Chevrolet Forward Control P30 (1985-1999) gauges fuse 8 Wiring diagrams

1-2 SHIFT SOL 1-2 SHIFT SOLENOID 2-3 SHIFT SOL 2-3 SHIFT SOLENOID 3-2 SHIFT SOL 3-2 SHIFT SOLENOID A/C COMPRESSOR RELAY, GENERATOR, TURBO CHARGER POWER VALVE A/T INPUT SPEED SENSOR (LEFT SIDE OF TRANSMISSION) A/T ISS SENS HI IN A/T ISS SENS LO IN ACCELERATOR PEDAL POSITION MODULE (ATTACHED TO ACCELERATOR PEDAL) APP 1 SIGNAL IN APP 2 SIGNAL IN APP 3 SIGNAL IN AUTOMATIC TRANSMISSION BATTERY IN BLK WIRE BLK/WHT WIRE BRAKE SWITCH IN BRN WIRE BRN/WHT WIRE BUSS BAR CLASS II DATA DATA LINK CONNECTOR (PARTIAL) (BELOW DASH, NEAR STEERING COLUMN) DK BLU WIRE DK BLU/WHT WIRE DK GRN/WHT WIRE ECM 1 FUSE 12 ECM-BAT FUSE 6 ECT SENSOR IN ELECTRONIC BRAKE CONTROL MODULE ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUEL PUMP RELAY, FUEL PUMP SWITCH/ENGINE OIL PRESSURE INDICATOR SENSOR GAUGES FUSE 8 GRY WIRE HAZARD LAMPS FLASHER (ABOVE STEERING COLUMN) HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START I-3 FUSE 9 I/P FUSE BLOCK IGNITION IN INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MIL CONTROL ORG/ WIRE PCM GROUND PCS SOL HI OUT PCS SOL LO OUT PNK INSTRUMENT CLUSTER WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF DRIVER'S ISLAND) PPL PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE SENSOR GROUND SERVICE ENGINE SOON INDICATOR STOP-HAZ FUSE 11 STOPLAMP SWITCH IN TFT SENSOR IN TORQUE CONVERTER CLUTCH BRAKE, STOPLAMP SWITCH TRANS FLUID TEMP SENSOR TRANS RANGE "A" TRANS RANGE "B" TRANS RANGE "C" TRANS RANGE PRESSURE SWITCH ASSEMBLY TRANSMISSION FUSE 17 TWISTED WIRE PAIR VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR CALIBRATOR (ABOVE ACCELERATOR PEDAL) VEHICLE SPEED SENSOR CALIBRATOR, ENGINE SHUTOFF SOLENOID VSS HI IN VSS LO IN VSS OUT YEL WIRE YEL/BLK WIRE

BLK WIRE DAYTIME RUNNING LAMPS CONTROL MODULE (ATTACHED TO I/P HARNESS) DAYTIME RUNNING LAMPS RELAY (LEFT SIDE OF DASH, ON RELAY BRACKET) DIODE NETWORK (ON I/P HARNESS) DK BLU WIRE DK GRN/WHT WIRE DRL INDICATOR FUSE BLOCK BREAKOUT) FUSIBLE LINK (16 GA- GAUGES FUSE 8 GRN WIRE HEADLAMP DIMMER SWITCH HEADLAMPS SWITCH OFF HI BEAM INDICATOR HI LO HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE BLOCK IGNITION SWITCH INSTRUMENT CLUSTER LEFT HEAD- LAMP LO HI LOCK OFF LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT LT ORG/ WIRE PARK BRAKE IN FOG LAMPS PARK BRAKE INDICATOR SWITCH (ON PARK BRAKE LEVER) PARK HEAD PNK IGNITION LAMP FEED HI BM INPUT HI BM INDICATOR RELAY CONTROL GROUND WIRE PNK WIRE RED WIRE RIGHT HEAD- LAMP RUN WIRE TAN WIRE WHT WIRE YEL WIRE

ABS IND. ACCY ACCY ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRAKE IND BRAKE PRESSURE DIFFERENTIAL SWITCH (INTERNAL TO ELECTRONIC BRAKE CONROL MODULE) BRN/WHT WIRE CHECK GAUGES IND COOLANT TEMPERATURE GAUGE DIESEL DIODE NETWORK (DASH HARN, DK BLU WIRE DK GRN WIRE DOOR AJAR IND DRL IND ECM 1 FUSE 12 ELECTRONIC BRAKE CONTROL MODULE (EBCM) (BELOW RADIATOR, ON LOWER CROSSMEMBER) ENG 1 FUSE 15 ENGINE CONTROLS OR STARTING/CHARGING SYSTEM ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM TRANSMISSIONS SYSTEM ENGINE COOLANT LEVEL SWITCH (ON LOWER LEFT END OF RADIATOR SURGE TANK) FOOT BRAKE (PARK BRAKE APPLY OPPTION) FUEL GAUGE FUEL SENDER (ON TOP OF FUEL TANK) GAS GAUGES FUSE 8 GRY WIRE GRY/BLK WIRE HAND BRAKE HEADLIGHTS SYSTEM HI-BEAM IND HOT IN RUN OR START I/P FUSE BLOCK I/P FUSE BLOCK (BODY BUILDER INSTALLED) I/P FUSE BLOCK) INSTRUMENT CLUSTER IGNITION SWITCH ILLUMINATION IN-LINE CONNECTOR PROVISIONS FOR BODY BUILDER INTERIOR LIGHTS SYSTEM WARNING SYSTEMS LEFT TURN IND LOCK LOCK OFF OFF LOW COOLANT IND LT BLU WIRE LT BLU/BLK WIRE LT GRN (OR WHT) WIRE LT GRN WIRE MALFUNCTION IND (MIL) (SERVICE ENGINE SOON IND) NCA WIRE OIL PRESSURE GAUGE PNK 4 13 WIRE PNK WIRE PPL PPL DIESEL PPL GAS PPL RIGHT TURN IND RUN WIRE SEAT BELT IND SERVICE THROTTLE SOON IND SPEEDOMETER TACHOMETER TAN WIRE TAN/WHT WIRE TRANS IND. VEHICLE CONTROL MODULE (ON LEFT SIDE OF RADIATOR SUPPORT) VOLTMETER VSS CALIBRATOR (LEFT SIDE OF DRIVER'S ISLAND, UNDER RELAY BRACKET) W/ DRL W/O DRL WAIT TO START IND WATER IN FUEL IND WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4 13 PNK WIRE A/T ABS IND. ACCY BULB TEST LOCK OFF ANTI-LOCK BRAKES SYSTEM AUTO PARK IND. BLK WIRE BLK/WHT WIRE BRAKE IND DRL IND BRN/WHT WIRE CHECK GAUGES IND COOLANT TEMPERATURE GAUGE DIESEL DK BLU WIRE DK GRN WIRE DOOR AJAR IND ECM 1 FUSE 12 ENGINE CONTROLS OR STARTING/ CHARGING SYSTEM ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM ENGINE COOLANT LEVEL SWITCH (ON LOWER LEFT END OF RADIATOR SURGE TANK) FUEL GAUGE FUEL SENDER (ON TOP OF FUEL TANK) GAS GAUGES FUSE 8 GRY WIRE GRY/BLK WIRE HEADLIGHTS SYSTEM HI-BEAM IND HOT IN RUN OR START I/P FUSE BLOCK (BEHIND DASH PANEL) (BODY BUILDER INSTALLED) IGNITION SWITCH ILLUMINATION IN-LINE CONNECTOR PROVISIONS FOR BODY BUILDER INSTRUMENT CLUSTER INTERIOR LIGHTS SYSTEM WARNING SYSTEMS LEFT TURN IND LOW COOLANT IND LT BLU WIRE LT GRN (OR WHT) WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION IND. LAMP (MIL) (SERVICE ENGINE SOON IND) OIL PRESSURE GAUGE PNK WIRE PPL PPL DIESEL PPL GAS PPL RIGHT TURN IND RUN WIRE SEAT BELT IND SERVICE THROTTLE SOON IND SPEEDOMETER TACHOMETER TAN WIRE TAN/WHT WIRE VEHICLE CONTROL MODULE (ON LEFT SIDE OF RADIATOR SUPPORT) VOLTMETER VSS CALIBRATOR (LEFT SIDE OF DRIVER'S ISLAND, UNDER RELAY BRACKET) WAIT TO START IND WATER IN FUEL IND WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

