Chevrolet Malibu V facelift (2000-2003) hot in run or start Wiring diagrams

1-2 SHIFT SOL 2-3 SHIFT SOL ANTI-LOCK BRAKES SYSTEM AUTO TRANS FUSE AUTOMATIC TRANSAXLE AUTOMATIC TRANSAXLE FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSAXLE FLUID TEMPERATURE SENSOR AUTOMATIC TRANSAXLE INPUT SHAFT SPEED SENSOR BLK WIRE BLK/WHT WIRE BODY FUNCTION CONTROLLER BRN WIRE BRN/WHT WIRE CRUISE CONTROL BRAKE SWITCH TCC/ BRAKE SWITCH CRUISE CONTROL SYSTEM CRUISE FUSE DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ENGINE COOLANT TEMPERATURE SENSOR (TOP REAR OF ENGINE) FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ACC, RUN OR START HOT IN RUN HOT IN RUN OR START INSTRUMENT CLUSTER IPC/ BFC ACC FUSE LEFT I/P JUNCTION BLOCK (LEFT END OF DASH) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SENSOR MALFUNCTION INDICATOR LAMP MAP SENSOR ORG/ WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (SIDE OF TRANSAXLE) PCM PCM BATT FUSE PCM IGN FUSE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF DASH) PPL PPL/ PPL/ PPL/ PRESSURE CONTROL SOL TCC PWM SOL RED WIRE RED/BLK WIRE REV,D,2,1 RIGHT I/P JUNCTION BLOCK (RIGHT END OF DASH) TAN WIRE TCC RELEASE THROTTLE POSITION SENSOR (TOP REAR OF ENGINE) UNDERHOOD JUNCTION BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (REAR OF TRANSAXLE) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1998-00 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) ELECTRONIC BRAKE CONTROL MODULE PPL FUSE GROUND PACK GROUND PACK HOT IN ACC, RUN OR START HOT IN RUN OR START IGNITION KEY INSTRUMENT CLUSTER IPC/BFC LEFT I/P JUNCTION BLOCK (LEFT SIDE OF DASH, LT BLU/BLK WIRE PASSLOCK CYLINDER (LEFT SIDE OF DASH) PASSLOCK GND PASSLOCK REF V PASSLOCK SIG PNK IGN 1 WIRE PNK WIRE POWERTRAIN CONTROL MODULE (BELOW LEFT SIDE OF DASH) PPL IGN PPL IGN (0) PPL PPL PPL SERIAL DATA CLASS 2 PPL SRL DATA CLASS 2 PPL/ PPL/ PPL/ SENSING, DIAG- NOSTIC MODULE SERIAL DATA RECEIVE SERIAL DATA TRANS SRL DATA RECEIVE SRL DATA TRANS THEFT SYSTEM IND UNDERHOOD JUNCTION BLOCK (ON LEFT SIDE OF ENG COMPT) A/C BFC WHT WIRE YEL WIRE

B/U LMP FUSE BLK WIRE HOT IN RUN OR START LEFT BACKUP LAMP LEFT REAR LAMP ASSEMBLY LT GRN WIRE PARK/NEUTRAL POSITION SWITCH (ON SIDE OF TRANSAXLE) PNK WIRE RIGHT BACKUP LAMP RIGHT I/P JUNCTION BLOCK (RIGHT END OF DASH) RIGHT REAR LAMP ASSEMBLY UNDERHOOD JUNCTION BLOCK (LEFT SIDE OF ENGINE COMPT)

