Chevrolet Forward Control P30 (1985-1999) wht Wiring diagrams

BLK WIRE BLU WIRE BRAKE SWITCH (ON BRAKE PEDAL SUPPORT) BRN WIRE DK BLU WIRE DK GRN WIRE FUSE BLOCK- I/P GRN WIRE HAZARD HAZARD FLASHER (RIGHT SIDE OF STEERING COLUMN) HEAD HEADLIGHT SWITCH HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START I/P DIMMER SWITCH INSTRUMENT CLUSTER LEFT FRONT MARKER LAMP LEFT LICENSE LAMP LEFT TAIL/STOP TURN LAMP LEFT TURN INDICATOR LT BLU WIRE LT GRN WIRE LT LT NORMAL OFF ORG/ WIRE PARK PPL PROVISIONS FOR PARK LAMPS PROVISIONS FOR REAR MARKER LAMPS RIGHT BACKUP LAMP LEFT BACKUP LAMP RIGHT FRONT MARKER LAMP RIGHT FRONT PARK/ TURN LAMP LEFT FRONT PARK/ TURN LAMP RIGHT LICENSE LAMP RIGHT TAIL/STOP/ TURN LAMP RIGHT TURN INDICATOR STOP/ HAZ FUSE TAIL LPS FUSE TURN LEFT TURN RIGHT TURN SIGNAL FLASHER TURN-B/U FUSE TURN/HAZARD SWITCH (LEFT SIDE OF STEERING COLUMN) WHT WIRE YEL WIRE

BACKUP LAMP SWITCH (ON STEERING COLUMN) BLK WIRE BLU WIRE BRN WIRE DK BLU WIRE DK GRN WIRE FUSE BLOCK (BEHIND LEFT SIDE OF I/P) G# N/A (IN REAR LAMPS HARNESS) GRN WIRE HAZARD HAZARD FLASHER HEAD HEADLIGHT SWITCH HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LEFT BACKUP LAMP RIGHT BACKUP LAMP LEFT FRONT MARKER LAMP LEFT LICENSE LAMP LEFT PARK LAMP LEFT TAIL/STOP TURN LAMP LEFT TURN INDICATOR LT BLU WIRE LT LT NORMAL OFF ORG/ WIRE PARK PPL PROVISIONS FOR CLEARANCE LAMPS PROVISIONS FOR REAR MARKER LAMPS RIGHT FRONT MARKER LAMP RIGHT FRONT PARK/ TURN LAMP LEFT FRONT PARK/ TURN LAMP RIGHT LICENSE LAMP RIGHT PARK LAMP RIGHT TAIL/STOP TURN LAMP RIGHT TURN INDICATOR STOP/ HAZ FUSE STOPLAMP SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) TAIL LPS FUSE TURN LEFT TURN RIGHT TURN SIGNAL FLASHER TURN-B/U FUSE TURN/HAZARD SWITCH (ON MULTI- FUNCTION LEVER) WHT WIRE YEL WIRE

BACKUP LAMP SWITCH (ON STEERING COLUMN) BLK WIRE BLU WIRE BRN WIRE DK BLU WIRE DK GRN WIRE FUSE BLOCK- I/P G# N/A (LEFT SHIPPING (PANEL) G# N/A (REAR LAMPS HARNESS) GRN WIRE HAZARD HAZARD FLASHER (TOP LEFT SIDE OF SHIPPING PANEL) HEAD HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START INSTRUMENT CLUSTER LEFT BACKUP LAMP RIGHT BACKUP LAMP LEFT FRONT MARKER LAMP LEFT LICENSE LAMP LEFT TAIL/STOP TURN LAMP LEFT TURN INDICATOR LIGHT SWITCH ASSEMBLY LT BLU WIRE LT LT NORMAL OFF ORG/ WIRE PARK PPL PROVISIONS FOR BODY BUILDER ADDED LAMPS PROVISIONS FOR MARKER LAMPS RIGHT FRONT MARKER LAMP RIGHT FRONT PARK/ TURN LAMP LEFT FRONT PARK/ TURN LAMP RIGHT LICENSE LAMP RIGHT TAIL/STOP TURN LAMP RIGHT TURN INDICATOR STOP/ HAZ FUSE STOPLAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAIL LPS FUSE TURN FLASHER TURN LEFT TURN RIGHT TURN SIGNAL SWITCH (LEFT SIDE OF STEERING COLUMN) TURN-B/U FUSE WHT WIRE YEL WIRE

