Chevrolet Forward Control P30 (1985-1999) i-3 fuse Wiring diagrams

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID 3-2 SHIFT SOL 3-2 SHIFT SOLENOID A/T ISS SENS HI IN A/T ISS SENS LO IN ACCELERATOR PEDAL POSITION (APP) MODULE (THROTTLE PEDAL MOUNT) APP 1 SIGNAL IN APP 2 SIGNAL IN APP 3 SIGNAL IN AUTO TRANSMISSION INPUT SHAFT SPEED SENSOR (INSIDE FRONT OF TRANSMISSION) AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BRAKE SWITCH ASSEMBLY (ON BRAKE PEDAL BRACKET) BRAKE SWITCH IN BRN WIRE BRN/WHT WIRE CLASS II DATA DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE ECM I FUSE ECT SENSOR IN ENGINE COOLANT TEMP SENSOR (LEFT LOWER FRONT OF ENGINE) GAUGES FUSE TRANS FUSE GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE POWERTRAIN CONTROL MODULE (ENGINE COMPT, TOP OF RADIATOR SUPPORT) PPL PPL DATA LINK CONNECTOR PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE SENSOR GROUND STOP/HAZ FUSE STOPLAMP SWITCH IN TFT SENSOR IN TRANS FLUID TEMP SENSOR TRANS RANGE "A" TRANS RANGE "B" TRANS RANGE "C" TRANS RANGE PRESSURE SWITCH ASSEMBLY VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR (VSS) BUFFER (ABOVE ACCELERATOR PEDAL) VSS HI IN VSS LO IN VSS OUT YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 9 6 DATA LINK CONNECTOR BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE ECM BAT FUSE ECM I FUSE ENGINE SPEED SENSOR (TOP CENTER OF ENGINE) GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK RANGE SIGNAL A RANGE SIGNAL B RANGE SIGNAL C WIRE PNK WIRE PPL PPL/WHT WIRE RANGE MODE SELECTOR PRESSURE CONTROL SOLENOID RED WIRE RED/BLK WIRE SERVICE TRANSMISSION INDICATOR SYSTEM GROUND SYSTEM GROUND 452 416 SENSOR GROUND 5 VOLTS REF TAN WIRE TCC SOL 2-3 SHIFT SOL TCC/BRAKE SWITCH (BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (RIGHT SIDE OF THROTTLE BODY) TRANS FUSE TRANS- MISSION TEMP SENSOR TRANSMISSION TRANSMISSION CONTROL MODULE (TCM) (LEFT SIDE OF DRIVER'S ISLAND) TRANSMISSION INPUT SHAFT SPEED SENSOR (LEFT FRONT SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR (REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER VEHICLE SPD OUTPUT VSS INPUTS WHT WIRE WHT/BLK WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1227 433 TRANS FLUID TEMP SIG BARO SENSOR INPUT 2-3 SHIFT SOL CTRL 1-2 SHIFT SOL CTRL DIAGNOSTIC TEST 9 6 DATA LINK CONNECTOR (PARTIAL) (BELOW DASH, NEAR STEERING COLUMN) A/T INPUT SPEED SENSOR (LEFT FRONT SIDE OF TRANSMISSION) AUTOMATIC TRANSMISSION BAROMETRIC PRESSURE SENSOR (TOP LEFT REAR OF INTAKE MANIFOLD) BATTERY FEED BLK WIRE BLK/WHT WIRE BRN WIRE DASH FUSE BLOCK DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE ECM BAT FUSE ENGINE SPEED SENSOR (IN FUEL INJECTION PUMP) ENGINE SPEED SIGNAL SENSOR GROUND TP SENSOR INPUT GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START I-3 FUSE INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE OUT PCS HI PCS LO IGNITION PNK WIRE PNK RANGE SIGNAL A RANGE SIGNAL B RANGE SIGNAL C WIRE PNK WIRE PPL PPL BRAKE SIGNAL TCC PWM CONTROL PPL/WHT WIRE PRESSURE CONTROL SOLENOID RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RUN WIRE SERVICE TRANS OUTPUT SERIAL DATA SERVICE TRANSMISSION INDICATOR STOP LAMPS, TORQUE CONVERTER BRAKE SWITCH SYSTEM GROUND SYSTEM GROUND 452 416 SENSOR GROUND 5 VOLTS REF TAN WIRE TCC PWM SOL 2-3 SHIFT SOL THROTTLE POSITION SENSOR (RIGHT SIDE OF FUEL INJECTION PUMP) TRANS FUSE TRANSMISSION CONTROL MODULE (LEFT INTERIOR FIREWALL) TRANSMISSION TEMPERATURE SENSOR VEHICLE SPD OUTPUT VEHICLE SPEED INPUT INPUT SPEED SENS LO INPUT SPEED SENS HI VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER VEHICLE SPEED SENSOR BUFFER, FUEL INJECTION PUMP FUEL SHUT OFF SOLENOID PNK WIRE VSS INPUTS WHT WIRE WHT/BLK WIRE YEL/BLK WIRE

4000 PULSES/MILE BLK WIRE BLU WIRE BRN WIRE CRUISE CONTROL MODULE (RADIATOR SUPPORT BRACKET) CRUISE CONTROL SWITCH CRUISE ON INPUT SET/COAST INPUT RESUME/ACCEL INPUT DK BLU WIRE DK GRN WIRE GRY WIRE GRY/BLK WIRE HAZARD LAMPS FLASHER HOT AT ALL TIMES HOT IN RUN I-3 FUSE I/P FUSE BLOCK LT BLU WIRE NCA WIRE OFF ORG/ WIRE PPL PPL DISENGAGE INPUT GROUND IGNITION BRAKE APPLIED INPUT R/A S/C STOP/HAZ FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) TORQUE CONVERTER CLUTCH AND STOPLAMPS SWITCH (TOP OF BRAKE PEDAL) VEHICLE SPEED INPUT VEHICLE SPEED SENSOR BUFFER (ABOVE ACCELERATOR PEDAL)

2-3 SHIFT SOL 6 9 DATA LINK CONNECTOR BLK WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE ECM BAT FUSE ECM I FUSE ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) GAUGES FUSE GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I-3 FUSE I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK IGNITION FEED WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT SIDE OF DRIVER'S ISLAND) PPL PPL PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOLENOID RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON INDIC SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) TAN WIRE TCC PWM SOL 1-2 SHIFT SOL TCC/BRAKE SWITCH (ON BRAKE PEDAL BRACKET) THROTTLE POSITION SENSOR (ON SIDE OF THROTTLE BODY) TRANS FLUID TEMP (TFT) SENSOR TRANS FUSE TRANSMISSION TRANSMISSION INPUT SHAFT SPEED SENSOR (FRONT OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

2-3 SHIFT SOL A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) ANTI-LOCK BRAKES AUTOMATIC TRANSMISSION BLK WIRE BRN WIRE BRN/WHT WIRE BUSS BAR CRUISE CONTROL SYSTEMS DASH FUSE BLOCK DATA LINK CONNECTOR (PARTIAL) (BELOW DASH, NEAR STEERING COLUMN) DK BLU WIRE DK BLU/WHT WIRE ECM BAT FUSE ECM I FUSE ENGINE CONTROLS SYSTEMS ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUEL INJECTORS (ENGINE CONTROLS) FUEL PUMP RELAY GAUGES FUSE GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START HOT IN RUN, BULB TEST OR START I-3 FUSE INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK IGNITION FEED WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF DASH) PPL PPL PNK WIRE PPL/WHT WIRE PRESSURE CONTROL SOL RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RUN WIRE SERVICE ENGINE SOON INDICATOR STOP LAMPS, TORQUE CONVERTER BRAKE SWITCH SWITCH TAN WIRE TCC PWM SOL 1-2 SHIFT SOL THROTTLE POSITION SENSOR (ON SIDE OF THROTTLE BODY) TRANS FLUID TEMP SENSOR TRANS FUSE VEHICLE SPEED SENSOR (LEFT REAR SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (ABOVE ACCELERATOR PEDAL) WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

85 30 PPL BLK WIRE BRAKE/ BRAKE/TRANSMISSION SHIFT INTERLOCK (BTSI) SOLENOID (ON STEERING COLUMN) BRN WIRE DIESEL DIESEL ONLY DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (BELOW RADIATOR ON CROSSMEMBER) GASOLINE HOT IN RUN I-3 FUSE I/P FUSE BLOCK PARK/NEUTRAL POSITION AND BACKUP LAMPS SWITCH (LEFT OF TRANS) PPL TORQUE CONVERTER CLUTCH AND STOP LAMPS SWITCH (RIGHT SIDE OF STEERING COLUMN) TRANS- MISSION CONTROL MODULE (TCM) (LEFT INTERIOR FIREWALL) TURN SIGNAL FLASHER (ON FUSE BLOCK) TURN-B/U FUSE VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENG COMPT) IGN YEL WIRE