A/C BFC FUSE AIR CONDITIONING SYSTEM ALC RELAY CONTROL FOG LIGHT RELAY CONTROL PARK LAMP SW SIG ON HORN RLY CTRL AMBIENT LIGHT SENSOR (ON TOP OF DASH TRIM PAD) ANTI-THEFT SYSTEM INSTRUMENT CLUSTER SYSTEM EXTERIOR LIGHTS SYSTEM BFC BATT FUSE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BELOW RIGHT SIDE OF DASH, NEAR BLOWER MOTOR) BRAKE FLUID LEVEL SWITCH (ON BRAKE MASTER CYLINDER RESERVOIR) BRN WIRE COMPUTER DATA LINES SYSTEM DOOR LOCKS SYSTEM ANTI-THEFT SYSTEM CRUISE FUSE DK BLU WIRE DK GRN/WHT WIRE DOOR LOCK UNLOCK AMBIENT LIGHT SENSOR SIGNAL DOOR LOCKS SYSTEM INSTRUMENT CLUSTER SYSTEM HEADLIGHTS SYSTEM DRIVER DR UNLOCK CTRL SERIAL DATA SPI DATA TRANSMIT FOG LIGHT SWITCH INPUT DRL RELAY CONTROL ENGINE COOLANT LEVEL SWITCH (ON ENGINE COOLANT SURGE TANK) FUSE GROUND SPLICE PACK GRY/BLK WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM HORNS SYSTEM HORNS SYSTEM HOT AT ALL TIMES HOT IN ACCY, RUN, OR START HOT IN RUN HOT IN RUN OR START IGNITION SWITCH INSTRUMENT CLUSTER SYSTEM DOOR LOCKS SYSTEM INT LPS FUSE IPC/BFC KEY WARNING SWITCH LEFT FRONT DOOR AJAR INPUT IGNITION 3 POSITIVE VOLTAGE LEFT I/P JUNCTION BLOCK LOW BEAM HEADLIGHT INPUT LOW ENGINE COOLANT INPUT A/C SWITCH REQUEST INPUT LOW WASHER SOLVENT INPUT SERIAL DATA SPI CLOCK ALL DR LOCK CTRL LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK BRAKE FLUID SW IN INADVERTENT POWER INPUT WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE PPL PPL IGNITION 0 POSITIVE VOLTAGE PARK LIGHT RELAY CTRL REAR COMPT RELEASE CTRL RIGHT I/P JUNCTION BLOCK TRUNK RELEASE CIRCUIT UNDERHOOD JUNCTION BLOCK WARNING SYSTEMS SYSTEM WARNING SYSTEMS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM WASHER FLUID LEVEL SENSOR (INSIDE LEFT FRONT FENDER) WHT WIRE YEL WIRE YEL/BLK WIRE

ALC PARK LMP CNTRL PRK LMP RLY BLK WIRE BODY CONTROL MODULE (BCM) (BELOW RIGHT SIDE OF DASH) BRAKE SWITCH (ON BRAKE PEDAL SUPPORT) BRN WIRE DK BLU WIRE GRY WIRE GRY/BLK WIRE HAZARD HAZARD LPS FUSE HAZARD SWITCH HIGH MOUNTED STOP LAMP ASSEMBLY HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LEFT LEFT FRONT PARK/TURN LAMP LEFT FRONT SIDE MARKER LAMP LEFT I/P JUNCTION BLOCK (LEFT END OF DASH) STOP LPS FUSE LEFT REAR LAMP ASSEMBLY LEFT REAR TAIL/STOP LAMP LEFT REAR TURN SIGNAL LAMP LEFT TURN IND LICENSE LAMP LT BLU WIRE LT BLU/BLK WIRE NCA WIRE OFF ORG/ WIRE PARK LAMP RELAY PARK LPS FUSE PNK WIRE PPL PPL PPL PPL TURN SIG IN PRK HEAD RIGHT RIGHT FRONT PARK/TURN LAMP RIGHT FRONT SIDE MARKER LAMP RIGHT I/P JUNCTION BLOCK (RIGHT END OF DASH) RIGHT REAR LAMP ASSEMBLY RIGHT REAR TAIL/STOP LAMP RIGHT REAR TURN SIGNAL LAMP RIGHT TURN IND SPLICE PACK 301 SPOILER HIGH MOUNTED STOP LAMP TIMER TURN LPS FUSE TURN/HEADLAMP/ WIPER SWITCH UNDERHOOD JUNCTION BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE

5 VOLTS 73 72 63 60 PPL A/C BFC FUSE A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH DIODE A/C COMPRESSOR CLUTCH RELAY A/C DISABLE A/C ON IND A/C REFIGERANT PRESSURE SENSOR (ON FRONT OF ENGINE COMPT) A/C REQ INPUT A/C REQUEST A/C REQUEST IGN DEFOG CTRL BAT AIR TEMPERATURE ACTUATOR (TOP RIGHT SIDE OF DASH) BLK WIRE BLK/WHT WIRE BLOWER MOTOR BLOWER MOTOR RELAY BLOWER RESISTOR ASSEMBLY (BELOW RIGHT SIDE OF DASH) BLOWER SWITCH BODY CONTROL MODULE (BCM) (BELOW RIGHT SIDE OF DASH) BRN WIRE CLUTCH RLY CTRL COOL FAN 1 FUSE COOL FAN 2 FUSE COOL FAN FUSE COOLING FAN MODE RELAY COOLING FAN RELAY 1 COOLING FAN RELAY 2 DEFOG ON IND DEFOG REQUEST DEFOGGER SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GROUND GRY WIRE HEATER, A/C CONTROL ASSEMBLY HI BLO MOT FUSE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HOT IN RUN RIGHT I/P JUNCTION BLOCK (RIGHT END OF DASH) HVAC BLOWER FUSE HTR A/C IGN FUSE HTR OUT ILLUM HVAC BATT FUSE IGNITION LEFT COOLING FAN MOTOR LEFT FAN CTRL LEFT I/P JUNCTION BLOCK LEFT I/P JUNCTION BLOCK (LEFT END OF DASH) LT BLU WIRE LT GRN WIRE OFF ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (BELOW LEFT SIDE OF DASH, NEAR STEERING COLUMN) PPL RED/BLK WIRE RIGHT COOLING FAN MOTOR RIGHT FAN CTRL SENSOR GROUND SENSOR SIGNAL SER DATA CLS 2 STEP DIM TAN WIRE TEMP REQ UNDERHOOD JUNCTION BLOCK (LEFT SIDE OF ENGINE COMPT) WHT WIRE YEL WIRE

