Chevrolet HHR I (2005-2011) hot in run or start Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 GMLAN + GMLAN + 1 2 3 4 5 6 7 8 TOR SENS GND EXCITING GND 1 2 3 4 5 6 SENS EXCITING 1 2 3 MTR W PHASE MTR V PHASE MTR U PHASE 1 2 B+ GND 2500 2500 COMPUTER DATA LINES SYSTEM (ON LEFT FRONT SHOCK TOWER) 642 1150 CRUISE CONTROL SYSTEM BLK WIRE BLU WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK PNK MOTOR RESOLVER WIRE ELECTRONIC POWER STEERING (EPS) MOTOR (AT BASE OF STEERING COLUMN) EPS COMPARTMENT, FUSE 1 NEXT TO LEFT STRUT TOWER) EPS/STR WHL CNTRL FUSE 19 EXCITING GND GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START LT BLU WIRE LT DK PNK IGN GMLAN - GMLAN - WIRE PNK PNK WIRE PNK WIRE RED WIRE RED/BLK WIRE SENS COS SENS SN TAN WIRE TAN/BLK WIRE TOR SENS EXCIT OUT SHAFT COS OUT SHAFT SN IN SHAFT COS IN SHAFT SN TORQUE RESOLVER UNDERHOOD FUSE BLOCK (IN ENGINE WHT WIRE YEL WIRE

B(+) BLK WIRE CLASS 2 SERIAL DATA COMPARTMENT, NEXT TO LEFT STRUT TOWER) COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM DK GRN/BLK WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ELECTRIC POWER STEERING (EPS) MOTOR EPS FUSE 1 EPS/STR WHL CNTRL FUSE 19 GRN WIRE GROUND HOT AT ALL TIMES HOT IN RUN OR START IGN 1 VOLT LEFT ASSIST MOTOR CTRL INSTRUMENT PANEL CLUSTER (IPC) LOGIC PNK PNK WIRE PNK WIRE POWER STEERING CONTROL MODULE (PSCM) RED WIRE RED/BLK WIRE RIGHT ASSIST MOTOR CTRL STEERING COLUMN) STEERING SHAFT TORQUE SENSOR TAN WIRE UNDERHOOD FUSE BLOCK (IN ENGINE

B(+) BLK WIRE CLASS 2 SERIAL DATA COMPARTMENT, NEXT TO LEFT STRUT TOWER) COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM DK GRN/BLK WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ELECTRIC POWER STEERING (EPS) MOTOR EPS FUSE 1 EPS/STR WHL CNTRL FUSE 19 GRN WIRE GROUND HOT AT ALL TIMES HOT IN RUN OR START IGN 1 VOLT LEFT ASSIST MOTOR CTRL INSTRUMENT PANEL CLUSTER (IPC) LOGIC PNK PNK WIRE PNK WIRE POWER STEERING CONTROL MODULE (PSCM) RED WIRE RED/BLK WIRE RIGHT ASSIST MOTOR CTRL STEERING COLUMN) STEERING SHAFT TORQUE SENSOR TAN WIRE UNDERHOOD FUSE BLOCK (IN ENGINE

2.0L TURBO, 5 SPEED 2.2L, 2.4L 2.0L 2500 2500 2501 2501 COMPUTER DATA LINES SYSTEM 39 35 11 42 55 380 2700 5514 2500 2501 SNS SIG 4 SPEED 5 V REF 5 VOLT REF LO REF ABS FUSE ABS IND. BAT POS VOLT RF WHEEL SPD SENS LO REF RF WHEEL SPD SENS SIG BCM 2 FUSE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (UNDER CENTER LOGIC BPP SENS BRAKE BOOSTER VACUUM SENSOR BRAKE IND BRAKE PEDAL POSITION SENSOR (BPP) (ON BRAKE PEDAL MOUNTING BRACKET) BRAKE PRESSURE MODULATOR VALVE (BPMV) BRK FLUID LVL SENS SIG BRN WIRE COMPUTER DATA LINES SYSTEM COMPUTER DATA LINES SYSTEM SPD GMLAN DASH, BELOW RADIO, ON RIGHT SIDE OF CENTER CONSOLE) DATA SERIAL DK BLU WIRE DK GRN WIRE DK GRN/BLK WIRE ENGINE CONTROLS GROUND GRY WIRE GRY/BLK WIRE HIGH 2 SERIAL DATA LOW 2 SERIAL DATA HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT PANEL CLUSTER (IPC) LEFT FRONT WHEEL SPEED SENSOR (WSS) (INSIDE LEFT FRONT WHEEL HUB) LEFT REAR WHEEL SPEED SENSOR (WSS) (INSIDE LEFT REAR WHEEL HUB) LF WHEEL SPD SENS SIG LF WHEEL SPD SENS LO REF LO REF LO REF HI SPD GLMAN (+) HI SPD GLMAN (-) 43 44 COMPUTER DATA LINES SYSTEM LOW REF VACUUM SENS SIG RR WHEEL SPD SENS LO REF RR WHEEL SPD SENS SIG LR WHEEL SPD SENS SIG LR WHEEL SPD SENS LO REF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PARK BRK PNK IGN 1 VOLT WIRE PNK WIRE PNK/BLK WIRE PUMP MOTOR CONTROL RED/BLK WIRE RED/WHT WIRE RIGHT FRONT WHEEL SPEED SENSOR (WSS) (INSIDE RIGHT FRONT WHEEL HUB) RIGHT REAR WHEEL SPEED SENSOR (WSS) (INSIDE RIGHT REAR WHEEL HUB) SENSOR LOW REF SIG STEERING ANGLE SENSOR (EXCEPT 2.0L) SW SIG SWITCH SYSTEM 2.0L 1 2 3 4 LOW REF BUS LO BUS HI TAN WIRE TAN/BLK WIRE TRAC DISABLE IND LOGIC TRACTION CONTROL SWITCH TRACTION CTRL SW WHT WIRE YAW, LATERAL ACCELEROMETER SENSOR YEL WIRE

1834 5045 SENSOR SIGNAL LOW REF 2116 2117 HIGH CONTROL LOW CONTROL 2132 2131 2133 2134 LEFT SIGNAL LEFT VOLTAGE RIGHT VOLTAGE RIGHT SIGNAL BLK/WHT WIRE BRN WIRE DK GRN WIRE GROUND GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HIGH CONTROL LOW CONTROL HOT IN RUN OR START HVAC/ IP/IGN FUSE 16 IND INFLATABLE RESTRAINT INFLATABLE RESTRAINT STEERING WHEEL MODULE (IN STEERING WHEEL) LEFT SEAT BELT PRETENSIONER LOGIC LOW CONTROL PNK LOW CONTROL HIGH CONTROL HIGH CONTROL LOW CONTROL WIRE LT BLU WIRE LT BLU/ORG WIRE ORG/ WIRE PNK (IN BODY HARNESS, PNK APPROXIMATELY 10 CM FROM BCM BREAKOUT) PNK PNK WIRE PNK IGNITION 1 VOLTAGE WIRE PNK OCCUPANT SENS SIG WIRE PNK PNK WIRE PNK WIRE PPL PPL PNK WIRE PPL SHORTING BAR PPL/WHT WIRE RED/WHT WIRE RIGHT SEAT BELT SW SHORTING BAR SHORTING BAR PNK WIRE STAGE 1 STAGE 2 STEERING WHEEL MODULE COIL (ON STEERING COLUMN, BEHIND STEERING WHEEL) TAN WIRE TAN/ORG WIRE TAN/WHT WIRE W/ HEAD CURTAIN AIR BAG W/O HEAD CURTAIN AIR BAG WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

1-2 2-3 SHIFT SHIFT SOLENOID SOLENOID (SS) (SS) VALVE VALVE 2-3 SS VLV CTRL 771 2762 1039 840 1226 SW SIG A LOW REFERENCE IGN 1 VOLTAGE B(+) TFP SW SIG C ACC VOLT ACC VOLTAGE AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION INPUT SHAFT SPEED (ISS) SENSOR BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DRIVE ECM/ TCM FUSE 25 ECM/ TRANS FUSE ENGINE CONTROLS SYSTEM ENGINE, ON TOP OF TRANSMISSION) EXTERIOR GMLAN BUS (-) GMLAN BUS (+) GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START ISS LOW SIG LIGHTS SYSTEM LOGIC LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PARK NEUTRAL POSITION (PNP) SWITCH (TOP OF AUTOMATIC TRANSMISSION) PNK WIRE PPL PPL 401 1229 VSS LOW SIG PC SOL VLV LO CTRL RED WIRE RED/WHT WIRE REV SW SIG B SW SIG C TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC RELEASE TCC RELEASE SW SIG TFP SW SIG B TFT SENS SIG TRANSMISSION CONTROL MODULE (TCM) (LEFT SIDE OF ENGINE COMPARTMENT) UNDERHOOD FUSE BLOCK (IN ENGINE COMPARTMENT, NEXT TO LEFT STRUT TOWER) VEHICLE SPEED SENSOR (AT REAR OF WHT WIRE YEL WIRE YEL/BLK WIRE