85 30 PPL BLK WIRE BRAKE/ BRAKE/TRANSMISSION SHIFT INTERLOCK (BTSI) SOLENOID (ON STEERING COLUMN) BRN WIRE DIESEL DK GRN/WHT WIRE GASOLINE HOT IN RUN I-3 FUSE I/P FUSE BLOCK PARK/ NEUTRAL POSITION SWITCH RELAY PARK/NEUTRAL POSITION, BACKUP LAMP SWITCH (LEFT OF TRANS) POWER- TRAIN CONTROL MODULE (LEFT OF DRIVER'S ISLAND) PPL TORQUE CONVERTER CLUTCH, STOP LAMPS SWITCH (REAR OF BRAKE SUPPORT BRACKET) TURN-B/U FUSE VEHICLE CONTROL MODULE (TOP OF RADIATOR SUPPORT) IGN YEL WIRE

1227 433 TFT SIG BARO PRESS SENS SIG 451 451 TCM GROUND TCM GROUND SENSOR RETURN 5 VOLT REF 8 9 PNK WIRE BAROMETRIC PRESSURE (BARO) SENSOR (TOP OF INTAKE MANIFOLD, LEFT SIDE IN BACK) BATTERY FEED BLK WIRE BLK/WHT WIRE BRN WIRE DK BLU WIRE ECM BAT FUSE ELECTRONIC BRAKE CONTROL MODULE (BELOW RADIATOR ON FIRST CROSSMEMBER) ENG-BAT FUSE ENGINE SPEED SENS IN SENSOR RETURN TP SENS SIG ENGINE SPEED SENSOR (IN FUEL INJECTION PUMP) FROM LEFT BULKHEAD GROMMET) GENERATOR JUMPER BREAKOUT) GLOWPLUG CONTROL SWITCH BREAKOUT) GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES I-3 FUSE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE PNK WIRE PPL PPL BRAKE PEDAL SW IN TCC PWM SOL CTRL PPL STOPLMP SW IN PRESS CTRL SOL (LO) IGN FEED PNK WIRE PRESS CTRL SOL. HI RED WIRE RED/BLK WIRE REF 5 VOLT RTN SENSOR SENSOR RTN SENSOR SIG SERVICE TRANS OUT SERIAL DATA SIG SENSOR TAN WIRE THROTTLE POSITION SENSOR (TPS) (RIGHT SIDE OF FUEL INJECTION PUMP) VEHICLE SPEED SIG WHT WIRE WHT/BLK WIRE YEL/BLK WIRE

4 7 8 9 11 12 13 15 VSS OUT VSS RETURN GROUND BLK WIRE BLK/RED WIRE BREAKOUT FOR ENGINE COOLANT FAN MOTOR, TOWARD CRUISE CONTROL MODULE) BRN WIRE BRN/WHT WIRE CONTACT CRUISE CONTROL MODULE (ON RADIATOR SUPPORT BRACKET) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BAT FUSE ENG 1 FUSE ENGINE COOLANT TEMPERATURE SENSOR (FRONT, CENTER OF ENGINE COOLANT INTAKE) FROM BREAKOUT FOR CRUISE CONTROL MODULE, TOWARD ENG) FROM BREAKOUT FOR GENERATOR) GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, START (CRANK) I-3 FUSE I/P FUSE BLOCK (MOUNTED ON THE I/P) IDLE SPEED CONTROL ACTUATOR (ON THROTTLE BODY) LEFT BULK- HEAD GROMMET UNDER I/P) LINEAR EGR SOLENOID VALVE (NO COMPONENT LOCATION AVAILABLE) LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE PNK 9 10 11 12 13 14 15 16 WIRE PNK PNK 1 2 3 4 5 WIRE PNK PNK 26 27 WIRE PNK WIRE PPL PPL 16 17 18 19 PPL TCC/STOPLAMP INPUT PPL/WHT WIRE RED WIRE TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON LEFT SIDE OF THROTTLE BODY) VEHICLE SPEED SENSOR (ON LEFT REAR SIDE OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (ON DRIVER'S ISLAND SUPPORT ABOVE ACCELERATOR PEDAL) VSS VSS LO VSS SIG VSS HI SECOND. VSS WHT WIRE YEL WIRE