Chevrolet HHR I (2005-2011) off Wiring diagrams

2500 2501 COMPUTER DATA LINES SYSTEM 43 44 GMLAN SERIAL DATA + GMLAN SERIAL DATA - 6 10 7 8 FUEL INJ 1 CTRL FUEL INJ 2 CTRL FUEL INJ 3 CTRL FUEL INJ 4 CTRL A/T A/T M/T ACC VOLT B(+) BATTERY (B+) BETWEEN DOOR HINGES) BLK WIRE BLK/WHT WIRE BRN WIRE CLSTR FUSE 7 COMPUTER DATA LINES SYSTEM DK GRN WIRE ENGINE CONTROLS SYSTEM EXCEPT PANEL VAN FUSE 10 GMLAN SERIAL DATA GMLAN SERIAL DATA - GMLAN SERIAL DATA + GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HEADLIGHTS SYSTEM HOOD AJAR SWITCH HORN RELAY CTRL HORNS SYSTEM HOT AT ALL TIMES HVAC IGN KEY RESISTOR SIG IGNITION SWITCH INSTRUMENT PANEL CLUSTER (IPC) LEFT REAR ACCESS PANEL LATCH (REAR OF LEFT REAR ACCESS PANEL) LOGIC LOGIC SECURITY IND SUPPLY VOLTAGE LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT LT M/T OFF OFF/RUN/CRANK PANEL VAN PARK LAMP RELAY CTRL PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL 3 4 19 20 1 22 RED WIRE RED/WHT WIRE RELAY CTRL RIGHT FRONT DOOR JAMB SWITCH (RIGHT "A" PILLAR RUN WIRE SECURITY IND SECURITY INDICATOR TAN WIRE TAN/BLK WIRE TAN/WHT WIRE W/ ONSTAR W/ REMOTE KEYLESS ENTRY LOCK CONTROL WHT WIRE WHT/BLK WIRE WHT/RED WIRE XM/ ONSTAR FUSE 24

1140 1140 POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM 1440 8 POWER DISTRIBUTION SYSTEM INTERIOR LIGHTS SYSTEM 1539 1539 POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM 228 8 8 WIPER/WASHER SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM 8 8 8 1040 INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM ACC VOLTAGE BATT POS VOLTAGE BATT POS VOLTAGE (NOT USED) BATT POS VOLTAGE I/P LAMP SUPPLY VOLTAGE BLK WIRE BRN WIRE COURTESY LAMP CONTROL GROUND GRY WIRE I/P LAMP DIM SW SIG I/P LAMP DIM SW SIG BATT POS VOLTAGE IGN 1 VOLTAGE IGN 1 VOLTAGE IGN 1 VOLTAGE IGNITION SWITCH KEY-IN IGNITION SWITCH LOGIC OFF ORG/ WIRE PNK PNK IGN 1 VOLTAGE WIRE PNK PNK PNK PNK PNK IGN 1 VOLTAGE WIRE POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM RAP FUSE VOLT RED/WHT WIRE RUN WIRE RUN/CRANK RLY COIL CTRL RUN IGN 3 VOLT WHT WIRE WHT/BLK WIRE WINDSHIELD WASHER PUMP CTRL I/P LAMPS DIMMER SW SIG YEL WIRE

6 6 2.0L TURBO PNK PNK 9 2 EXCEPT 2.0L ALO ASA TURBO WIRE A/T AMP FUSE AUDIO AMPLIFIER BLK WIRE BODY CONTROL MODULE (BCM) BRN WIRE CHMSL RELAY CLSTR FUSE DISPLAY DRIVER INFORMATION CENTER (DIC) DRIVER INFORMATION CENTER (DIC) DISPLAY EPS/STR WHL CNTRL FUSE FROM UNDERHOOD FUSE BLOCK (DIAGRAM 1 OF 4) FUSE HVAC HVAC CONTROL ASSEMBLY HVAC/ IP IGN FUSE IGNITION SWITCH IGNITION THEFT LOCK DETERRENT CYLINDER MODULE CONTROL (TDM) ACTUATOR INFLATABLE RESTRAINT I/P MODULE INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL INSIDE TURBO REAR REARVIEW CHARGER VIEW MIRROR BOOST CAMERA GAGE INSTRUMENT PANEL CLUSTER (IPC) KEY-IN IGNITION SWITCH LEFT STEERING WHEEL CONTROL SWITCH LOGIC M/T M/T A/T NCA WIRE OFF PNK PNK PNK WIRE PNK PNK WIRE PNK WIRE PROVISIONAL PROVISIONAL FUSE HOLDER RED WIRE RUN WIRE STOP LP FUSE THEFT DETERRENT MODULE (TDM) UNDERHOOD FUSE BLOCK (DIAGRAM 1 OF 4) UNDERHOOD RELAY BLOCK W/ ENHANCED AUDIO SPEAKER SYSTEM W/ MULITIPLE INFORMATION W/ MULITIPLE INFORMATION DISPLAY W/ PANEL VAN W/ REARVIEW MIRROR 2.0L TURBO W/ ROOF W/O ROOF W/O REAR- W/ REAR- VIEW CAMERA VIEW CAMERA W/O ROOF W/ ROOF WHT WIRE WPR FUSE AIR BAG FUSE YEL WIRE

2.0L TURBO 2.2L, 2.4L 2.2L, 2.4L 2.0L TURBO BATTERY BLK WIRE BLK/WHT WIRE CHARGING CIRCUIT CLUTCH ST NEUTRAL ST SIG PARK/NEUTRAL SIG COMPUTER DATA LINES SYSTEM CRNK FUSE 5 CRNK RELAY 34 DK GRN WIRE HI SPEED GMLAN SERIAL DATA - HOT AT ALL TIMES IGN KEY SIG IGNITION SWITCH OFF OFF/RUN/CRANK VOLTAGE PARK/NEUTRAL POSITION (PNP) SWITCH (4 SPEED A/T) (TOP OF AUTOMATIC TRANSMISSION) POWER DISTRIBUTION SYSTEM PPL PPL/WHT WIRE RED WIRE RUN WIRE STARTER ENABLE RELAY CONTROL STARTER MOTOR TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (IN ENGINE COMPT, NEXT TO LEFT STRUT TOWER) WHT WIRE WHT/BLK WIRE

14 13 PARK BRAKE SW SIG BRK FLUID LVL SENS SIG PNK WIRE 18 36 LOW SPD GMLAN SERIAL DATA LOW SPD GMLAN SERIAL DATA 5060 5060 COMPUTER DATA LINES SYSTEM BATTERY BCM 2 FUSE 6 BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BLU WIRE BRAKE IND BRN WIRE BRN/WHT WIRE CLASS 2 SERIAL DATA DK GRN WIRE DK GRN/BLK WIRE DRIVER SEAT BELT BUCKLE DRIVER SEAT BELT SWITCH EXCEPT PANEL PANEL VAN VAN EXCEPT PANEL VAN GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES IGNITION SWITCH INFLATABLE RESTRAINT I/P MODULE INDICATOR INSTRUMENT PANEL CLUSTER (IPC) KEY-IN IGNITION SWITCH LATCH (REAR OF RIGHT REAR ACCESS PANEL) RIGHT "B" PILLAR, BETWEEN HINGES) LEFT FRONT DOOR JAMB SWITCH (LEFT "A" PILLAR BETWEEN DOOR HINGES) LEFT REAR ACCESS PANEL LATCH (REAR OF LEFT REAR ACCESS PANEL) LEFT REAR DOOR JAMB SWITCH (CENTER OF LEFT "B" PILLAR BETWEEN HINGES) LOGIC LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE LT LT OFF ORG/ WIRE PANEL EXCEPT VAN PANEL VAN PANEL VAN PARK BRAKE SWITCH (IN CENTER CONSOLE, ATTACHED TO EMERGENCY BRAKE) PASSENGER SEAT BELT BUCKLE PASSENGER SEAT BELT SWITCH PILLAR BETWEEN DOOR HINGES) PNK WIRE PPL PPL PASS SEAT BELT IND RED WIRE RED/BLK WIRE RIGHT FRONT DOOR JAMB SWITCH (RIGHT `A' RIGHT REAR ACCESS PANEL RIGHT REAR DOOR JAMB SWITCH (CENTER OF RUN WIRE SEAT BELT IND TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TURN SIGNAL/ MULTI-FUNCTION SWITCH PARK AUTO OFF HEAD UNDERHOOD FUSE BLOCK (IN ENGINE COMPT, NEXT TO LEFT STRUT TOWER) WHT WIRE

5-VOLT REF 1 A/T ACC VOLTAGE ACTR LO CTRL AIR TEMP AND PRESS BLK WIRE BRN WIRE BRN/WHT WIRE CONSOLE) CRANKSHAFT POSITION (CKP) SENSOR (ABOVE STARTER MOTOR) DIRECT FUEL INJECTOR (DFI) DK GRN WIRE DK GRN/WHT WIRE ECM/TCM FUSE 25 ECT SENS SIG GRY WIRE GRY/WHT WIRE HEATED OXYGEN SENS HI PRESS FUEL PUMP HI VOL SPLY CYL 1 HOT AT ALL TIMES IC 2 CTRL IC 3 CTRL IGNITION SWITCH IN PUMP CURRENT SENS 1 KS 1 SIG KS 2 SIG LO REF LOGIC LOW REF LT BLU WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP LEFT SIDE OF ENGINE) NCA WIRE OFF ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL 12 13 14 15 16 PPL 7 8 9 PPL/WHT WIRE PRE-THROTTLE RED/WHT WIRE RLY COIL CTRL RUN WIRE SPARK PLUG TAN WIRE TAN/WHT WIRE TP SENS 1 SIG TP SENS 2 SIG WHT WIRE YEL WIRE

