Chevrolet HHR I (2005-2011) Wiring diagram engine performance 2.2l vin b

335 465 COOLING FANS SYSTEM 5 VOLT REF A/T ACC VOLT ACC VOLTAGE AIR CONDITIONING SYSTEM APP SENS 2 SIG IGN 1 VOLT BATT POSITIVE VOLT LOW REF BLK WIRE BODY CONTROL MODULE (BCM) BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION (CPP) SENSOR (M/T) CLUTCH POS SENS RTN CLUTCH RLY CTRL COMPUTER DATA LINES SYSTEM COOLING FAN RLY CTRL FUEL PUMP RLY CTRL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/WHT WIRE ECM TRANS FUSE 43 ECM/ TCM FUSE 25 ENABLE RLY CTRL ENGINE CONTROL MODULE (ECM) ENGINE OIL IND FUEL LEVEL SENSOR FUEL PUMP FUEL PUMP, SENDER ASSEMBLY (INSIDE FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON TOP OF FUEL TANK) GROUND GRY WIRE HOT AT ALL TIMES IGNITION SWITCH INSTRUMENT PANEL CLUSTER (IPC) LO SPD GMLAN SERIAL DATA LOGIC LOGIC (UNDER CENTER DASH, BELOW RADIO, ON RIGHT SIDE OF CENTER CONSOLE) LOW REF PRESS SENS SIG LOW REF PRESS SENS SIG SERIAL DATA (+) SERIAL DATA (-) CLUTCH POSITION LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE MAF SENS SIG MAL- FUNCTION IND MIL CTRL OFF ORG/ WIRE ORG/BLK WIRE ORG/GRN WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN RLY CTRL PPL PPL FUEL LVL SENS SIG PPL/WHT WIRE RED/WHT WIRE RLY COIL CTRL RUN WIRE RUN/ CRANK RELAY 51 SENS SPLY STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (IN ENGINE COMPARTMENT, NEXT TO LEFT STRUT TOWER) UP SHIFT IND VEHICLE SPEED SENSOR (VSS) (M/T) (AT REAR OF ENGINE, ON TOP OF TRANSMISSION) VSS SIGNAL HIGH VSS SIGNAL LOW WHT/BLK WIRE YEL WIRE

5 VOLT REF A/C REFRIGERANT PRESSURE SENSOR (ON A/C LINE, NEAR COMPRESSOR) BLK WIRE BLK/WHT WIRE CLUTCH POSITION CNSTR VENT FUSE 64 DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM FUSE 41 EXH FUSE 33 EVAP SOL CTRL FUEL PUMP FUSE 13 FUEL PUMP RELAY 19 GRY WIRE HOT AT ALL TIMES IAT SENS SIG IGN 1 VOLT INJ IGN MDL FUSE 45 LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP OF INTAKE MANIFOLD) ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE PPL/WHT WIRE PWR/TRN RELAY 26 RED/WHT WIRE SENS SIG START SIG STARTING/ CHARGING SYSTEM STOP LP SPLY VOLT TAN WIRE UNDERHOOD FUSE BLOCK (IN ENGINE COMPARTMENT, NEXT TO LEFT STRUT TOWER) WHT WIRE YEL WIRE

6 7 PPL BLK WIRE BRN WIRE BRN/WHT WIRE CRANKSHAFT POSITION (CKP) SENSOR (LOWER LEFT REAR OF ENGINE BLOCK) DK BLU WIRE DK GRN/WHT WIRE EXHAUST CAMSHAFT POSITION (CMP) ACTUATOR SOLENOID VALVE (TOP FRONT OF ENGINE) GRY WIRE INTAKE CAMSHAFT POSITION (CMP) ACTUATOR SOLENOID VALVE (TOP FRONT OF ENGINE) KNOCK SENSOR (KS) (LOWER LEFT REAR OF ENGINE BLOCK) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PLUG SPARK PNK WIRE PNK/BLK WIRE PPL PPL 9 10 11 PPL/WHT WIRE SPARK PLUG TAN WIRE YEL WIRE

5-VOLT REF 2 5-VOLT REF 2 5-VOLT REF EXHAUST CAM SOL CTRL INTAKE CAM SOL CTRL TAC MTR CTRL 1 6 7 PPL BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CKP SENS 1 SIG CMP INTAKE SENS CMP EXHAUST SENS DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE OIL PRESSURE (EOP) SWITCH (LOWER LEFT REAR OF ENGINE BLOCK) GRY WIRE GRY/WHT WIRE HEATED OXYGEN HEATED OXYGEN SENSOR IC 2 CTRL INTAKE SENS LOW REF EXHAUST SENS LOW REF IC 1 CTRL IC 3 CTRL IC 4 CTRL LOW REF KNOCK SENS SIG RTN KNOCK SENS SIG LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG LOW REF LOW REF LOW REF GEN FIELD DUTY CYCLE SIG NCA WIRE OIL PRESS SW SIG ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK/BLK WIRE PPL PPL 9 10 11 PPL/WHT WIRE SIG GND STARTING/ CHARGING SYSTEM STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TP SENS 1 SIG ECT SENS SIG TP SENS 2 SIG INTAKE CAM SOL RTN EXHAUST CAM SOL RTN YEL WIRE YEL/BLK WIRE