AUTOMATIC TRANSMISSION SHIFT LOCK CONTROL ACTUATOR (UNDER CENTER CONSOLE) B-U LMP/BTSI FUSE BLK WIRE BRAKE SWITCH (OPEN WITH BRAKE PEDAL DEPRESSED) (ON BRAKE PEDAL SUPPORT) DK GRN/WHT WIRE GROUND SPLICE PACK (RIGHT SIDE OF DASH) HOT IN RUN OR START LEFT I/P JUNCTION BLOCK (LEFT SIDE OF DASH, LT GRN WIRE PARK/ NEUTRAL POSITION SWITCH (ON SIDE OF PNK WIRE TRANSAXLE UNDERHOOD JUNCTION BLOCK

1-2 VALVE CTRL LOW FAN CTRL HIGH FAN CTRL CMP SENSOR ENGINE SPD SIG CKP SENSOR 13 14 15 16 17 18 19 20 PNK WIRE AUTOMATIC TRANSAXLE AUTOMATIC TRANSAXLE INPUT SHAFT SPEED SENSOR BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE COOLING FANS SYSTEM CRUISE CONTROL SYSTEM CRUISE DISABLE FUEL INJ 5 DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE EVAP PURGE FUEL INJ 1 2-3 VALVE CTRL FUEL INJ 3 FUEL INJ 2 LOW REF FUEL INJECTORS GRN WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN ACCY, RUN, OR START HOT IN RUN OR START IAC COIL B HIGH IC CONTROL IC CONTROL VSS OUTPUT PCM GROUND PCM GROUND IGN MOD FUSE 41 INJ 6 DRIVER SENSOR GROUND INSTRUMENT CLUSTER SYSTEM (VEHICLE SPEED SIGNAL) INTAKE AIR TEMPERATURE (IAT) SENSOR (IN AIR INTAKE DUCT, NEAR THROTTLE BODY) KNOCK SENSOR (LEFT SIDE OF ENGINE) LEFT I/P FUSE BLOCK LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MASS AIRFLOW SENSOR (ON AIR INTAKE DUCT ASSEMBLY) ORG/ WIRE ORG/BLK WIRE PCM ACC FUSE G PCM BATT FUSE 44 PCM GROUND SENSOR GROUND PNK 1 2 3 4 5 6 WIRE PNK TRANS RANGE A WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (BELOW LEFT SIDE OF DASH) PPL PPL IGN BATT VOLTAGE PPL SERIAL DATA PCM GROUND SENSOR GROUND ISS SENSOR ISS SENSOR VSS HIGH VSS LOW PPL/WHT WIRE RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR GROUND BRAKE SW INPUT SENSOR GROUND EGR SOL VALVE KS SIGNAL PPL TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TR SW INPUT B MAF SENSOR UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (REAR OF TRANSAXLE) WHT DK GRN/ WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

13 14 15 16 17 18 19 20 PNK WIRE 18 19 20 21 22 23 24 PPL AUTO TRANS FUSE 38 BLK WIRE BLK/WHT WIRE BRAKE SWITCH (ON BRAKE PEDAL SUPPORT) BRN WIRE BRN/WHT WIRE CRANKSHAFT POSITION SENSOR B (LOWER RIGHT OF ENGINE) CRUISE FUSE D DK BLU WIRE DK GRN/WHT WIRE ENGINE OIL LEVEL SWITCH (IN OIL PAN) F/P INJR FUSE 48 FUEL PUMP RELAY GRY WIRE GRY/BLK WIRE HOT IN RUN HOT IN RUN OR START IDLE AIR CONTROL (IAC) VALVE (ON TOP CENTER REAR OF ENGINE) IGNITION CONTROL MODULE (TOP RIGHT SIDE OF ENGINE) LEFT I/P FUSE BLOCK LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE ORG/BLK WIRE PARK/NEUTRAL POSITION SWITCH (SIDE OF TRANSAXLE) PCM IGN FUSE 39 PNK 1 2 3 4 5 6 WIRE PNK 30 31 WIRE PNK WIRE PPL PPL/WHT WIRE RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK TAN WIRE TAN/BLK WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE