Chevrolet Forward Control P30 (1985-1999) spark plugs Wiring diagrams

3 4 5 PNK PNK WIRE 389 419 VSS OUTPUT MIL CTRL 420 1807 PPL PPL BRAKE SIG SERIAL DATA 440 1225 1224 IGN FEED RANGE SIG "B" RANGE SIG "A" A/C REQUEST SIG A/C SYSTEM BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE BULKHEAD GROMMET TOWARD IGNITION SW) CYLINDER 2 CYLINDER 1 CYLINDER 5 CYLINDER 3 CYLINDER 4 CYLINDER 6 DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM-BAT FUSE 6 EGR VALVE CTRL ELECTRONIC BRAKE CONTROL MODULE FEED FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK (BEHIND DASH PANEL) (BODY BUILDER INSTALLED) IGN FEED IGNITION IGNITION COIL (TOP RIGHT SIDE OF ENGINE) IGNITION CONTROL MODULE (RIGHT TOP OF ENGINE, AT IGNITION COIL) LT BLU/WHT WIRE ORG/ WIRE PCS SOL (HI) INPUT SPD SENS SIG INPUT SPD SENS RTN TIMING CTRL SIG PCS SOL (LO) VCM GROUND VCM GROUND GROUND 451 451 470 PNK 6 7 8 9 10 11 12 13 14 15 WIRE PNK IGN FEED WIRE PNK WIRE PPL PPL (ENGINE HARN, 18 CM FROM BREAKOUT TO BULKHEAD CONN) PPL FUEL LEVEL PRESSURE SWITCH IN RANGE SIG "C" RED WIRE RED/ BLK WIRE RED/BLK WIRE SHIFT INTERLOCK SYSTEM PPL SPARK PLUGS TIMING CONTROL RETURN TIMING CONTROL SIGNAL) TORQUE CONVERTER CLUTCH, STOP LAMP SWITCH (AT BRAKE PEDAL SUPPPORT) TRANSMISSION INPUT SPEED SENSOR (ON LEFT SIDE OF TRNASMISSION, NEAR THE MIDDLE) WHT WIRE WHT/ BLU WIRE WHT/BLK WIRE

3 4 5 6 7 8 9 10 11 12 13 14 15 16 PNK PNK WIRE 389 419 VSS OUTPUT MIL CTRL 420 1807 PPL PPL BRAKE SIG SERIAL DATA 440 1225 1224 IGN FEED RANGE SIG "B" RANGE SIG "A" A/C REQUEST SIG A/C SYSTEM A/T INPUT SPEED SENSOR (TRANSMISSION, LEFT FRONT) ANTI-LOCK BRAKES SYSTEM BLK RED/ WIRE BLK WIRE BLK/WHT WIRE BLU/ WHT WIRE BRN WIRE BRN/WHT WIRE BULKHEAD GROMMET TOWARD IGNITION SW) CLUTCH PEDAL POSITION SWITCH (LEFT SIDE OF BRAKE PEDAL BRACKET) CLUTCH SIG CYLINDER NO.2 CYLINDER NO.1 CYLINDER NO.5 CYLINDER NO.3 CYLINDER NO.4 CYLINDER NO.6 DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM B FUSE 6 EGR VALVE CTRL FEED IGNITION FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) FUEL PUMP RELAY (ON FIRE- WALL, UNDER BATTERY JUNCTION BLOCK) GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) IGN FEED IGNITION COIL (TOP RIGHT SIDE OF ENGINE) IGNITION CONTROL MODULE (RIGHT TOP OF ENGINE) LT BLU/WHT WIRE ORG/ WIRE PCS SOL (HI) INPUT SPD SENS SIG INPUT SPD SENS RTN TIMING CTRL SIG PCS SOL (LO) SYSTEM GROUND SYSTEM GROUND GROUND 451 451 470 PNK IGN FEED WIRE PNK WIRE PPL PPL FUEL LEVEL PRESSURE SWITCH IN RANGE SIG "C" RED WIRE RED/BLK WIRE RETURN CONTROL TIMING SHIFT INTERLOCK SYSTEM PPL SIGNAL CONTROL TIMING SPARK PLUGS TCC/STOP LAMPS SWITCH (RIGHT SIDE OF STEERING COLUMN UPPER SUPPORT) VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE WHT/BLK WIRE

389 419 VSS OUTPUT MIL CTRL 440 1225 1224 IGN FEED RANGE SIG "B" RANGE SIG "A" 5 6 7 8 9 PNK PNK WIRE A/C REQUEST SIG A/C SW IN A/C SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION SWITCH (TOP OF CLUTCH PEDAL SUPPORT) CLUTCH SIG CYLINDER 1 CYLINDER 4 CYLINDER 5 CYLINDER 3 CYLINDER 6 CYLINDER 7 CYLINDER 2 CYLINDER 8 DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK BLU/ WHT WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM-BAT FUSE 6 EGR CTRL ELECTRONIC BRAKE CONTROL MODULE FEED IGNITION FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK (BEHIND DASH PANEL) (BODY BUILDER INSTALLED) IGN FEED IGNITION COIL (TOP RIGHT SIDE OF ENGINE) IGNITION CONTROL MODULE (RIGHT TOP OF ENGINE, AT IGNITION COIL) LT BLU/WHT WIRE ORG/ WIRE PCS SOL (HI) INPUT SPD SENS SIG INPUT SPD SENS RTN TIMING CTRL SIG PCS SOL (LO) VCM GND VCM GND GND 451 451 470 PNK IGN FEED WIRE PNK WIRE PPL PPL 1 2 PPL 2 4 5 16 DATA LINK CONNECTOR (DLC) (BELOW DASH, NEAR STEERING COLUMN) PPL ANTI-LOCK BRAKE SYSTEM PPL FUEL LEV PPL PPL 420 1807 BRAKE SIG SERIAL DATA RANGE SIG "C" RED WIRE RED/ BLK WIRE RED/BLK WIRE RETURN CONTROL TIMING SIGNAL CONTROL TIMING SPARK PLUGS TORQUE CONVERTER CLUTCH, STOP LAMP SWITCH (AT BRAKE PEDAL SUPPORT) TRANSMISSION INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION, NEAR THE MIDDLE) WHT WIRE WHT/BLK WIRE

389 419 VSS OUTPUT MIL CTRL 440 1225 1224 IGN FEED RANGE SIG "B" RANGE SIG "A" A/C REQUEST SIG A/C SW IN A/C SYSTEM A/T INPUT SPEED SENSOR (TRANSMISSION, LEFT FRONT) BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION SWITCH (TOP OF CLUTCH PEDAL SUPPORT) CLUTCH SIG CYLINDER 1 CYLINDER 4 CYLINDER 5 CYLINDER 3 CYLINDER 6 CYLINDER 7 CYLINDER 2 CYLINDER 8 DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM B FUSE 6 EGR CTRL FROM LEFT BULKHEAD GROMMET) PPL FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) FUEL PUMP RELAY (ENGINE BULKHEAD RELAY BRACKET UNDER BATTERY JUNCTION BLOCK) GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) IGN FEED IGNITION COIL (TOP RIGHT SIDE OF ENGINE) IGNITION CONTROL MODULE (BRACKET AT TOP EDGE OF RIGHT CYLINDER HEAD) IGNITION FEED LT BLU/WHT WIRE ORG/ WIRE PCS SOL (HI) INPUT SPD SENS SIG INPUT SPD SENS RTN TIMING CTRL SIG PCS SOL (LO) SYSTEM GND SYSTEM GND GND 451 451 470 PNK IGN FEED WIRE PNK PNK WIRE PNK WIRE PPL PPL 1 2 PPL 2 4 5 16 DATA LINK CONNECTOR (DLC) (BELOW DASH, NEAR STEERING COLUMN) PPL ANTI-LOCK BRAKE SYSTEM PPL FUEL LEV PPL PPL 420 1807 BRAKE SIG SERIAL DATA RANGE SIG "C" RED WIRE RED/ BLK WIRE RED/BLK WIRE SHIFT INTERLOCK SYSTEM SPARK PLUGS TCC/ STOP LAMPS SWITCH (RIGHT SIDE OF STEERING COLUMN UPPER SUPPORT) TIMING CONTROL RETURN TIMING CONTROL SIGNAL) VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/ DK BLU WIRE WHT/BLK WIRE

1 2 3 4 5 6 7 8 PNK PNK WIRE A/C COMP CYL SW A/C REQUEST SIGNAL AIR CONDITIONING SYSTEM AUX ELECT COOLING FAN BRAKE SIGNAL SERIAL DATA PPL PPL B(+) BATTERY FEED RANGE SIGNAL B RANGE SIGNAL A BLK RED/ WIRE BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE COOLING FANS SYSTEM CRUISE CONTROL MODULE (ON RADIATOR SUPPORT BRACKET) CRUISE CTRL ENGAGED CRUISE ENGAGED SIG CTRL EST CYLINDER 1 CYLINDER 4 CYLINDER 5 CYLINDER 3 CYLINDER 6 CYLINDER 7 CYLINDER 2 CYLINDER 8 DISTRIBUTOR DK BLU WIRE DK GRN WIRE DK GRN/ WHT WIRE DK GRN/WHT WIRE ECM B FUSE 6 EGR VALVE FEED EGR VLV CTRL FUEL PMP RLY CTRL 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) GRN WIRE GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK IGN FEED IGNITION COIL (ON BRACKET AT REAR OF INTAKE PLENUM) IGNITION CONTROL MODULE (ON BRACKET AT REAR OF INTAKE PLENUM) LT BLU/BLK WIRE LT BLU/WHT WIRE ORG/ WIRE PCS HIGH INPUT SPEED SENS LOW INPUT SPEED SENS HIGH IC CNTRL PCS LOW VCM GROUND VCM GROUND SENS GROUND PNK 16 17 18 19 20 21 WIRE PNK 22 23 WIRE PNK IGN FEED WIRE PNK WIRE PPL PPL ANTI-LOCK BRAKES SYSTEM PPL PPL DATA LINK CONNECTOR (DLC) (BELOW DASH, NEAR STEERING COLUMN) 4 5 PPL FUEL LEVEL MODULE A/C REC PPL TCC/STOPLAMP INPUT RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SIGNAL TIMING CTRL ELEC SPK SPARK PLUGS SPEED SENSOR INPUT TCC STOPLAMP SWITCH (OPENS W/BRAKE DEPRESSED) (AT BRAKE PEDAL SUPPORT) VSS OUTPUT SIGNAL VSS OUTPUT SIGNAL CHECK ENGINE LP CTRL WHT WIRE WHT/ BLU WIRE WHT/BLK WIRE

1 2 3 4 5 6 7 8 PNK PNK WIRE A/C COMP CYL SW A/C REQUEST SIGNAL AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM PPL AUX ELECT COOLING FAN BRAKE SIGNAL SERIAL DATA PPL PPL 420 1807 B(+) BATTERY FEED RANGE SIGNAL B RANGE SIGNAL A 1225 1224 PNK WIRE BLK RED/ WIRE BLK WIRE BLK/WHT WIRE BLU/ WHT WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE COOLING FANS SYSTEM CRUISE CONTROL MODULE (ON RADIATOR SUPPORT BRACKET) CRUISE CTRL ENGAGED CRUISE ENGAGED SIG CYLINDER 1 CYLINDER 4 CYLINDER 5 CYLINDER 3 CYLINDER 6 CYLINDER 7 CYLINDER 2 CYLINDER 8 DISTRIBUTOR DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM B FUSE 6 EGR VALVE FEED EGR VLV CTRL ELEC SPK TIMING CTRL SIGNAL EST CTRL FUEL PMP RLY CTRL 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY (LEFT SIDE OF ENGINE COMPT) GRN WIRE GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK IGN FEED IGNITION COIL (ON BRACKET AT REAR OF INTAKE PLENUM) IGNITION COIL MODULE (ON BRACKET AT REAR OF INTAKE PLENUM) LT BLU/BLK WIRE LT BLU/WHT WIRE ORG/ WIRE PCS HIGH INPUT SPEED SENS LOW INPUT SPEED SENS HIGH IC CNTRL PCS LOW GROUND GROUND SENS GROUND PNK 22 23 WIRE PNK IGN FEED WIRE PNK WIRE PPL PPL DATA LINK CONNECTOR (DLC) (BELOW DASH, NEAR STEERING COLUMN) 4 5 PPL FUEL LEVEL MODULE A/C REC PPL TCC/STOPLAMP INPUT RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SPARK PLUGS SPEED SENSOR INPUT VEHICLE CONTROL MODULE (VCM) (ON CENTER FRONT OF ENGINE COMPARTMENT) VSS OUTPUT SIGNAL VSS OUTPUT SIGNAL CHECK ENGINE LP CTRL 389 419 WHT DK GRN/ WIRE WHT WIRE WHT/BLK WIRE