Chevrolet Forward Control P30 (1985-1999) lt grn/blk Wiring diagrams

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID 4.3L (VIN W), 5.7L (VIN R) A/C COMPRESSOR RELAY, GENERATOR, SEAT BELT/ HEADLAMPS ALARM MODULE A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH A/T ISS HI IN A/T ISS LO IN ANTI-LOCK BRAKES, CRUISE CONTROL, SHIFT INTERLOCK SYSTEMS AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE DATA CLASS II DK BLU WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE, CRUISE CONTROL MODULE ENGINE CONTROLS SYSTEM FUEL INJECTORS (ENGINE CONTROLS SYSTEM) FUEL PUMP RELAY, SWITCH GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE PPL PPL DATA LINK CONNECTOR (PARTIAL) (BELOW DASH NEAR STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN SERVICE ENGINE SOON INDICATOR TCC PWM SOL TCC PWM SOLENOID TCC/ STOP LAMPS SWITCH THROTTLE POSITION SENSOR (ON THROTTLE BODY) TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 17 TRANS TEMP SIG IN VEHICLE CONTROL MODULE (CENTER FRONT OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VSS HI VSS LO YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID 4.3L (VIN W), 5.7L (VIN R) A/C COMPRESSOR RELAY, GENERATOR, SEAT BELT/ HEADLAMPS ALARM MODULE A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH A/T ISS HI IN A/T ISS LO IN ANTI-LOCK BRAKES, CRUISE CONTROL, SHIFT INTERLOCK SYSTEMS AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE DATA CLASS II DK BLU WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE, CRUISE CONTROL MODULE ENGINE CONTROLS SYSTEM FUEL INJECTORS (ENGINE CONTROLS SYSTEM) FUEL PUMP RELAY, SWITCH GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE PPL PPL DATA LINK CONNECTOR (PARTIAL) (BELOW DASH NEAR STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN SERVICE ENGINE SOON INDICATOR TCC PWM SOL TCC PWM SOLENOID TCC/ STOP LAMPS SWITCH THROTTLE POSITION SENSOR (ON THROTTLE BODY) TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 17 TRANS TEMP SIG IN VEHICLE CONTROL MODULE (CENTER FRONT OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VSS HI VSS LO YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID 3-2 SHIFT SOL 3-2 SHIFT SOLENOID A/C COMPRESSOR RELAY, GENERATOR, TURBO CHARGER POWER VALVE A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) A/T ISS SENS HI IN A/T ISS SENS LO IN A/T OUTPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) ACCELERATOR PEDAL POSITION MODULE (ATTACHED TO ACCELERATOR PEDAL) APP 1 SIGNAL IN APP 2 SIGNAL IN APP 3 SIGNAL IN AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE SWITCH IN BRN WIRE BRN/WHT WIRE CLASS II DATA DATA LINK CONNECTOR (PARTIAL) (BELOW DASH, NEAR STEERING COLUMN) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENSOR IN ELECTRONIC BRAKE CONTROL MODULE ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) EXTERIOR LIGHTS FUEL PUMP RELAY, FUEL PUMP SWITCH/ENGINE OIL PRESSURE INDICATOR SENSOR GAUGES FUSE 8 GRY WIRE HAZARD LAMPS FLASHER HOT AT ALL TIMES HOT IN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE OSS HI IN OSS IN OSS LO IN OSS OUT PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK INSTRUMENT CLUSTER WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF DRIVER'S ISLAND) PPL PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE RUN WIRE SENSOR GROUND SERVICE ENGINE SOON INDICATOR STOP-HAZ FUSE 11 STOPLAMP SWITCH IN TAN WIRE TFT SENSOR IN TORQUE CONVERTER CLUTCH, STOPLAMP SWITCH TRANS FLUID TEMP SENSOR TRANS RANGE "A" TRANS RANGE "B" TRANS RANGE "C" TRANSMISSION FUSE 17 VEHICLE SPEED SENSOR CALIBRATOR (LEFT SIDE OF DRIVER'S ISLAND) VEHICLE SPEED SENSOR CALIBRATOR, ENGINE SHUTOFF SOLENOID VSS IN VSS OUT WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID 3-2 SHIFT SOL 3-2 SHIFT SOLENOID A/C COMPRESSOR RELAY GENERATOR A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) A/T ISS SENS HI IN A/T ISS SENS LO IN A/T OUTPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) ACCELERATOR PEDAL POSITION MODULE (ATTACHED TO ACCELERATOR PEDAL) APP 1 SIGNAL IN APP 2 SIGNAL IN APP 3 SIGNAL IN AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE SWITCH IN BRN WIRE BRN/WHT WIRE CLASS II DATA DATA LINK CONNECTOR (PARTIAL) (BELOW DASH, NEAR STEERING COLUMN) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENSOR IN ELECTRONIC BRAKE CONTROL MODULE ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUEL PUMP RELAY, ENGINE OIL PRESSURE INDICATOR SENSOR GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE OSS HI IN OSS LO IN OSS OUT PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF DRIVER'S ISLAND) PPL PPL PPL PPL/WHT WIRE PRESS CTRL HI SOLENOID RED WIRE RED/BLK WIRE SENSOR GROUND SERVICE ENGINE SOON INDICATOR STOP-HAZ FUSE 11 STOPLAMP SWITCH IN TAN WIRE TFT SENSOR IN TORQUE CONVERTER CLUTCH, STOPLAMP SWITCH TRANS FLUID TEMP SENSOR TRANS RANGE "A" TRANS RANGE "B" TRANS RANGE "C" TRANSMISSION FUSE 17 VEHICLE SPEED SENSOR BUFFER VEHICLE SPEED SENSOR CALIBRATOR (LEFT SIDE OF DRIVER'S ISLAND) VSS LO IN VSS OUT WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

2-3 SHIFT SOL CTRL 1-2 SHIFT SOL CTRL DIAGNOSTIC TEST 9 6 DATA LINK CONNECTOR (PARTIAL) (BELOW DASH, NEAR STEERING COLUMN) A/T INPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) A/T OUTPUT SHAFT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) AUTOMATIC TRANSMISSION BAROMETRIC PRESSURE SENSOR (TOP LEFT REAR OF INTAKE MANIFOLD) BATTERY FEED BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE SIGNAL TCC PWM CONTROL BRN WIRE DK BLU WIRE DRL MODULE, DRL RELAY, GENERATOR ECM 1 FUSE 12 ECM-BAT FUSE 6 ELECTRONIC BRAKE CONTROL MODULE ENGINE OIL PRESSURE INDICATOR SENSOR, FUEL PUMP RELAY ENGINE SPEED SENSOR (REAR OF INTAKE MANIFOLD) ENGINE SPEED SIGNAL SENSOR GROUND TP SENSOR INPUT FUEL INJECTION PUMP SHUTOFF SOLENOID,, FUEL PUMP RELAY GAUGES FUSE 8 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGN BUSS INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE OSS INPUTS OUT PCS HI PCS LO IGNITION PNK WIRE PPL PPL/WHT WIRE PRESSURE CONTROL SOLENOID RANGE MODE SELECTOR RANGE SIGNAL A RANGE SIGNAL B RANGE SIGNAL C RED WIRE RED/BLK WIRE RUN WIRE SERVICE TRANS IND SERIAL DATA SERVICE TRANSMISSION INDICATOR SYSTEM GROUND SYSTEM GROUND SENSOR GROUND 5 VOLTS REF TAN WIRE TCC PWM SOL 1-2 SHIFT SOL 2-3 SHIFT SOL THROTTLE POSITION SENSOR (RIGHT SIDE OF FUEL INJECTION PUMP) TORQUE CONVERTER CLUTCH, STOPLAMP SWITCH TRANS FLUID TEMP SIG BARO SENSOR INPUT TRANS FUSE 17 TRANSMISSION CONTROL MODULE (LEFT SIDE OF DRIVER'S ISLAND) TRANSMISSION TEMPERATURE SENSOR VEHICLE SPEED INPUT INPUT SPEED SENS LO INPUT SPEED SENS HI VEHICLE SPEED SENSOR CALIBRATOR VEHICLE SPD OUTPUT WHT WIRE WHT/BLK WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID 4.3L (VIN W), 5.7L (VIN R) A/C COMPRESSOR RELAY, GENERATOR, SEAT BELT/ HEADLAMPS ALARM MODULE A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH A/T ISS HI IN A/T ISS LO IN ANTI-LOCK BRAKES, CRUISE CONTROL, SHIFT INTERLOCK SYSTEMS AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE DATA CLASS II DK BLU WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE, CRUISE CONTROL MODULE ENGINE CONTROLS SYSTEM FUEL INJECTORS (ENGINE CONTROLS SYSTEM) FUEL PUMP RELAY, SWITCH GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE PPL PPL DATA LINK CONNECTOR (PARTIAL) (BELOW DASH NEAR STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN SERVICE ENGINE SOON INDICATOR TCC PWM SOL TCC PWM SOLENOID TCC/ STOP LAMPS SWITCH THROTTLE POSITION SENSOR (ON THROTTLE BODY) TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 17 TRANS TEMP SIG IN VEHICLE CONTROL MODULE (CENTER FRONT OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VSS HI VSS LO YEL WIRE YEL/BLK WIRE

14 15 16 PPL PPL 2-3 SHIFT SOL CTRL ANTI-LOCK BRAKE SYSTEM BLK WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CAM POSIT SENS RTN FUEL LEV SIGNAL PPL CAM POSIT SENS SIG CAMSHAFT POSITION (CMP) SENSOR (INTERNAL TO DISTRIBUTOR) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/ WHT WIRE DK GRN/WHT WIRE FUEL TANK PRESSURE SENSOR (AT FUEL TANK) GRY WIRE HALL EFFECT SENSOR HALL EFFECT SENSOR PNK WIRE IDLE AIR CONTROL (IAC) VALVE KNOCK SENS SIG KNOCK SENSOR (KS) (LOWER RIGHT SIDE OF ENGINE) LT BLU/ BLK WIRE LT BLU/ WHT WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WHT/ WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MAP SENSOR IN IAT SENS SIG ECT SENSOR IN THROTTLE POSIT SENS TANK PRESSURE NCA WIRE PNK PNK 1 2 WIRE PNK PNK 30 31 WIRE PNK WIRE PNK/BLK WIRE PPL PPL CKP SENS RTN VSS RTN VSS SIG PPL PPL PPL/WHT WIRE PURGE VENT RED/BLK WIRE TAN WIRE TAN/ WHT WIRE TAN/WHT WIRE VEHICLE SPEED OUT VEHICLE SPEED SENSOR (VSS) (LEFT SIDE OF TRANSMISSION) WHT PPL/ WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOLENOID 14 15 16 PPL PPL 2-3 SHIFT SOLENOID AUTOMATIC TRANSMISSION (A/T) (IF EQUIPPED) (REAR OF ENGINE) BLK WIRE BLU WIRE BLU/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ENG 1 FUSE 15 EXHAUST GAS RECIRCULATION (EGR) VALVE (TOP FRONT OF ENGINE) FUEL INJECTOR 1 FUEL INJECTOR 2 FUEL INJECTOR 3 FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 6 FUEL INJECTOR 7 FUEL INJECTOR 8 GRY WIRE HOT IN RUN, START I/P FUSE BLOCK (BEHIND DASH PANEL) (BODY BUILDER INSTALLED) LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE PNK 5 6 WIRE PNK PNK 1 2 WIRE PNK PNK 30 31 WIRE PNK PNK PNK PNK 1 2 3 4 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL 8 9 10 11 12 13 14 15 16 17 PPL/WHT WIRE PRESSURE CONTROL SOLENOID (PCS) RED WIRE RED/BLK WIRE REV TAN WIRE TAN/WHT WIRE TCC PWM SOLENOID TRANSMISSION FLUID TEMPERATURE SENSOR TRANSMISSION RANGE (TR) PRESSURE SWITCH ASSEMBLY WHT PPL/ WIRE WHT TAN/ WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

2 3 PPL 2-3 SHIFT SOL CTRL ANTI-LOCK BRAKES SYSTEM BANK 2 SENSOR 1 (ON RIGHT EXHAUST DOWN PIPE, BEFORE CATALYTIC CONVERTER) BLK LT GRN/ WIRE BLK WIRE BLK/WHT WIRE BLU/BLK WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (INTERNAL TO DISTRIBUTOR) CMP LOW FUEL GAUGE PPL DK BLU WIRE DK BLU/WHT WIRE FEED IGN GRN/BLK WIRE HEATED OXYGEN KS SIGNAL LEFT KNOCK SENSOR (ON LOWER LEFT SIDE OF ENGINE) LT BLU/ BLK WIRE LT BLU/ WHT WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WHT/ WIRE LT GRN WIRE LT GRN/ BLK WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MAP SIGNAL IAT SIGNAL ECT SIGNAL NCA WIRE PNK 8 9 10 WIRE PNK IGN FEED SENS RTN SENS SIG WIRE PNK WIRE PNK/BLK WIRE PPL PPL CKP LOW VSS LOW VSS SIGNAL PPL PPL PPL/ WHT WIRE PPL/WHT WIRE RED/BLK WIRE RIGHT KNOCK SENSOR (ON LOWER RIGHT SIDE OF ENGINE) SENSOR RTN SIGNAL SENSOR T/P SIGNAL TAN WIRE TAN/WHT WIRE TFT SIGNAL MAF SIGNAL IAC HIGH IAC LOW INJECTOR 4 CTRL INJECTOR 3 CTRL VSS YEL WIRE YEL/BLK WIRE