Chevrolet Forward Control P30 (1985-1999) i-3 fuse 9 Wiring diagrams

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID A/C COMPRESSOR RELAY, GENERATOR, SEAT BELT/ HEADLAMPS ALARM MODULE A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) A/T ISS HI IN A/T ISS LO IN A/T OUTPUT SPEED SENSOR ANTI-LOCK BRAKES, CRUISE CONTROL, SHIFT INTERLOCK SYSTEMS AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE BUSS BAR GAUGES FUSE 8 DATA CLASS II DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE, CRUISE CONTROL MODULE ENGINE CONTROLS SYSTEM FUEL INJECTORS (ENGINE CONTROLS SYSTEM) FUEL PUMP RELAY, SWITCH GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE PPL PPL DATA LINK CONNECTOR (PARTIAL) (BELOW DASH NEAR STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN SERVICE ENGINE SOON INDICATOR TCC PWM SOL TCC PWM SOLENOID TCC/ STOP LAMPS SWITCH TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 17 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS TEMP SIG IN TWISTED WIRE PAIR VEHICLE CONTROL MODULE (CENTER FRONT OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VSS HI VSS LO YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID A/C COMPRESSOR RELAY, GENERATOR, SEAT BELT/ HEADLAMPS ALARM MODULE A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) A/T ISS HI IN A/T ISS LO IN A/T OUTPUT SPEED SENSOR ANTI-LOCK BRAKES, CRUISE CONTROL, SHIFT INTERLOCK SYSTEMS AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BRAKE SWITCH INPUT BRN WIRE BRN/WHT WIRE BUSS BAR GAUGES FUSE 8 DATA CLASS II DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENS INPUT ELECTRONIC BRAKE CONTROL MODULE, CRUISE CONTROL MODULE ENGINE CONTROLS SYSTEM FUEL INJECTORS (ENGINE CONTROLS SYSTEM) FUEL PUMP RELAY, SWITCH GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK WIRE PPL PPL DATA LINK CONNECTOR (PARTIAL) (BELOW DASH NEAR STEERING COLUMN) PPL/WHT WIRE PRESS CTRL SOLENOID RANGE SIGNAL "A" RANGE SIGNAL "B" RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SENSOR RETURN SERVICE ENGINE SOON INDICATOR TCC PWM SOL TCC PWM SOLENOID TCC/ STOP LAMPS SWITCH TP SENS INPUT TRANS FLUID TEMP SENSOR TRANS FUSE 17 TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANS TEMP SIG IN TWISTED WIRE PAIR VEHICLE CONTROL MODULE (CENTER FRONT OF ENGINE COMPT) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VSS HI VSS LO YEL WIRE YEL/BLK WIRE

BLK WIRE BLU WIRE BRAKE APPLIED INPUT BRN WIRE CRUISE ON INPUT DK BLU WIRE DK GRN/WHT WIRE GRY WIRE GRY/BLK WIRE HAZARD LAMPS FLASHER HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK LT BLU WIRE MULTIFUNCTION LEVER NCA WIRE OFF ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT SIDE OF DRIVER'S ISLAND) PPL PPL DISENGAGE INPUT R/A RESUME/ACCEL INPUT S/C DK SET/COAST INPUT STOP/HAZ FUSE 11 STOPLAMP SWITCH (TOP OF BRAKE PEDAL) VEHICLE SPEED SENSOR BUFFER (ABOVE ACCELERATOR PEDAL) VSS HI VSS LO

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID 3-2 SHIFT SOL 3-2 SHIFT SOLENOID A/C COMPRESSOR RELAY, GENERATOR, TURBO CHARGER POWER VALVE A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) A/T ISS SENS HI IN A/T ISS SENS LO IN ACCELERATOR PEDAL POSITION MODULE (ATTACHED TO ACCELERATOR PEDAL) APP 1 SIGNAL IN APP 2 SIGNAL IN APP 3 SIGNAL IN AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BRAKE SWITCH IN BRN WIRE BRN/WHT WIRE BUSS BAR CLASS II DATA DATA LINK CONNECTOR (PARTIAL) (BELOW DASH, NEAR STEERING COLUMN) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENSOR IN ELECTRONIC BRAKE CONTROL MODULE ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUEL PUMP RELAY, FUEL PUMP SWITCH/ENGINE OIL PRESSURE INDICATOR SENSOR GAUGES FUSE 8 GRY WIRE HAZARD LAMPS FLASHER (ABOVE STEERING COLUMN) HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK INSTRUMENT CLUSTER WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF DRIVER'S ISLAND) PPL PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE SENSOR GROUND SERVICE ENGINE SOON INDICATOR STOP-HAZ FUSE 11 STOPLAMP SWITCH IN TFT SENSOR IN TORQUE CONVERTER CLUTCH BRAKE, STOPLAMP SWITCH TRANS FLUID TEMP SENSOR TRANS RANGE "A" TRANS RANGE "B" TRANS RANGE "C" TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANSMISSION FUSE 17 TWISTED WIRE PAIR VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR CALIBRATOR (ABOVE ACCELERATOR PEDAL) VEHICLE SPEED SENSOR CALIBRATOR, ENGINE SHUTOFF SOLENOID VSS HI IN VSS LO IN VSS OUT YEL WIRE YEL/BLK WIRE

396 817 CRUISE STATUS VEHICLE SPEED INPUT 4000 PULSES/MILE CRUISE STATUS BLK WIRE BLU WIRE BRN WIRE CRUISE CONTROL MODULE (RADIATOR SUPPORT BRACKET) CRUISE CONTROL SWITCH CRUISE ON INPUT SET/COAST INPUT RESUME/ACCEL INPUT DK BLU WIRE DK GRN/WHT WIRE GRY WIRE GRY/BLK WIRE HAZARD LAMPS FLASHER HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE OFF ORG/ WIRE PPL PPL DISENGAGE INPUT GROUND IGNITION BRAKE APPLIED INPUT PPL/WHT WIRE R/A S/C STOP/HAZ FUSE 11 STOPLAMP SWITCH (TOP OF BRAKE PEDAL) VEHICLE CONTROL MODULE (VCM) (TOP OF RADIATOR SUPPORT) VEHICLE SPEED SENSOR (VSS) VSS RETURN VSS SIGNAL

1996 VFTC 7.4L VIN J ENGINE 7.4L VIN J ENGINES A/C COMPRESSOR RELAY GENERATOR AUX CIRCUIT BREAKER 13 BRN WIRE BUSS BAR CANADIAN MODELS CRUISE CONTROL MODULE CRUISE CONTROL SWITCH DAYTIME RUNNING LAMP RELAY DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE FROM ENG-1 FUSE (DIAGRAM 2 OF 4) FROM IGNITION SWITCH (DIAGRAM 2 OF 4) GAUGES FUSE 8 GRY WIRE HTR FUSE 1 I-3 FUSE 9 I/P FUSE BLOCK (MOUNTED ON THE DASH) INSTR LPS FUSE 16 INSTRUMENT CLUSTER INTERIOR LIGHTS SYSTEM (INSTRUMENT PANEL DIMMER SWITCH) NCA WIRE ORG/ WIRE PNK PNK WIRE PNK WIRE SEATBELT/ LAMPS ALARM MODULE DAYTIME RUNNING LAMP CONTROL MODULE TO ECM 1 FUSE DIAGRAM 3 OF 4) TORQUE CONVERTER CLUTCH AND STOP LAMPS SWITCH TURN B/U FUSE 5 TURN SIGNAL FLASHER VEHICLE CONTROL MODULE WIPER MOTOR BREAKOUT) PNK WIRE