BLK WIRE GAUGES FUSE 8 GRY WIRE HORN/DM FUSE 3 HOT AT ALL TIMES HOT IN RUN AND START HOT W/ PARK OR HEADLAMPS SWITCH ON I/P FUSE BLOCK INSTR LPS FUSE 16 INSTRUMENT CLUSTER LAMP ON INPUT GROUND POWER (BATTERY) SEAT BELT INPUT ORG/ WIRE PNK POWER (IGNITION) WIRE PNK WIRE SEAT BELT LAMP OUTPUT SEAT BELTS ALARM MODULE (AT THE BOTTOM OF THE I/P FUSE BLOCK) YEL WIRE

8 250 40 250 250 LAMP ON INPUT GROUND POWER (BATTERY) SEAT BELT SWITCH BLK WIRE GAUGES FUSE 8 GRY WIRE HORN/DM FUSE 3 HOT AT ALL TIMES HOT IN RUN AND START HOT W/ PARK OR HEADLAMPS SWITCH ON I/P FUSE BLOCK INSTR LPS FUSE 16 INSTRUMENT CLUSTER ORG/ WIRE PNK POWER (IGNITION) WIRE PNK WIRE SEAT BELT TELL TALE SEAT BELT/LAMPS ALARM MODULE (AT THE BOTTOM OF THE I/P FUSE BLOCK) YEL WIRE

3 4 5 6 7 8 9 10 11 12 13 14 15 16 PNK PNK WIRE A/C COMPRESSOR HIGH PRESSURE CUT-OFF SWITCH (REAR OF A/C COMPRESSOR) BLK WIRE BREAKOUT) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENG BAT FUSE 10 ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) FROM ECT SENSOR BREAKOUT) FROM TPS BREAKOUT) FUEL GAUGE FUEL PUMP SWITCH, ENGINE OIL PRESSURE GAUGE SENSOR (TOP LEFT REAR OF ENGINE) FUEL SENDER, FUEL PUMP (TOP OF FUEL TANK) GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN, START I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP REAR OF ENGINE) MAP REF LO MASS AIR FLOW SENSOR (MAF) (MOUNTED IN FRESH AIR INTAKE, BEHIND AIR FILTER BOX) NCA WIRE OIL PRESS GAUGE ORG/ WIRE PNK PNK PNK 2 3 4 5 WIRE PNK PNK WIRE PNK WIRE PPL RED WIRE RED/BLK WIRE REF LO TEMP REF THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY, TOP OF ENGINE) SENSOR BREAKOUT) SPEEDO- METER TACHO- METER TAN WIRE WHT WIRE YEL WIRE

