Chevrolet Malibu VI (2003-2006) battery Wiring diagrams

2 1 CELL PHONE LOW REF CELL PHONE VOICE SIG ANTENNA ANTENNA AMPLIFIER MODULE BATTERY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRN WIRE CELL PHONE LOW REF CELL PHONE VOICE SIG COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE GMLAN SER DATA GMLAN SER DATA GROUND GRY WIRE HOT AT ALL TIMES LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LOGIC LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE RADIO RADIO ANTENNA RADIO FUSE REAR WINDOW ANTENNA MODULE RED WIRE RED/WHT WIRE RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER SUPPLY VOLTAGE TAN WIRE VEHICLE COMMUNICATION INTERFACE MODULE (W/ ON STAR) WHT WIRE YEL WIRE

1180 OHMS 1270 OHMS 2370 OHMS 294 OHMS 348 OHMS 475 OHMS 5060 5060 COMPUTER DATA LINES SYSTEM 6980 OHMS 715 OHMS BARE BARE 10 11 12 BATTERY BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CELL PHONE LOW REF CELL PHONE VOICE SIG COMPUTER DATA LINES SYSTEM DIGITAL RADIO ANTENNA DIGITAL RADIO RECEIVER (W/ DIGITAL AUDIO SYSTEM) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GMLAN SER DATA GMLAN SER DATA GRN WIRE GROUND GROUND AUDIO COMMON DRAIN WIRE GRY WIRE HOT AT ALL TIMES INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL LEFT STEERING WHEEL CONTROLS LT AUDIO SIG (+) RT AUDIO SIG (+) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PNK/BLK WIRE RADIO RADIO ANTENNA RADIO FUSE REAR BLOCK FUSE (LEFT REAR OF PASSENGER COMPT) RED WIRE RED/WHT WIRE RIGHT STEERING WHEEL CONTROLS RKE/XM/ DVD/UGD FUSE 16 TAN WIRE TAN/WHT WIRE VEHICLE COMMUNICATION INTERFACE MODULE (W/ ON STAR) WHT WIRE WHT/BLK WIRE YEL WIRE

2 1 CELL PHONE LOW REF CELL PHONE VOICE SIG 5060 5060 COMPUTER DATA LINES SYSTEM ANTENNA AMPLIFIER MODULE BARE BATTERY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DIGITAL RADIO ANTENNA DIGITAL RADIO RECEIVER (W/ DIGITAL AUDIO SYSTEM) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EXTENDED SEDAN GMLAN SER DATA GMLAN SER DATA GROUND GROUND AUDIO COMMON DRAIN WIRE GRY WIRE HOT AT ALL TIMES LOGIC ANTENNA LT AUDIO SIG (+) RT AUDIO SIG (+) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE RADIO RADIO ANTENNA RADIO FUSE REAR WINDOW ANTENNA MODULE RED WIRE RED/WHT WIRE RKE/XM/ DVD/UGD FUSE 16 SEDAN SUPPLY VOLTAGE TAN WIRE TAN/WHT WIRE VEHICLE COMMUNICATION INTERFACE MODULE (W/ ONSTAR) WHT WIRE WHT/BLK WIRE YEL WIRE

2 1 CELL PHONE LOW REF CELL PHONE VOICE SIG 5060 5060 COMPUTER DATA LINES SYSTEM BARE BATTERY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DIGITAL RADIO ANTENNA DIGITAL RADIO RECEIVER (W/ DIGITAL AUDIO SYSTEM) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GMLAN SER DATA GMLAN SER DATA GROUND AUDIO COMMON DRAIN WIRE GRY WIRE HOT AT ALL TIMES LT AUDIO SIG (+) RT AUDIO SIG (+) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/BLK WIRE PNK/BLK WIRE PPL RADIO RADIO ANTENNA RADIO FUSE REAR BLOCK FUSE (LEFT REAR OF PASSENGER COMPT) RED WIRE RED/WHT WIRE REM RADIO CTRL SIG RKE/XM/ DVD/UGD FUSE 16 RSA ENABLE SIG TAN WIRE TAN/WHT WIRE VEHICLE COMMUNICATION INTERFACE MODULE (W/ ON STAR) WHT WIRE WHT/BLK WIRE YEL WIRE

