Chevrolet HHR I (2005-2011) lt grn/wht Wiring diagrams

22 7 LOCK CTRL SW SIG BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DOOR LOCK RELAY DRIVER LEFT REAR ACCESS PANEL RELEASE SWITCH DRIVER RIGHT REAR ACCESS PANEL RELEASE SWITCH GRY WIRE HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER (IPC) L/GATE/ S/ROOF FUSE 10 LEFT REAR ACCESS PANEL LOCK LEFT REAR ACCESS PANEL RELAY LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE PASSENGER RIGHT REAR ACCESS PANEL RELEASE SWITCH REAR ACCESS PANEL FUSE BLOCK (PANEL VAN) (RIGHT REAR OF CARGO AREA) RED/WHT WIRE RIGHT REAR ACCESS PANEL LOCK RIGHT REAR ACCESS PANEL RELAY TAN/BLK WIRE UNDERHOOD FUSE BLOCK (IN ENGINE COMPT, NEXT TO LEFT STRUT TOWER) UNDERHOOD RELAY BLOCK

1589 2759 PPL 2.0L 2.2L, 2.4L 25 44 43 GMLAN SER DATA- GMLAN SER DATA- GMLAN SER DATA+ 55 42 339 1440 PNK WIRE 39 24 36 9 FUEL LVL SENS SIG LOW REF ABS IND. AIR BAG IND BACKLIGHTING IND BAT POS VOLT BLK WIRE BLK/WHT WIRE BRAKE IND BRN/WHT WIRE CHARGING IND CLSTR FUSE 7 COMPUTER DATA LINES SYSTEM DIC SW SIG DK GRN WIRE DK GRN/BLK WIRE DK GRN/WHT WIRE DOOR LOCK RELAY DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE IND EXCEPT PANEL VAN PANEL VAN FOG LAMP IND FUEL LEVEL FUEL PUMP, SENDER ASSEMBLY (INSIDE FUEL TANK) GMLAN GMLAN SERIAL DATA GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HVAC/ IP IGN FUSE 16 IGN IGN 1 VOLT INSTRUMENT PANEL CLUSTER (IPC) LEFT TURN IND LOGIC LT BLU/BLK WIRE LT GRN/WHT WIRE MALFUNCTION IND MESSAGE REQUEST MIL CTRL OIL LEVEL IND OIL PRES SW SIG ORG/ WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL RED/WHT WIRE RIGHT TURN IND SEAT BELT IND SECURITY IND SECURITY IND SPLY VOLT SERIAL DATA SPEEDOMETER TACHOMETER TAN WIRE TAN/BLK WIRE TRACTION OFF IND TRUNK, TAILGATE, FUEL DOORS SYSTEM UP SHIFT IND WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 PPL 1 2 3 4 5 6 7 8 9 10 11 12 13 14 BATTERY POSITIVE VOLTAGE SUPPLY VOLTAGE 1 2 3 L AUDIO SIG (+) R AUDIO SIG (+) RADIO ON SIG 10 VOLT REF REMOTE RADIO CTRL SIG VOICE LOW REF 117 200 201 118 RF SPKR OUT (-) RF SPKR OUT (+) LF SPKR OUT (+) LF SPKR OUT (-) 2 1 8 TELEPHONE VOICE LOW REF TELEPHONE VOICE SIGNAL DRAIN WIRE 2 3 10 11 LEFT AUDIO SIG (+) RADIO RIGHT AUDIO AUDIO COMMON DRAIN WIRE 651 372 GROUND AMP FUSE 6 ANTENNA SIG APPROXIMATELY 8 CM FROM AUDIO AMPLIFIER (BEHIND LEFT REAR QUARTERPANEL) BARE BARE (BLUNT CUT) BARE BARE BATTERY BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE COAX COMPUTER DATA LINES SYSTEM COMPUTER LO SPD GMLAN SERIAL DATA LO SPD GMLAN SERIAL DATA DATA LINES SYSTEM DIGITAL RADIO RECEIVER (RIGHT REAR CORNER OF VEHICLE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE GRN/WHT WIRE GRY WIRE HOT AT ALL TIMES LEFT FRONT TWEETER SPEAKER LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE ORG/BLK WIRE PERSONAL AUDIO LINK (PAL) CONNECTOR PERSONAL AUDIO LINK (PAL) MODULE PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM RADIO RADIO ANTENNA BASE (CENTER FRONT OF HEADLINER) RADIO ON SIGNAL RED WIRE RED/WHT WIRE REMOTE RADIO CTRL RIGHT FRONT LEFT FRONT SPEAKER SPEAKER RIGHT FRONT TWEETER SPEAKER RIGHT REAR SPEAKER RIGHT STEERING WHEEL CONTROL SWITCH (W/ ACCESSORY STEERING WHEEL) STEERING WHEEL CTRL SIG SUBWOOFER SPEAKER TAN WIRE TAN/WHT WIRE VOICE REC VOL UP VOL DN SEEK DN SEEK UP W/ PERSONAL AUDIO LINE MODULE W/O PERSONAL AUDIO LINE MODULE WHT WIRE WHT/BLK WIRE YEL WIRE

335 465 COOLING FANS SYSTEM 5 VOLT REF A/T ACC VOLT ACC VOLTAGE AIR CONDITIONING SYSTEM APP SENS 2 SIG IGN 1 VOLT BATT POSITIVE VOLT LOW REF BLK WIRE BODY CONTROL MODULE (BCM) BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION (CPP) SENSOR (M/T) CLUTCH POS SENS RTN CLUTCH RLY CTRL COMPUTER DATA LINES SYSTEM COOLING FAN RLY CTRL FUEL PUMP RLY CTRL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/WHT WIRE ECM TRANS FUSE 43 ECM/ TCM FUSE 25 ENABLE RLY CTRL ENGINE CONTROL MODULE (ECM) ENGINE OIL IND FUEL LEVEL SENSOR FUEL PUMP FUEL PUMP, SENDER ASSEMBLY (INSIDE FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON TOP OF FUEL TANK) GROUND GRY WIRE HOT AT ALL TIMES IGNITION SWITCH INSTRUMENT PANEL CLUSTER (IPC) LO SPD GMLAN SERIAL DATA LOGIC LOGIC (UNDER CENTER DASH, BELOW RADIO, ON RIGHT SIDE OF CENTER CONSOLE) LOW REF PRESS SENS SIG LOW REF PRESS SENS SIG SERIAL DATA (+) SERIAL DATA (-) CLUTCH POSITION LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE MAF SENS SIG MAL- FUNCTION IND MIL CTRL OFF ORG/ WIRE ORG/BLK WIRE ORG/GRN WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN RLY CTRL PPL PPL FUEL LVL SENS SIG PPL/WHT WIRE RED/WHT WIRE RLY COIL CTRL RUN WIRE RUN/ CRANK RELAY 51 SENS SPLY STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (IN ENGINE COMPARTMENT, NEXT TO LEFT STRUT TOWER) UP SHIFT IND VEHICLE SPEED SENSOR (VSS) (M/T) (AT REAR OF ENGINE, ON TOP OF TRANSMISSION) VSS SIGNAL HIGH VSS SIGNAL LOW WHT/BLK WIRE YEL WIRE

5 VOLT REF A/C REFRIGERANT PRESSURE SENSOR (ON A/C LINE, NEAR COMPRESSOR) BLK WIRE BLK/WHT WIRE CLUTCH POSITION CNSTR VENT FUSE 64 DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM FUSE 41 EXH FUSE 33 EVAP SOL CTRL FUEL PUMP FUSE 13 FUEL PUMP RELAY 19 GRY WIRE HOT AT ALL TIMES IAT SENS SIG IGN 1 VOLT INJ IGN MDL FUSE 45 LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP OF INTAKE MANIFOLD) ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE PPL/WHT WIRE PWR/TRN RELAY 26 RED/WHT WIRE SENS SIG START SIG STARTING/ CHARGING SYSTEM STOP LP SPLY VOLT TAN WIRE UNDERHOOD FUSE BLOCK (IN ENGINE COMPARTMENT, NEXT TO LEFT STRUT TOWER) WHT WIRE YEL WIRE

335 465 COOLING FANS SYSTEM 5 VOLT REF A/T ACC VOLT ACC VOLTAGE AIR CONDITIONING SYSTEM APP SENS 2 SIG IGN 1 VOLT BATT POSITIVE VOLT LOW REF BLK WIRE BODY CONTROL MODULE (BCM) BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION (CPP) SENSOR (M/T) CLUTCH POS SENS RTN CLUTCH RLY CTRL COMPUTER DATA LINES SYSTEM COOLING FAN RLY CTRL FUEL PUMP RLY CTRL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/WHT WIRE ECM TRANS FUSE 43 ECM/ TCM FUSE 25 ENABLE RLY CTRL ENGINE CONTROL MODULE (ECM) ENGINE OIL IND FUEL LEVEL SENSOR FUEL PUMP FUEL PUMP, SENDER ASSEMBLY (INSIDE FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON TOP OF FUEL TANK) GROUND GRY WIRE HOT AT ALL TIMES IGNITION SWITCH INSTRUMENT PANEL CLUSTER (IPC) LO SPD GMLAN SERIAL DATA LOGIC LOGIC (UNDER CENTER DASH, BELOW RADIO, ON RIGHT SIDE OF CENTER CONSOLE) LOW REF PRESS SENS SIG LOW REF PRESS SENS SIG SERIAL DATA (+) SERIAL DATA (-) CLUTCH POSITION LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE MAF SENS SIG MAL- FUNCTION IND MIL CTRL OFF ORG/ WIRE ORG/BLK WIRE ORG/GRN WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN RLY CTRL PPL PPL FUEL LVL SENS SIG PPL/WHT WIRE RED/WHT WIRE RLY COIL CTRL RUN WIRE RUN/ CRANK RELAY 51 SENS SPLY STARTING/CHARGING SYSTEM TAN WIRE TAN/BLK WIRE TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (IN ENGINE COMPARTMENT, NEXT TO LEFT STRUT TOWER) UP SHIFT IND VEHICLE SPEED SENSOR (VSS) (M/T) (AT REAR OF ENGINE, ON TOP OF TRANSMISSION) VSS SIGNAL HIGH VSS SIGNAL LOW WHT/BLK WIRE YEL WIRE

5 VOLT REF A/C REFRIGERANT PRESSURE SENSOR (ON A/C LINE, NEAR COMPRESSOR) BLK WIRE BLK/WHT WIRE CLUTCH POSITION CNSTR VENT FUSE 64 DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM FUSE 41 EXH FUSE 33 EVAP SOL CTRL FUEL PUMP FUSE 13 FUEL PUMP RELAY 19 GRY WIRE HOT AT ALL TIMES IAT SENS SIG IGN 1 VOLT INJ IGN MDL FUSE 45 LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP OF INTAKE MANIFOLD) ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE PPL/WHT WIRE PWR/TRN RELAY 26 RED/WHT WIRE SENS SIG START SIG STARTING/ CHARGING SYSTEM STOP LP SPLY VOLT TAN WIRE UNDERHOOD FUSE BLOCK (IN ENGINE COMPARTMENT, NEXT TO LEFT STRUT TOWER) WHT WIRE YEL WIRE