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (RIGHT END OF DASH) BRAKE PEDAL POSITION SENS SIG BRAKE PEDAL POSITION SENSOR (ON BRAKE PEDAL SUPPORT) BRN WIRE COMPUTER DATA LINES SYSTEM CRUISE CONTROL SWITCH SIGNAL CRUISE INDICATOR DK GRN WIRE GMLAN GROUND GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/CRANK RELAY ENERGIZED IBCM (R/C) FUSE 21 IBCM 2 FUSE 25 INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL INSTRUMENT PANEL CLUSTER INTERIOR LIGHTS FUSE 25 LEFT STEERING WHEEL CONTROLS LOGIC LOW REFERENCE LOW SPEED GMLAN SERIAL DATA PNK WIRE POWERTRAIN CONTROL MODULE (AT FRONT OF BATTERY) PPL R/A RED/BLK WIRE RIGHT STEERING WHEEL CONTROLS RUN/CRANK FUSE S/C STOP LAMP SWITCH SIGNAL STP SIG SWITCH SIGNAL TAN WIRE THROTTLE ACTUATOR CONTROL MODULE (ON INTAKE MANIFOLD) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPARTMENT) VSS SIG W/ 2.2L W/ 3.5L W/O ACCESSORY CONTROL STEERING WHEEL W/ ACCESSORY CONTROL STEERING WHEEL WHT WIRE YEL WIRE

1 2 HI SPD SER DATA + HI SPD SER DATA - BLK WIRE BODY CONTROL MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRAKE LAMP DIAGNOSTIC RESISTOR BRN WIRE CHIME CLUSTER/ THEFT FUSE COMPUTER DATA LINES SYSTEM DK DK DK GRN WIRE EXTENDED SEDAN GRN WIRE GRY WIRE HAZARD SWITCH HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER LEFT BACKUP LAMP LEFT LICENSE LAMP RIGHT LICENSE LAMP LEFT TAIL LAMP LEFT TAIL/ STOP/ TURN SIGNAL LAMP LEFT TURN SIG IND LICENSE LAMP LOW SPD SER DATA LOW SPD SER DATA LT BLU WIRE NCA WIRE POWERTRAIN CONTROL MODULE (FRONT OF BATTERY) RED WIRE RIGHT BACKUP LAMP RIGHT TAIL LAMP RIGHT TAIL/ STOP/ TURN SIGNAL LAMP RIGHT TURN SIG IND SEDAN TAN WIRE TAN/BLK WIRE UNDER- HOOD FUSE BLOCK UNDER- HOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

2.2L, 3.5L A/C COMPRESSOR CLUTCH BATTERY BLK WIRE BODY CONTROL MODULE BRAKE FLUID LEVEL SWITCH BRAKE LAMP DIAGNOSTIC RESISTOR COOL SER/PAR RELAY 29 COOLANT LEVEL SWITCH DATA LINK CONNECTOR FRT FOG RELAY 36 HORN SWITCH HVAC CONTROL MODULE IGNITION CONTROL MODULE INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL INSTRUMENT PANEL CLUSTER LEFT STEERING WHEEL CONTROLS MASS AIR FLOW/ INTAKE AIR SENSOR PARK/ NEUTRAL POSITION SWITCH POWER STEERING CONTROL MODULE POWERTRAIN CONTROL MODULE RADIO RIGHT COOLING FAN RIGHT STEERING WHEEL CONTROLS RUN/CRANK RELAY 32 SEDAN EXTENDED SEDAN THEFT DETERRENT CONTROL MODULE TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK W/ ACCESSORY ELECTRONIC SYSTEM W/O ACCESSORY ELECTRONIC SYSTEM W/ CRUISE W/O CRUISE WHT WIRE WINDSHIELD WIPER MOTOR WIPER 1 RELAY 39 WIPER 2 RELAY 40

16 33 3 192 317 1970 FOG LMP SW SIG FOG LMP RLY CTRL LOW BEAM IN 29 19 1969 317 HIGH BEAM IN FOG LMP RLY CTRL AMBIENT LIGHT SENSOR BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRN WIRE COMPUTER DATA LINES SYSTEM DK GRN WIRE FOG LAMP SWITCH FRT FOG LP FUSE 10 FRT FOG RELAY 36 FTP GRN WIRE HEAD HIGH BEAM IND HIGH BEAM RELAY 35 HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER LEFT HIGH BEAM HEADLAMP LEFT LOW BEAM HEADLAMP LH HIGH FUSE 11 LH LOW FUSE 7 LOW BEAM RELAY 38 LT GRN/BLK WIRE OFF AUTO PARK ORG/ WIRE PNK PNK WIRE PNK/WHT WIRE PPL PPL PPL/WHT WIRE RH HIGH FUSE 12 RH LOW FUSE 9 RIGHT FRONT FOG LAMP LEFT FRONT FOG LAMP RIGHT HIGH BEAM HEADLAMP RIGHT LOW BEAM HEADLAMP SER DATA TAN WIRE TAN/WHT WIRE TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/ AUTO A/C W/ MANUAL A/C WHT WIRE YEL WIRE YEL/BLK WIRE

ACC VLT SIG AIRBAG (BATT) FUSE BLK WIRE BODY CONTROL MODULE BODY CONTROL MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRN WIRE CLUSTER/ THEFT FUSE DATA LINK CONNECTOR FROM A/C CLU FUSE 1 (DIAGRAM 2 OF 5) HIGH BEAM RELAY 35 HORN FUSE 8 HORN RELAY 37 HVAC CONTROL MODULE HVAC CTRL (BATT) FUSE IBCM 1 FUSE 20 IGN 1 VLT SIG IGN SENSOR FUSE IGNITION SWITCH INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE INSTRUMENT PANEL CLUSTER KEY-IN IGNITION SWITCH LOGIC LOW BEAM RELAY 38 OFF OFF/CRNK/RUN PNK WIRE RADIO RADIO FUSE RED WIRE RUN WIRE THEFT DETERRENT CONTROL MODULE THEFT DETERRENT CONTROL MODULE INSTRUMENT PANEL CLUSTER THEFT RESISTOR TO RUN RLY FUSE 19 (DIAGRAM 4 OF 5) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT WIRE

1 2 3 4 B+ SERIAL DATA 1 3 AJAR 4 6 AJAR AJAR AJAR SWITCH PASS DR ANTENNA BLK WIRE CNTRL ACT UNLOCK DOOR LOCK DK GRN WIRE DOOR LOCK ACT LOCK CNTRL DOOR LOCK FUSE DOOR LOCK LCK/UNLCK DR DOOR KEY CYL RESISTOR 620 OHMS DRIVER DOOR LOCK ACTUATOR DRIVER DOOR LOCK SWITCH DRVR DR AJAR SWITCH SIGNAL GROUND GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT AT ALL TIMES REAR FUSE BLOCK RKE/XM/ DVD/UGD FUSE 16 INSTRUMENT PANEL CLUSTER LEFT REAR DOOR LOCK ACTUATOR LOCK LOGIC LOW SPD LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE PASSENGER LOCK ACTUATOR PASSENGER LOCK SWITCH PPL PPL UNLOCK 8 6 RADIO REAR FUSE BLOCK RED WIRE REMOTE CONTROL DOOR LOCK RECEIVER (IF EQUIPPED) (ON REAR PACKAGE SHELF) RIGHT REAR DOOR LOCK ACTUATOR SERIAL DATA SERIAL DATA GMLAN SERIAL DATA GMLAN LOW SPD SIGNAL SIGNAL KEY SWITCH DRVR DR TAN WIRE TAN/WHT WIRE TRUNK REL RELAY CONTROL TRUNK RELEASE RELAY UNLK CNTRL LOCK ACT DRVR DR UNLOCK VEHICLE COMMUNICATIONS INTERFACE MODULE W/O VEHICLE COMMUNI- CATIONS W/ VEHICLE COMMUNICATIONS WHT WIRE

AIR BAG INDICATOR BODY CONTROL MODULE (UNDER FRONT END OF CENTER CONSOLE, UNDER DASH) BRN WIRE COMPUTER DATA LINES SYSTEM DK GRN WIRE GRY WIRE INFLATABLE RESTRAINT I/P MODULE INFLATABLE RESTRAINT STEERING WHEEL MODULE INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL SHORTING CLIP INSTRUMENT PANEL CLUSTER LOGIC ORG/ WIRE PNK WIRE PPL SERIAL DATA SERIAL DATA (-) SERIAL DATA (+) SHORTING BAR SHORTING CLIP STAGE 1 STAGE 2 TAN WIRE TWISTED PAIR WIRES VEHICLE COMMUNICATIONS INTERFACE MODULE (BEHIND RIGHT SIDE OF DASH) W/ VEHICLE COMMUNICATIONS W/O VEHICLE COMMUNICATIONS WHT WIRE YEL WIRE