335 465 COOLING FANS SYSTEM 5 VOLT REF A/T ACC VOLT ACC VOLTAGE AIR CONDITIONING SYSTEM APP SENS 2 SIG IGN 1 VOLT BATT POSITIVE VOLT LOW REF BLK WIRE BODY CONTROL MODULE (BCM) BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION (CPP) SENSOR (M/T) CLUTCH POS SENS RTN CLUTCH RLY CTRL COMPUTER DATA LINES SYSTEM COOLING FAN RLY CTRL FUEL PUMP RLY CTRL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/WHT WIRE ECM TRANS FUSE 43 ECM/ TCM FUSE 25 ENABLE RLY CTRL ENGINE CONTROL MODULE (ECM) ENGINE OIL IND FUEL LEVEL SENSOR FUEL PUMP FUEL PUMP, SENDER ASSEMBLY (INSIDE FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON TOP OF FUEL TANK) GROUND GRY WIRE HOT AT ALL TIMES IGNITION SWITCH INSTRUMENT PANEL CLUSTER (IPC) LO SPD GMLAN SERIAL DATA LOGIC LOGIC (UNDER CENTER DASH, BELOW RADIO, ON RIGHT SIDE OF CENTER CONSOLE) LOW REF PRESS SENS SIG LOW REF PRESS SENS SIG SERIAL DATA (+) SERIAL DATA (-) CLUTCH POSITION LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE MAF SENS SIG MAL- FUNCTION IND MIL CTRL OFF ORG/ WIRE ORG/BLK WIRE ORG/GRN WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN RLY CTRL PPL PPL FUEL LVL SENS SIG PPL/WHT WIRE RED/WHT WIRE RLY COIL CTRL RUN WIRE RUN/ CRANK RELAY 51 SENS SPLY STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (IN ENGINE COMPARTMENT, NEXT TO LEFT STRUT TOWER) UP SHIFT IND VEHICLE SPEED SENSOR (VSS) (M/T) (AT REAR OF ENGINE, ON TOP OF TRANSMISSION) VSS SIGNAL HIGH VSS SIGNAL LOW WHT/BLK WIRE YEL WIRE

335 465 COOLING FANS SYSTEM 5 VOLT REF A/T ACC VOLT ACC VOLTAGE AIR CONDITIONING SYSTEM APP SENS 2 SIG IGN 1 VOLT BATT POSITIVE VOLT LOW REF BLK WIRE BODY CONTROL MODULE (BCM) BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION (CPP) SENSOR (M/T) CLUTCH POS SENS RTN CLUTCH RLY CTRL COMPUTER DATA LINES SYSTEM COOLING FAN RLY CTRL FUEL PUMP RLY CTRL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/WHT WIRE ECM TRANS FUSE 43 ECM/ TCM FUSE 25 ENABLE RLY CTRL ENGINE CONTROL MODULE (ECM) ENGINE OIL IND FUEL LEVEL SENSOR FUEL PUMP FUEL PUMP, SENDER ASSEMBLY (INSIDE FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON TOP OF FUEL TANK) GROUND GRY WIRE HOT AT ALL TIMES IGNITION SWITCH INSTRUMENT PANEL CLUSTER (IPC) LO SPD GMLAN SERIAL DATA LOGIC LOGIC (UNDER CENTER DASH, BELOW RADIO, ON RIGHT SIDE OF CENTER CONSOLE) LOW REF PRESS SENS SIG LOW REF PRESS SENS SIG SERIAL DATA (+) SERIAL DATA (-) CLUTCH POSITION LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE MAF SENS SIG MAL- FUNCTION IND MIL CTRL OFF ORG/ WIRE ORG/BLK WIRE ORG/GRN WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN RLY CTRL PPL PPL FUEL LVL SENS SIG PPL/WHT WIRE RED/WHT WIRE RLY COIL CTRL RUN WIRE RUN/ CRANK RELAY 51 SENS SPLY STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (IN ENGINE COMPARTMENT, NEXT TO LEFT STRUT TOWER) UP SHIFT IND VEHICLE SPEED SENSOR (VSS) (M/T) (AT REAR OF ENGINE, ON TOP OF TRANSMISSION) VSS SIGNAL HIGH VSS SIGNAL LOW WHT/BLK WIRE YEL WIRE