BLK WIRE BRN WIRE DAYTIME RUNNING LAMP INDICATOR DAYTIME RUNNING LAMPS MODULE (IN I/P HARNESS) DAYTIME RUNNING LAMPS RELAY (IN I/P HARNESS) DK BLU/WHT WIRE DK GRN/YEL WIRE FUSE BLOCK GRN WIRE HEAD PARK HEADLAMP DIMMER SWITCH HEADLIGHT SWITCH ASSEMBLY HI BEAM INDICATOR HI LO HORN/DM FUSE HOT AT ALL TIMES HOT IN RUN HTR FUSE INSTRUMENT CLUSTER LEFT HEADLAMP ASSEMBLY LT GRN WIRE LT GRN/BLK WIRE OFF OFF HEAD ORG/ WIRE PARK PARK BRAKE WARNING SWITCH (AT PARK BRAKE, UNDER LEFT SIDE OF I/P) PROVISIONS FOR FOG LAMPS RIGHT HEADLAMP ASSEMBLY TAN WIRE TAN/WHT WIRE WHT WIRE YEL WIRE

12 13 PNK WIRE 1222 1224 1225 1226 1350 PNK WIRE 2-3 SHIFT SOL CTRL FUEL INJ CTRL 4 WHEEL DRIVE LOW SWITCH 999 998 961 452 PPL ACCELERATOR PEDAL POSITION (APP) MODULE (TOP OF ACCELERATOR BRACKET) APP 1 SENSOR APP 2 SENSOR APP 3 SENSOR B/H BATTERY FEED 4 WHL LOW SW BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE ON/OFF SIG DATA LINK CONNECTOR (NO LOCATION AVAILABLE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/WHT WIRE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENG SHUT-OFF CTRL ENGINE COOLANT TEMPERATURE (ECT) SENSOR (RIGHT SIDE OF ENGINE) ENGINE GROUND (NO LOCATION AVAILABLE) ENGINE SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) FUEL INJ CTRL FUEL SOLENOID (TOP FRONT OF ENGINE) FUEL SOLENOID DRIVER (TOP FRONT FUSE BLOCK FUSIBLE LINK (NO LOCATION AVAILABLE) GRY WIRE GRY/BLK WIRE GRY/RED WIRE HI RESOLUTION SIG HOT AT ALL TIMES HOT IN RUN OR START LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE OF ENGINE) OPTICAL SENSOR AND FUEL TEMPER- ATURE SENSOR (TOP FRONT OF ENGINE) ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT SIDE OF DRIVER'S ISLAND) PPL PPL 15 16 PRESSURE CONTROL SOL RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RESUME/ACCEL SIG SET/COAST SIG SYSTEM GND CLOSURE GRD APP 2 SENS GND APP 1 SENS GND APP 3 SENS GND SENSOR GND TAN WIRE TCC BRAKE SW TCC SOL 2-3 SHIFT SOL 1-2 SHIFT SOL TRANS FLUID TEMP (TFT) SENSOR TRANS FUSE TRANS INPUT SPD LO CKP SIG OPTICAL SENS GND OPTICAL SENS CAM SIG TRANS OUTPUT TRANSMISSION INPUT SPEED SENSOR VEHICLE SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (NO LOCATION AVAILABLE) VSS VSS INPUT VSS OUTPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

