Chevrolet Forward Control P30 (1985-1999) hot in run and start Wiring diagrams

1-3 FUSE 9 12 2 DATA LINK CONNECTOR (BELOW DASH, NEAR STEERING COLUMN) PPL ABS IND. BATTERY GROUND BLK (OR BLK/WHT) WIRE BLK WIRE BRAKE IND BRAKE PRESSURE DIFFERENTIAL SWITCH (INTERNAL TO ELECTRONIC BRAKE CONTROL MODULE) BRN WIRE DIESEL DIESEL: ENGINE HARN, 32 CM FROM BREAKOUT TO BATTERY JUNCTION BLOCK) DIODE NETWORK (ON I/P HARNESS, BODY BUILDER INSTALLED) DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (BELOW RADIATOR, ON LOWER CROSSMEMBER) FUSE LINK (IN BATTERY JUNCTION BLOCK, AT LEFT REAR OF ENGINE COMPT) GAS GAS DIESEL GAUGES FUSE 8 HOT AT ALL TIMES HOT IN RUN HOT IN RUN AND START I/P FUSE BLOCK (BEHIND DASH PANEL) (BODY BUILDER INSTALLED) IGNITION ABS LAMP CONTROL BRAKE SW INPUT INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LT BLU WIRE LT GRN WIRE NCA WIRE PNK WIRE PPL PPL PPL 1807 680 RED WIRE RIGHT FRONT WHEEL SPEED SENSOR SENSOR LOW SENSOR LOW SENSOR HIGH SENSOR HIGH 873 833 STOPLAMPS SWITCH (AT BRAKE PEDAL SUPPORT) TAN WIRE TAN/WHT WIRE VEHICLE SPEED SENSOR CALIBRATOR (LEFT SIDE OF DRIVER'S ISLAND ON RELAY BRACKET) WARNINGS SYSTEM YEL WIRE YEL/BLK WIRE

1-3 FUSE 9 12 2 DATA LINK CONNECTOR (BELOW DASH, NEAR STEERING COLUMN) PPL ABS IND. BATTERY GROUND BLK (OR BLK/WHT) WIRE BLK WIRE BRAKE IND BRAKE PRESSURE DIFFERENTIAL SWITCH (INTERNAL TO ELECTRONIC BRAKE CONTROL MODULE) BRN WIRE DIESEL DIODE NETWORK (ON I/P HARNESS, BODY BUILDER INSTALLED) DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (BELOW RADIATOR, ON LOWER CROSSMEMBER) FUSE LINK (IN BATTERY JUNCTION BLOCK, AT LEFT REAR OF ENGINE COMPT) GAS GAS DIESEL GAUGES FUSE 8 HOT AT ALL TIMES HOT IN RUN HOT IN RUN AND START I/P FUSE BLOCK (BEHIND DASH PANEL) (BODY BUILDER INSTALLED) IGNITION ABS LAMP CONTROL BRAKE SW INPUT INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LT BLU WIRE LT GRN WIRE NCA WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF DRIVER'S ISLAND ON RELAY BRACKET) PPL PPL PPL 1807 680 RED WIRE RIGHT FRONT WHEEL SPEED SENSOR SENSOR LOW SENSOR LOW SENSOR HIGH SENSOR HIGH 873 833 STOPLAMPS SWITCH (AT BRAKE PEDAL SUPPORT) TAN WIRE TAN/WHT WIRE VEHICLE CONTROL MODULE (TOP OF RADIATOR SUPPORT) VEHICLE SPEED SENSOR CALIBRATOR (LEFT SIDE OF DRIVER'S ISLAND ON RELAY BRACKET) WARNINGS SYSTEM YEL WIRE YEL/BLK WIRE

BAT BAT (BASE) GENERATOR BATTERY BLK WIRE FUSIBLE LINK FUSIBLE LINK (10 GA-RUST) GASOLINE DIESEL GAUGES FUSE HOT IN RUN AND START I/P FUSE BLOCK INSTRUMENT CLUSTER TACH (DIESEL) PNK (COMMERCIAL) (MOTOR HOME) PNK WIRE PNK WIRE POWER DISTRIBUTION SYSTEM RED (OR GRY) WIRE RED WIRE SECONDARY BATTERY (DIESEL) STARTER SOLENOID WHT WIRE

BLK WIRE GAUGES FUSE 8 GRY WIRE HORN/DM FUSE 3 HOT AT ALL TIMES HOT IN RUN AND START HOT W/ PARK OR HEADLAMPS SWITCH ON I/P FUSE BLOCK INSTR LPS FUSE 16 INSTRUMENT CLUSTER LAMP ON INPUT GROUND POWER (BATTERY) SEAT BELT INPUT ORG/ WIRE PNK POWER (IGNITION) WIRE PNK WIRE SEAT BELT LAMP OUTPUT SEAT BELTS ALARM MODULE (AT THE BOTTOM OF THE I/P FUSE BLOCK) YEL WIRE

8 250 40 250 250 LAMP ON INPUT GROUND POWER (BATTERY) SEAT BELT SWITCH BLK WIRE GAUGES FUSE 8 GRY WIRE HORN/DM FUSE 3 HOT AT ALL TIMES HOT IN RUN AND START HOT W/ PARK OR HEADLAMPS SWITCH ON I/P FUSE BLOCK INSTR LPS FUSE 16 INSTRUMENT CLUSTER ORG/ WIRE PNK POWER (IGNITION) WIRE PNK WIRE SEAT BELT TELL TALE SEAT BELT/LAMPS ALARM MODULE (AT THE BOTTOM OF THE I/P FUSE BLOCK) YEL WIRE

5 VOLT REF ACCELERATOR PEDAL POSITION MODULE (ATTACHED TO ACCELERATOR PEDAL) APP 1 SENSOR APP 2 SENSOR APP 3 SENSOR BLK WIRE BRN WIRE BRN/WHT WIRE CLOSURE GRD CLOSURE SIGNAL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ENGINE SHUTOFF SOLENOID FUEL SOL CTRL FUEL SOL HIGH FUEL SOL LOW FUEL SOLE- NOID FUEL SOLENOID DRIVER (TOP LEFT OF ENGINE) GRN WIRE GRY WIRE HAZARD FLASHER (INNER LEFT SIDE OF MAIN SUPPORT BRACKET) HIGH LOW HIGH RES SIG HOT AT ALL TIMES HOT IN HOT IN RUN AND START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IGNITION TIMING STEPPER MOTOR (PART OF FUEL INJECTION PUMP) LOW HIGH LT BLU WIRE LT GRN WIRE OPTICAL FUEL TEMPERATURE SENSOR (PART OF FUEL INJECTION PUMP) ORG/ WIRE ORG/BLK WIRE PNK PNK PPL 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 WIRE PNK WIRE PNK/BLK WIRE PPL PPL PPL PPL PPL 28 29 30 31 32 PUMP CAM SIG RED WIRE RED/BLK WIRE RUN WIRE SENSOR GROUND STOP-HAZ FUSE 11 TAN WIRE TAN/BLK WIRE TCC/ STOPLAMP SWITCH (AT REAR OF BRAKE PEDAL SUPPORT BRACKET) TRANS FUSE 17 WHT WIRE YEL WIRE YEL/BLK WIRE

18 19 PNK WIRE A/C COMPRESSOR CLUTCH RELAY (RIGHT SIDE OF DRIVER'S ISLAND) A/C HIGH PRESSURE CUT-OFF SWITCH (ON REAR OF THE A/C COMPRESSOR) BLK WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM B FUSE 6 ENG BAT FUSE 10 FUEL LIFT PUMP (INSIDE RIGHT FRAME RAIL, AHEAD OF FUEL TANK) FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY (IN UNDERHOOD FUSE/RELAY CENTER) FUEL PUMP SWITCH AND ENGINE OIL PRESSURE GAUGE SWITCH (LEFT REAR OF ENGINE) GAUGES FUSE 8 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN AND START I/P FUSE BLOCK INDICATOR INSTRUMENT CLUSTER LT GRN WIRE MALFUNCTION INDICATOR LAMP (MIL) NCA WIRE OIL PRESS GAUGE ORG/ WIRE PNK PNK WIRE PNK WIRE RED WIRE SERVICE THROTTLE SOON INDICATOR SPEED METER TAN WIRE WAIT TO WATER IN FUEL INDICATOR WATER IN-FUEL INPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

"SERV THROTTLE SOON" IND 18 19 PNK WIRE A/C ENABLE GROUND GROUND 451 551 ANTILOCK BRAKES SYSTEM BATTERY BATTERY WASTEGATE SOL CTRL ESO SOLENOID CTLR BLK WIRE BLK/WHT WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ENG 1 FUSE 15 ESO CTRL FUEL HEATER (TOP REAR OF ENGINE) FUEL INJECT CTRL FUSIBLE LINK FUSIBLE LINKS GLOW PLUG 1 GLOW PLUG 2 GLOW PLUG 3 GLOW PLUG 5 GLOW PLUG 7 GLOW PLUG 6 GLOW PLUG 4 GLOW PLUG 8 GLOW PLUG OUT GLOW PLUG RELAY (TOP REAR OF INTAKE MANIFOLD) GROUND GRY WIRE HOT AT ALL TIMES HOT IN RUN AND START I/P FUSE BLOCK LT GRN WIRE NCA WIRE ORG/ WIRE PNK IGNITION WIRE PNK PNK 439 439 IGNITION IGNITION BATTERY MIL IND CTRL WIRE PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT SIDE OF DRIVER'S ISLAND) PPL RED WIRE RELAY CTRL WASTEGATE SOLENOID WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

2 3 PPL AUTOMATIC TRANSMISSION BANK 1 SENSOR 1 (ON LEFT EXHAUST PIPE BEFORE CATALYTIC CONVERTER) BANK 1 SENSOR 2 (ON LEFT EXHAUST PIPE AFTER CATALYTIC CONVERTER) BANK 2 SENSOR 2 (ON RIGHT EXHAUST PIPE AFTER CATALYTIC CONVERTER) BLK WIRE BLK/WHT WIRE BLU WIRE BLU/BLK WIRE BRN WIRE DK BLU WIRE DK BLU/WHT WIRE ECM 1 FUSE 12 ENG 1 FUSE 15 EXHAUST GAS RECIRCULATION VALVE SOLENOID (LEFT SIDE OF INTAKE PLENUM) FLUID TEMPERATURE SENSOR (INTERNAL) FORCE MOTOR FUEL INJ 1 FUEL INJ 2 FUEL INJ 3 FUEL INJ 5 FUEL INJ 4 FUEL INJ 6 FUEL INJ 7 FUEL INJ 8 GRN WIRE GRN/BLK WIRE GRY WIRE HEATED OXYGEN HOT IN RUN AND START I/P FUSE BLOCK IGNITION INTAKE AIR TEMP SENSOR (MOUNTED IN FRESH AIR INTAKE BEHIND AIR FILTER BOX) LT BLU/WHT WIRE LT GRN WIRE NCA WIRE PNK 8 9 10 WIRE PNK PNK 2 3 WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL PPL PNK 9 10 11 12 13 14 15 WIRE PPL/ WHT WIRE PPL/WHT WIRE RED WIRE RED/BLK WIRE SOLENOID 1-2 SOLENOID 2-3 SWITCH PRESSURE TAN WIRE TAN/ WHT WIRE TAN/WHT WIRE TCC SOLENOID WHT LT BLU/ WIRE WHT PPL/ WIRE WHT TAN/ WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

A/C COMPRESSOR HIGH PRESSURE CUT-OFF SWITCH (ON REAR OF A/C COMPRESSOR) BLK WIRE BREAKOUT FOR CRUISE CONTROL MODULE, TOWARD RELAYS) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENG BAT FUSE 10 ENGINE COOLANT TEMPERATURE SENSOR (ON TOP FRONT OF ENGINE) FUEL GAUGE FUEL PUMP AND FUEL TANK SENDER (ON TOP OF FUEL TANK) FUEL PUMP/ OIL PRESSURE SWITCH (ON TOP LEFT REAR OF ENGINE) GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN AND START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP (MIL) "SERVICE ENGINE SOON" MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP CENTER FRONT OF ENGINE) MASS AIR FLOW SENSOR (RIGHT FRONT OF ENGINE COMP, ON AIR INTAKE ASSEMBLY) NCA WIRE OIL PRESS GAUGE ORG/ WIRE PNK 22 23 WIRE PNK PNK 2 3 WIRE PNK PNK WIRE PNK WIRE PPL PPL PNK 9 10 11 12 13 14 15 WIRE RED WIRE RED/BLK WIRE SPEED METER TACH TAN WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY, TOP OF ENGINE) TRANS FUSE 17 WHT WIRE YEL WIRE