Chevrolet Forward Control P30 (1985-1999) ign feed Wiring diagrams

2-3 SHIFT SOL CTRL ANTI-LOCK BRAKE SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CAM POSIT SENS RTN FUEL LEV PPL CAMSHAFT POSITION (CMP) SENSOR (INTERNAL TO DISTRIBUTOR) CKP DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRY WIRE HALL EFFECT SENSOR IGN FEED KNOCK SENS SIG KNOCK SENSOR (KS) (TOP CENTER REAR OF ENGINE) LT BLU WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE NCA WIRE PNK PNK PNK 2 3 4 WIRE PNK WIRE PNK/BLK WIRE PPL PPL CKP SENS RTN VSS RTN VSS SIG PPL/WHT WIRE PURGE VENT CTRL RETURN SENSOR CKP SENSOR SIGNAL TAN WIRE TAN/WHT WIRE TANK PRESSURE SENSOR (TOP OF FUEL TANK) VEHICLE SPEED OUT VEHICLE SPEED SENSOR (VSS) (LEFT SIDE OF TRANSMISSION) WHL SPD SIG, LEFT FRT CAM POSIT SENS SIG WHT DK GRN/ WIRE WHT LT BLU/ WIRE WHT LT GRN/ WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

3 4 5 PNK PNK WIRE 389 419 VSS OUTPUT MIL CTRL 420 1807 PPL PPL BRAKE SIG SERIAL DATA 440 1225 1224 IGN FEED RANGE SIG "B" RANGE SIG "A" A/C REQUEST SIG A/C SYSTEM BLK WIRE BLK/WHT WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE BULKHEAD GROMMET TOWARD IGNITION SW) CYLINDER 2 CYLINDER 1 CYLINDER 5 CYLINDER 3 CYLINDER 4 CYLINDER 6 DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM-BAT FUSE 6 EGR VALVE CTRL ELECTRONIC BRAKE CONTROL MODULE FEED FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK (BEHIND DASH PANEL) (BODY BUILDER INSTALLED) IGN FEED IGNITION IGNITION COIL (TOP RIGHT SIDE OF ENGINE) IGNITION CONTROL MODULE (RIGHT TOP OF ENGINE, AT IGNITION COIL) LT BLU/WHT WIRE ORG/ WIRE PCS SOL (HI) INPUT SPD SENS SIG INPUT SPD SENS RTN TIMING CTRL SIG PCS SOL (LO) VCM GROUND VCM GROUND GROUND 451 451 470 PNK 6 7 8 9 10 11 12 13 14 15 WIRE PNK IGN FEED WIRE PNK WIRE PPL PPL (ENGINE HARN, 18 CM FROM BREAKOUT TO BULKHEAD CONN) PPL FUEL LEVEL PRESSURE SWITCH IN RANGE SIG "C" RED WIRE RED/ BLK WIRE RED/BLK WIRE SHIFT INTERLOCK SYSTEM PPL SPARK PLUGS TIMING CONTROL RETURN TIMING CONTROL SIGNAL) TORQUE CONVERTER CLUTCH, STOP LAMP SWITCH (AT BRAKE PEDAL SUPPPORT) TRANSMISSION INPUT SPEED SENSOR (ON LEFT SIDE OF TRNASMISSION, NEAR THE MIDDLE) WHT WIRE WHT/ BLU WIRE WHT/BLK WIRE

3 4 5 6 7 8 9 10 11 12 13 14 15 16 PNK PNK WIRE 389 419 VSS OUTPUT MIL CTRL 420 1807 PPL PPL BRAKE SIG SERIAL DATA 440 1225 1224 IGN FEED RANGE SIG "B" RANGE SIG "A" A/C REQUEST SIG A/C SYSTEM A/T INPUT SPEED SENSOR (TRANSMISSION, LEFT FRONT) ANTI-LOCK BRAKES SYSTEM BLK RED/ WIRE BLK WIRE BLK/WHT WIRE BLU/ WHT WIRE BRN WIRE BRN/WHT WIRE BULKHEAD GROMMET TOWARD IGNITION SW) CLUTCH PEDAL POSITION SWITCH (LEFT SIDE OF BRAKE PEDAL BRACKET) CLUTCH SIG CYLINDER NO.2 CYLINDER NO.1 CYLINDER NO.5 CYLINDER NO.3 CYLINDER NO.4 CYLINDER NO.6 DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM B FUSE 6 EGR VALVE CTRL FEED IGNITION FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) FUEL PUMP RELAY (ON FIRE- WALL, UNDER BATTERY JUNCTION BLOCK) GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) IGN FEED IGNITION COIL (TOP RIGHT SIDE OF ENGINE) IGNITION CONTROL MODULE (RIGHT TOP OF ENGINE) LT BLU/WHT WIRE ORG/ WIRE PCS SOL (HI) INPUT SPD SENS SIG INPUT SPD SENS RTN TIMING CTRL SIG PCS SOL (LO) SYSTEM GROUND SYSTEM GROUND GROUND 451 451 470 PNK IGN FEED WIRE PNK WIRE PPL PPL FUEL LEVEL PRESSURE SWITCH IN RANGE SIG "C" RED WIRE RED/BLK WIRE RETURN CONTROL TIMING SHIFT INTERLOCK SYSTEM PPL SIGNAL CONTROL TIMING SPARK PLUGS TCC/STOP LAMPS SWITCH (RIGHT SIDE OF STEERING COLUMN UPPER SUPPORT) VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE WHT/BLK WIRE