3 4 5 6 7 8 9 10 11 12 13 14 15 16 PNK PNK WIRE 389 419 VSS OUTPUT MIL CTRL 420 1807 PPL PPL BRAKE SIG SERIAL DATA 440 1225 1224 IGN FEED RANGE SIG "B" RANGE SIG "A" A/C REQUEST SIG A/C SYSTEM A/T INPUT SPEED SENSOR (TRANSMISSION, LEFT FRONT) ANTI-LOCK BRAKES SYSTEM BLK RED/ WIRE BLK WIRE BLK/WHT WIRE BLU/ WHT WIRE BRN WIRE BRN/WHT WIRE BULKHEAD GROMMET TOWARD IGNITION SW) CLUTCH PEDAL POSITION SWITCH (LEFT SIDE OF BRAKE PEDAL BRACKET) CLUTCH SIG CYLINDER NO.2 CYLINDER NO.1 CYLINDER NO.5 CYLINDER NO.3 CYLINDER NO.4 CYLINDER NO.6 DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM B FUSE 6 EGR VALVE CTRL FEED IGNITION FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) FUEL PUMP RELAY (ON FIRE- WALL, UNDER BATTERY JUNCTION BLOCK) GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) IGN FEED IGNITION COIL (TOP RIGHT SIDE OF ENGINE) IGNITION CONTROL MODULE (RIGHT TOP OF ENGINE) LT BLU/WHT WIRE ORG/ WIRE PCS SOL (HI) INPUT SPD SENS SIG INPUT SPD SENS RTN TIMING CTRL SIG PCS SOL (LO) SYSTEM GROUND SYSTEM GROUND GROUND 451 451 470 PNK IGN FEED WIRE PNK WIRE PPL PPL FUEL LEVEL PRESSURE SWITCH IN RANGE SIG "C" RED WIRE RED/BLK WIRE RETURN CONTROL TIMING SHIFT INTERLOCK SYSTEM PPL SIGNAL CONTROL TIMING SPARK PLUGS TCC/STOP LAMPS SWITCH (RIGHT SIDE OF STEERING COLUMN UPPER SUPPORT) VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPARTMENT) WHT WIRE WHT/BLK WIRE

389 419 VSS OUTPUT MIL CTRL 440 1225 1224 IGN FEED RANGE SIG "B" RANGE SIG "A" A/C REQUEST SIG A/C SW IN A/C SYSTEM A/T INPUT SPEED SENSOR (TRANSMISSION, LEFT FRONT) BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH PEDAL POSITION SWITCH (TOP OF CLUTCH PEDAL SUPPORT) CLUTCH SIG CYLINDER 1 CYLINDER 4 CYLINDER 5 CYLINDER 3 CYLINDER 6 CYLINDER 7 CYLINDER 2 CYLINDER 8 DISTRIBUTOR (TOP REAR OF ENGINE) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM B FUSE 6 EGR CTRL FROM LEFT BULKHEAD GROMMET) PPL FUEL PUMP PRIME CONNECTOR (TAPED TO FUEL PUMP RELAY BREAKOUT) FUEL PUMP RELAY (ENGINE BULKHEAD RELAY BRACKET UNDER BATTERY JUNCTION BLOCK) GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) IGN FEED IGNITION COIL (TOP RIGHT SIDE OF ENGINE) IGNITION CONTROL MODULE (BRACKET AT TOP EDGE OF RIGHT CYLINDER HEAD) IGNITION FEED LT BLU/WHT WIRE ORG/ WIRE PCS SOL (HI) INPUT SPD SENS SIG INPUT SPD SENS RTN TIMING CTRL SIG PCS SOL (LO) SYSTEM GND SYSTEM GND GND 451 451 470 PNK IGN FEED WIRE PNK PNK WIRE PNK WIRE PPL PPL 1 2 PPL 2 4 5 16 DATA LINK CONNECTOR (DLC) (BELOW DASH, NEAR STEERING COLUMN) PPL ANTI-LOCK BRAKE SYSTEM PPL FUEL LEV PPL PPL 420 1807 BRAKE SIG SERIAL DATA RANGE SIG "C" RED WIRE RED/ BLK WIRE RED/BLK WIRE SHIFT INTERLOCK SYSTEM SPARK PLUGS TCC/ STOP LAMPS SWITCH (RIGHT SIDE OF STEERING COLUMN UPPER SUPPORT) TIMING CONTROL RETURN TIMING CONTROL SIGNAL) VEHICLE CONTROL MODULE (VCM) (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/ DK BLU WIRE WHT/BLK WIRE

5 VOLT REF ACCELERATOR PEDAL POSITION MODULE (ATTACHED TO ACCELERATOR PEDAL) APP 1 SENSOR APP 2 SENSOR APP 3 SENSOR BLK WIRE BRN WIRE BRN/WHT WIRE CLOSURE GRD CLOSURE SIGNAL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ENGINE SHUTOFF SOLENOID FUEL SOL CTRL FUEL SOL HIGH FUEL SOL LOW FUEL SOLE- NOID FUEL SOLENOID DRIVER (TOP LEFT OF ENGINE) GRN WIRE GRY WIRE HAZARD FLASHER (INNER LEFT SIDE OF MAIN SUPPORT BRACKET) HIGH LOW HIGH RES SIG HOT AT ALL TIMES HOT IN HOT IN RUN AND START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IGNITION TIMING STEPPER MOTOR (PART OF FUEL INJECTION PUMP) LOW HIGH LT BLU WIRE LT GRN WIRE OPTICAL FUEL TEMPERATURE SENSOR (PART OF FUEL INJECTION PUMP) ORG/ WIRE ORG/BLK WIRE PNK PNK PPL 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 WIRE PNK WIRE PNK/BLK WIRE PPL PPL PPL PPL PPL 28 29 30 31 32 PUMP CAM SIG RED WIRE RED/BLK WIRE RUN WIRE SENSOR GROUND STOP-HAZ FUSE 11 TAN WIRE TAN/BLK WIRE TCC/ STOPLAMP SWITCH (AT REAR OF BRAKE PEDAL SUPPORT BRACKET) TRANS FUSE 17 WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 PNK PNK WIRE A/C COMP CYL SW A/C REQUEST SIGNAL AIR CONDITIONING SYSTEM ANTI-LOCK BRAKES SYSTEM PPL AUX ELECT COOLING FAN BRAKE SIGNAL SERIAL DATA PPL PPL 420 1807 B(+) BATTERY FEED RANGE SIGNAL B RANGE SIGNAL A 1225 1224 PNK WIRE BLK RED/ WIRE BLK WIRE BLK/WHT WIRE BLU/ WHT WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE COOLING FANS SYSTEM CRUISE CONTROL MODULE (ON RADIATOR SUPPORT BRACKET) CRUISE CTRL ENGAGED CRUISE ENGAGED SIG CYLINDER 1 CYLINDER 4 CYLINDER 5 CYLINDER 3 CYLINDER 6 CYLINDER 7 CYLINDER 2 CYLINDER 8 DISTRIBUTOR DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM B FUSE 6 EGR VALVE FEED EGR VLV CTRL ELEC SPK TIMING CTRL SIGNAL EST CTRL FUEL PMP RLY CTRL 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY (LEFT SIDE OF ENGINE COMPT) GRN WIRE GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN I-3 FUSE 9 I/P FUSE BLOCK IGN FEED IGNITION COIL (ON BRACKET AT REAR OF INTAKE PLENUM) IGNITION COIL MODULE (ON BRACKET AT REAR OF INTAKE PLENUM) LT BLU/BLK WIRE LT BLU/WHT WIRE ORG/ WIRE PCS HIGH INPUT SPEED SENS LOW INPUT SPEED SENS HIGH IC CNTRL PCS LOW GROUND GROUND SENS GROUND PNK 22 23 WIRE PNK IGN FEED WIRE PNK WIRE PPL PPL DATA LINK CONNECTOR (DLC) (BELOW DASH, NEAR STEERING COLUMN) 4 5 PPL FUEL LEVEL MODULE A/C REC PPL TCC/STOPLAMP INPUT RANGE SIGNAL "C" RED WIRE RED/BLK WIRE SENSOR GROUND SPARK PLUGS SPEED SENSOR INPUT VEHICLE CONTROL MODULE (VCM) (ON CENTER FRONT OF ENGINE COMPARTMENT) VSS OUTPUT SIGNAL VSS OUTPUT SIGNAL CHECK ENGINE LP CTRL 389 419 WHT DK GRN/ WIRE WHT WIRE WHT/BLK WIRE