"TRANS" LAMP 1-2 SHIFT SOL 2-3 SHIFT SOL TCC SOL 2-3 SHIFT SOL CTRL 1-2 SHIFT SOL CTRL DIAGNOSTIC TEST A/C INPUT BRAKE SIGNAL TCC CONTROL PPL ACCY AIR CONDI- TIONING SYSTEM ALT FUSE B/H BATTERY FEED BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN WIRE BULB TEST COLD ADVANCE FAST IDLE TEMPERATURE SWITCH (RIGHT REAR OF ENGINE) COLD ADVANCE SOLENOID (TOP FRONT OF ENGINE) DATA LINK CONNECTOR (BEHIND LEFT SIDE SHIPPING DIODE (BEHIND GENERATOR) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECM BAT FUSE ECM CRANK FUSE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENGINE SPEED SIGNAL SENSOR GROUND TP SENSOR INPUT FAST IDLE SOLENOID (TOP LEFT SIDE OF ENGINE) FUEL HEATER (TOP REAR OF ENGINE) FUEL SHUT- OFF SOLENOID (TOP FRONT OF ENGINE) FUSE BLOCK FUSIBLE LINK (20 GA-RUST) FUSIBLE LINKS GLOW PLUG CONTROLLER (LEFT SIDE OF ENGINE) GLOW PLUG WAIT LAMP GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT AT ALL TIMES FUSIBLE LINK HOT IN CRANK HOT IN RUN, BULB TEST OR START INPUTS INSTRUMENT CLUSTER LEFT BANK GLOW PLUGS LOCK OFF LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE PANEL) PCS HI PCS LO IGNITION PNK RANGE SIGNAL A RANGE SIGNAL B RANGE SIGNAL C WIRE PNK WIRE PNK/BLK WIRE PPL PRESSURE CONTROL SOLENOID RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RIGHT BANK GLOW PLUGS RUN WIRE SERVICE TRANS OUTPUT SERIAL DATA SYSTEM GROUND SYSTEM GROUND 452 416 SENSOR GROUND 5 VOLTS REF TAN/BLK WIRE TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT) TRANS FLUID TEMP SIG MAP SENS TRANS FUSE TRANS- MISSION FLUID TEMP (TFT) SENSOR TRANSMISSION CONTROL MODULE (TCM) (BEHIND LEFT SIDE OF SHIPPING PANEL) TRANSMISSION INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VEHICLE SPEED INPUT TRANS INPUT SPD LO TRANS INPUT SPD HI VEHICLE SPEED SENSOR (REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT SIDE OF I/P) VEHICLE SPD OUTPUT VSS WATER IN FUEL INDICATOR WATER-IN FUEL SENSOR (TOP REAR OF ENGINE) WHT WIRE WHT/BLK WIRE YEL/BLK WIRE

4.3L 5.7L 5.7L ONLY 4.3L ONLY 7.4L 7.4L ONLY AIR CONDITION- ING SYSTEM BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE SIGNAL DIAGNOSTIC TEST TP SENSOR SIGNAL INJECTOR 1 CONTROL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ECM BAT FUSE ECM CRNK FUSE EGR CONTROL GOVERNOR CONTROL EGR ELECTONIC VACUUM REGULATOR SOLENIOD VALVE (TOP RIGHT FRONT OF ENGINE) EVAPORATIVE CANISTER PURGE CONTROL SOLENOID (TOP RIGHT SIDE OF ENGINE) EXHAUST GAS RECIRCULATION VALVE SOLENOID (TOP RIGHT SIDE OF ENGINE) FUEL PUMP RELAY CTRL PCS LOW FUEL PUMP SIGNAL MAP SIGNAL FUSE BLOCK GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IC BYPASS SENSOR GROUND SENSOR GROUND TFT SIGNAL IDLE AIR CONTROL ACTUATOR (TOP REAR OF ENGINE) IDLE SPEED ACTUATOR CONTROL SOLENOID (NO LOCATION AVAILABLE) INJ FUSE KNOCK SENSOR INPUT ECT SIGNAL KNOCK SIGNAL EGR PINTLE POSITION SIGNAL LINEAR EGR VACUUM REGULATOR SOLENOID VALVE (TOP FRONT OF ENGINE) LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/ WIRE OXYGEN SENSOR GROUND PNK 26 27 WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SHIPPING PANEL) PPL PPL 24 25 PPL/WHT WIRE RANGE SIGNAL A INPUT SPEED SIGNAL HIGH INPUT SPEED SIGNAL LOW RANGE SIGNAL B RANGE SIGNAL C MIL CONTROL RED WIRE RED/BLK WIRE TAN WIRE TAN/BLK WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) TRANSMISSION INPUT SPEED SENSOR (NO LOCATION) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