389 419 VSS OUTPUT MIL CTRL 440 1225 1224 IGN FEED RANGE SIG "B" RANGE SIG "A" 5 6 7 8 9 PNK PNK WIRE A/C REQUEST SIG A/C SW IN A/C SYSTEM BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION SWITCH (TOP OF CLUTCH PEDAL SUPPORT) CLUTCH SIG CYLINDER 1 CYLINDER 4 CYLINDER 5 CYLINDER 3 CYLINDER 6 CYLINDER 7 CYLINDER 2 CYLINDER 8 DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK BLU/ WHT WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM-BAT FUSE 6 EGR CTRL ELECTRONIC BRAKE CONTROL MODULE FEED IGNITION FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK (BEHIND DASH PANEL) (BODY BUILDER INSTALLED) IGN FEED IGNITION COIL (TOP RIGHT SIDE OF ENGINE) IGNITION CONTROL MODULE (RIGHT TOP OF ENGINE, AT IGNITION COIL) LT BLU/WHT WIRE ORG/ WIRE PCS SOL (HI) INPUT SPD SENS SIG INPUT SPD SENS RTN TIMING CTRL SIG PCS SOL (LO) VCM GND VCM GND GND 451 451 470 PNK IGN FEED WIRE PNK WIRE PPL PPL 1 2 PPL 2 4 5 16 DATA LINK CONNECTOR (DLC) (BELOW DASH, NEAR STEERING COLUMN) PPL ANTI-LOCK BRAKE SYSTEM PPL FUEL LEV PPL PPL 420 1807 BRAKE SIG SERIAL DATA RANGE SIG "C" RED WIRE RED/ BLK WIRE RED/BLK WIRE RETURN CONTROL TIMING SIGNAL CONTROL TIMING SPARK PLUGS TORQUE CONVERTER CLUTCH, STOP LAMP SWITCH (AT BRAKE PEDAL SUPPORT) TRANSMISSION INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION, NEAR THE MIDDLE) WHT WIRE WHT/BLK WIRE

389 419 VSS OUTPUT MIL CTRL 440 1225 1224 IGN FEED RANGE SIG "B" RANGE SIG "A" A/C REQUEST SIG A/C SW IN A/C SYSTEM A/T INPUT SPEED SENSOR (TRANSMISSION, LEFT FRONT) BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION SWITCH (TOP OF CLUTCH PEDAL SUPPORT) CLUTCH SIG CYLINDER 1 CYLINDER 4 CYLINDER 5 CYLINDER 3 CYLINDER 6 CYLINDER 7 CYLINDER 2 CYLINDER 8 DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM B FUSE 6 EGR CTRL FROM LEFT BULKHEAD GROMMET) PPL FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) FUEL PUMP RELAY (ENGINE BULKHEAD RELAY BRACKET UNDER BATTERY JUNCTION BLOCK) GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) IGN FEED IGNITION COIL (TOP RIGHT SIDE OF ENGINE) IGNITION CONTROL MODULE (BRACKET AT TOP EDGE OF RIGHT CYLINDER HEAD) IGNITION FEED LT BLU/WHT WIRE ORG/ WIRE PCS SOL (HI) INPUT SPD SENS SIG INPUT SPD SENS RTN TIMING CTRL SIG PCS SOL (LO) SYSTEM GND SYSTEM GND GND 451 451 470 PNK IGN FEED WIRE PNK PNK WIRE PNK WIRE PPL PPL 1 2 PPL 2 4 5 16 DATA LINK CONNECTOR (DLC) (BELOW DASH, NEAR STEERING COLUMN) PPL ANTI-LOCK BRAKE SYSTEM PPL FUEL LEV PPL PPL 420 1807 BRAKE SIG SERIAL DATA RANGE SIG "C" RED WIRE RED/ BLK WIRE RED/BLK WIRE SHIFT INTERLOCK SYSTEM SPARK PLUGS TCC/ STOP LAMPS SWITCH (RIGHT SIDE OF STEERING COLUMN UPPER SUPPORT) TIMING CONTROL RETURN TIMING CONTROL SIGNAL) VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/ DK BLU WIRE WHT/BLK WIRE

B+ BREAKOUT) BATTERY JUNCTION BLOCK (LEFT SIDE OF ENGINE BULKHEAD, ABOVE RELAY BRACKET) BLK WIRE BLU WIRE BRN WIRE BULKHEAD GROMMET) DK BLU WIRE DK GRN WIRE ENG-1 FUSE 20 A FUEL HEATER (REAR OF INTAKE MANIFOLD, PART OF FUEL/WATER SEPARATOR) (FILTER) FUEL INJECTION PUMP COLD ADVANCE SOLENOID (IN FUEL INJECTION PUMP) FUSIBLE LINK FUSIBLE LINK (12 GA- FUSIBLE LINK (14 GA- FUSIBLE LINK (20 GA- FUSIBLE LINK FUSIBLE LINK FUSIBLE LINK FUSIBLE LINK FUSIBLE LINK GLOW PLUG STUD GLOWPLUG CONTROL SWITCH (REAR OF LEFT CYLINDER HEAD) GROUND GRY WIRE HOT AT ALL TIMES HOT IN (ON) RUN, START (CRANK) I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) IGN FEED LEFT BANK GLOWPLUGS (CYLINDER HEADS BELOW VALVE COVERS) LEFT GLOWPLUG BREAKOUTS) LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/ WIRE PNK (COIL) WIRE PNK 12 13 15 WIRE PNK IGN FEED IND LAMP OUT GROUND WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL (NOT USED) PPL PPL PNK 3 4 5 6 7 8 WIRE PPL STARTER FEED PPL/WHT WIRE PRESSURE DIFF SW BREAKOUT) RED WIRE RIGHT BANK GLOWPLUGS (CYLINDER HEADS BELOW VALVE COVERS) STUD TRANS FUSE VEHICLE SPEED SENSOR (VSS) (LEFT REAR OF TRANSMISSION, NEAR CENTER) VSS RTN GROUND IGN FEED VSS SIG VSS VSS OUT YEL/BLK WIRE

5-VOLT 6 9 DATA LINK CONNECTOR (PARTIAL) (BELOW DASH, NEAR STEERING COLUMN) BAROMETRIC PRESSURE (BARO) SENSOR (TOP LEFT REAR OF INTAKE MANIFOLD) BATTERY FEED BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE EBCM ECM 1 FUSE 12 ECM-BAT FUSE 6 ELECTRONIC BRAKE CONTROL MODULE (BELOW RADIATOR, ON LOWER CROSSMEMBER) ENG SPEED SENS IN SENSOR RETURN TP SENS SIG ENGINE SPEED SENSOR (REAR OF INTAKE MANIFOLD, NEAR FUEL FILTER) GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK (BEHIND DASH PANEL) (BODY BUILDER INSTALLED) IGN FEED LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK 3 4 5 6 7 8 WIRE PNK WIRE PPL PPL BRAKE PEDAL SW IN TCC PWM SOL CTRL PPL STOPLMP SW IN PPL/WHT WIRE PRESS CTRL SOL (LO) IGN FEED PNK WIRE PRESS CTRL SOL. HI RED WIRE RED/BLK WIRE REF RTN SENSOR SERVICE TRANS OUT SERIAL DATA SIG TAN WIRE TCM GROUND TCM GROUND SENSOR RETURN TFT SIG BARO PRESS SENS SIG THROTTLE POSITION SENSOR (TPS) (RIGHT SIDE OF FUEL INJECTION PUMP) TO GLOWPLUG CONTROLLER) VEHICLE SPEED SENSOR (VSS) (LEFT SIDE OF TRANSMISSION) VEHICLE SPEED SIG SPEED SENSOR SPEED SENSOR VSS VSS INPUT VSS OUT VSS RTN VSS SIG WHT WIRE YEL/BLK WIRE

BATTERY JUNCTION BLOCK (LEFT SIDE OF ENGINE BULKHEAD, ABOVE RELAY BRACKET) BLK WIRE BLU WIRE DK BLU WIRE ECM-1 FUSE 20 A ENG-1 FUSE 20 A FUEL HEATER (REAR OF INTAKE MANIFOLD, PART OF FUEL/WATER SEPARATOR) (FILTER) FUEL INJECTION PUMP FUEL SHUT-OFF SOLENOID (AT FUEL INJECTION PUMP) FUSIBLE LINK FUSIBLE LINK (12 GA- FUSIBLE LINK (14 GA- FUSIBLE LINK (20 GA- FUSIBLE LINK FUSIBLE LINK GLOW PLUG STUD GLOWPLUG CONTROL SWITCH (REAR OF LEFT CYLINDER HEAD) GROUND GRY WIRE HOT AT ALL TIMES HOT IN (ON) RUN, START (CRANK) I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) IGN FEED LEFT BANK GLOWPLUGS (CYLINDER HEADS BELOW VALVE COVERS) LEFT GLOWPLUG BREAKOUTS) NCA WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM PPL PPL STARTER FEED RED WIRE RIGHT BANK GLOWPLUGS (CYLINDER HEADS BELOW VALVE COVERS) STUD

2 3 PPL 2-3 SHIFT SOL CTRL ANTI-LOCK BRAKES SYSTEM BANK 2 SENSOR 1 (ON RIGHT EXHAUST PIPE BEFORE CATALYTIC CONVERTER) BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BLU/BLK WIRE BRN WIRE BRN/WHT WIRE CAMSHAFT POSITION SENSOR (INTERNAL TO DISTRIBUTOR) CMP LOW FUEL GAUGE PPL DK BLU WIRE DK BLU/WHT WIRE GRN/BLK WIRE HEATED OXYGEN IGN FEED KS SIGNAL LEFT KNOCK SENSOR (ON LOWER LEFT SIDE OF ENGINE) LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/ BLK WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MAP SIGNAL IAT SIGNAL ECT SIGNAL NCA WIRE PNK 8 9 10 WIRE PNK IGN FEED SENS RTN SENS SIG WIRE PNK WIRE PNK/BLK WIRE PPL PPL CKP LOW VSS LOW VSS SIGNAL PPL PPL PPL/WHT WIRE RED/BLK WIRE RIGHT KNOCK SENSOR (ON LOWER RIGHT SIDE OF ENGINE) SENSOR RTN SENSOR SIGNAL T/P SIGNAL TAN WIRE TAN/WHT WIRE TFT SIGNAL MAF SIGNAL IAC HIGH IAC LOW INJECTOR 4 CTRL INJECTOR 3 CTRL VEHICLE CONTROL MODULE (VCM) (CENTER FRONT OF ENGINE COMPARTMENT) VSS WHT LT BLU/ WIRE WHT LT GRN/ WIRE WHT PPL/ WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 PNK PNK WIRE A/C COMP CYL SW A/C REQUEST SIGNAL AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM PPL AUX ELECT COOLING FAN BRAKE SIGNAL SERIAL DATA PPL PPL 420 1807 B(+) BATTERY FEED RANGE SIGNAL B RANGE SIGNAL A 1225 1224 PNK WIRE BLK RED/ WIRE BLK WIRE BLK/WHT WIRE BLU/ WHT WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE COOLING FANS SYSTEM CRUISE CONTROL MODULE (ON RADIATOR SUPPORT BRACKET) CRUISE CTRL ENGAGED CRUISE ENGAGED SIG CYLINDER 1 CYLINDER 4 CYLINDER 5 CYLINDER 3 CYLINDER 6 CYLINDER 7 CYLINDER 2 CYLINDER 8 DISTRIBUTOR DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM B FUSE 6 EGR VALVE FEED EGR VLV CTRL ELEC SPK TIMING CTRL SIGNAL EST CTRL FUEL PMP RLY CTRL 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY (LEFT SIDE OF ENGINE COMPT) GRN WIRE GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK IGN FEED IGNITION COIL (ON BRACKET AT REAR OF INTAKE PLENUM) IGNITION COIL MODULE (ON BRACKET AT REAR OF INTAKE PLENUM) LT BLU/BLK WIRE LT BLU/WHT WIRE ORG/ WIRE PCS HIGH INPUT SPEED SENS LOW INPUT SPEED SENS HIGH IC CNTRL PCS LOW GROUND GROUND SENS GROUND PNK 22 23 WIRE PNK IGN FEED WIRE PNK WIRE PPL PPL DATA LINK CONNECTOR (DLC) (BELOW DASH, NEAR STEERING COLUMN) 4 5 PPL FUEL LEVEL MODULE A/C REC PPL TCC/STOPLAMP INPUT RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SPARK PLUGS SPEED SENSOR INPUT VEHICLE CONTROL MODULE (VCM) (ON CENTER FRONT OF ENGINE COMPARTMENT) VSS OUTPUT SIGNAL VSS OUTPUT SIGNAL CHECK ENGINE LP CTRL 389 419 WHT DK GRN/ WIRE WHT WIRE WHT/BLK WIRE