A/C SYSTEM A/T SHIFT LCK CTRL SOL SUPPL VOLTAGE AMBIENT AIR TEMP SENS SIG ANTI-LOCK BRAKES SYSTEM BATTERY BLK WIRE BODY CONTROL MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRN/WHT WIRE COMPUTER DATA LINES SYSTEM EXTERIOR LIGHTS SYSTEM COOLANT LEVEL SW SIG DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DOOR LOCKS FUSE DOOR LOCKS SYSTEM DRIVER DOOR KEY SW SIG ENGINE CONTROLS, INSTRUMENT CLUSTER SYSTEMS EXTENDED SEDAN EXTERIOR LIGHTS SYSTEM DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM EXTERIOR LIGHTS SYSTEM TRUNK, TAILGATE, FUEL DOORS SYSTEM GROUND GROUND HORN RLY CTRL GRY/BLK WIRE HEADLAMP HI BEAM RLY CTRL HEADLIGHTS SYSTEM HORNS SYSTEM HOT AT ALL TIMES INTERIOR LIGHTS FUSE LF DOOR AJAR SW SIG LOGIC LOW SPD GMLAN SER DATA LEFT DRL/TURN SUPPLY VOLTAGE LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/BLK WIRE PARK LAMP RELAY CTRL DOOR LOCK/UNLOCK SIGNAL DOOR LOCK/UNLOCK SIGNAL PNK WIRE PNK/BLK WIRE PPL REAR COMPT LID AJAR SW SIG FOG LAMP RLY CTRL REV LAMP RLY CTRL TRUNK RELEASE RLY CTRL SEDAN SHIFT INTERLOCK SYSTEM STOP LAMP SUPPLY VOLTAGE STOP LAMP VOLTAGE TAN WIRE TAN/WHT WIRE TRACTION CTRL SW SIG TRUNK KEY SWITCH SIG LIFT GATE REL SW SIG TRUNK, TAILGATE, FUEL DOORS SYSTEM TRUNK, TAILGATE, FUEL DOORS SYSTEM HEADLIGHTS SYSTEM W/ AUTO A/C W/ MANUAL A/C W/ TRACTION CONTROL WHT WIRE WHT/BLK WIRE WINDSHIELD WIPER SW SIG 2 WIPER/WASHER SYSTEM YEL WIRE

A/C SYSTEM ACCESSORY VOLTAGE BATTERY BATTERY BATTERY BLK WIRE BLOWER MTR SUPPLY VOLTAGE BODY CONTROL MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRN WIRE DK BLU WIRE GROUND GRY WIRE I/P LAMP SUPPLY VOLTAGE IGNITION 3 VOLTAGE LOGIC LT GRN WIRE ORG/ WIRE PNK IGNITION 1 VOLTAGE WIRE PNK PNK PPL IGNITION 1 VOLTAGE WIRE POWER DISTRIBUTION POWER DISTRIBUTION, A/C SYSTEM POWER DISTRIBUTION, ANTI-THEFT SYSTEM POWER DISTRIBUTION, ANTI-THEFT SYSTEM POWER DISTRIBUTION, CRUISE CONTROL SYSTEM POWER DISTRIBUTION, ELECTRONIC POWER STEERING SYSTEM POWER DISTRIBUTION, NAVIGATION SYSTEM POWER DISTRIBUTION, SEATS SYSTEM POWER DISTRIBUTION, SEATS SYSTEM POWER DISTRIBUTION, SOUND SYSTEM POWER DISTRIBUTION, WIPER/WASHER SYSTEM RED/BLK WIRE RED/WHT WIRE SERIAL DATA HIGH BLOWER MTR CTRL PARK LAMP SUPPLY VOLTAGE W/ MANUAL A/C WINDSHIELD WASHER PUMP CTRL I/P LAMP SUPPLY VOLTAGE IGNITION 3 VOLTAGE WIPER/WASHER SYSTEM INTERIOR LIGHTS SYSTEM POWER DISTRIBUTION, A/C SYSTEM YEL WIRE

AJAR AJAR AJAR BATTERY BLK WIRE BODY CONTROL MODULE (BCM) (BELOW RIGHT SIDE OF DASH) CARGO LAMP CARGO LAMP SWITCH COURTESY V+ CTSY LP CTRL DOME DOME/ READING LAMP READING DOOR DOOR AJAR EXTENDED SEDAN FRONT COURTESY/ READING LAMPS FRONT PASSENGER DOOR LATCH FRONT PASSENGER DOOR LOCK ACTUATOR GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES INTERIOR LIGHTS FUSE LEFT REAR DOOR LOCK ACTUATOR RIGHT REAR DOOR LOCK ACTUATOR LEFT VANITY MIRROR LAMP LF DOOR AJAR LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE OFF ORG/ WIRE ORG/BLK WIRE PPL REAR COMP- ARTMENT COURTESY LAMP REAR COMP- ARTMENT LID LATCH REAR FUSE BLOCK REAR LID AJAR RIGHT VANITY MIRROR LAMP SEDAN TAN WIRE TAN/WHT WIRE WHT WIRE WHT/BLK WIRE

2.2L, 3.5L A/C COMPRESSOR CLUTCH BATTERY BLK WIRE BODY CONTROL MODULE BRAKE FLUID LEVEL SWITCH BRAKE LAMP DIAGNOSTIC RESISTOR COOL SER/PAR RELAY 29 COOLANT LEVEL SWITCH DATA LINK CONNECTOR FRT FOG RELAY 36 HORN SWITCH HVAC CONTROL MODULE IGNITION CONTROL MODULE INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL INSTRUMENT PANEL CLUSTER LEFT STEERING WHEEL CONTROLS MASS AIR FLOW/ INTAKE AIR SENSOR PARK/ NEUTRAL POSITION SWITCH POWER STEERING CONTROL MODULE POWERTRAIN CONTROL MODULE RADIO RIGHT COOLING FAN RIGHT STEERING WHEEL CONTROLS RUN/CRANK RELAY 32 SEDAN EXTENDED SEDAN THEFT DETERRENT CONTROL MODULE TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK W/ ACCESSORY ELECTRONIC SYSTEM W/O ACCESSORY ELECTRONIC SYSTEM W/ CRUISE W/O CRUISE WHT WIRE WINDSHIELD WIPER MOTOR WIPER 1 RELAY 39 WIPER 2 RELAY 40

12 43 55 12 LOW REF FUEL LEVEL PPL 15 1 2 6 15 1 2 40 SERIAL DATA SERIAL BUS + SERIAL BUS - MIL CTRL 2 32 3 4 SERIAL DATA SERIAL DATA BELT SWITCH LOW REF 2.2L 3 1440 PNK WIRE 3.5L 3.5L, 2.2L 5060 1807 5057 5016 COMPUTER DATA LINES SYSTEM ABS IND. AIR BAG IND BATT IND BATTERY BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRAKE FLUID LEVEL BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE IND BRN/WHT WIRE CLUSTER/ THEFT FUSE COMPUTER DATA LINES SYSTEM COOLANT TEMP IND CRUISE IND DK GRN WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMP FUEL LEVEL GROUND GROUND SERIAL DATA SERIAL DATA BATTERY GRY WIRE HIGH BEAM IND HOT AT ALL TIMES IGNITION IGNITION (RUN/ START) IGNITION BATTERY IGNITION SWITCH ILLUMINATION INSTRUMENT PANEL CLUSTER (IPC) LEFT TURN IND LOGIC LOW REF LOW REF ECT SENS 52 35 LOW TRACTION IND LT BLU WIRE MALFUNCTION IND LAMP OFF OIL PRESS OIL PRESSURE IND ORG/BLK WIRE PARK BRAKE SWITCH (ON PARK BRAKE ASSEMBLY) PNK WIRE POWERTRAIN CONTROL MODULE (IN FRONT OF BATTERY) PPL RED/WHT WIRE RIGHT TURN IND RUN WIRE SEAT BELT IND SECURITY IND SERIAL BUS+ SERIAL DATA SECURITY IND SIGNAL PARK BRAKE SWITCH SERVICE VEHICLE SOON IND SPEEDOMETER TACHOMETER TAN WIRE TAN/BLK WIRE TRACTION OFF IND TRIP RESET TRIP RESET SWITCH VF DISPLAY 000000 TRIP YEL WIRE

26 58 PPL A/T SHIFT LOCK CONTROL ASSEMBLY ADJUSTABLE PEDAL POSITION SWITCH BATTERY BLK WIRE BODY CONTROL MODULE (BCM) (BELOW RIGHT SIDE OF DASH) BRN WIRE DIMMER SIG LOW REF DIMMER SWITCH DK GRN WIRE DK PPL DRIVER DOOR LOCK SWITCH DRIVER HEATED SEAT SWITCH PASSENGER HEATED SEAT SWITCH DRIVER WINDOW SWITCH FOG LAMP SWITCH GRN WIRE GRY WIRE HAZARD SWITCH HOT AT ALL TIMES HVAC CONTROL MODULE I/P LAMP V+ ILLUM ILLUM (4 BULBS) INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL INSTRUMENT PANEL CLUSTER (IPC) INTERIOR LIGHTS FUSE LEFT STEERING WHEEL CONTROLS LOGIC NCA WIRE OUTSIDE REARVIEW MIRROR SWITCH REAR COMP- ARTMENT/ LIFTGATE RELEASE SWITCH PARK LPS FUSE 6 PARK LPS RELAY 27 PASS- ENGER DOOR LOCK SWITCH PASS- ENGER WINDOW SWITCH PK LAMP CTRL PK LAMP V+ REAR SEAT AUDIO CONTROLLER RIGHT STEERING WHEEL CONTROLS TRACTION CONTROL SWITCH WHT WIRE