A/C COMPRESSOR HIGH PRESSURE CUT-OFF SWITCH (REAR OF A/C COMPRESSOR) BLK WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENG-B FUSE 10 ENGINE COOLANT TEMPERATURE (ECT) SENSOR (TOP FRONT OF ENGINE) FROM ECT SENSOR BREAKOUT) FROM MAF SENSOR BREAKOUT) FROM TP SENSOR BREAKOUT) FUEL GAUGE FUEL PUMP SWITCH, ENGINE OIL PRESSURE GAUGE SENSOR (TOP LEFT REAR OF ENGINE) FUEL SENDER, FUEL PUMP (TOP OF FUEL TANK) GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN (ON) RUN, START (CRANK) I/P FUSE BLOCK (DASH PANEL PROVIDED BY BODY BUILDER) (BODY BUILDER INSTALLED) INSTRUMENT CLUSTER INTAKE AIR TEMPERATURE (IAT) SENSOR (IN FRESH AIR INTAKE, BEHIND AIR FILTER BOX) LT BLU/WHT WIRE LT GRN WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP RIGHT REAR OF ENGINE) MAP MASS AIR FLOW (MAF) SENSOR (IN FRESH AIR INTAKE BEHIND AIR FILTER BOX) NCA WIRE OIL PRESS GAUGE ORG/ WIRE PNK 10 11 12 13 14 15 16 17 WIRE PNK 5 6 WIRE PNK PNK PNK PNK 1 2 3 4 WIRE PNK PNK WIRE PNK WIRE PPL PPL 1 2 PPL 8 9 RED WIRE RED/BLK WIRE REF LO REF LO TEMP REF THROTTLE POSITION (TP) SENSOR (THROTTLE BODY, TOP OF ENGINE) SERVICE ENGINE SOON INDICATOR SPEEDO- METER TACHO- METER TAN WIRE TRANS FUSE 17 WHT WIRE YEL WIRE

18 19 PNK WIRE A/C COMPRESSOR CLUTCH RELAY (RIGHT SIDE OF DRIVER'S ISLAND) A/C HIGH PRESSURE CUT-OFF SWITCH (ON REAR OF THE A/C COMPRESSOR) BLK WIRE BLU WIRE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM B FUSE 6 ENG BAT FUSE 10 FUEL LIFT PUMP (INSIDE RIGHT FRAME RAIL, AHEAD OF FUEL TANK) FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY (IN UNDERHOOD FUSE/RELAY CENTER) FUEL PUMP SWITCH AND ENGINE OIL PRESSURE GAUGE SWITCH (LEFT REAR OF ENGINE) GAUGES FUSE 8 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN AND START I/P FUSE BLOCK INDICATOR INSTRUMENT CLUSTER LT GRN WIRE MALFUNCTION INDICATOR LAMP (MIL) NCA WIRE OIL PRESS GAUGE ORG/ WIRE PNK PNK WIRE PNK WIRE RED WIRE SERVICE THROTTLE SOON INDICATOR SPEED METER TAN WIRE WAIT TO WATER IN FUEL INDICATOR WATER IN-FUEL INPUT WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

A/C COMPRESSOR HIGH PRESSURE CUT-OFF SWITCH (ON REAR OF A/C COMPRESSOR) BLK WIRE BREAKOUT FOR CRUISE CONTROL MODULE, TOWARD RELAYS) BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENG BAT FUSE 10 ENGINE COOLANT TEMPERATURE SENSOR (ON TOP FRONT OF ENGINE) FUEL GAUGE FUEL PUMP AND FUEL TANK SENDER (ON TOP OF FUEL TANK) FUEL PUMP/ OIL PRESSURE SWITCH (ON TOP LEFT REAR OF ENGINE) GAUGES FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN AND START I/P FUSE BLOCK INSTRUMENT CLUSTER LT BLU/WHT WIRE LT GRN WIRE MALFUNCTION INDICATOR LAMP (MIL) "SERVICE ENGINE SOON" MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP CENTER FRONT OF ENGINE) MASS AIR FLOW SENSOR (RIGHT FRONT OF ENGINE COMP, ON AIR INTAKE ASSEMBLY) NCA WIRE OIL PRESS GAUGE ORG/ WIRE PNK 22 23 WIRE PNK PNK 2 3 WIRE PNK PNK WIRE PNK WIRE PPL PPL PNK 9 10 11 12 13 14 15 WIRE RED WIRE RED/BLK WIRE SPEED METER TACH TAN WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY, TOP OF ENGINE) TRANS FUSE 17 WHT WIRE YEL WIRE