3 121 PNK WIRE 4.3L AND 7.4L 5.7L ACCY ALT FUSE BLK WIRE BLK/RED WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IGNITION COIL (TOP RIGHT REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (LEFT REAR OF ENGINE, NEAR OIL PRESSURE SENDER) KNOCK SENSOR MODULE (TOP RIGHT SIDE OF ENGINE) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION (SERVICE ENGINE SOON) INDICATOR MANIFOLD ABSOLUTE PRESSURE SENSOR (ABOVE VALVE COVER) NCA WIRE ORG/ WIRE PNK 25 26 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 2 3 4 PPL 23 24 PPL/WHT WIRE PROVISIONS FOR TACHOMETER RED WIRE RED/BLK WIRE RUN WIRE TAN/BLK WIRE TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

5.7L 7.4L 7.4L ONLY AIR CONDITION- ING SYSTEM BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE DIAGNOSTIC TEST TP SENSOR SIGNAL INJECTOR 1 CONTROL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ECM BAT FUSE ECM I FUSE ECT SIGNAL EGR CONTROL EVAPORATIVE CANISTER PURGE CONTROL SOLENOID (TOP RIGHT SIDE OF ENGINE) EXHAUST GAS RECIRCULATION VALVE SOLENOID (TOP RIGHT SIDE OF ENGINE) FUEL PUMP RELAY CTRL PCS LOW FUEL PUMP SIGNAL MAP SIGNAL FUSE BLOCK GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IC BYPASS SENSOR GROUND SENSOR GROUND TFT SIGNAL 470 455 PPL IDLE AIR CONTROL ACTUATOR (TOP REAR OF ENGINE) IDLE SPEED ACTUATOR CONTROL SOLENOID (NO LOCATION AVAILABLE) KNOCK SIGNAL EGR PINTLE POSITION SIGNAL LINEAR EGR VACUUM REGULATOR SOLENOID VALVE (TOP FRONT OF ENGINE) LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE ORG/ WIRE OXYGEN SENSOR (IN EXHAUST MANIFOLD) OXYGEN SENSOR GROUND PNK 22 23 WIRE PNK RANGE SIGNAL A INPUT SPEED SIGNAL HIGH INPUT SPEED SIGNAL LOW WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SHIPPING PANEL) PPL PPL 20 21 PPL/WHT WIRE RANGE SIGNAL B RANGE SIGNAL C MIL CONTROL RED WIRE RED/BLK WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) TRANSMISSION INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

3 121 PNK WIRE ACCY BLK WIRE BLK/RED WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE BULB TEST DISTRIBUTOR (CENTER REAR OF ENGINE) DK BLU WIRE DK GRN/WHT WIRE ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUSE BLOCK GAGES FUSE GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IGNITION COIL (TOP RIGHT REAR OF ENGINE) IGNITION SWITCH INSTRUMENT CLUSTER KNOCK SENSOR (LEFT REAR OF ENGINE, NEAR OIL PRESSURE SENDER) LOCK OFF LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION (SERVICE ENGINE SOON) INDICATOR MANIFOLD ABSOLUTE PRESSURE SENSOR (ABOVE VALVE COVER) NCA WIRE ORG/ WIRE PNK 22 23 WIRE PNK WIRE PNK/BLK WIRE PPL PPL 20 21 PPL 3 4 PPL/WHT WIRE PROVISIONS FOR TACHOMETER RED WIRE RED/BLK WIRE RUN WIRE TAN/BLK WIRE TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT BRACKET) THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANS FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE